display MINI Hardtop 2 Door 2006 Owner's Guide

99
OVERVIEW REPAIRSOPERATIONCONTROLS DATA INDEX
REFUELING
Always switch off the engine before
refueling; otherwise no fuel can be
added to the tank and the SERVICE ENGINE
SOON lamp may come on.<
1. Open the fuel filler door
2. Turn the gas cap counterclockwise
3. Put the gas cap in the bracket attached
to the fuel filler door.
Always observe all applicable precau-
tionary measures and regulations
when handling fuels. Do not carry any
spare fuel containers in the vehicle. They
can leak and cause an explosion or fire in
the event of an accident.<
Observe the following when refueling
Always observe all safety precautions
posted at the service station when
handling fuel.<
When refueling, insert the filler nozzle
completely into the filler pipe. Pulling the
nozzle out of the pipe during refueling:
>Results in premature pump shutoff
>Will reduce the effect of the fuel vapor
recovery system on the pump.
As long as the filler nozzle is used properly,
the fuel tank is full whenever the nozzle
shuts off the first time.
Closing the gas cap
1. Insert gas cap
2. Turn gas cap clockwise until it clicks
3. Close fuel filler door.
Insert the cap and turn it clockwise
until it audibly clicks.
Do not jam the strap between the gas cap
and the vehicle. The following message is
displayed if the cap is loose or missing.<
US models only:
The warning lamp
* comes on.
The gas cap is not correctly closed
or missing. Check if the gas cap is
correctly closed.
Fuel tank volume
Approx. 13.2 gallons/50 liters, of which
approx. 2.1 gallons/8 liters are reserve
capacity.
Do not drive until the fuel tank is
totally empty. Otherwise engine
operations are not guaranteed and damage
could occur.<
Fuel quality
Do not fill the tank with leaded gasoline;
otherwise the catalytic converter will be
permanently damaged.
Required fuel
Premium Unleaded Gasoline,
Minimum Octane Rating: 91.
Minimum Octane Rating corresponds to
the Anti Knock Index (AKI) and is deter-
mined according to the so-called (R+M)/
2method.

117
OVERVIEW REPAIRSOPERATIONCONTROLS DATA INDEX
BRAKE SYSTEM
Brake fluid level
The warning lamp comes on
although the parking brake is
released:
The brake fluid level in the reservoir is too
low, refer to page16. At the same time,
brake pedal travel may become signifi-
cantly longer.
Have the system checked immediately.
If the brake fluid level is too low and brake
pedal travel has become longer, there may
be a defect in one of the brake system's
hydraulic circuits.
Display of the malfunction
described above in Canadian mod-
els.
If you continue driving, higher brake
application pressure may be neces-
sary, and there may be a slight pull to one
side. Brake pedal travel may also be longer.
Please remember to adapt your driving
style accordingly.<
Brake pads
Brake pad sensors in the left brake pads of
the front axle and in the right brake pads of
the rear axle monitor the brake pad condi-
tion. When the brake pads reach the wear
limit, the brake wear warning lights up,
refer to page18.
Use brake pads which the manufac-
turer of your MINI has approved for
your particular vehicle model. The manu-
facturer of your MINI cannot evaluate non-
approved brake pads to determine if they
are suitable for use, and therefore cannot
ensure the operating safety of the vehicle
in the event of their use.<

118
MINI MAINTENANCE SYSTEM
The MINI maintenance system helps main-
tain your vehicle's road safety and opera-
tional safety.
Please bear in mind that regular mainte-
nance is not only necessary for the safety of
your vehicle, but also plays a significant
role in maintaining the resale value of the
vehicle.
Service interval display
While conventional systems specify main-
tenance according to fixed distances
driven, the MINI Maintenance System takes
account of the operating conditions of the
vehicle, for distances can be driven in many
different ways:
60,000 miles/100,000 km short distance
operation can not be equated with
60,000 miles/100,000 km long distance
operation from a maintenance standpoint.
The condition-based MINI Maintenance
System includes the Engine Oil Service and
Inspections I and II.
Determining the maintenance intervals
according to the actual use of the vehicle
covers every kind of operating situation.
People who drive very little, i.e. much less
than 6,000 miles/10,000 km per year,
should have the engine oil changed at least
every 2 years since oil deteriorates over
time, regardless of use.
For more information on the service inter-
val display, refer to page68.
Service and Warranty Information
Booklet for US models, Warranty and
Service Guide Booklet for Canadian
models
For additional information on maintenance
intervals and procedures, please refer to
the Service and Warranty Information
Booklet for US models or the Warranty and
Service Guide Booklet for Canadian models.
As a precaution against rust, it is advisable
to have the body checked for damage from
rocks or gravel at the same time, depending
upon operating conditions.
The manufacturer of your MINI rec-
ommends having maintenance and
repair work carried out only by a MINI
Dealer or a workshop that has specially
trained personnel working in accordance
with the specifications of the MINI manu-
facturer.
Make sure that maintenance work is con-
firmed with an entry in the Service and
Warranty Information Booklet for
US models or the Warranty and Service
Guide Booklet for Canadian models. These
entries are your proof that the vehicle has
received regular maintenance.<

