water pump MITSUBISHI GALANT 1989 Service Owner's Guide

14-18COOLING - Water Pump
Quality canvas Core wire
\\Adhesive rubber
\Rib rubberlCOO29
W
ater pump
J--iLi+
O-ring
W

ater pipe
I I
SERVICE POINTS OF REMOVALMl4MCAK
2. REMOVAL OF ENGINE MOUNT BRACKET
(1) Place a wooden block at the oil pan part of the engine, and
then jack up the vehicle.
Caution
Jack up carefully,
so as not to apply a load to each part.
(2) Remove the engine mount bracket.
5. REMOVAL OF DRIVE BELT Before removing the V-ribbed belt, loosen the water pump
pulley installation bolt.
INSPECTION
V-RIBBED BELT
M14MDAG
Check following items and replace if faulty.
l Check belt surface for damage, peeling or cracks.
l Check belt surface for oil or grease.
l Check belt rubber for wear or brittleness.
l Check the pulleys for cracks or damage.
WATER PUMP
lCheck each part for cracks, damage or wear, and replace
the water pump assembly if necessary.
l Check the bearing for damage, abnormal noise and sluggish rotation, and replace the water pump assembly if
necessary.
lCheck the seal unit for leaks, and replace the water pump
assembly if necessary.
lCheck for water leakage. If water leaks from hole “A”, seal
unit is leaking. Replace as an assembly.
SERVICE POINTS OF INSTALLATION
Ml4MEAm
26. INSTALLATION OF O-RING Insert the O-ring to the water inlet pipe, and coat the outer
circumference of the O-ring with water. By coating with water, the insertion to the water pump will
become easier.
Caution
1.Care must be taken not to permit engine oil or other
greases to adhere to the O-ring.
2.When inserting the pipe, check to be sure that there is no sand, dirt, etc. on its inner surface.
1 TSB Revision

COOLING - Water Pump 14-19
Identification mark

504A0046
< 1993 models>
Generator brace
6c00010
24.lNSTALLATlON OF WATER PUMP
(1) Clean both gasket
surfaces of water pump body and
cylinder block.
(2) Install new water pump gasket and water pump assembly and tighten the bolts.

No.IdentificationBolt diameter (d)Torque
mark x length
(C) mm (in.)
Nm (ftlbs.)
148 x20(31x.79)12-15
(g-10)
248x
30(.31x1.18)
3 7 8 x65(.31x
2.56)20-27(15-19)
47 8 x65(.31x
2.56)
TSB Revision1
548 x30(31x1.18)12-15 (9-10)
< 1993
models>
No.Identification Bolt diameter(d)markx length (4) mm (in.)N~i-.“s.)
148 x 14 (.31x 55)
24
8 x 22 (.31x .87)12-15(9-10)
348 x 25 (.31x .98)
4
78 x 65 (31x 2.56) 20-27
(15-19)
548 x 22 (.31x .87)12-15(9-10)

14-20COOLING - Water Pump
WATER PUMP
M14ME6
REMOVAL AND INSTALLATIONw.I50-65 Nm
(Refer to GROUP 00-Maintenance
Post-installation Operation*Installation of the Under Cover
*Supplying of the Engine Coolant (Refer to GROUP
00-MaintenanceService.)aEngine Adjustment(Refer to GROUP 11-ServiceAdjustment Procedures.)
30-40 Nm
22-29 ft.lbs. 12-19

ft.lbs.
OlA0308
20-27 Nm14-20 ft.lbs./
8-10 Nm6-7 ftlbs.
IO-12 Nm
7-9 ft.lbs.
b..
43-55 Nm31-40 ft.lbs.
v&l-30 Nm23-27 Nm 14-22

ftlbs. 17-20
ft.lbs.OlA0113
Removal steps
1. Clamp part of hoses (Power steering and
air conditioning)
2. Engine mount bracket (Refer to P.14-18.)3. Drive belt (Refer to GROUP OO-Maintenance Service.)4. Drive belt (Power steeringj (Refer to GROUP 00-Maintenance Service.)
5. Tension pullev bracket
6. Drive belt (Air conditioning) (Refer to
10. Timing belt upper cover (Refer to GROUP
11 -Timing Belt.)
11. Timing belt lower cover (Refer to GROUP11 -Timing Belt.)12. Automatic tensioner (Refer to GROUP11 -Timing Belt.)
13. Tensioner pulley
14. Timing belt (Refer to GROUP 11 -Timing
Belt B.)
GROUP 00-Maintenance Service.)
7. Water pump pulley
8. Water pump pulley (Power steering)
9. Crankshaft pulley
1 TSB RevisionI

