wheel alignment NISSAN ALMERA N16 2003 Electronic Owner's Manual
[x] Cancel search | Manufacturer: NISSAN, Model Year: 2003, Model line: ALMERA N16, Model: NISSAN ALMERA N16 2003Pages: 3189, PDF Size: 54.76 MB
Page 3150 of 3189

SST489B
Checking Steering Wheel PlayNJST0007With wheels in a straight-ahead position, check steering wheel
play.
Steering wheel play:
35 mm (1.38 in) or less
If it is not within specification, check the following for loose or
worn components.
Steering gear assembly
Steering column
Front suspension and axle
SST490BA
Checking Neutral Position on Steering WheelNJST0008PRE-CHECKINGNJST0008S01Make sure that wheel alignment is correct.
Wheel alignment:
Refer to SU-14, SDS.
Verify that the steering gear is centered before removing the
steering wheel.
CHECKINGNJST0008S021. Check that the steering wheel is in the neutral position when
driving straight ahead.
2. If it is not in the neutral position, remove the steering wheel and
reinstall it correctly.
3. If the neutral position is between two teeth, loosen tie-rod lock
nuts. Turn the tie-rods by the same amount in opposite direc-
tions on both left and right sides.
SMA127
Front Wheel Turning AngleNJST00091. Rotate steering wheel all the way right and left; measure turn-
ing angle.
Turning angle of full turns:
Refer to SU-14, SDS.
2. If it is not within specification, check rack stroke.
Rack stroke “S”:
Refer to SDS, ST-30.
SST663B
Checking Gear Housing MovementNJST00101. Check the movement of steering gear housing during station-
ary steering on a dry paved surface.
Apply a force of 49 N (5 kg, 11 lb) to steering wheel to check
the gear housing movement.
Turn off ignition key while checking.
Movement of gear housing:
±2mm(±0.08 in) or less
2. If movement exceeds the limit, replace mount insulator after
confirming proper installation of gear housing clamps.
ON-VEHICLE SERVICE
Checking Steering Wheel Play
ST-6
Page 3184 of 3189

Wheel alignment (rear)...................................SU-18
Wheel bearing (front)........................................AX-3
Wheel bearing (rear) ......................................AX-23
Wheel hub (front)..............................................AX-5
Wheel hub (rear) ............................................AX-24
Wheel sensors (ABS) .....................................BR-70
Wheelarch height .............................................SU-6
Wheelbase (Dimensions) ................................GI-44
Width (Dimensions) .........................................GI-44
Window, rear <0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110025[T- 6 8
Windshield<0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
1100110011[..BT-68WIP/R - Wiring diagram ................................EL-164
WIPER - Wiring diagram ..............................EL-160
Wiper, front<0011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100110011001100
110011[EL-158
Wiring Diagram (Cell code) list .....................EL-599
Wiring diagram - AT - LAN...............AT-194, AT-397
Wiring diagrams...............................................GI-12
Withdrawal lever (clutch) ..........................CL-17, 20
Wrist pin - See Piston pin inspection
(YD engine) ................................................EM-71
ALPHABETICAL INDEX
IDX-10