belt OLDSMOBILE AURORA 2003 Workshop Manual

Wood Panels
Use a clean cloth moistened in warm, soapy water (use
mild dish washing soap). Dry the wood immediately
with a clean cloth.
Care of Safety Belts
Keep belts clean and dry.
Glass Surfaces
Glass should be cleaned often. GM Glass Cleaner or a
liquid household glass cleaner will remove normal
tobacco smoke and dust films on interior glass. See
GM
Vehicle Care/Appearance Materials on page 5-88.
Notice: Don't use abrasive cleaners on glass,
because they may cause scratches. Avoid placing
decals
on the inside rear window, since they
may have to be scraped
off later. If abrasive cleaners
are used on the inside of the rear window, an
electric defogger element may be damaged. Any
temporary license should not be attached across the defogger grid.
Do not bleach or dye safety belts. If you do, it
may severely weaken them. In a crash, they
might not be able to provide adequate
protection. Clean safety belts only with mild
soap and lukewarm water.
Weatherstrips
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with
a clean cloth at least every six
months. During very cold, damp weather more frequent
application may be required. See
Part D: Recommended
Fluids and Lubricants on page 6- 15.
5-84
ProCarManuals.com

Removing the Rear Seat Cushion
To access the battery and rear compartment fuse
panels, the rear seat cushion
must be removed. This
procedure is somewhat difficult. You may wish to have
your dealer do this for you.
Notice: The battery and main fuse blocks are
located under the rear seat cushion. The battery’s
ground terminal and some relay wires are exposed.
To help avoid damage to the battery and wires,
be careful when removing or reinstalling the seat
cushion.
Do not remove covers from covered parts.
Do not store anything under the seat, as objects
could touch exposed wires and cause a short.
To remove the rear seat cushion, do the following:
1. Pull up on the front of the cushion to release the
2. Pull the cushion up and out toward the front of the
front hooks.
vehicle.
To reinstall the rear seat cushion, do the following: A safety belt that
isn’t properly routed through
the seat cushion or
is twisted won’t provide
the protection needed
in a crash. ld the safety
belt hasn’t been routed through the seat
cushion at all,
it won’t be there to work for the
next passenger. The person sitting
in that
position could be badly injured. After
reinstalling the seat cushion, always check to
be sure that the safety belts are properly
routed and are not twisted.
5-95
ProCarManuals.com

1.
2.
Buckle the center passenger position safety belt,
then route the safety belts through the proper slots
in the seat cushion. Don’t let the safety belts get
twisted.
Slide the rear of the cushion up and under the
seatback
so the rear locating guides hook into
the wire loops on the back frame.
3. With the seat cushion lowered, push rearward and
then press down
on the seat cushion until the
spring locks on both ends engage.
4. Check to make sure the safety belts are properly
routed and that no portion
of any safety belt is
trapped under the seat.
Also make sure the seat
cushion is secured.
Rear Underseat Fuse Block
The rear fuse block is
located below the rear seat
on the driver’s side. The rear seat cushion must be
removed to access the
fuse block. See
Removing
the Rear Seat Cushion
on
page 5-95.
5-96
ProCarManuals.com

90,000 Miles (150 000 km)
0 Inspect throttle body bore and valve plates for
deposits, open the throttle valve and inspect all
surfaces. Clean as required.
An Emission Control
Service. (See footnote
t.)
Control Service.
page
5-63 for proper rotation pattern and additional
information.
(See footnote @.) (See footnote +.)
0 Replace engine air cleaner filter. An Emission
0 Rotate tires. See Tire Inspection and Rotation on
97,500 Miles (162 500 km)
U Rotate tires. See Tire Inspection and Rotation on
page 5-63 for proper rotation pattern and additional
information.
(See footnote @.) (See footnote +.)
100,000 Miles (1 66 000 km)
0 Replace spark plugs. An Emission Control Service.
0 Change automatic transaxle fluid and bottom screens
if the vehicle is mainly driven under one or more of
these conditions:
- In heavy city traffic where the outside
temperature regularly reaches
90°F (32°C) or
higher.
- In hilly or mountainous terrain.
- When doing frequent trailer towing.
0 If you haven’t used your vehicle under severe service
conditions listed previously and therefore, haven’t
changed your automatic transaxle fluid, change both
the fluid and filter.
150,000 Miles (240 000 km)
0 Drain, flush and refill cooling system (or every
60 months since last service, whichever occurs first).
See
Engine Coolant on page 5-24 for what to use.
Inspect hoses. Clean radiator, condenser, pressure
cap and neck. Pressure test the cooling system and pressure cap.
An Emission Control Service.
U Inspect engine accessory drive belt. An Emission
Control Service.
- Uses such as found in taxi, police or delivery
service.
6-8
ProCarManuals.com

