engine OPEL ANTARA 2009 Manual Online

Service, maintenance214
Not every engine oil available on the
market meets the quality requirements,
always check the required specification
and rating is marked on the container.
If engine oil of the required quality is not
available, a maximum of 1 litre of ACEA
A3/B4 or A3/B3 grade may be used (only
once between each oil change). The
viscosity should be of the correct rating.
Use of ACEA A1/B1 and A5/B5 engine oil is
expressly forbidden, since they can cause
long-term engine damage under certain
operating conditions.
Engine oil additives
The use of engine oil additives could cause
damage and invalidate the warranty.
Engine oil viscosity
SAE 0W-30, 0W-40, 5W-30 or 5W-40 The SAE viscosity rating defines the ability
of an oil to flow. When cold, oil is more
viscous than when hot.
Multigrade oil is indicated by two figures.
The first figure, followed by a W, indicates
low temperature viscosity and the second
figure the high temperature viscosity.
Coolant and antifreeze
Use antifreeze of recommended
specification: silicate-free LLC (Long Life
Coolant).
The system is factory-filled with coolant
designed for frost protection down to
approx. -28 °C. This concentration should
be maintained all year-round.
Coolant additives intended to give
additional corrosion protection or seal
against minor leaks can cause function
problems. Liability for consequences
resulting from the use
of coolant additives
will be rejected.
Brake and clutch fluid
Only use DOT4 brake fluid.
Over time, brake fluid absorbs moisture
which will reduce braking effectiveness.
The brake fluid should therefore be
replaced at the specified interval.
Brake fluid should be stored in a sealed
container to avoid water absorption.
Ensure it does not become contaminated
with fluids containing mineral oil (oil,
petrol, cleaner) as this can damage the
seals and sleeves of the brake system.
9 Warning
Brake fluid is poisonous!
9 Warning
Due to its corrosive nature, it must not
come in contact with the paintwork. Flush
any escaped brake fluid with plenty of
water.

Technical data215
Technical data
Vehicle documents,
identification plate
The technical data is determined in
accordance with European Community
standards. We reserve the right to make
modifications. Specifications in the vehicle
documents always have priority over those
given in this manual.
The Vehicle Identification Number (VIN) is
on the vehicle identification plate,
attached to the top of the front panel
support, visible when the bonnet is open.
The vehicle identification plate may also
list, in kilograms, the Gross Vehicle Weight
(GVW), the Gross Train Weight (GTW) and
the maximum front and rear axle loads
respectively. Observe these limits when
using the full load or towing capacity of
your vehicle. Information on identification plate
1):
1 Manufacturer
2 Trim level
3 Colour code
4 Type approval number
5 Vehicle Identifi cation Number
6 Permissible Gross Vehicle Weight
7 Permissible Gross Train Weight
8 Maximum permissible front axle load
9 Maximum permissible rear axle load
Vehicle documents,
identification plate........................... 215
Coolant, brake fluid, oils .................... 216
Engine data......................................... 217
Performance........................................ 218
Fuel consumption, CO
2emissions ..... 219
Weights, payload and roof load ....... 221
Tyres .................................................... 223
Electrical system ................................. 225
Capacities ........................................... 225
Dimensions .......................................... 226
Mounting dimensions of caravan/ trailer towing equipment ................. 227
1)The VIN plate on your ve hicle may differ from
the illustration shown.

Technical data216
The Vehicle Identification Number (VIN)
is also engraved on the top right-hand side
of the bulkhead near the centre of the
engine firewall.
Engine identifier code and engine number:
stamped on the cylinder block under the
engine’s exhaust manifold (petrol engines),
or the intake manifold (diesel engines).
Coolant, brake fluid, oils
Use approved fluids only.
Use of unsuitable fluids could cause serious
damage to the vehicle.Engine oils
Information on engine oils is available on
page 213.

