torque MERCEDES-BENZ SL500 2003 R230 Owner's Manual

238 OperationTires and wheelsIf you wish to cancel activation:
Press
ç
button.
If the following message appears in the
speedometer display field:
Reactivate tire press. monit.


Re-start the activation of the tire infla-
tion pressure monitor.
If the following message appears in the
speedometer display field:
Tire pressure

Check tires!


Re-start the activation of the tire infla-
tion pressure monitor.
Rotating wheels
On vehicles with the same wheel size all
around, wheels can be rotated every 3000
to 6000 miles (5 000 to 10 000 km), or
sooner if necessary, according to the de-
gree of tire wear. The same direction of tire
rotation must be retained.
Rotate the wheels before the characteris-
tic tire wear pattern becomes visible
(shoulder wear on front wheels and tread
center wear on rear wheels).Thoroughly clean the inner side of the
wheels after each rotation. Check and en-
sure proper tire inflation pressure, activat-
ing the tire inflation pressure monitor if
necessary. Warning!
G
Rotate front and rear wheels only if they are
of the same size.
Warning!
G
Have the tightening torque checked after
changing a wheel. Wheels could become
loose if not tightened with a torque of
96 ft.lb. (130 Nm).
Only use genuine Mercedes-Benz wheel
bolts specified for your vehicle's rims.

318 Practical hintsFlat tireLowering the vehicle
Lower vehicle by turning crank coun-
terclockwise until the full weight of the
vehicle is resting on the ground.

Pull the jack out of the jack support
tube.
1 - 5 Wheel bolts

Tighten the five wheel bolts evenly, fol-
lowing the diagonal sequence illustrat-
ed (1 to 5), until all bolts are tight.
Observe a tightening torque of 96 ft lb
(130 Nm).

Before storing the jack in the trunk,
crank back to storage position and fold
in the arm.Replacing jack support tube cover

Slide tongue of cover under the upper
edge of the tube opening.

Applying even pressure, press cover
until it snaps into place. Be careful not
to damage the locking tabs or clamp
the plastic retaining strap.
Warning!
G
Have the tightening torque checked after
changing a wheel. The wheels could come
loose if they are not tightened to a torque of
96 ft lb (130 Nm).

336 Technical dataEngine
EngineModel
SL 500 (230.475
(1))
SL 55 AMG (230.474
(1))
Engine
113
113
Mode of operation
4-stroke engine, gasoline injection
4-stroke engine, gasoline injection
No. of cylinders
8
8
Bore
3.82 in (97.00 mm)
3.82 in (97.00 mm)
Stroke
3.31 in (84.00 mm)
3.60 in (92.00 mm)
Total piston displacement
302.9 cu.in. (4966 cm
3)
331.8 cu.in. (5439 cm
3)
Compression ratio
10:1
9:1
Output acc. to SAE J 1349
302 hp / 5 600 rpm
(225 kW / 5 600 rpm)
493 hp / 6 100 rpm
(368 kW / 6 100 rpm)
Maximum torque acc. to SAE J 1349
339 ft.lb / 2 700 rpm
(460 Nm / 2700 rpm)
516 ft.lb / 2 750-4000 rpm
(700 Nm / 2 750-4000 rpm)
Maximum engine speed
6000 rpm
6500 rpm
Firing order
1-5-4-2-6-3-7-8
1-5-4-2-6-3-7-8
Poly-V-belt
7ft 10in (2390mm)
8ft 1in/4ft 3in (2462mm/1289mm)
1The quoted data apply only to the standard vehicle. See an authorized Mercedes-Benz Center for the corresponding data of all special bodies and special equipment.

339 Technical data
Electrical system
Electrical system
Model
SL 500
SL 55 AMG
Generator (alternator)
14 V/150 A
14 V/180 A
Starter motor
12 V/1.7 kW
12 V/1.7 kW
BatteryStarter battery
12 V/35 Ah
12 V/35 Ah
Battery for electrical consumers
12 V/70 Ah
12 V/70 Ah
Spark plugs
Bosch F 8 DPER
NGK PFR 5 R-11
NGK IL FR 6 A
Electrode gap
0.039 in (1.0 mm)
0.039 in (1.0 mm)
Tightening torque
15 – 22 ft.lb (20 – 30 Nm)
15 – 22 ft.lb (20 – 30 Nm)

354 Technical termsMultifunction display
Two display fields in the instrument
cluster used to present information
provided by the control system.
Multifunction steering wheel
Steering wheel with buttons for operat-
ing the control system.
Overspeed range
Engine speeds within the red marking
of the tachometer dial. Avoid this en-
gine speed range, as it may result in se-
rious engine damage that is not
covered by the Mercedes-Benz Limited
Warranty.
Parktronic*
System which uses visual and acoustic
signals to assist the driver during park-
ing maneuvers.
Poly-V-belt drive
Drives engine-components (alternator,
AC compressor, etc.) from the engine.Power train
Collective term designating all compo-
nents used to generate and transmit
motive power to the drive axles, includ-
ing


engine


clutch/torque converter


transmission


transfer case


drive shaft


differential


axle shafts/axles
Program mode selector switch
Used to switch the automatic transmis-
sion between standard operation (S)
and winter operation (W).
SL 55 AMG with steering wheel gear-
shift control and manual shift program:
in addition to S and W (for regular S or
winter W operation, see above), you
can use MANUAL for manual shift pro-
gramRemote Vehicle Diagnostics
Transmission of vehicle data and cur-
rent location to the Mercedes-Benz
Customer Assistance Center for sub-
scribers to Tele Aid service.
REST
(Residual Engine Heat Utilization)
Feature that uses the engine heat
stored in the coolant to heat the vehi-
cle interior for a short time after the en-
gine has been turned off.
Retractable hardtop
Hardtop roof that can be opened and
closed at the push of a button and
stored in the trunk.
Roll bar
Occupant protection system which
consists of tubular steel sheathed in
plastic. The roll bar is lowered into the
car body during normal driving condi-
tions and raised automatically. It may
also be manually raised and lowered by
operating a button during critical driv-
ing situations.