COOLING- Water Pump 14-21
15. Crankshaft sprocket
15. Crankshaft sprocket16. Flange (Refer to GROUP 11 -Timing Belt
16. Flange (Refer to GROUP 11 -Timing Belt
B.)B.)17. Timing belt B tensioner
17. Timing belt B tensioner18. Timing belt B (Refer to GROUPII-Timing Belt B.)
19. Generator brace*4 20. Water pump.,.
21. Water pump gasketC.’
22. O-ring (Refer to P.14-18.).‘* .
18. Timing belt B (Refer to GROUPll-Timing Belt B.)
19. Generator brace*4 20. Water pump.,.
21. Water pump gasketC.’
22. O-ring (Refer to P.14-18.).‘* 1
TSB RevisionTSB Revision
20-27 14-20
olAol4

14-22COOLING - Water Pump
ldeniification mark
Generator brace INSPECTION
V-RIBBED BELT Refer to
P.14-18.
Ml4mDAN
WATER PUMP
0Check each part for cracks, damage or wear, and replace
the water pump assembly if necessary.
l Check the bearing for damage, abnormal noise and
sluggish rotation, and replace the water pump assembly ifnecessary.
l Check the seal unit for leaks, and replace the water pump
assembly if necessary.
l Check for water leakage.
SERVICE POINTS OF INSTALLATION
MMMEAU
20. INSTALLATION OF WATER PUMP
(1) Clean both gasket surfaces of water pump body and cylinder block.
(2) Install new water pump gasket and water pump assembly and tighten the bolts.
No, identification Bolt diameter (d)mark x length (4) mm (in.)NmT”iptK.)
148 x 14 (.31 x ,551
248 x 22 (.31
x ,87112-15 (9-10)
348
x 30 t.31 x 1.18)
478x
65(.31 x2.56)20-27(15-l 9)
5
48 x28(.31
x1.10)12-15
(9-10)
TSB Revision

17-28EMISSION CONTROL SYSTEMS -Exhaust Gas Recirculation (EGR) Svstem
n
7@
REMOVAL
(1) When removing the thermal vacuum valve, do not use
wrenches or other tools on the resin part.
(2) When disconnecting the vacuum hose, put a mark on thehose so that it may be reconnected at original position.
INSTALLATION
(1) Apply specified sealant to the threads of thermal vacuumvalve and tighten to specified torque. When installing the
thermal vacuum valve, do not use wrenches or other tools
on the resin part.
Specified sealant: 3M
NUT Locking Part
No.4171 or equivalent
Specified torque:
20-40 Nm (15-30 ft.lbs.)
(2) Reconnect the vacuum hose as it was before.
EGR TEMPERATURE SENSOR Ml’IICZB
INSPECTION
(1) Remove the EGR temperature sensor.
(2) Place the EGR temperature sensor in water, and then
measure the resistance value between terminals 1 and 2
while increasing the water’s temperature.
Replace the EGR temperature sensor if there is a signifi-
cant deviation from the standard value.
INSTALLATION
(1) Install the EGR temperature sensor, tighten to specified
torque.
Specified tightening torque:
lo-12 Nm (7.3-8.6 ft.lbs.1
EGR SOLENOID
INSPECTION
NOTE
Ml7ICRB
When disconnecting the vacuum hose, make an identification
mark on it so that it can be reconnected to the original posi-
tion.
(1) Disconnect the vacuum hoses (yellow and green stripe)
from the solenoid valve.
(2) Disconnect the harness connector.
(3) Connect a hand vacuum pump to the nipple to which the
green-striped vacuum hose was connected.
TSB Revision