Technical data 217
Engine data
Sales designation
Engine stamp
Engine identifier code 2.4 Petrol
Z 24 SE
Z 24 XE3.2 V6 Petrol
10 HM
Z 32 SE 2.0 Diesel
Z 20 S
Z 20 DMH2.0 Diesel
Z 20 S
Z 20 DM
Number of cylinders 4644
Bore dia. (mm) 87.589.0 83.083.0
Stroke (mm) 100.085.6 92.092.0
Piston displacement (cm
3) 2405 3195 1991 1991
Max. engine power (kW) at rpm 103
5200167
6600 110
400093
4000
Torque (Nm) at rpm 220
2400297
3200 320
2000295
2000
Compression ratio 9.6 10.3 17.5 17.5
Fuel type Petrol Petrol Diesel Diesel
Cetane requirement (CN) --49 (D)
1)
1)Standard high-quality fuels: D = Diesel.
49 (D)1)
Octane requirement (RON)2)
unleaded
or unleaded
2)Standard high-quality fuels, e.g. unleaded DIN EN 228; value printed in bold: recommended fuel.
913)4)
953)
3)Knock control system automatically adjusts ignition timing according to type of fuel used (octane number).4)Use of 91 RON fuel reduces power and torque. If no unleaded Premium fuel is available, 91 RON can be used, taking care to avoid high engine load
or full load as well as driving in mountainous terrain with a caravan/trailer load or high payload.
913)4)
953)-
- -
-
Max. permissible engine speed, continuous operation (rpm) approx. 6200 6700 4750
5)/45006)
5)Manual transmission.6)Automatic transmission.
4750
Engine oil consumption (l/1000 km) 0.60.60.60.6

218 Technical data
Performance
(approx. km/h / mph)
Engine
1)
1)Sales designation - see page 217.
Z 24 XEZ 32 SEZ 20 DMH Z 20 DM
Maximum speed
2)
Manual transmission
Automatic transmission
2)The maximum speed indicated is achievable at kerb weight (without driver) plus 200 kg payload. Optional equipment could reduce the specified
maximum speed of the vehicle.
175/109
- -
203/126180/112
178/111174/108

-

220 Technical data
Fuel consumption
(approx. l/100 km), CO2 emission (approx. g/km)
Engine
1)
1)Sales designation – see page 217.
Z 24 XE Z 32 SEZ 20 DMH Z 20 DM
Manual transmission/Automatic transmission urban
extra-urban
total
CO
2
13.3/-
7.3/ -
9.6/ -
229/- - /16.4
- / 8.9
- /11.6
- /278 8.7/10.9
6.8/ 7.3
7.6/ 8.6
198/238 8.8/-
6.7/-
7.5/-
200/-

222 Technical data
Weights
(kg), Kerb weights
ModelEngine1)
1)Sales designation - see page 217.
Kerb weight2)3)
Manual transmission
2)The Gross Train Weight (GTW), along with the Gross Vehicle Weight (GVW) are shown on the VIN plate - see page 215.3)With driver (75kg) and all fluids (tank 90% full).
Kerb weight3)
Automatic transmission
Enjoy/Edition Z 24 XE 1805 -
Z 32 SE - 1845
Z 20 DMH 1845 1865
Z 20 DM 1845 -
Cosmo Z 24 XE 1805 -
Z 32 SE - 1845
Z 20 DMH 1845 1865
Z 20 DM 1845 -

224 Technical data
Tyre pressures in kPa/bar
The tyre pressures given are valid for cold
tyres. The increased tyre pressure resulting
from extensive driving must not be
reduced.
The tyre pressures specified apply to both
summer and winter tyres.
Always inflate the spare wheel to the tyre
pressure for full load.
Further information - see pages 149 to 153. Tyre pressure for load of
up to 4 persons
Tyre pressure for full load
Engine
1)
1)Sales designation - see page 217.
Tyres Front Rear Front Rear
Z 24 XE,
Z 20 DMH,
Z 20 DM 215/70 R 16,
235/60 R 17,
235/65 R 17,
235/55 R 18 210/2.1 210/2.1 230/2.3 240/2.4
Z 32 SE 215/70 R 16
2),
235/60 R 17,
235/65 R 17,
235/55 R 18
2)Only permitted as winter tyres.
210/2.1 210/2.1 230/2.3 240/2.4
All T 155/90 R 16 (temporary
spare)
3)
3)For notes on the temporary spare wheel - see pages 153, 178.
410/4.1 410/4.1 410/4.1 410/4.1

