engine oil PEUGEOT 207 2011 User Guide

8
i
CHECKS
130
CHECKS
Unless otherwise indicated, check these
components in accordance with the
Warranty and Maintenance Record and in
relation to your engine.
Otherwise, have them checked by a
PEUGEOT dealer or a qualifi ed workshop.


Battery

The battery does not require
any maintenance.
However, check that the ter-
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.


Air filter and passenger compartment filter

Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
vals for these components.
Depending on the environ-
ment (dusty atmosphere...) and the use
of the vehicle (city driving...), replace
them twice as often if necessary
.
A clogged passenger compartment fi lter
may have an adverse effect on the per-
formance of the air conditioning system
and generate undesirable odours.


Particle emission filter (Diesel)

Illumination of the service warning lamp togeth-
er with a related message indicates the start of
saturation of the particle emissions fi lter.
As soon as the driving conditions permit, re-
generate the fi lter by driving at a speed of at
least 35 mph (60 km/h) until the service warn-
ing lamp goes off.
Maintenance of the particle emission fi lter
must be carried out by a PEUGEOT dealer or
a qualifi ed workshop.


Oil filter

Replace the oil fi lter each time
the engine oil is changed.
Refer to the Warranty and
Maintenance Record for de-
tails of the replacement inter-
val for this component. Following prolonged operation of
the vehicle at very low speed or at
idle, you may, exceptionally, notice
the emission of water vapour at
the exhaust on acceleration. This
does not have any adverse effect
on the performance of the vehicle
or on the environment.

8
!
CHECKS
131

Automatic gearbox

The gearbox does not re-
quire any maintenance (no oil
change).

Refer to the Warranty and
Maintenance Record for de-
tails of the checking intervals
for this component.


Parking brake

If the parking brake travel is too
long or if you notice a loss of effec-
tiveness of this system, the parking
brake must be adjusted, even be-
tween two services.
This system must be checked by a PEUGEOT
dealer or a qualifi ed workshop.


Manual gearbox

The gearbox does not re-
quire any maintenance (no oil
change).

Refer to the Warranty and
Maintenance Record for de-
tails of the level checking in-
tervals for this component.


Brake disc and drum wear

For any information relating
to checking of the brake disc
and/or drum wear, contact a
PEUGEOT dealer or a quali-
fi ed workshop. Only use products recommend-
ed by PEUGEOT or products of
equivalent quality and specifi ca-
tions.
In order to optimise the operation
of units as important as the brak-
ing system, PEUGEOT selects
and offers very specifi c products.
To avoid damaging the electrical
units, the use of a high pressure
washer in the engine compart-
ment is strictly prohibited
.


Brake pads

Brake wear depends on the
style of driving, particularly in
the case of vehicles used in
town, over short distances. It
may be necessary to have the
condition of the brakes checked, even
between vehicle services.
Unless there is a leak on the circuit, a
drop in the brake fl uid level indicates
that the brake pads are worn.

9
!
PRACTICAL INFORMATION
135

2. Infl ation


)
Turn the selector A
to the
"air" position.

)
Uncoil the black pipe H
fully.

)
Connect the black pipe to
the valve of the wheel.
)
Connect the compressor's electric
plug to the vehicle's 12 V socket.

)
Start the vehicle again and leave the
engine running.
)
Adjust the pressure using the com-
pressor (to infl ate: switch B
in po-
sition "I"
; to defl ate: switch B
in
position "O"
and press button C
), in
accordance with the vehicle's tyre
pressure label (located on the left
hand door aperture).
A loss of pressure indicates that the
puncture has not been fully plugged;
contact a PEUGEOT dealer or qual-
ifi ed workshop for assistance.

)
Remove and stow the kit.

)
Drive at reduced speed (50 mph
[80 km/h] max) limiting the distance
travelled to approximately 120 miles
(200 km).
)
Visit a PEUGEOT dealer or a
qualifi ed workshop as soon as
possible.
You must inform the techni-
cian that you have used this
kit. After inspection, the tech-
nician will inform you whether
the tyre can be repaired or
must be replaced.

9
!
PRACTICAL INFORMATION
136

Removing the cartridge




)
Stow the black pipe.

)
Detach the angled base from the
white pipe.

)
Support the compressor vertically.

)

Unscrew the cartridge from the bottom.



