fuel fill door release NISSAN X-TRAIL 2003 Service Repair Manual

BL-2 PRELIMINARY CHECK ....................................... 53
SYMPTOM CHART ............................................. 54
Power Supply and Ground Circuit Check ............... 55
Door Lock/Unlock Switch Check ............................ 56
Door Key Cylinder Switch Check ............................ 58
Front Door Lock Actuator (Driver Side) Check ....... 60
Front Door Lock Actuator (Passenger Side) Check ... 61
Rear Door Lock Actuator LH Check ....................... 62
Rear Door Lock Actuator RH Check ....................... 63
Back Door Lock Actuator Check ............................. 64
Door Switch Check ................................................. 65
Door Unlock Sensor Check .................................... 66
Key Switch Check ................................................... 67
Super Lock Actuator (Driver Side) Check ............... 68
Super Lock Actuator (Passenger Side) Check ....... 69
Super Lock Actuator Check / Rear LH ................... 70
Super Lock Actuator Check / Rear RH ................... 71
NATS Release Signal Check .................................. 72
Ignition Switch “ON” Circuit Check ......................... 73
MULTI-REMOTE CONTROL SYSTEM ..................... 74
Component Parts and Harness Connector Location ... 74
System Description ................................................. 75
FUNCTION .......................................................... 75
LOCK OPERATION ............................................. 75
UNLOCK OPERATION ........................................ 75
HAZARD REMINDER .......................................... 75
MULTI-REMOTE CONTROLLER ID CODE
ENTRY ................................................................ 75
Schematic ............................................................... 76
Wiring Diagram — MULTI — .................................. 77
Terminal and Reference Value for Multi-remote
Control Unit ............................................................. 80
Terminal and Reference Value for Time Control Unit ... 80
Symptom Chart ....................................................... 81
Remote Controller Battery Check ........................... 82
Power Supply and Ground Circuit Check for Time
Control Unit ............................................................. 82
Power Supply and Ground Circuit Check for Multi-
Remote Control Unit ............................................... 83
Time Control Unit Lock Signal Circuit Check .......... 84
Time Control Unit Unlock Signal Circuit Check ...... 85
Hazard Reminder Check ........................................ 86
ID Code Entry Procedure ....................................... 89
Remote Controller Battery Replacement ................ 90
FRONT DOOR LOCK ............................................... 91
Component Parts Location ..................................... 91
Component Parts Location (Super Lock) ................ 91
Inspection and Adjustment ..................................... 91
OUT SIDE HANDLE ROD ADJUSTMENT .......... 92
Removal and Installation ........................................ 92
REMOVAL ........................................................... 92
INSTALLATION .................................................... 93
Disassembly and Assembly .................................... 93
DISASSEMBLY ................................................... 93
ASSEMBLY ......................................................... 93
Disassembly and Assembly .................................... 93
DISASSEMBLY (SUPER LOCK) ......................... 93
ASSEMBLY ......................................................... 94
REAR DOOR LOCK .................................................. 95Component Parts Location ..................................... 95
Component Parts Location (Super Lock) ................ 95
Inspection and Adjustment ...................................... 95
OUT SIDE HANDLE ROD ADJUSTMENT .......... 96
Removal and Installation ......................................... 96
REMOVAL ............................................................ 96
INSTALLATION .................................................... 97
Disassembly and Assembly .................................... 98
DISASSEMBLY .................................................... 98
ASSEMBLY .......................................................... 98
Disassembly and Assembly .................................... 98
DISASSEMBLY (SUPER LOCK) ......................... 98
ASSEMBLY .......................................................... 98
BACK DOOR ............................................................. 99