At Least Twice a Year
Restraint System Check
Make sure the safety belt reminder light and all your
belts, buckles, latch plates, retractors and anchorages
are working properly. Look for any other loose or
damaged safety belt system parts.
If you see anything
that might keep a safety belt system from doing its
job, have it repaired. Have any torn or frayed safety belts
replaced.
Also look for any opened or broken air bag coverings,
and have them repaired or replaced. (The air bag
system does not need regular maintenance.)
Wiper Blade Check
Inspect wiper blades for wear or cracking. Replace
blade inserts that appear worn or damaged or that
streak or miss areas of the windshield.
Also see
“Windshield Wiper and Wiper Blades” under Cleaning
the Outside
of Your Vehicle on page 5-85.
Weatherstrip Lubrication
Silicone grease on weatherstrips will make them last
longer, seal better, and not stick or squeak. Apply
silicone grease with a clean cloth. During very cold,
damp weather more frequent application may be
required. See
Part D: Recommended Fluids and
Lubricants on page
6- 15.
Automatic Transaxle Check
Check the transaxle fluid level; add if needed. See
Automatic Transaxle Fluid on page 5-22. A fluid loss
may indicate a problem. Check the system and repair if
needed.
At Least Once a Year
Key Lock Cylinders Service
Lubricate the key lock cylinders with the lubricant
specified in Part D.
Body Lubrication Service
Lubricate all body door hinges. Also lubricate all hinges
and latches, including those for the hood, rear
compartment, glove box door, console door and any
folding seat hardware. Part
D tells you what to use. More
frequent lubrication may be required when exposed to
a corrosive environment.
6-1 0
ProCarManuals.com

Accessory Power Outlets ................................. 3-21
Adding Washer Fluid
....................................... 5-38
Additional Program Information
........................... 7-8
Additives, Fuel
................................................. 5-6
Add-on Electrical Equipment
............................ 5-91
Adjusting the Speakers (Balance/Fade)
.............. 3-62
Air Bag
Readiness Light
.......................................... 3-34
Air Bag Systems
............................................. 1-47
How Does an Air Bag Restrain? .................... 1-52
Servicing Your Air Bag-Equipped Vehicle
......... 1-54
What Makes an Air Bag Inflate?
.................... 1-52
What Will You See After an Air Bag Inflates? ...... 1-52
When Should an Air Bag Inflate?
................... 1-51
Where Are the Air Bags?
.............................. 1-49
Air CleanedFilter, Engine
................................. 5-21
All Overseas Locations
...................................... 7-4
Aluminum or Chrome-Plated Wheels
.................. 5-86
Antenna, Diversity
........................................... 3-76
Anti-Lock Brake, System Warning Light
.............. 3-36
Appearance Care
............................................ 5-82
Care
of Safety Belts .................................... 5-84
AM
............................................................... 3-74
r-11 It1-Iucln u1anG \JYQLGI II
uw) f-r A,-.+: I ,.-I, D.-~.I,A C?.,-+A- /A DC A7 ...........................
Appearance Care (cont.)
Chemical Paint Spotting
............................... 5-87
Cleaning the inside of Your Vehicle
................ 5-82
Cleaning the Outside of Your Vehicle
.............. 5-85
Finish Damage
............................................ 5-87
GM Vehicle Care/Appearance Materials
.......... 5-88
Sheet Metal Damage
................................ 5-87
Underbody Maintenance
........ ........ 5-87
Weatherstrips
........................... .... 5-84
Ashtrays
..................................... ........ 3-22
Assist Handles
............................................... 2-45
Audio System(s)
............................................. 3-59
Audio Systems
Audio Steering Wheel Controls
...................... 3-74
Care of Your Cassette Tape Player
................ 3-74
Care of Your CD Player
............................... 3-76
Care of Your CDs
........................................ 3-75
Chime Level Adjustment
............................... 3-76
Diversity Antenna System
............................. 3-76
NavigatiodRadio System
.............................. 3-69
Personal Choice Radio Controls
.................... 3-73
Radio with Cassette and CD
......................... 3-60
~eLlilly LIIt: I It lit3 3-a3
Theft-Deterrent Feature ................................ 3-73
Trunk-Mounted CD Changer
.......................... 3-70
Understanding Radio Reception
..................... 3-74
0 -LA:.- - . &I- - -r:.-- n rn ..........................................
1
ProCarManuals.com