ALPHABETICAL INDEX1
A
ABS
Checking by the ABS Warnrng Light................
. 35-68-l
Troubleshooting ...........................
35-l 5-l
ABS POWER RELAY, Chec
k 35-74-l
ACCELERATOR CABLE
Inspection and Adjustment
13-398-l
Inspection and Adjustment ........ 13-329-l
ACCELERATOR SWITCH, Inspection and Adjustment 13-329-I
A/C COMPRESSOR CLUTCH RELAY
On-vehicle Inspection
.............
. 13-285-l
On-vehrcle
Inspection
.........
. 13-83-t
On-vehicle Inspection
......
. 13-176-l
ACTIVE-ECS ON-BOARD DIAGNOSTIC, Check......

. 338-88-I
ACTIVE-ECS RELAY.......................

. 338-141
-I
ACTIVE-ECS SENSOR....

.
...... ............ 338-138-I
ACTIVE-ECS SYSTEM
Checking by Using Alarm Light
.................
. 338-87-I
Operation Check ........................... 338-90-I
AERO PARTS..

.
........................... 51-18-l
AIR CLEANER...............................

. 15-9-I
AIR CLEANER ELEMENT
Inspection and Replacement
....................
. 15-6-l
Maintenance .......................... 00-39-l
AIR COMPRESSOR..........................

. 338-125-I
AIR CONDITIONING SWITCH
Emission control
...........................
.
17-21 -I
Heater, Air
Conditionrng
and Ventilation .............. 55-29-l
On-vehicle Inspection ................. 13-285-l
On-vehicle Inspection
...........
. 13-83-l
On-vehicle Inspection

..........
. 13-176-l
AIR TUBE..............

.
....................... 338-133-I
ALARM LIGHT, Check. ......................... 338-87-I
ALARM SYSTEM, Theft ..........................
54-165-11
ALIGNMENT
Front Wheel, Adjustment .......................
. 33A-5-l
Rear
Wheel, inspection ..................
. 34-23-l
Rear Wheel, Inspection
....................
. 34-5-l
ANTENNA ......................................
54-153-11
ANTI-LOCK BRAKING SYSTEM, Troubleshooting .........
.
35-15-1
ARM
Lower
......................
. 338-103-I
Lower Suspension>......................
.
33A-10-I
Lower
................... 34-28-l
Torsion
................
.
338-l 19-l
Torsion Suspension-FWD>
...................34-l 5-lTrailing
................. 34-31-l
Upper
.................. 34-28-l
AUDIO
SYSTEM................

.
.................
54-l 12-11
AUTO-CRUISE CONTROL. ..........................
. 13-408-I
AUTO-CRUISE CONTROL INDIVIDUAL PARTS, inspection..

. 13-401-I
AUTO-CRUISE CONTROL SYSTEM...................

. 13-332-l
AUTO-CRUISE CONTROL SYSTEM, Inspection..........

. 13-397-l
AUTOMATIC TRANSAXLE, Maintenance ................. 00-43-I
AXLE
Rear, Maintenance
...............................
. 00-45-I
Torsion
........................
.
338-l 19-l
Torsion .....

.
......................... 34-15-l
AXLE HUB
Rear
Disc Brakes> ...................... 27-8-l
Rear CFWD-Rear
Drum Brakes> ................... 27-6-l
AXLE SHAFT ..............................

.
27-17-1
B
BACKLASH. Total, Rear Axle, Check ............
. 27-15-l
BALL JOINT
Rotation Starting Torque Check ...................... 378-8-I
Tie Rod End, Staning Torque Check .................. 37A-15-l
Tie Rod End, Variation Check ....................... 37A-15-l
BALL JOINT SEALS, Maintenance ..................... 00-45-I
BAR
Stabilizer ....................

