fuel OPEL COMBO 2010 Owner's Guide

169 Opel Service, maintenance
⊕Additional work.
o Intervals are shorter under extreme operating conditions and when such is necessary due to conditions specific to the country.
Service work after year
1)
km (x 1000)
1)
1)Whichever occurs first.
1
152
303
454
605
75
⊕
Replace toothed belt and tension roller
Z 16 YNGevery 6 years/90,000 km
Z 17 DTHevery 10 years/90,000 km
Z 16 XEPevery 10 years/150,000 km
Change engine oil and oil filter x x x x x
⊕o
Drain water from diesel fuel filter
(with high humidity and/or low fuel grade)xxxxx
Empty oil separator, Z 16 YNG every 4 years/60,000 km
Replace and drain water from fuel filter,
Z 13 DTJ, Z 17 DTHevery 2 years/60,000 km
Replace fuel filter, Z 16 YNG every 4 years/60,000 km
Check and adjust parking brake (wheels unladen); visually inspect wheel suspension
and spring suspension front and back, brake pipes, brake pressure hoses, fuel pipes,
gas lines on natural-gas powered vehicles and exhaust systemxx
Check external bodywork/underbody corrosion protection; note damage in the
Service and Warranty Bookletxxxxx
⊕o
Visually inspect front and rear wheel brakes
2)
2)If loss is great/leaks are present, carry out follow-up work with customer consent.
xx
Annual service check when the annual mileage is more than 20,000 km
Visually inspect engine, transmission (AT, MT), air conditioning compressor for leaks
2)
xxxxx
⊕o
Remove, clean and visually inspect brake drum every 4 years/60,000 km

171
Opel Service, maintenance
Additional service workAdditional work ⊕
Additional work is work which is not
required for every service but can be
carried out along with a regular service.
Time allowances for such work are not
included within the scope of a regular
service and must be accounted for
separately. However, it is more cost
effective to carry out this work as part of a
planned service than to have it done
separately.
Extreme operating conditions o
Operating conditions are considered
extreme when one or more of the following
occur frequently:
zCold starts,
zStop-and-go,
zCaravan/trailer towing,
zDriving on inclines and/or in high
altitudes,
zPoor road conditions,
zSand and dust,
zExtreme temperature fluctuations.
Police vehicles, taxis and driving school
vehicles are also classified as operating
under extreme conditions.When operating conditions are extreme, it
may be necessary to have certain service
work carried out more frequently than the
planned service intervals.
We recommend obtaining technical advice
for the service requirements of your vehicle
based on the special conditions of use.
Recommended fluids and
lubricants Only use products which have been tested
and approved. Damage caused by using
non-approved operating materials is not
covered by the warranty.
9 Warning
Fuels are dangerous and require
appropriate care when handling. If
swallowed, immediately call a doctor.
Do not inhale fumes and avoid contact
with the skin. Keep out of the reach of
children. Fuels must not be allowed to
contaminate wastewater, groundwater
or soils. Dispose of empty containers
properly. Always keep in mind that fuels
are hazardous to health.

177
Opel Service, maintenance
Diesel fuel filter On the event of engine oil change, have
fuel filter checked for possible water
residue by a workshop.
Illumination of A indicates water in the
fuel filter 3.
Have fuel filter checked at shorter intervals
if the vehicle is subjected to extreme
operating conditions such as high humidity
(primarily in coastal areas), extremely high
or low outside temperatures and
substantially varying daytime and
night-time temperatures.
Coolant The coolant provides anti-freeze
protection down to approx. -28 C. .
Picture no: 11676s.tif
Antifreeze and corrosion protection
Have the concentration of the radiator
contents tested by a workshop before
winter starts. The amount of antifreeze
must provide protection down to approx.
-28 C. A lower antifreeze concentration
will reduce the amount of protection from
frost and corrosion. Add antifreeze if
necessary.
If coolant loss is topped up with water,
have concentration checked and add
antifreeze if necessary. Caution
Only use approved anti-freeze.
Coolant additives for additional
corrosion protection and sealing small
leaks can cause operation problems. No
liability is accepted for damage caused
by using coolant additives.
9 Warning
Antifreeze is a danger to health; it must
therefore be kept in the original
container and out of the reach of
children.