Care of
Care of Your
Safety
Belts
........... ... 5-84
Cassette Tape Player
................................... 3-74
CD Player
.................................................. 3-76
Cassette Tape Messages
................................. 3-66
Cassette Tape Player Service
............................. 6-9
CD Changer, Trunk-Mounted
............................ 3-70
Chains, Tires
.................................................. 5-70
Check Engine Light
............................................... 3-39
Tire Pressure System
................................... 5-62
Check Engine Light
......................................... 3-39
Checking Coolant
............................................ 5-26
Checking Engine Oil
........................................ 5-16
Checking Things Under the Hood
...................... 5-12
Checking Your Restraint Systems
...................... 1-55
Chemical Paint Spotting
................................... 5-87
Child Restraints
Child Restraint Systems
............................... 1-34
Infants and Young Children
........................... 1-30
Lower Andlorayes arid Tup Teiilers ior
Children (LATCH System) .......................... 1-40
Older Children
............................................. 1-28
Securing a Child Restraint Designed for the
LATCH System
........................................ 1-42
Securing a Child Restraint
in a Rear Seat
Position
.............................................. 1-42
CDS
.......................................................... 3-75
Child Restraints
(cont.)
Securing a Child Restraint in the Right Front
Seat Position
........................................... 1-44
Top Strap
................................................... 1-38
Top Strap Anchor Location
............................ 1-39
Where to Put the Restraint
........................... 1-37
Cigarette Lighter
............................................. 3-22
Cleaning Inside of Your Vehicle
.................................. 5-82
Outside of Your Vehicle
................................ 5-85
Underbody Maintenance
............................... 5-87
Weatherstrips
.............................................. 5-84
Cleaning Exterior LampdLenses
....................... 5-85
Climate Control System
Automatic
................................................... 3-23
Climate Controls Personalization
.................... 3-29
Outlet Adjustment
........................................ 3-27
Chime
Level Adjustment
.................................. 3-76
Steering Wheel Controls
............................... 3-28
Compact Disc Errors
....................................... 3-72
Compact Disc Messages
.................................. 3-68
Compact Spare Tire
........................................ 5-81
Compass Calibration
....................................... 2-35
Compass Operation
......................................... 2-35
Compass Variance
.......................................... 2-36
Control of a Vehicle
.......................................... 4-5
Convenience Net ............................................ 2-46
3
ProCarManuals.com

Coolant Engine Temperature Gage
............................ 3-38
Heater. Engine
............................................ 2-25
Surge Tank Pressure Cap
............................. 5-28
Cooling System
.............................................. 5-31
Courtesy Lamps
............................................. 3-18
Cruise Control
................................................ 3-1 1
Cruise Control Light
........................................ 3-43
Current and Past Model Order Forms
................ 7-10
Customer Assistance Information
Courtesy Transportation
.................................. 7-6
Customer Assistance for Text Telephone
(TTY)
Users ....................................................... 7-3
Customer Assistance Offices
........................... 7-3
Customer Satisfaction Procedure
..................... 7-2
GM Mobility Program for Persons with
Disabilities
................................................ 7-5
Reporting Safety Defects
to General Motors ...... 7-9
Reporting Safety Defects to the Canadian
Government
.............................................. 7-9
Reporting Safety Defects to the United States
Government
.............................................. 7-8
Roadside Assistance Program ......................... 7-5
Service Publications Ordering Information
......... 7-9 Date/Elapsed
Time
.......................................... 3-45
Daytime Running Lamps
.................................. 3-15
Defensive Driving
............................................. 4-2
Defogging and Defrosting
................................. 3-26
Delayed Entry Lighting
..................................... 3-18
Delayed Exit Lighting
....................................... 3-19
Delayed Locking
..................................... 2-1 1, 3-57
Dinghy Towing
................................................ 4-33
Diversity Antenna
............................................ 3-76
Doing Your Own Service Work
........................... 5-4
Dolly Towing
.................................................. 4-34
Door Central Door Unlocking System
..................... 2-11
Delayed Locking
.......................................... 2-11
Door Ajar Reminder
..................................... 2-11
Power Door Locks
....................................... 2-11
Programmable Automatic Door Locks
............. 2-12
Rear Door Security Locks
............................. 2-13
Driver
Position, Safety Belt
..................................... 1-14
Driver ID
....................................................... 3-57
Locks
........................................................ 2-10
4
ProCarManuals.com