119
OVERVIEW REPAIRSOPERATIONCONTROLS DATA INDEX
SOCKET FOR ONBOARD DIAGNOSTICS OBD CARING FOR YOUR VEHICLE
Primary components of exhaust emissions
can be checked by a device via the OBD
socket.
This socket is located to the left of the
driver's side, on the bottom of the instru-
ment panel underneath a cover.
Exhaust emission values
The warning lamp comes on. The
exhaust emissions have deterio-
rated. Have the vehicle checked as
soon as possible.
Display of the malfunction
described above in Canadian mod-
els.
Under some circumstances, the lamp will
flash. This indicates severe engine misfir-
ing. In this case, you should reduce your
speed and visit your nearest MINI Dealer as
soon as possible. Severe engine misfiring
can quickly lead to serious damage of emis-
sions-related components, especially the
catalytic converter.
If the fuel filler cap is not properly
tightened, the OBD system may con-
clude that fuel vapors are escaping, causing
an indicator to light up. If the filler cap is
then tightened, the indicator should go out
within a few days. Use the cleaning and car-care prod-
ucts available at your MINI Dealer.<
Washing your vehicle
You can wash your new MINI or MINI Con-
vertible in automatic car washes from the
beginning. Preference should be for cloth
car washes. If, due to lack of availability,
brush car washes must be used, modern
systems with soft brushes should be given
preference.
When using steam cleaners or high-
pressure cleaners, maintain sufficient
distance to the vehicle and do not exceed a
maximum temperature of 1407/606. If
the jet is too close or the pressure is too
high, this can lead to damage or initial
damage that can develop into more serious
damage. Water that enters vehicle compo-
nents can lead to damage over the long
term.
After washing the vehicle, apply the brakes
briefly to dry them, otherwise water can
reduce braking efficiency over the short
term and the brake rotors can corrode.
Switch the rain sensor off when passing
through an automatic car wash, refer to
page62. Failure to do so could result in

120
CARING FOR YOUR VEHICLE
damage caused by undesired wiper activa-
tion.<
Rod antenna
If necessary, for example before
entering a car wash or a garage with
elevator ramp, remove the rod antenna.
To do so, grip the rod antenna at the base
and unscrew it from the antenna foot by
turning it to the left.<
Headlamps
When cleaning the headlamps,
please observe the following: do not
rub them dry, and never use abrasives or
strong solvents. Remove dirt and contami-
nation, such as insects, by soaking with
shampoo and then rinsing with plenty of
water. Always use a deicer spray to remove
accumulated ice and snow; never use a
scraper.<
Vehicle paintwork
Regular care contributes greatly to driving
safety and value retention.
Environmental influences varying from one
region to the next can affect the vehicle
paintwork. Please base the frequency and
scope of car care on these various influ-
ences.
Care of upholstery
Depressions that come about on the uphol-
stery material of the seats in daily use can
be brushed out using a slightly damp brush
against the grain.
The fact that velour lays down is not a qual-
ity defect, but rather is inevitable in the
case of home textiles or clothing materials.
In the case of strong sunlight and longer
parking periods, cover the seats or all win-
dows to prevent discoloration.
Care of special parts
>Light-alloy wheels*:
Use wheel cleaner especially during the
winter months, but do not use any
aggressive, acidic, strong alkali or rough
cleansers or steam jets above 1407/
606. Observe the manufacturer's
instructions
>Chrome parts
* such as bonnet grill, door
handles, etc.:
Especially if exposed to road salt, care-
fully clean these parts with plenty of
water and possibly with a shampoo addi-
tive. For additional treatment, use
chrome polish
>Rubber parts:
Treat only with water or rubber care
products.
Do not use silicon sprays or other
silicon-containing care products,
otherwise noise and damage could
occur.<
>Plastic parts, imitation leather surfaces,
headliner, lamp glass, covering glass for
the display elements, as well as matt
black molded parts:
Clean with water and, if necessary, plas-
tic care products. Do not dampen seats
and the headliner.
Never use solvents such as lacquer thin-