355 Technical terms
RON
The Research Octane Number for gaso-
line as determined by a standardized
method. It is an indication of a gaso-
line's ability to resist undesired detona-
tion (knocking). The average of both
the MON (Motor Octane Number) and
RON (Research Octane Number) is
posted at the pump, also known as AN-
TI-KNOCK INDEX.
SBC
(S
ensotronic B
rake C
ontrol)
Electronically controlled hydraulic
braking system for increased braking
safety and comfort.
Shift lock
When the vehicle is parked, this lock
prevents the transmission selector le-
ver from being inadvertently moved out
of position P without key turned and
brake pedal depressed. SRS
(S
upplemental R
estraint S
ystem)
Seat belts, emergency tensioning de-
vice and airbags. Though independent
systems, they are closely interfaced to
provide effective occupant protection.
Tele Aid System
(Tele
matic A
larm I
dentification on D
e--
mand)
The Tele Aid system consists of three
types of response: automatic and man-
ual emergency, roadside assistance
and information. Tele Aid is initially ac-
tivated by completing a subscriber
agreement and placing an acquain-
tance call.
The Tele Aid system is operational pro-
viding that the vehicle’s battery is
charged, properly connected, not dam-
aged and cellular and GPS coverage is
available.Tightening torque
Force times lever arm (e.g. a lug
wrench) with which threaded fasteners
such as wheel bolts are tightened.
TIREFIT
Accessory for emergency and tempo-
rary tire repair. The TIREFIT kit consists
of a container with sealant material, a
filler hose, a valve stem tool, a valve in-
sert, and an air compressor.
Tire speed rating
Part of tire designation; indicates the
speed range for which a tire is ap-
proved.
Traction
Force exerted by the vehicle on the
road via the tires.

372 IndexTele Aid 200
Emergency calls 202
Information 205
Initiating an emergency call
manually 203
Messages in display 263
Roadside assistance 204
SOS button 25, 203
Tele Aid system 201
Tele Aid System 355
Telephone* 22, 199
Answering a call 134
Dialing 135
Ending a call 135
Hands-free microphone 25
Loading phone book* 135
Messages in display 270
Operating 133
Redialing 136
Signal strength 134
Telephones and two-way radios 223Temperature
Outside temperature indicator 109
Sensor 25
Setting interior temperature 149
Setting units in display 122
Tires 236
Tightening torque 318, 355
Tilt
Head restraint 34
Time display mode
Setting 122
Tire inflation pressure 305, 310
Checking 226, 235
Setting units 129
Tire speed rating 220, 355
Tire traction 220
TIREFIT 355
TIREFIT kit 289, 302, 308
TIREFIT kit 1
Instructions for use 302
TIREFIT kit 2
Instructions for use 308Tires 234, 348
Direction of rotation 235
Driving instructions 219
Messages in display 281
Retreads 234
Rims and tires 337
Rotating 238
Service life 235
SL 500 338
SL 55 AMG Kompressor 338
Temperature 236, 349
Tread depth 239
Wear pattern 238
Winter 239
Tools 288
Tow-away alarm 24, 77
Arming 77
Disarming 77
Disarming for transport 77
Tow-away alarm switch 24
Towing eye bolt (vehicle tool kit) 288
Installing 327
Towing the vehicle 325
Traction 141, 355
Transmission see Automatic transmission
Fluid level 230

374 IndexVIN (vehicle identification number) 334,
356
Voice control system* 19
Hands-free microphone 25
Voice control system+ 353
W
Warning lamps see Lamps, indicator and
warning
Warning sounds
Distance warning function* 179
Distronic* 173
Warranty coverage 333
Washing the vehicle 245
Wear pattern (tires) 238
Wheel change 312
Tightening torque 318
Wind screen 165, 356
Installing 165
Removing 166
Windows see Side windows
Windshield
Refilling washer fluid 233
Washer fluid 45, 233
Washer system 233
Windshield and headlamp washer
system 347Windshield washer fluid 45
Filler neck 233
Message in display 287
Mixing ratio 347
Refilling 233
Windshield wipers 19, 44
Fast wiper speed 44
Intermittent wiping 44
Replacing wiper blades 301
Wiping with windshield washer
fluid 45
Winter driving
Snow chains 240
Tires 239
Transmission program mode 141
Winter driving instructions 221
Winter tires 239
Wrench, hex-socket (vehicle tool
kit) 288, 292
Wrench, open-end (vehicle tool kit) 288
Wrench, wheel (vehicle tool kit) 288, 289
X
Xenon headlamps 356
Bi-Xenon 351