Fitting Adjustment ................................................... 99
VERTICAL/LATERAL CLEARANCE ADJUST-
MENT ................................................................... 99
Back Door Assembly .............................................100
REMOVAL AND INSTALLATION .......................100
INSPECTION .....................................................100
Removal and Installation of Back Door Handle ....100
REMOVAL ..........................................................100
INSTALLATION ..................................................101
Removal and Installation of Back Door Lock and
Actuator .................................................................101
REMOVAL ..........................................................101
INSTALLATION ..................................................101
Removal and Installation of Back Door Weatherstrip .102
REMOVAL ..........................................................102
INSTALLATION ..................................................102
FUEL FILLER LID OPENER ...................................103
Component Parts Location ...................................103
THEFT WARNING SYSTEM ...................................104
Wiring Diagram — THEFT —/PRI-WIRE ..............104
LHD MODELS ....................................................104
RHD MODELS ...................................................106
NATS (NISSAN ANTI-THEFT SYSTEM) .................108
Component Parts and Harness Connector Location .108
System Description ...............................................109
System Composition .............................................110
ECM Re-communicating Function ........................110
Wiring Diagram — NATS — .................................. 111
LHD MODELS .................................................... 111
RHD MODELS ...................................................113
CONSULT-II ..........................................................115
CONSULT-II INSPECTION PROCEDURE ........115
CONSULT-II DIAGNOSTIC TEST MODE FUNC-
TION ..................................................................116
HOW TO READ SELF-DIAGNOSTIC RESULTS .116
NATS SELF-DIAGNOSTIC RESULTS ITEM
CHART ...............................................................117
Work Flow .............................................................118
Trouble Diagnoses ................................................119
SYMPTOM MATRIX CHART 1 ..........................119
SYMPTOM MATRIX CHART 2 ..........................121
DIAGNOSTIC SYSTEM DIAGRAM ...................121
Diagnostic Procedure 1 .........................................121
Diagnostic Procedure 2 .........................................122
Diagnostic Procedure 3 .........................................125

IDX-5
A
C
D
E
F
G
H
I
J
K
L B
IDX
ALPHABETICAL INDEX
Front Door Trim ................................................... EI-32
Front fog lamp .................................................... LT-52
Front passenger air bag .................................. SRS-35
Front seat .......................................................... SE-24
Front seat belt ...................................................... SB-3
Front seat belt pre-tensioner .... SB-2, SRS-3, SRS-40
Front side air bag ............................................. SRS-37
Front suspension ............................................... FSU-5
Front washer ...................................................... WW-4
Front wiper ......................................................... WW-4
FRPS - Wiring diagram .................... EC-999, EC-1309
FTS - Wiring diagram ...................... EC-994, EC-1304
FUEL - Wiring diagram ...................... EC-218, EC-225
Fuel check valve ................................ EC-473, EC-865
Fuel cut control (at no load high engine speed) EC-38,
EC-500
, EC-887, EC-1218
Fuel filler lid ...................................................... BL-103
Fuel filter .......................................... EC-890, EC-1221
Fuel filter replacement(QR20DEQR25DE) .......... FL-4
Fuel filter replacement(YD22DDTi) ....... FL-17, MA-31
Fuel gauge ............................................................ DI-4
Fuel injection control system ........... EC-885, EC-1216
Fuel injection system ......................... EC-216, EC-223
Fuel injector adjustment resistor .... EC-1115, EC-1404
Fuel injector and fuel tube(QR20DEQR25DE) . EM-32
Fuel injector and fuel tube(YD22DDTi) ............ EM-157
Fuel line inspection(QR20DEQR25DE) . FL-3, MA-23
Fuel line inspection(YD22DDTi) ............ FL-16, MA-31
Fuel pressure check ............................ EC-48, EC-510