137
OVERVIEW REPAIRSOPERATION CONTROLS DATA INDEX
MINI MOBILITY SYSTEM*
If an air pressure of 26 psi/180 kPa
cannot be reached, unscrew the
hose 1 and drive back and forth
about 33 ft/10 m so that the liquid seal-
ant is distributed in the tire. Afterwards
repeat the procedure.
If an air pressure of 26 psi/180 kPa is still
not reached, the tire is too badly dam-
aged. Please contact the nearest MINI
Dealer.<
5. Turn off compressor 2
6. Unscrew hose 1 from the tire valve
7. Store the MINI Mobility System back in
the vehicle.
The instructions for using the MINI
Mobility System are also given on the
equipment.<
Distributing liquid sealant
Immediately drive for approx. 10 minutes,
so that the liquid sealant is uniformly dis-
tributed.
Do not exceed a speed of 40 mph /
60 km/h.
If possible do not drive at a speed lower
than 10 mph / 20 km/h.<
Checking tire inflation pressure
1. After driving for approx. 10 minutes, pull
over at a suitable location
2. Screw hose with manometer back onto
the tire valve
3. Check the tire inflation pressures.
The tire inflation pressure must be
at least 18 psi/130 kPa. If it is not,
do not continue driving.<
If 18 psi/130 kPa are displayed:
4. Ignition key position 1:
Turn on compressor 2. Correct the tire
inflation pressure to the specified value,
refer to the tire inflation pressure table
on page102
5. Replace the tire as soon as possible.
The use of the MINI Mobility System
may be ineffective with tire damage
larger than approx. 1/6 in/4 mm. Please
contact the nearest MINI Dealer if the tire
cannot be made drivable with the MINI
Mobility System.<
Driving on
Do not exceed the permitted maxi-
mum speed of 50 mph / 80 km/h;
otherwise an accident could happen.<
Replace the defective tire as soon as
possible and have the new wheel/tire
assembly balanced. Have the MINI Mobility
System refilled.<
Tire change set
When changing a tire, always observe the
safety measures and the procedure for
changing tires starting on page131.
In case of a flat tire the tire change
set is not needed due to the availabil-
ity of the MINI Mobility System.<

EVERYTHING FROM A TO Z
156
Convertible top35
care121
convenience operation37
electrical malfunction38
emergency closing38
malfunction38
Coolant115
indicator lamp16
level116
temperature gauge67
Coolant temperature gauge67
Cooling function
air conditioning system79
automatic climate control82
Cooling system, refer to
Capacities151
Cooling, refer to Air
conditioning82
Cooling, refer to Cooling
function79
Copyright2
Cornering Brake Control (CBC)
warning lamp17
Correct tires105
Cosmetic mirror, refer to
Illuminated vanity mirror48
Cruise control64
buttons on the steering
wheel20
indicator lamp19 Cup holders, refer to Beverage
holders85
Curb weight, refer to
Weights149,150
Current fuel consumption70
setting units70
Cylinders, refer to Engine
data146
D
Daily odometer, refer to Trip
odometer66
Dashboard lighting, refer to
Instrument lighting61
Dashboard, refer to Cockpit12
Data
capacities151
dimensions147
engine146
technical146
weights149
Date of the Owner's Manual7
Daytime driving lamps60
Deep water, refer to Driving
through water98
Defrost setting, refer to
Defrosting and demisting
windows80,83 Defrosting and demisting
windows
air conditioning system80
automatic climate control83
Defrosting front windows, refer
to Defrosting and demisting
windows80,83
Defrosting windows80,83
air conditioning system79
automatic climate control82
Defrosting windshield, refer to
Defrosting and demisting
windows80,83
Demisting windows80,83
Digital clock66
Dimensions147,148
Dimming interior rearview
mirror96
Dipstick, engine oil114
Directional turn signal,
refer to Turn signal
indicators60
Disc brakes97
Displacement, refer to Engine
data146
Display elements13
with navigation system or
Cockpit Chrono Pack14
Display lighting, refer to
Instrument lighting61 Disposal
vehicle battery138
Distance covered, refer to
Odometer66
Distance warning, refer to Park
Distance Control (PDC)77
Door keys24
Door lock27
Doors, locking and unlocking
acknowledgment
signals26,27
from inside28
from outside26
DOT quality grades105
Draft-free ventilation80,83
Drink holders, refer to Beverage
holders85
Driving downhill97
Driving hints, refer to Driving
notes96
Driving lamps, refer to Parking
lamps/Low beams59
Driving notes96
Driving stability control
systems71
Dry air, refer to Cooling
function79,82
Drying air,
refer to Cooling
function79,82

