fuel filter MITSUBISHI L200 2018 Owner's Manual (in English)
[x] Cancel search | Manufacturer: MITSUBISHI, Model Year: 2018, Model line: L200, Model: MITSUBISHI L200 2018Pages: 466, PDF Size: 28.42 MB
Page 102 of 466
Indication and warning lamps (multi information display)E005015040931. Front fog lamp indication lamp*® p. 5-13
2. Turn-signal indication lamps/Hazard warning indication lamps ® p. 5-13
3. High-beam indication lamp ® p. 5-13
4. Auto Stop & Go (AS&G) indication lamp* ® p. 6-23
5. Lane departure warning (LDW) standby indication lamp (green)* ® p. 6-75
Lane departure warning (LDW) lamp
(amber)* ® p. 6-75
6. Position lamp indication lamp* ® p. 5-147. Lane departure warning (LDW) system
ON indication lamp* ® p. 6-75
8. Rear fog lamp indication lamp ® p. 5-13
9. Cruise control indication lamp* ® p. 6-63
10. Diesel particulate filter (DPF) warning lamp ® p. 6-22
11. Diesel preheat indication lamp ® p. 5-14
12. Charge warning lamp ® p. 5-16
13. Check engine warning lamp ® p. 5-15
14. Fuel filter indication lamp ® p. 5-1415. A/T (automatic transmission) fluid tem-
perature warning lamp (vehicles with
A/T) ® p. 6-34
16. Oil pressure warning lamp ® p. 5-16
17. Auto Stop & Go (AS&G) OFF indica- tion lamp* ® p. 6-26
18. Washer fluid level warning lamp* ® p. 5-16
19. Multi-information display ® p. 5-02
20- For details, refer to “Warning activa- tion” on page 3-12 (if so equipped).
21. For details, refer to “Warning activa- tion” on page 3-12 (if so equipped).
22- Door ajar warning lamp ® p. 5-16
Indication and warning lamps (multi information display)
5-12OKTE18E1Instruments and controls5Type 1
Type 2
Page 104 of 466
Position lamp indication lamp*
E00508901301
This indication lamp illumi-
nates while the position
lamps are on.
Diesel preheat indication lamp
E00502301390
This indicates the glow plug
preheat condition.
[Except for vehicles equip-
ped with keyless operation system]
When the ignition switch is
turned to the “ON” position, the lamp illumi-
nates. As the glow plug becomes hot, the lamp goes out and the engine can be started.
[For vehicles equipped with keyless opera- tion system]
When the operation mode is put in ON, the
lamp illuminates and preheating of the glow
plug starts automatically. As the glow plug becomes hot, the lamp goes out and the en-
gine starts.
CAUTIONl If the diesel preheat indication lamp comes
on after the engine is started, the engine speed may not rise above the idling speedbecause of fuel freezing. In this case, keep
the engine idling for about 10 minutes, then turn off the ignition switch or put in OFF the operation mode, and immediately turn it onor put in ON again to confirm that the diesel
preheat indication lamp is off.NOTEl If the engine is cold, the diesel preheat indi-
cation lamp is on for a longer time.
l [Except for vehicles equipped with keyless
operation system]
When the engine has not been started within about 5 seconds after the diesel preheat indi- cation lamp went out, return the ignition
switch to the “LOCK” position. Then, turn
the ignition switch to the “ON” position to preheat the engine again.
l When the engine is warm, the diesel preheat
indication lamp does not come on even if the
ignition switch is placed in the “ON” posi-
tion or the operation mode is in ON.Fuel filter indication lamp
E00509901353
This indication lamp illumi-
nates when the ignition switch is turned to the “ON”
position or the operation
mode is put in ON, and goes off after the engine has star-
ted. If it lights up while the engine is running,
it indicates that water has accumulated inside the fuel filter; if this happens, take action as
follows.
Remove the water from the fuel filter. Refer to “Removal of water from the fuel filter” on
page 8-11.
When the lamp goes out, you can resume driving. If it either does not go out or comes
on from time to time, we recommend you to have the vehicle inspected.