. 338-106-I
Stabilizer
...................
. 33A-13-l
Stabilizer Suspension-AWD>...............
. 34-37-l
BAROMETRIC PRESSURE SENSOR
On-vehicle Inspection
................
. 13-266-l
On-vehicle Inspection
13-53-l
On-vehicle Inspection
..........
. 13-154-l
BASIC IDLE SPEED
Adjustment
...........................
. 13-245-l
Adjustment
..................... 13-33-l
Adjustment
...................
. 13-133-l
BATTERY.........................................

.
54-2-11
BATTERY, Flat Remedy.
.............................
. 35-75-l
BEARING
Wheel, Adjustment ................

. 338-87-I
Wheel, Adjustment ............. 33A-5-l
BELT
Drive, Compressor, Adjustment
....................
. 55-17-l
Drive (For Water Pump and Generator), Maintenance ..... 00-41-I
Drive, Tension Adjustment ................. 11-61-I
Drive, Tension Adjustment ................. 11-12-l
Seat..........................................

. 52-39-l
Timing ...................... ......... 11-80-I
Timing................................

. 11-34-l
Timing, Maintenance ............................... 00-40-I
Timing, Tension Adjustment ................ 11-10-I
BLEEDING
Clutch
..........................................
. 21-6-l
4ws...........................................

. 370-4-I
Service Brakes. .................................. 35-57-l
Steering ........................................ 37A-22-l
BLOWER..........................................

. 55-32-l
BOOSTER
Brake
.........................................
. 35-85-l
Brake, Operating Inspection ......................... 35-54-l
BOOST METER, On-vehicle Inspection ... 13-311-l
BOOTS, Drive Shaft, Maintenance ....................... 00-45-I
BRAKE
Disc, Front
......................................
. 35-94-l
Disc, Rear.....................................

.
35-l 14-l
BRAKE BOOSTER
...................................
. 35-85-l
BRAKE BOOSTER, Operating Inspection .................. 35-54-l
BRAKE DISC
Front, Run-out Check.
.............................
. 35-63-l
Front, Run-out Correction ........................... 35-64-l
Front, Thickness Check ............................. 35-65-l
Rear, Run-out Check ............................... 35-66-l
Rear, Run-out Correction. ........................... 35-66-l
Rear, Thickness Check............................

. 35-66-l
BRAKE DRUM, tnside
Diameter, Check ................... 35-67-l
BRAKE FLUID LEVEL SENSOR, Check...................

. 35-54-l
BRAKE FLUID PRESSURE SWITCH
AWD-ABS (Up to 1991 Models)
....................
.
35-133-l
AWD-ABS
(Up to 1991 models), Check ...............
. 35-75-l
BRAKE HOSES, Maintenance ........................... 06-45-t
BRAKELINE
........................................
35-87-l

ALPHABETICAL INDEX3
DISC BRAKEFront
......................................
.
35-94-I
Rear......................................

.
35-114-l
DlSC BRAKE PADS. Marntenance.......................

.
00-44-j
DWHARGlNG
SYSTEM ......................... 55-26-l
DISJRIBUTOR..............................

.
16-55-11
DOoR
........................................
42-74-lDOOR. Fit Adjustment
..............................
. 42-51-l
DOOR DRIP LINE WEATHERSTRIP
Front.......

.
........................... 42-112-j
Rear.....................................

.
42-114-IDOOR GLASS
Adjustment
...............................
42-52-f
Front..................................
.
42-80-l
Rear ........... 42-83-I
DOOR HANDLE
Front
...........
.
........ ............ 42-96-l
Rear.
.................. ................. 42-99-l
DOOR INSIDE HANDLE, Play Check.....................

.
42-52-l
DOOR LATCH
Front
.........
.
............... ........ 42-96-l
Rear.................................

. 42-99-l
DOOR MIRROR...............................

.
51-33-1
DOOR
MOULDING
Front
....................................
.
42-112-l
Rear......................................

.
42-114-l
DOOR REGULATOR
Front
......................................
.
42-80-I
Rear...............

.
.................... 42-83-l
DOOR RUNCHANNEL..........................

.
42-l 10-l
DOOR TRIM
Front
......................................
.
42-76-l
Rear.......................................