EVERYTHING FROM A TO Z
158
Fuel filler door99
unlocking in the event of
electrical malfunction100
Fuel tank capacity151
Fuses139
G
Garage door opener, refer to
Integrated universal remote
control86
Gas, refer to Average
consumption70
Gas, refer to Fuel quality99
Gasoline gauge, refer to Fuel
gauge66,67
Gasoline, refer to Fuel
quality99
Gear indicator, for automatic
transmission with
Steptronic57
Gear shifts, automatic
transmission with
Steptronic56
Gearshift lever
automatic transmission with
Steptronic56
manual transmission55
General driving notes96 Glass sunroof, electric33
convenience operation27
opening and closing in the
event of an electrical
malfunction34
remote control26
Glove compartment84
Gross weight, refer to
Weights149,150
H
Handbrake, refer to Parking
brake54
Hazard warning flashers12
Head airbags75
Head restraints44
Headlamp flasher60
indicator lamp19
Headlamp washer reservoir63
capacity, refer to
Capacities151
Headlamp washer system
cleaning headlamps63
washer fluid63
Headlamps
bulb replacement128
care120
Heated mirrors48
Heated rear window
air conditioning system79
automatic climate control82 Heating78
exterior mirrors48
rear window79,82
seats47
windshield79,82
Heavy load, refer to Loading92
Height adjustment
seats43
steering wheel47
Height, refer to
Dimensions147,148
High beams60
bulb replacement128
headlamp flasher60
indicator lamp19
High Performance Synthetic
Oil, refer to Engine oil115
capacity151
recommended oils115
specified oils115
Holders for beverages85
Horn12
Hot exhaust system98
Hydraulic brake117
Hydroplaning
97
I
Ignition53
Ignition key24
Ignition key positions, refer to
Ignition lock53 Ignition lock53
Illuminated vanity mirror48
Imitation leather120
Imprint2
Index154
Indicator and warning lamps,
overview16
Indicator/warning lamp
airbags76
ASC72
brakes117
coolant temperature67
DSC72
fasten safety belts46
Flat Tire Monitor74
fog lamps61
reserve fuel capacity66,67
Individual air distribution83
Individual settings, refer to
Vehicle Memory49
Inflation pressure monitor,
refer to Flat Tire Monitor73
Inflation pressure, refer to Tire
inflation pressure101
Inspection68
Instrument cluster, refer to
Display elements13
Instrument lighting61
Instrument panel, refer to
Cockpit12

EVERYTHING FROM A TO Z
159
OVERVIEW REPAIRS OPERATION CONTROLS DATA INDEX
Integrated universal remote
control86
Interior lamp, remote
control26
Interior lamps61
Interior rearview mirror48
automatic dimming96
Interlock, refer to Steering
locked53
Intermittent operation of the
wipers62
Interval
display, service118
J
Jack131,135
points134
Jack, refer to Tire change set
MINI Mobility System135
Run Flat tires108
space-saver spare tire131
Jacking points134
Jets, refer to Ventilation80,83
Jets, refer to Windshield
washer jets63
John Cooper Works Kit146
Jump-starting140
K
Keys24
Kickdown57 Knock control99
L
Lamp defect127
Lamp replacement, refer to
Lamps and bulbs127
Lamps and bulbs127
Lamps, refer to Parking lamps/
Low beams59
Lashing eyelets, refer to
Securing the load92
LATCH child-restraint fixing
system52