Indication lamps
5-14OKTE18E1Instruments and controls5
Page 140 of 466
Diesel particulate filter(DPF) E00619801457
The diesel particulate filter (DPF) is a device that captures most of the particulate matter
(PM) in the exhaust emissions of the diesel engine. The DPF automatically burns away trapped PM during vehicle operation. Under
certain driving conditions, however, the DPF is not able to burn away all of the trapped PM
and, as a result, an excessive amount of PM accumulates inside it.WARNINGl The DPF reaches very high temperatures.
Do not park your vehicle in areas where combustible materials such as dry grass
or leaves can come in contact with a hot exhaust system since a fire could occur.CAUTIONl Do not use any type of fuel or engine oil that
is not specified for your vehicle. Also, do not use any moisture-removing agent or oth-
er fuel additive. Such substances could have a detrimental effect on the DPF.
Refer to “Fuel selection” on page 2-02 and
“Engine oil” on page 10-05.NOTEl To minimize the likelihood of excessive ac-
cumulation of PM, try to avoid driving for long periods at low speeds and repeatedly
driving short distances, and try to keep high
engine speed driving as much as possible.
l The engine sounds slightly different than
usual while the DPF automatically burns
away trapped PM. The change in the engine
sound does not indicate a fault.
DPF warning lamp
The DPF warning lamp comes on in the
event of an abnormality in the DPF system.
If the DPF warning lamp
comes on during vehicle opera- tion
Steady illumination of the DPF warning lamp shows that the DPF has not been able to burn
away all of the trapped PM and that, as a re-
sult, an excessive amount of PM has accumu- lated inside it. To enable the DPF to burn
away the PM, try to drive the vehicle as fol-
lows:
l With the bar graph of engine coolant
temperature display stabilized in roughly
the middle of the scale, drive for approx- imately 20 minutes at a speed of at least
40 km/h (25 mph).
If the DPF warning lamp subsequently stays
on, contact your MITSUBISHI MOTORS
Authorized Service Point.
CAUTIONl You do not have to continuously drive ex-
actly as indicated above. Always strive to
drive safely in accordance with road condi- tions.
Diesel particulate filter (DPF)
6-22OKTE18E1Starting and driving6
Page 315 of 466
ERA-GLONASS*............................................................................... 8-02
If the vehicle breaks down.................................................................. 8-07 If the operation mode cannot be changed to OFF (vehicles equipped with the keyless operation system)................................. 8-07
Emergency starting............................................................................. 8-07
Engine overheating............................................................................. 8-09
Bleeding the fuel system..................................................................... 8-10
Removal of water from the fuel filter................................................. 8-11
Tools, jack and jack handle................................................................. 8-11 How to change a tyre.......................................................................... 8-17
Towing................................................................................................ 8-23
Operation under adverse driving conditions....................................... 8-27For emergencies
OKTE18E18
Page 324 of 466
Stop the engine immediately and contacta MITSUBISHI MOTORS Authorized
Service Point for assistance.
A- Cooling fan
B- Reserve tank
C- Radiator cap
WARNINGl Be careful not to get your hands or clothes
caught in the cooling fan.4. Check the coolant level in the reserve
tank (B).
5. Add coolant to the radiator and/or re-
serve tank if necessary (refer to the
“Maintenance” section).
WARNINGl Make sure that the engine has cooled
down before removing the radiator cap (C), because hot steam or boiling water
otherwise will gush from the filler port and may scald you.CAUTIONl Do not add coolant while the engine is hot.
Suddenly adding cold coolant could damage the engine. Wait for the engine to cool
down, then add coolant a little at a time.6. Examine the radiator hoses for coolant
leakage and the drive belt for looseness
or damage.
If there is anything wrong with the cool-
ing system or drive belt, we recommend
you to have it checked and repaired.Bleeding the fuel system
E00800701423
The fuel system should be bled to remove air
as described below if the fuel supply is ex- hausted during travel.
Pump the hand pump (A) at the top of the fuel filter until the hand pump becomes stiff.Then try again to start the engine.
If the engine does not start, repeat the process
above.
Bleeding the fuel system
8-10OKTE18E1For emergencies8 FULLLOW
Page 325 of 466
CAUTIONlDo not smoke or have any other open flame
near the vehicle while bleeding the fuel sys-
tem.
l Be sure to carefully clean away any spilt fuel
which could ignite and cause a fire.Removal of water from the
fuel filter E00800801525
If the fuel filter indication lamp in the instru-ment panel illuminates during driving, it indi-
cates that water has accumulated in the fuel filter. If this occurs, remove the water as de-
scribed below. 1. Loosen the drain plug (A) of the fuel fil-
ter.