.
42-78-i
DOOR WATERPROOF FILM
Fron

t
.................................... 42-76-l
Rear........................................

.
42-78-l
DRIVE BELT
Compressor, Adjustment
....................
.
55-17-l
Tension Adjustment ..................... 11-61-l
Tension Adjustment ...................... 11-12-I
Water Pump and Generator, Maintenance ..............
00-41 -IDRIVE SHAFTFront Axle
.....................................
. 26-12-l
Rear
Axle

............................
. 27-20-I
DRIVE SHAFT BOOTS, Maintenance....................

.
00-45-j
DRIVE SHAFT OIL SEALSReplacement
...........................
.
23-92-I
Replacement
.......................
.
22-18-l
Replacement
........................
.
22-4-l
DRUMBrake, inside Diameter, Check
......................
.
35-67-j
Brake,
Rear..............................
.
..... 35-108-l
DRUM BRAKE, Rear
................................
.
35-108-1
DRUM BRAKE LININGS, Rear, Maintenance
..............
.
06-44-j
DRYER........................................

.
33B-127-l
E
EGR SOLENOID Emission Control
.................................
.
17-28-j
On-vehicle
Inspection ................. 13-307-j
On-vehicle
Inspection

..I........
.
13-101-t
On-vehicle
Inspection

..........
.
13-191-l
EGR SYSTEM

speccon
..........................
.
17-25-j inspection

...........................
.
17-25-1
EGR TEMPERATURE SENSOR
Emission Control
................................
.
17-28-l
On-vehicle Inspection .................. 13-288-l
On-vehicle Inspection

13-85-l
On-vehicle
Inspection
..........
.
13-177-l
EGRVALVE........................................

.
17-27-f
EGR VALVE CONTROL VACUUM
.......................
.
17-26-l
ELECTRONIC CONTROL UNIT
35-134-jELEMENT
Air Cleaner. Inspection
and Replacement ................ 15-6-l
Air Cleaner, Maintenance ........................... go-39-j
END PLAY
Hub.
Inspection
................
.
33B-86-l
Hub. Inspection
...................
.
26-5-l
Rear. Wheel Bearing, Adjustment
...........
.
27-3-l
Rear Wheel Bearing. Check
...............
.
27-15-i
ENGINE
DOHC
.......................................
.
11-63-l
SOHC.......................................

.
11-14-1
ENGINE CONTROL................................

.
13-328-l
ENGINE CONTROL MODULE POWER GROUND
On-vehicle Inspectron
..................
.
13-257-l
On-vehicle Inspection
............
.
13-45-l
On-vehicle Inspection
..........
.
13-146-1
ENGINE CONTROL MODULE TERMINAL VOLTAGE
On-vehicle Inspection ..................
.
13-315-I
On-vehicle Inspection
........... 13-105-I
On-vehicle Inspection

..........
.
13-192-l
ENGINE COOLANT
Concentration Test
....
.
............................
14-8-l LeakCheck
....................................... 14-8-l
Maintenance ..................................... 00-44-I
Replacement ..............................
,......
.
14-8-I
ENGINE COOLANT TEMPERATURE GAUGE UNIT.........

. 14-31-l
ENGINE COOLANT TEMPERATURE SENSOR
Cooling
........................................
. 14-31-I
Emission Control .................................. 17-21-l
On-vehicle Inspection ................... 13-268-l
On-vehicle Inspection
............
.
13-55-j
On-vehicle Inspection
..........
.
13-155-l
ENGINE COOLANT TEMPERATURE SWITCH
Cooling........................................
. 14-31-I
Heater, Air Conditioning and Ventilation ......... 55-57-l
ENGINE MOUNTING..................................

.
32-4-l
ENGINE OILCheck
................................
.
11-57-j
Check.................................

. 11-7-l
Maintenance .....................................
00-41-1
ENGINE OIL FILTER, Maintenance ......................
.
60-41-j
ENGINE RPLL
STOPPER..............................
.
32-6-j
EPS CONTROL UNIT................................