182 Technical dataTechnical data
Picture no: 11679s.tif
Vehicle data The technical data is determined in
accordance with European Community
standards. We reserve the right to make
modifications. Specifications in the vehicle
documents always have priority over those
given in this Owner’s Manual.
The identification plate is affixed to the
front right door frame.
Picture no: 11724s.tif
In other versions the type plate is attached
to the right spring strut dome in the engine
compartment. Vehicle data ......................................... 182
Engine data.......................................... 184
Performance......................................... 185
Fuel consumption, CO
2-emissions ......
186
Fuel consumption, natural gas........... 186
Weights, payload and roof load ........ 189
Tyres ..................................................... 191
Capacities ............................................ 195
Dimensions ........................................... 196
Mounting dimensions of towing
equipment with fixed coupling
ball bar............................................... 197

184 Technical dataEngine data Sales designation
Engine identifier code1.4 TWINPORT
Z 14 XEPCNG
Z 16 YNG1.3 CDTI
Z 13 DTJ1.7 CDTI
Z 17 DTH
Number of cylinders 4 4 4 4
Piston displacement [cm
3 ] 1364 1598 1248 1686
Brake horse power [kW/bhp]
at rpm 66
560069
620055
400074
4400
Torque [Nm]
at rpm 125
4000133
4200170
1750 to 2500240
2300
Fuel type
1)
1)Standard high-quality fuels, unleaded DIN EN 228, diesel DIN EN 590. Any commercially available natural gas containing methane can be used for
natural gas operation.
Petrol Natural gas/petrol Diesel Diesel
Octane requirement [RON]
2)
recommended
possible
possible
Cetane requirement [CN]
2)
2)Standard high-quality fuels: R = Regular, P = Premium, PP = Premium Plus, D = Diesel. Value printed in bold: recommended fuel.
95 (P)
3)
98 (PP)
3)
91 (R)
3)4)
–
3)Knock control system automatically adjusts ignition timing according to type of fuel used (octane number). 4)Slight reduction in engine output and torque if 91 RON is used.
95 (P)
3)
98 (PP)
3)
–
––
–
–
49 (D)
5)
5)A lower value is possible with winter diesel fuels.
–
–
–
49 (D)
5)
Max. permissible engine speed,
continuous operation approx. [rpm ]. 6200 6400 5020 to 5180 5000 to 5200
Oil consumption [l/1000 km] 0.6 0.6 0.6 0.6

186 Technical dataFuel consumption, CO
2-emissions
Directive 80/1268/EEC (last changed by
2004/3/EC) has applied for the
measurement of fuel consumption since
1996.
The directive is oriented to actual driving
practices: Urban driving is rated at
approx.
1/3 and off-road driving with
approx. 2/3 (urban and extra-urban
consumption). Cold starts and acceleration
phases are also taken into consideration.
The specification of CO
2 emission is also a
constituent of the directive.The figures given must not be taken as a
guarantee for the actual fuel consumption
of a particular vehicle.
All values stem from the EU base model
with standard equipment.
The calculation of fuel consumption as
specified by directive 2004/3/EC takes
account of the vehicle’s kerb weight,
ascertained in accordance with the said
regulation. Optional extras may result in
slightly higher fuel consumption and CO
2
emission levels than those quoted.
Saving Fuel, Protecting the Environment
3108.
Fuel consumption, natural gasThe data on fuel consumption has been
ascertained with reference fuel G20
(methane content 99 - 100 mol%) under
prescribed driving conditions (see previous
columns). The fuel consumption values will
deviate from those specified if natural gas
with a lower methane content is used.
All values stem from the EU base model
with standard equipment. The
consumption calculated according to the
1999/100/EC directive takes into
consideration the kerb weight laid down in
agreement with this regulation. Additional
equipment as well as the gas condition,
filling station pressure, mode of driving and
the road and traffic conditions can lead to
higher consumptions and CO
2 values than
those specified.