Driver Information Center (DIC) ___ ....... 3-45
DIC Vehicle Personalization .......................... 3-52
DIC Warnings and Messages .......... ....... 3-50
At Night ..................................................... 4-16
City ........................................................... 4-21
Defensive ..................................................... 4-2
Drunken ....................................................... 4-2
Freeway ..................................................... 4-22
Hill and Mountain Roads .............................. 4-24
In Rain and on Wet Roads ........................... 4-18
Winter ........................................................ 4-26
Driving On Grades .......................................... 4-42
Driving Through Deep Standing Water ............... 4-20
Driving Through Flowing Water ...................... 4-20
Driving with a Trailer .................................... 4-40
Driving
Driving on Snow or Ice
.................................... 4-28
E
Electrical System
Add-on Equipment
............................... 5-91
Fuses and Circuit Breakers ........................... 5-92
Headlamp Wiring ......................................... 5-91
Power Windows and Other Power Options ...... 5-91
Removing the Rear Seat Cushion .................. 5-95
Windshield Wiper Fuses ............................... 5-91
Emergency Trunk Release Handle ..................... 2-1 6
Emissions Inspection and Maintenance
Programs
................................................... 3-42
Engine
Air Cleaner/Filter
......................................... 5-21
Battery ....................................................... 5-42
Check and Service Engine Soon Light ............ 3-39
Coolant ...................................................... 5-24
Coolant Heater ............................................ 2-25
Coolant Temperature Gage ........................... 3-38
Cooling System Inspection ............................ 6-14
Engine Compartment Overview ...................... 5-14
Exhaust ..................................................... 2-33
Oil ............................................................. 5-15
Overheating ................................................ 5-28
Starting ...................................................... 2-24
Engine Compartment Fuse Block ...................... 5-92
Engine Coolant Level Check .............................. 6-9
Engine Cooling When Trailer Towing .................. 4-43
Engine Oil Additives ........................................ 5-19
Engine Oil Level Check ..................................... 6-9
Engine Oil Scheduled Maintenance ..................... 6-5
Engine Specifications ..................................... 5-1 00
Engiishiivietric ................................................. 3-45
Entry Lighting ................................................. 3-18
Erasing HomeLink@ Buttons .............................. 2-44
Express-Down Window .................................... 2-18
Extender, Safety Belt ....................................... 1-27
Exterior Lamps ............................................... 3-14
Exterior Lighting Battery Saver .......................... 3-17
5
ProCarManuals.com

H
Hazard Warning Flashers ................................... 3-4
Head Restraints
....................................... . 1-7
Headlamp
Aiming
....................................................... 5-50
Headlamp High/Low-Beam Changer .................... 3-7
Headlamp Horizontal Aiming
............................. 5-51
Headlamp Vertical Aiming
................................. 5-52
Headlamp Wiring ............................................ 5-91
Headlamps
.................................................... 5-55
Bulb Replacement
....................................... 5-54
Front Turn Signal and Parking Lamps
............. 5-57
Halogen Bulbs
............................................ 5-54
Headlamps on Reminder
.................................. 3-15
Heated Seats
............................................... 1-5
Highway Hypnosis ................................. ... 4-24
Hill and Mountain Roads
................ ... 4-24
Hitches
.......................................................... 4-39
HomeLink Transmitter, Programming
.................. 2-42
HomeLink@ Transmitter
.................................... 2-41
Hood
UI ICLRII ly I I Ill 1y3 VI IUGl 5- I L
Release ..................................................... 5-1 3
Horn
............................................................... 3-5
How to Add Coolant to the Coolant Surge Tank
.. 5-33
How to Add Fluid
............................................ 5-24
How to Check ........................................ 5-22, 5-61
OL--I..-- TI^: --.- I I--1- .. Am ................................
How to Check Power Steering Fluid ....... .... 5-37
How to Use This Manual
................................... ii
How to Wear Safety Belts Properly ............... 1-13
Hydroplaning
.............................................. 4-19
If
No Steam Is Coming From Your Engine .......... 5-30
If Steam Is Coming From Your Engine ............... 5-29
If the Light Is Flashing ..................................... 3-40
If the Light Is on Steady .................................. 3-41
If You Are Stuck in Sand, Mud, Ice or Snow ....... 4-32
If You Do Decide To Pull A Trailer
..................... 4-37
If You’re Caught in a Blizzard ........................... 4-29
Ignition Positions
............................................. 2-23
Ignition Transaxle Lock Check
.......................... 6-12
Inadvertent Power Battery Saver
....................... 3-20
Infants and Young Children, Restraints
............... 1-30
Inflation
-- Tire Pressure .................................. 5-60
Inspection
Brake System
.......................... ........ 6-14
Exhaust System
.......................................... 6-13
Fuel System
............................................... 6-13
Part C
- Periodic Maintenance ....................... 6-13
Steering, Suspension and Front Drive Axle
Boot and Seal
......................................... 6-13
Throttle System
........................................... 6-14
Engine
Cooling System
................. .... 6-14
7
ProCarManuals.com