Beware of discharges of fl uid.
The expiry date of the fl uid is indi-
cated on the cartridge.
The sealant cartridge is designed
for single use; even if only partly
used, it must be replaced.
After use, do not discard the car-
tridge into the environment, take
it to an authorised waste disposal
site or a PEUGEOT dealer.
Do not forget to obtain a new sealant
cartridge, available from PEUGEOT
dealers or from a qualifi ed work-
shop.



Checking tyre pressures/
inflating accessories

You can also use the compressor, without
injecting any product, to:


- check or adjust the pressure of your
tyres,

- infl ate other accessories (balls, bi-
cycle tyres...).


)
Turn the selector A
to the
"Air" position.

)
Uncoil the black pipe H
fully.

)
Connect the black pipe to
the valve of the wheel or accessory.
If necessary, fi t one of the adaptors
supplied with the kit fi rst.
)
Connect the compressor's electri-
cal connector to the vehicle's 12 V
socket.

)
Start the vehicle and let the engine
run.

)
Adjust the pressure using the com-
pressor (to infl ate: switch B
in
position "I"
; to defl ate: switch B
in
position "O"
and press button C
),
according to the vehicle's tyre pres-
sure label or the accessory's pres-
sure label.

)
Remove the kit then stow it.

9PRACTICAL INFORMATION
151

Engine compartment fuses

The fusebox is placed in the engine
compartment, near the battery (left-
hand side).

Access to the fuses


)
Unclip the cover.

)
Replace the fuse (refer to the cor-
responding paragraph).

)
When you have fi nished, carefully
close the cover carefully to ensure
correct sealing of the fusebox.

Fuse table


Fuse N°



Rating



Functions




F1



20 A

Engine control unit and fan assembly control relay
supply, timing and canister electrovalves (1.6 litre
16V THP), air fl ow sensor (Diesel), injection pump
(Diesel), water in diesel sensor (Diesel), EGR
electrovalves, air heating (Diesel).


F2



15 A

Horn.


F3



10 A

Front and rear screenwash.


F4



20 A

Headlamp wash.


F5



15 A

Fuel pump (petrol), Turbo electrovalves (1.6 l 16V
THP).


F6



10 A

Vehicle speed sensor, automatic gearbox.


F7



10 A

Electric power steering, switching and protection
unit (Diesel).


F8



25 A

Starter motor control.


F9



10 A

ABS/ESP control unit, brake pedal switch.


F10



30 A

Engine control unit actuators (petrol: ignition coils,
electrovalves, oxygen sensors, injectors, heaters,
electronic thermostat) (Diesel: electrovalves,
heaters).


F11



40 A

Air conditioning blower.


F12



30 A

Windscreen wipers Low/High speed.

10
162
TECHNICAL DATA

*
Not available on SW Outdoor. MODELS:
ENGINES AND GEARBOXES

PETROL ENGINES


1.4 litre 75 hp

*


1.4 litre VTi 95 hp


Cubic capacity (cc)
1 360
1 397
Bore x stroke (mm)
75 x 77
75 x 77
Maximum power: EU standard (kW)
54
70
Maximum power engine speed (rpm)
5 400
6 000
Maximum torque: EU standard (Nm)
11 8
136
Maximum torque engine speed (rpm)
3 300
4 000
Fuel
Unleaded
Unleaded
Catalytic converter
Yes
Yes

GEARBOXES

Manual
(5-speed)
Manual
(5-speed)

OIL CAPACITIES (in litres)






Engine (with fi lter replacement)
3.25
4.25

10TECHNICAL DATA
163

MODELS:


ENGINES AND GEARBOXES



PETROL ENGINES


1.6 litre VTi 120 hp



1.6 litre THP 156 hp **


Cubic capacity (cc)
1 598
1 598
Bore x stroke (mm)
77 x 85.8
77 x 85.8
Maximum power: EU standard (kW)
88
115
Maximum power engine speed (rpm)
6 000
5 800
Maximum torque: EU standard (Nm)
160
240
Maximum torque engine speed (rpm)
4 250
1 400
Fuel
Unleaded
Unleaded
Catalytic converter
Yes
Yes

GEARBOXES

Manual
(5-speed)
Automatic
(4-speed)
Manual
(6-speed)

OIL CAPACITIES
(in litres)








Engine (with fi lter replacement)
4.25
4.25
4.25

**
Only on 5-door saloon.

10
170
TECHNICAL DATA

MODELS:


