NISSAN X-TRAIL 2005 Service Repair Manual

NISSAN X-TRAIL 2005 Service Repair Manual X-TRAIL 2005 NISSAN NISSAN https://www.carmanualsonline.info/img/5/57403/w960_57403-0.png NISSAN X-TRAIL 2005 Service Repair Manual
Trending: Starting, coolant temperature, EC-275, Component Inspection, spare tire location, DI-4, wipers, language

Page 191 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual PREPARATION
EM-137
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
EM
 
Cylinder head bolt wrench Loosening and tightening cylinder head bolt, 
and used with angle wrench [SST: 
KV10112100]
a: 13 (0.51) dia.
b: 12

Page 192 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual EM-138
[YD22DDTi]
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
 
NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTINGPFP:00003
NVH Troubleshooting — Engine NoiseEBS00LR8
PBIC2311E

Page 193 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual NOISE, VIBRATION AND HARSHNESS (NVH) TROUBLESHOOTING
EM-139
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
EM
 
Use the Chart Below to Help You Find the Cause of the Symptom.EBS00LR9
1. Locate the area where noise

Page 194 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual EM-140
[YD22DDTi]
DRIVE BELTS
 
DRIVE BELTSPFP:02117
Checking Drive BeltsEBS00LRA
Before inspecting engine, make sure engine has cooled down;
wait approximately 30 minutes after engine has been stopp

Page 195 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual DRIVE BELTS
EM-141
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
EM
 
A/C COMPRESSOR BELT
1. Remove RH engine undercover.
2. Loosen idler pulley lock nut (A).
3. Turn adjusting bolt (B) to adjust. Refer to EM-140

Page 196 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual EM-142
[YD22DDTi]
AIR CLEANER AND AIR DUCT
 
AIR CLEANER AND AIR DUCTPFP:16500
Removal and InstallationEBS00LRD
REMOVAL
1. Remove mass air flow sensor harness clamp.
2. Disconnect harness connector fr

Page 197 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual AIR CLEANER AND AIR DUCT
EM-143
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
EM
 
CHANGING AIR CLEANER FILTER
Removal
1. Unfasten clips and lift up air cleaner case (upper).
2. Remove air cleaner filter.
Install

Page 198 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual EM-144
[YD22DDTi]
CHARGE AIR COOLER
 
CHARGE AIR COOLERPFP:14461
Removal and InstallationEBS00LRE
REMOVAL
1. Remove charge air cooler cover.
2. Disconnect harness connector from turbocharger boost con

Page 199 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual CHARGE AIR COOLER
EM-145
[YD22DDTi]
C
D
E
F
G
H
I
J
K
L
MA
EM
 
Align marks. Attach each joint. Screw clamps firmly.

Page 200 of 4555

NISSAN X-TRAIL 2005  Service Repair Manual EM-146
[YD22DDTi]
INTAKE MANIFOLD
 
INTAKE MANIFOLDPFP:14003
Removal and InstallationEBS00LRF
REMOVAL
WARNING:
To avoid the danger of being scalded, do not drain engine coolant when engine is hot.
1.
Trending: heater, key fob battery, steering wheel adjustment, coolant, Combination meter, catalytic converter, ac unit