2. Operate the hand pump (B) slowly 6 or 7
times in order to force the water out
through the drain plug (A).
3. Tighten the drain plug (A) when water
no longer comes out.
4. Bleed the air in the fuel system. (Refer to “Bleeding the fuel system” onpage 8-10.)
5. Check to be sure that the fuel filter indi-
cation lamp illuminates when the igni- tion switch is turned to “ON” or the op-
eration mode is put in ON, and that it
goes off when the engine is started. If in
doubt, we recommend you to consult a specialist for necessary information.
CAUTIONl Do not smoke or have any other open flame
near the vehicle while bleeding the fuel sys-
tem.CAUTIONl Be sure to carefully clean away any water
drained out because any fuel mixed with the
water could ignite and cause a fire.Tools, jack and jack handle
E00800902695
Storage
The storage location of the tools, jack andjack handle should be remembered in case ofan emergency.
Single cab
A- Tool (wheel nut wrench)
B- Jack handle
Removal of water from the fuel filter
8-11OKTE18E1For emergencies8 Type 1
Page 403 of 466
Safety and disposal information forused engine oil............................................. 2-06
Specifications.............................................. 11-14
Entering or leaving the vehicle..........................2-05
ERA-GLONASS............................................... 8-02
Exterior and interior lamp operation............... 10-16
F
First-aid kit and warning triangleband for securing........................................... 7-108
Floor console box............................................ 7-105
Fluid Automatic transmission fluid...................... 11-17
Brake fluid........................................ 10-08,11-17
Clutch fluid....................................... 10-09,11-17
Engine coolant.................................. 10-06,11-17
Power steering fluid.......................... 10-09,11-17
Washer fluid..................................... 10-08,11-17
Front fog lamps
Bulb capacity.............................................. 10-22
Indication lamp............................................. 5-13
Replacement................................................ 10-27
Switch........................................................... 5-22
Front room lamp.............................................. 7-102
Bulb capacity.............................................. 10-24
Replacement................................................ 10-30
Front seats......................................................... 4-02
Front turn-signal lamps Bulb capacity.............................................. 10-22
Indication lamp............................................. 5-13
Replacement................................................ 10-26
Switch........................................................... 5-21
Frozen road warning..........................................5-06
Fuel consumption............................................ 11-16
Fuel remaining warning display........................ 5-07
Fuel Bleeding the fuel system............................... 8-10Filling the fuel tank....................................... 2-03Fuel filter indication lamp............................. 5-14
Fuel remaining display.................................. 5-07
Fuel remaining warning display....................5-07
Fuel selection................................................ 2-02
Modification/alterations to the electrical or fuel systems............................. 2-06
Removal of water from the fuel filter........... 8-11
Tank capacity................................................ 2-03
Fuses................................................................ 10-17
Fusible links.................................................... 10-17
G
General maintenance....................................... 10-16
General vehicle data........................................ 11-04
Genuine parts.....................................................2-06
Glove box........................................................ 7-104
Glove box lamp Bulb capacity.............................................. 10-24
Replacement................................................ 10-31
H
Hazard warning flasher switch.......................... 5-21
Hazard warning indication lamps......................5-13
HDMI terminal.................................................. 7-98
Head restraints................................................... 4-05
Headlamp levelling switch................................ 5-19
Headlamp washer switch...................................5-26
Headlamps Auto-cutout function..................................... 5-18Bulb capacity.............................................. 10-22
Daytime running lamps................................. 5-19Dipper (High/Low beam change)................. 5-19
Headlamp flasher.......................................... 5-19
High-beam indication lamp...........................5-13
Lamp monitor buzzer.................................... 5-18
Replacement................................................ 10-24
Switch........................................................... 5-17
Heated mirror.................................................... 6-12
Switch........................................................... 5-27
Heated seats....................................................... 4-03
Heater........................................................ 7-04,7-09
High-mounted stop lamp Bulb capacity.............................................. 10-23
Hill start assist................................................... 6-54
Warning indicator......................................... 6-55
Hinges and latches lubrication........................ 10-16
Hooks Coat hook.................................................... 7-108Convenient hook......................................... 7-108
Horn switch....................................................... 5-28
I
If the operation mode cannot bechanged to OFF................................................8-07
If the vehicle breaks down................................ 8-07
Ignition switch................................................... 6-13
Indication and warning lamps........................... 5-12
Indication lamps........................................ 5-12,5-13