Technical data 225
Electrical system
Capacities

(approx. in litres) Engine
1)
1)Sales designation - see page 217.
Z 24 XE Z 32 SE Z 20 DMH Z 20 DM
B a tte ry V olt a g e1 2 V1 2 V1 2 V1 2 V
Amp hours 60 Ah70 Ah90 Ah90 Ah
Battery for radio frequency
remote control CR 2032 or
equivalentCR 2032 or
equivalentCR 2032 or
equivalentCR 2032 or
equivalent
Engine
1)
1)Sales designation - see page 217.
Z 24 XE Z 32 SE Z 20 DMH Z 20 DM
Engine coolant 9.010.09.09.0
Fuel tank 65656565
Engine oil with filter change 4.77.4 6.26.2
Engine oil between MIN and MAX on dipstick 1.0 1.01.01.0
Washer fluid reservoir for windscreen and tailgate
washer system 4.0
4.04.04.0
Washer fluid reservoir for windscreen, headlamp
and tailgate washer system 6.7
6.76.76.7

Index228
IndexA
ABS ......................................................... 148
Accessories
......... 45, 57, 69, 169, 191, 200
Accessory sockets
................................... 69
Active Rollover Protection (ARP)
.......... 138
Air conditioning system
................ 103, 109
Air distribution
....................................... 106
Air intake
............................................... 114
Air quality sensor
.................................. 112
Air recirculation mode
.......................... 109
Air vents
................................................. 104
Airbags
.................................. 42, 52, 54, 55
Alarm
....................................................... 29
Alarm system
........................................... 27
All Wheel Drive (AWD)
.......................... 121
Alternator
................................................ 74
Antenna
......................................... 101, 202
Antifreeze
...................................... 195, 214
Antifreeze protection
.................... 195, 199
Anti-knock quality of fuel
..................... 131
Octane number
................................. 217
Anti-lock Brake System (ABS)
.............. 148
Anti-theft alarm system
.......................... 27
Anti-theft locking system
........................ 27
Towing equipment
............................ 166
Approach lighting
................................... 94
Aquaplaning
......................................... 151
Armrests
............................................. 40, 42
Ashtrays
................................................... 67
Illumination
........................................ 100
Assist grips
............................................... 69
Automatic air recirculation
.................. 112
Automatic anti-dazzle exterior mirrors
.31 Automatic anti-dazzle interior mirror
... 32
Automatic dipped beam activation
...... 95
Automatic level control
.................. 97, 143
Automatic transmission
................. 18, 115
Automatic mode
............................... 116
Engine braking assistance
............... 118
Fault
................................................... 120
Interruption of power supply
............ 120
Kickdown
................................... 117, 118
Manual mode
.................................... 117
Rocking the vehicle
........................... 119
Selector lever
..................................... 116
Transmission display
........................ 116
Winter program
................................. 117
B
Battery ................................................... 200
Interruption of power supply
............ 120
Battery discharge protection
............... 100
Before starting-off
.................................. 18
Belt force limiters
.................................... 44
Belt tensioners
......................................... 44
Belts
....................................... 8, 42, 43, 204
Bleeding, diesel fuel system
................. 171
Board information display
............... 76, 78
Bonnet
.................................................... 171
Boot, see Luggage compartment
......... 41
Brake assist
........................................... 146
Brake fluid
............................................. 214
Brake system
......................................... 145