Leather care121
LEDs light-emitting diodes130
Length, refer to
Dimensions147,148
License plate lamp, bulb
replacement130
Lifting handle, space-saver
spare tire131
Light switch59
Light-alloy wheels, care120
Light-emitting diodes
(LEDs)130
Lighter85
Lighting of the instruments61
Lights on warning60
Load securing devices, refer to
Securing the load92
Loading the vehicle90 Loads, refer to Loading cargo90
Locking
from inside28
from outside26
Locking/unlocking the vehicle,
acknowledgment
signals26,27
Low beams59
bulb replacement128
Lower back support, refer to
Lumbar support44
Luggage compartment
cover88
emergency operation, refer
to Manual release30
expanding88
lid, refer to Tailgate29
opening from the outside29
opening with the remote
control26
opening/closing, refer to
Tailgate29
volume149,
150
Luggage compartment in the
MINI88
Luggage compartment lid
emergency operation, refer
to Manual release30
opening with the remote
control26 Luggage compartment lid, refer
to Tailgate29
Luggage compartment net92
Luggage rack, refer to Roof-
mounted luggage rack93
Lumbar support44
M
M+S tires, refer to Winter
tires110
Maintenance system118
Maintenance, refer to Service
and Warranty Information
Booklet for US models,
Warranty and Service Guide
Booklet for Canadian
models118
Make-up mirror, illuminated48
Malfunction
automatic transmission with
Steptronic58
convertible top38
door lock27
fuel filler door100
glass sunroof, electric34
tailgate30
Manual air distribution79

EVERYTHING FROM A TO Z
160
Manual operation
door lock27
driver's door27
fuel filler door100
glass sunroof, electric34
power convertible top38
tailgate30
transmission lock, automatic
transmission with
Steptronic56
Manual transmission55
Master keys with remote
control24
Maximum cooling82
Maximum speed, with winter
tires110
MC operation, refer to
Owner's Manual for Radio
Mechanical keys, refer to
Master keys24
Memory, refer to Vehicle
Memory49
Microfilter
air conditioning system80
automatic climate control83
MINI Maintenance System118
MINI manufacturer6
MINI Mobility System135
compressor136
liquid sealant136 Mirrors48
heating48
Mobile telephone, refer to
separate Owner's Manual
Mobility System135
Modifications, technical, refer
to For your own safety7
Multifunction steering
wheel20
Multifunction steering wheel,
refer to Buttons on the
steering wheel20
Multifunction switch
turn signal indicator/
headlamp flasher60
washer/wiper system62

N
Navigation system, refer to
separate Owner's Manual
Neck restraints, refer to Head
restraints44
New tires109
Non-smoker's equipment
package, refer to Cigarette
lighter socket85
Nylon rope, refer to Towing and
tow-starting142
O
OBD interface socket119 Octane number, refer to Fuel
quality99
Odometer66
Oil
additives, refer to Adding
engine oil115
capacity151
dipstick114
Oil change intervals, refer to
Service and Warranty
Information Booklet for US
models, Warranty and
Service Guide Booklet for
Canadian models
Oil consumption114
Oil filter change151
Oil level114
indicator lamp16
Oil pressure, indicator lamp16
Oil service68
Onboard computer69
Onboard tool kit126
MINI Mobility System135
Run Flat tires126
space-saver spare tire131
Opening and closing
from inside28
from outside25
via remote control26
via the door lock27 Outlets, refer to
Ventilation78,81
Outside air79

air conditioning system79
Outside air mode, automatic
climate control82
Outside temperature
display69
changing units69
in the onboard computer69
P
Paintwork care, refer to Vehicle
paintwork120
Park Distance Control (PDC)77
Parking
the vehicle98
Parking aid, refer to Park
Distance Control (PDC)77
Parking brake54
warning lamp17
Parking lamps59
bulb replacement128
Parking lamps/Low beams59
Parking lock, refer to
PParking56
Parts and accessories, refer to
Your individual vehicle6
Pathway lighting59
PDC Park Distance Control77
Plastic120