Inside rear-view mirror......................................6-08
Inspection and maintenance following rough road operation........................................ 6-51
Installation of accessories..................................2-05
Instruments........................................................ 5-02
Alphabetical index
12- 3
OKTE18E1Alphabetical index
Page 405 of 466
Rear turn-signal lampsBulb capacity.............................................. 10-23
Indication lamp............................................. 5-13
Replacement................................................ 10-28
Switch........................................................... 5-20
Rear window demister switch........................... 5-27
Rear-view camera..............................................6-79
Rear-view mirror Inside............................................................. 6-08
Outside.......................................................... 6-09
Removal of water from the fuel filter................8-11
Replacement of lamp bulbs............................. 10-22
Reversing lamps Bulb capacity.............................................. 10-22
Replacement................................................ 10-28
Room lamp...................................................... 7-102
Running-in recommendations........................... 6-04
S
Safe driving techniques..................................... 6-03
Safety and disposal information for used engine oil................................................. 2-06
Seat belt............................................................. 4-07 Adjustable seat belt anchor........................... 4-09Child restraint................................................4-11Force limiter system...................................... 4-11
Inspection...................................................... 4-23
Pregnant women restraint............................. 4-10
Pretensioner system...................................... 4-10
Seat belt reminder..............................................4-08
Seat Adjustment.................................................... 4-02Armrest (Double cab)................................... 4-04
Front seats..................................................... 4-02
Head restraints.............................................. 4-05
Heated seats.................................................. 4-03
Rear seat........................................................ 4-04
Service precaution........................................... 10-02
Side turn-signal lamps Bulb capacity.............................................. 10-22Indication lamp............................................. 5-13
Switch........................................................... 5-21
Snow tyres....................................................... 10-14
Spare wheel....................................................... 8-17
Specifications.................................................. 11-02
Speed Limiter.................................................... 6-69 Switch........................................................... 6-69
Speed Limiter information on the multi information display area......................... 6-70
Starting.............................................................. 6-18
Steering wheel audio remote control switches................................................... 7-28,7-51
Steering Power steering fluid.......................... 10-09,11-17
Power steering system...................................6-58
Steering wheel height and reach adjustment. 6-07
Steering wheel lock....................................... 6-16
Stop lamps
Bulb capacity.............................................. 10-22
Replacement................................................ 10-28
Storage spaces................................................. 7-104
Centre console under tray........................... 7-105Floor console box........................................ 7-105Glove box.................................................... 7-104
Sunglasses holder........................................ 7-106
Sun visors.......................................................... 7-99
Sunglasses holder............................................ 7-106
Super Select 4WD II......................................... 6-40 2WD/4WD operation indication lamp.. 6-40,6-42Low-range indication lamp........................... 6-42
Supplemental restraint system...........................4-24
Curtain airbag system................................... 4-32
Driver’s and front passenger’s air- bag system................................................... 4-28
Driver’s knee airbag system..........................4-28
Front passenger’s airbag indicator................ 4-27
Front passenger’s airbag ON-OFF switch.... 4-27
How the Supplemental Restraint System works...............................................4-25
Servicing....................................................... 4-35
Side airbag system........................................ 4-31
Warning lamp................................................4-34
T
Tail lampsBulb capacity.............................................. 10-23
Replacement................................................ 10-28
Tank capacity.................................................... 2-03
Time Setting.............................................. 7-36,7-70
Tools.................................................................. 8-12 Storage.......................................................... 8-11
Towing.............................................................. 8-23
Trailer Stability Assist (TSA)........................... 6-62
Trailer towing.................................................... 6-84
Transfer oil...................................................... 11-17
Transmission Automatic transmission................................ 6-29Fluid............................................................ 11-17
Manual transmission..................................... 6-27
Turbocharger operation..................................... 6-23
Turn-signal indication lamps.............................5-13
Turn-signal lever............................................... 5-20
Tyres................................................................ 10-12
Alphabetical index
12- 5
OKTE18E1Alphabetical index