.
37A-59-l
EPS MODE SELECTOR SWITCH.......................

.
37A-59-j
EpS SOLENOID, Check
..............................
.
37A-19-j
EVAPORATIVE EMISSION CANISTER...................

.
77-21-j
EVAPORATIVE EMISSION CONTROL SYSTEM............

.
17-15-l
EVAPORATIVE EMISSION PURGE SOLENOIDEmission Control
.................................
.
17-21-1
On-vehicle
Inspection ..................
, 13-307-I
On-vehicle
Inspection

............
.
13-99-1
On-v&i&
inspection

........... 13-189-j
EVAPORATOR....

.
................................ 55-34-f
EXHAUST GAS RECIRCULATION (EGR) SYSTEM..........

.
17-22-I
EXHAUST MANIFOLD
DOHC-Non-Turbo................................
.
15-30-1

4ALPHABETICAL INDEX
DOHC-Turbo.................................
. 15-31-f
SOHC-8VALVE..................................

.
15-27-t
SOHC-1 GVALVE............................

.
15-28-l
EXHAUST PIPEDOH

C
......................... 15-33-I
SOHC.....................................

.
15-32-l
EXHAUST SYSTEM, Maintenance ..................... 00-45-I
F
FAN MOTOR
Condenser
.............................
.
55-48-l
Radiator...................

.
......... 14-12-I
FEEDER CABLE ..........................
54-l 55-11FENDER................................
.
42-61-t
FILLER DOOR, Fuel Tank.........................

.
42-60-I
FILLER TUBE CAP, Fuel Tank, Inspection...............

.
17-21 -I
FILTER
Engine 011. Maintenance ....................
. 00-41-I
Fuel ........................... 13-327-l
Fuel
....
.
...................
13-I 15-lFuel ........................
.
13-195
FITTINGS, Handling................................
. 55-22-l
FIXED SAS
Adjustment
........................
.
13-250-I
Adjustment
...................
.
13-138-I
FLAT BATTERY, Remedy............................

.
35-75-l
FLOOR CONSOLE................................

.
52-29-l
FLUID
Power Steering, Level Check
...................
. 37A-21-l
Power Steering, Replacement ................. 37A-21-l
Transaxle, Replacement ..................... 23-82-l
FLUID LEVEL, Transaxle, Inspection .................. 23-82-l
FOG LIGHT................

.
......................
54-94-11FOG LIGHT SWITCH................................
.
54-99-114WS, Function Check
..........................
. 37B-6-l
FRONT BRAKE DISC
Run-out Check
...................................
. 35-63-I
Run-out Correction ........................... 35-64-l
Thickness Check .............................. 35-65-l
FRONT DISC BRAKE.................................

. 35-94-l
FRONT DISC BRAKE PAD, Check and Replacement ......... 35-59-l
FRONT DOOR DRIP LINE WEATHERSTRIP 42-112-I
FRONT DOOR GLASS...............................

. 42-80-l
FRONT DOOR HANDLE.........................

. 42-96-l
FRONT DOOR LATCH...

.
......... .......... 42-96-l
FRONT DOOR
MOULDING
........................... 42-112-I
FRONT DOOR REGULATOR........................

. 42-80-I
FRONT DOOR TRIM.................................

. 42-76-l
FRONT DOOR WATERPROOF FILM....................

. 42-76-l
FRONT GRILLE..................................

. 51-12-l
FRONT SEAT,...................................

. 52-35-l
FRONT WHEEL ALIGNMENT Adjustment
.....................
. 338-86-I
Adjustment .................... 33A-5-l
FUEL FILTER
DOHC
.......................................
. 13-327-I
SOHC-8VALVE
.................................
13-l 15-l SOHC-IGVALVE
................................ 13-195-I
FUEL HOSES, Maintenance ............................
00-39-1
FUEL LINE
DOHC-AWD ..................................
.
13-326-l
DOHC-FWD....................................

.
13-324-l
SOHC-8VALVE
................................. 13-113-l
SOHC-1 ~VALVE............................