187 Technical data
Fuel consumption, CO
2 emissions
(up to tyre width of 185 mm)

Fuel consumption, CO
2 emissions
(up to tyre width of 205 mm)

Engine
Z 14 XEP Z 13 DTJ Z 17 DTH
Manual/manual transmission automated
urban [l/100 km]
extra-urban [l/100 km]
altogether [l/100 km]
CO
2 [g/km] 7.9/–
5.2/–
6.2/–
148/– 6.1/ 5.9
4.5/ 4.5
5.1/ 5.0
134/135 6.6/–
4.4/–
5.2/–
140/–
Engine
Z 14 XEP Z 13 DTJ Z 17 DTH
Manual/manual transmission automated
urban [l/100 km]
extra-urban [l/100 km]
altogether [l/100 km]
CO2 [g/km] 8.1/–
5.4/–
6.4/–
153/– 6.3/ 6.1
4.7/ 4.7
5.3/ 5.2
139/140 6.8/–
4.6/–
5.4/–
146/–

188 Technical dataFuel consumption
(H gas)
1)
1)These values relate to the use of test gas G20 (H gas) in compliance with calculation method
1999/100/EC
.
Engine Z 16 YNG
Manual transmission
urban [m
3/100 km]
extra-urban [m
3/100 km]
altogether [m3/100 km] 10.1
5.9
7.5
Fuel consumption
(H gas)
1)
Engine
Z 16 YNG
Manual transmission
urban [kg/100 km]
extra-urban [kg/100 km]
altogether [kg/100 km] 6.6
3.9
4.9 CO
2 emissions
2)(natural gas operation, g/km according to 80/1268/EEC)
2)Emission reduction as per Euro4.Engine Z 16 YNG
CO
2 altogether [g/km] 133

195 Technical data
CapacitiesEngine oil
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Incl. filter [l] 3.5 3.5 5.0
Between MIN and MAX [l] 1.0 1.0 1.0
Fuel tank
EngineZ 14 XEP Z 13 DTJ Z 17 DTH
Petrol/diesel, nominal capacity [l] 52 52 52
Engine oil
EngineZ 16 YNG
Incl. filter [l]3.5
Between MIN and MAX [l]1.0
Fuel tank
EngineZ 16 YNG
Natural gas, nominal capacity [kg]
petrol, nominal capacity [l]17.5
1)
14
1)17.5 kg (average fill limit), corresponding to a tank volume of 108 l. Fill weight in kg is dependent on outside temperature, filling pressure and type of
tank system.

198 IndexIndex
AABS (Anti-lock Braking System) ........... 119
Accessories ............................................. 133
Accessory socket ..................................... 61
Air intake .................................................. 99
Air recirculation system ........................... 97
Air vents ................................................... 93
Airbags ..................................................... 56
Alarm ........................................................ 33
Alternator ................................................. 69
Antenna ........................................... 90, 161
Anti-corrosion service ............................ 173
Antifreeze ............................................... 177
Antifreeze protection .................... 177, 180
Anti-knock quality of fuel
Octane number .................................. 184
Anti-theft alarm system .......................... 31
Anti-theft lock
Alloy wheels ....................................... 139
Anti-theft protection ............................... 17
Aquaplaning .......................................... 123
Ashtray ..................................................... 62
BBattery ........................................... 107, 180
Interruption of power supply ...... 37, 105
Before starting off ................................... 15
Belt tensioners ......................................... 49
Bleeding, diesel fuel system ................. 128
Bonnet .................................................... 128
Boot, see Luggage
compartment ............................. 28, 29, 42
Brake assist ............................................ 120
Brake lamps ........................................... 157
Brake system ......................................... 118
Brakes
ABS ..................................................... 119
Brake assist ........................................ 120
Brake lamps ....................................... 157
Brake servo unit ................................. 106
Hand brake ........................................ 120
Bulb replacement .................................. 151
Bulbs ....................................................... 151