ENGINES AND GEARBOXES



DIESEL ENGINES


1.4 litre HDi 70 hp
PEF *



1.6 litre HDi 90 hp
PEF 98g *



1.6 litre HDi 92 hp
PEF


1.6 litre HDi
112 hp PEF

Cubic capacity (cc)
1 398
1 560
1 560
1 560
Bore x stroke (mm)
73.7 x 82
75 x 88.3
75 x 88.3
75 x 88.3
Maximum power: EU standard (kW)
50
66
68
82
Maximum power engine speed (rpm)
4 000
4 000
4 000
4 000
Maximum torque: EU standard (Nm)
160
215
230
270
Maximum torque engine speed (rpm)
2 000
1 750
1 750
1 750
Fuel
Diesel
Diesel
Diesel
Diesel
Catalytic converter
Yes
Yes
Yes
Yes
Particle emission fi lter
Yes
Yes
Yes
Yes

GEARBOXES

Manual
(5-speed)
Manual
(5-speed)
Manual
(5-speed)
Manual
(6-speed)

OIL CAPACITIES (in litres)










Engine (with fi lter replacement)
3.75
3.25
3.25
3.25

*
Not available on SW and SW Outdoor.

239
VISUAL SEARCH
TECHNICAL DATA - MAINTENANCE

Running out of Diesel ............... 125
Checking levels .................128-129


- oil

- brake fl uid

- coolant

- screenwash/headlamp wash fl uid
Changing bulbs .................142-147


- front

- rear Petrol engines ...................162-169
Diesel engines ...................170-173
Dimensions ............................... 174
Identifi cation markings .............. 175
Opening the bonnet .................. 124
Under-bonnet layout, petrol ...... 126
Under-bonnet layout, Diesel ..... 127 Checking components .......130-131


- air fi lter

- passenger compartment fi lter

- oil fi lter

- brake pads/discs
Engine
compartment fuses ..........151-152
Battery ...............................153-154
Economy mode ........................ 155

240
ALPHABETICAL INDEX
Accessories ....................................160Accessories socket, 12V ............62,66Access to rear seats (3-door)..........................................52Adjusting headlamps........................85Adjusting seat belt height ...............105Adjusting the steering wheel............59Air conditioning.................................17Air conditioning (digital)..............46,50Air conditioning (manual)............46,47Air distribution adjustment..........47,50Air filter...........................................r130Air flow adjustment .....................47,50Air intake....................................47,50Air recirculation...........................47,50Air vents...........................................45Anti-pinch..........................................72Anti-theft steering lock ......................69Armrest .............................................52Assistance call........................101,178Athermic windscreen........................59Audible warning..............................102Audio streaming(Bluetooth)...................................224Automatic gearbox.................114,130Automatic illumination
of headlamps.................................84Automatic operation
of hazard warning lamps.............102Automatic rain sensitive windscreen
wipers............................................88Auxiliary socket..............................198Auxiliary sockets.......................60,222
Capacity, fuel tank............................79CD MP3 ..................................197, 219Central locking ..................................75Changing a bulb .............142,144, 146Changing a fuse.............................148Changing a wheel...........................137Changing a wiper blade .................155Changing the date ..........................202Changing the remote control battery...............................70Changing the time ....33,202,225, 226Checking levels .......................126-128Checking the engine oil level ...........30Checking tyre pressures (using the kit) ............................... 132Checks............................ 126,127, 130Child lock ........................................ 100Children...........................93,94,97-99
Child seats.......................................90Child seats, conventional ...........93,94Closing the boot .........................76,77Closing the doors .............................74Connectors, audio ....60,198,220,222Control for panoramic sunroof blind ..................................78Control stalk, wipers ...................86,88Coolant level ...................................128Coolant temperature indicator..........r31Courtesy lamps................................89Courtesy mirror.................................r59Cruise control.................................119Cup holder........................................r61Curtain airbags ........................110,111
Battery....................................130, 153Battery, remote control...............70, 71Battery recharge.............................153Bluetooth (hands-free)....199,200, 223Bluetooth (telephone).............199, 200Bonnet............................................124Bonnet stay....................................124Boot............................................76, 77Brake discs.....................................130Brake lamps...........................144, 146Brake pads.....................................130Braking assistance system.............103
AB
CD
Dashboard fusebox........................148Dashboard instruments ....................19Date (display).................................202Daytime running lamps.....................82Deactivating the passenger airbag ...108Deactivating the rear windows.........72Defrosting...................................47,49Demisting..........................................47Dials..................................................19Diesel additive level........................128Diesel engine ....................80,125,127Dimensions.....................................174Dipped beam ............................82,142Dipstick.............................................30Direction indicators.................101,142Door mirrors.....................................57Doors................................................74Door trays .........................................61