.
13-l 95-IFUEL PRESSURE
On-vehicle Inspection
On-vehicle Inspection

On-vehicle Inspection
FUEL PRESSURE SOLENOID ,
On-vehicle Inspection >
FUEL PUMP
On-vehicle Inspection
On-vehicle Inspection

On-vehicle Inspection
FUEL SYSTEM, Maintenanc

e
FUEL TANK
DOHC-AWD .,.......
DOHC-FW

D
SOHC-8VALVE
SOHC-16VALVE
FUEL TANK FILLER DOO

R
FUEL TANK FILLER TUBE CAP, Inspection
FUEL TANK PRESSURE CONTROL VALVE. 13-312-l
13-102-I
,.....13-I
92-l
13-307-I
......
13-258-l
....... 13-46-l
...... 13-147-l
....... 00-39-l
......
13-322-l
...... 13-318-l
..... 13-109-I
...... 13-195-I
....... 42-60-I
....... 17-21-I
....... 17-21-l
G
GARNISHES
51-13-l
GASKET
Cylinder Head 1 l-73-l
Cylinder Head 1 l-25-l
GAUGE UNIT, Engine Coolant Temperature
14-31-l
GEAR BOX, Power Steering 37A-32-l
GEAR OIL, Level Check
27-15-l
GENERATOR
16-g-11
GLASS
Door, Adjustmen
t
42-52-l
Door, Front 42-80-I
Door, Rear 42-83-l
Quarter Window 42-70-I
Window.............
.._......_...... 42-63-i
Window,Rear
42-72-i
GRILLE,Front
_. _. _.
51-12-l
G-SENSOR
Service Brakes
35-132-l
Output Voltage, Check 336-96-l
H
HANDLE
Door, Front
..........................
.
Door,Rear
...........................
Door Inside, Play Check. ..................
HAZARD SWITCH.........................
.
HEADLIGHTS............................

.
HEADLINING.............................

.
HEATED OXYGEN SENSOR, On-vehicle Inspection
>
...............................
HEATER CONTROL.......................
.
HEATER UNIT............................

.
HEIGHT SENSOR.........................

.
HIGH MOUNTED STOP LIGHT...............

.
42-96-1 42-99-l
42-52-l
54-98-11
54-92-11
52-31-l
13-290-I
55-25-l
55-30-I
338-l
35-l
54-96-11HIGH PRESSURE SWITCH (HIGH-PRESSURE TANK SIDE),Actuation Pressure Check. 338-94-I
16-42-11
42-55-l
42-50-I
54-l 03-11
54-105-11
HIGH TENSION CABLE, Spark Test
HOOD .__...._..._......__._...................
HOOD, Alignment Adjustment .
HOR

N
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . HORNRELAY

._.._._....___.........__.._._..___
HOSE
Brake, Maintenance
.
00-45-I

6ALPHABETICAL INDEX
LOW PRESSURE SWITCH (LOW-PRESSURE TANK SIDE)
Actuation Pressure Check
.
M
MAIN MUFFLER
DOH
C
SOHC
MANIFOLD
Exhaust
Exhaust >
Exhaust

Exhaust
Intake >
Intake

Intake 1
Vacuum Inspection
Vacuum Inspection
MANUAL TRANSAXLE
AWD
FW
D
Maintenance
MASTER CYLINDER
Clutch
Service Brakes.
METER, Boost, On-vehrcle
Inspectron
METERS AND GAUGES
MIRROR, Door
MIRROR SWITCH. Remote Controlled
MIXTURE CONTROL [MFI) SYSTEM : : : : : :
MODE SELECTOR SWITCH EPS
MOTOR 15-30-I
15-31 -I
15-27-l
15-28-l
15-21-l
15-14-l
15-18-l
11-60-I
11-9-l
22-l 5-l
22-2-i
00-42-l
21-12-l
35-81 -I
13-311-I
54-8-11
51-33-l
51-34-l
17-29-l
37A-59-l
Idle Arr Control (DC Motor), On-vehicle Inspection
Idle Air Control (Stepper Motor), On-vehicle Inspection
>
Idle Speed Control (DC Motor),
6n-vehicle
Inspection
Starte
r
MOULDING
Door. Front
Door. Rear
Exterio
r
MOUNTING 42-112-l
42-1 14-l
51-15-l
Engine.
,,,.....
Transaxl
e
MUFFLER
Main
Main
> 32-4-l
32-5-l
15-33-l
15-32-I
N
NOISE. Compressor, Adjustmen