Fuel pressure release .......................... EC-48, EC-510
Fuel pump .......... EC-443, EC-835, EC-890, EC-1127,
EC-1416
Fuel pump and gauge(QR20DEQR25DE) .......... FL-4
Fuel rail pressure sensor ................. EC-997, EC-1307
Fuel system(QR20DEQR25DE) .......................... FL-3
Fuel system(YD22DDTi) ..................................... FL-16
Fuel tank(QR20DEQR25DE) ............................ FL-11
Fuel tank(YD22DDTi) ......................................... FL-23
Fuel temperature sensor ................. EC-993, EC-1303
Fuse ................................................................... PG-12
Fuse and fusible link box ................................... PG-76
Fusible link ......................................................... PG-12
G
Gauges ................................................................. DI-4
Gear components (M/T) ....................... MT-20, MT-25
Generator .......................................................... SC-12
Generator - See Alternator ................................ SC-12
Generic scan tool (GST) .................... EC-112, EC-931
Glass .................................................. GW-80, GW-83
GLOW - Wiring diagram EC-1070, EC-1170, EC-1458
Glow plug ....................................... EC-1169, EC-1457
Glow plug(YD22DDTi) ..................................... EM-152
Glow relay ...................... EC-1069, EC-1169, EC-1457
GPS antenna ..................................................... AV-43
Grille - See Exterior ............................................. EI-19
Ground distribution ............................................ PG-13
H
H/AIM - Wiring diagram ...................................... LT-29
H/LAMP - Wiring diagram ........................... LT-4, LT-7
H/MIRROR - Wiring diagram ............................ GW-21
Harness connector ............................................. PG-70
Harness layout ................................................... PG-30
Headlamp ............................................................. LT-4
Headlamp aiming control .................................... LT-29
Headlamp leveler - See Headlamp aiming control .......
LT-29
Headlamp washer ............................................ WW-20
Headlining - See Roof trim .................................. EI-39
Heated oxygen sensor 1 .... EC-176, EC-183, EC-193,
EC-318
, EC-324, EC-611, EC-618, EC-786
Heated oxygen sensor 1 heater ......... EC-138, EC-771
Heated oxygen sensor 2 .... EC-201, EC-208, EC-330,
EC-338
, EC-792
Heated oxygen sensor 2 heater ......... EC-144, EC-776
Heated seat ........................................... SE-18, SE-21
HEATER - Wiring diagram ................................ MTC-6
Heater and cooling unit (Heater core) ............ ATC-131
Heater mirror ..................................................... GW-21
Heater system - Wiring diagram ....................... MTC-6
Heater unit (heater core) .. ATC-136, MTC-27, MTC-30
HFC134a (R134a) system precaution ............... ATC-4
HFC134a (R134a) system service procedure ATC-141
HFC134a (R134a) system service tools .......... ATC-15
HFC134a system service equipment precaution ..........
ATC-10
HO2S1 - Wiring diaram ...... EC-178, EC-186, EC-196,
EC-613
, EC-620
HO2S1H - Wiring diagram ............................... EC-140
HO2S2 - Wiring diagram .... EC-203, EC-211, EC-333,
EC-341
HO2S2H - Wiring diagram ............................... EC-146
Hood .................................................................. BL-12
Horn ................................................................. WW-25
HORN - Wiring diagram ................................... WW-25
How to erase DTC ........................... EC-514, EC-1223
How to erase DTC for OBD system ..... EC-63, EC-895
I
IATS - Wiring diagram ...... EC-158
, EC-977, EC-1287
IATSEN - Wiring diagram ................................ EC-782
Identification ...................................... ATC-12, ATC-13
Idle air volume learning ........................ EC-46, EC-508
Idle speed ............. EC-79, EC-526, EC-905, EC-1231
Ignition coil ......................................... EC-417, EC-798
Ignition coil(QR20DEQR25DE) ....................... EM-29
Ignition control system ....................... EC-417, EC-798
Ignition timing ....................................... EC-79, EC-526
IGNSYS - Wiring diagram .................. EC-418, EC-799
ILL - Wiring diagram ........................................... LT-66
Illumination .......................................................... LT-66
In vehicle sensor ........... ATC-111, ATC-113, ATC-122
INJE/PW - Wiring diagram ............. EC-1158, EC-1446
INJECT - Wiring diagram . EC-429, EC-821, EC-1008,