t
NORMAL VEHICLE HEIGHT, Check and Adjustment
OIL 55-23-l
338-88-I
0
Engine. Check
Engine. Check
1 : : 1 : 1
Engine, Maintenance.
.
Transaxle. Replacement

Transaxle. Replacement
Transfer. Replacemen
t
OIL COOLER HOSES, Transaxle
OIL FILTER, Engine, Maintenance. 11-57-l
11-7-l
00-41-I
22-18-l
22-4-l
23-82-l
23-l
00-l
00-41 -I338-95-I
15-33-l
15-32-l
13-l
84-l
13-298-l
13-93-l
16-19-f
OIL LEVEL
Gear, Check ............................
.
27-l 5-f
Transaxle, Inspection ....................

. 22-17-l
Transaxle, Inspection
......................
. 22-4-l
Transfer, Inspection ............................... 23-82-l
OIL LINE, Rear. .............. ..................... 378-13-I
OIL PAN
DOHC.....................................
. 11-71-l
SOHC......

.
.................................. 11-23-l
OIL PRESSURE SWITCH, Power Steering. Check ........... 37A-24-l
OIL PUMP Power Steering ................................. 37A-48-l
Power Steering, Pressure Test ...................... 37A-23-l
Rear..........

.
...
......................... 378-15-I
...
Rear, Discharge Flow Volume Check .................. 378-6-I “s
OIL SCREEN.
DOHC.....................................

.
11-71-l
SOHC.
......................................
.
1 l-23-l
OIL SEALS Camshaft .......................... 11-68-I
Camshaft
........................... 11-19-l
Drive Shaft. Replacement .................... 23-92-l
Drive Shaft, Replacement
................
. 22-18-l
Drive Shaft, Replacement
...................
. 22-4-l
Transfer, Replacement
...................
. 22-19-l
OUTPUT VOLTAGE,
G sensor, Check ..................
. 33B-96-l
OXYGEN SENSOR
On-vehicle
inspectron
............
.
13-87-l
On-vehicle Inspection .........

. 13-179-l
P
PAD
Disc Brake. Front, Check and Replacement ............
. 35-59-l
Disc Brake. Maintenance. ........................... 00-44-i
Disc Brake. Rear, Check and Replacement
’.............
. 35-65-l
PANEL. Loose ....................................... 42-62-l
PARKING BRAKE CABLE..............................

. 36-5-l
PARKING BRAKE LEVER...............................

. 36-4-l
PARKING BRAKE LEVER, Stroke Check...................

. 36-2-l
PARKING BRAKE SWITCH, Check.......................

. 36-3-l
PARK/NEUTRAL POSITION SWITCH
Adjustment ..................................... 23-84-l
On-vehrcle
Inspection ................ 13-284-l
On-vehicle Inspection A/T>......... 13-78-l
On-vehicle Inspection A/T>....... 13-172-l
PCV VALVE, Inspection
................................ 17-14-l
PEDAL
Brake
..........................................
. 35-76-l
Brake, Inspection
and Adjustment
.................... 35-53-l
Clutch.........................................

. 21-7-l
Clutch. Inspection
and Adjustment
..................... 21-5-l
PERFORMANCE TEST...............................

. 55-21-l
PIPE
Exhaust ................................15-33-1
Exhaust \-...............................

. 15-32-l
Water
....................... 14-26-l
Water
..........................
. 14-28-l
Water
................................
. 14-23-l
PLAY
End. Hub, Inspection
................. 338-86-I
End. Hub. Inspection ..............
. 26-6-l
End, Rear Wheel Bearing, Check
27-15-1End, Wheel Bearing, Adjustment .............
. 27-3-l