belt Peugeot 307 CC 2003 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2003, Model line: 307 CC, Model: Peugeot 307 CC 2003Pages: 173, PDF Size: 2.12 MB
Page 8 of 173
22-09-2003
125124
9YOUR 307 CC AT A GLANCE
AIR BAGS The air bag system has been designed to maximise the safetyof the occupants in the event ofserious collisions. It works in con-junction with the force limitingseat belts. Front air bags These are folded in the centre of the steering wheel for the driverand in the fascia for the front pas-
senger. They are deployed simul-
taneously, except in cases wherethe passenger air bag is dis-armed. Precautions regarding the passenger air bag disarm the air bag if you install a rear-facing child seat,
activate the air bag for an
adult passenger. Disarming the passenger air bag*
With the ignition off , insert
the ignition key into the pas- senger air bag slot 1and turn
it to the "OFF"position.
As soon as you remove the childseat, turn the air bag switch to the"ON" position, to activate the air
bag again. Disarming check
With the ignition switchedon (2nd notch), illumina-tion of this warning light,accompanied by an audi-
ble signal and the message"Passenger air bag deactivated"
on the multi-function display, indi-cates that the passenger air bagis disarmed (slot in the "OFF"
position). The warning light remains on throughout the disarming process. Side air bags The side air bags are incorporat- ed into the front seat back frame,on the door side and aredeployed independently of each
other, on whichever side the colli-sion occurs.
* According to destination.
Page 16 of 173
22-09-2003
PEUGEOT SERVICING19
SPECIAL FEATURES Some of your vehicle's vital components have specific servicing schedules. The brake fluid must be replaced every every 40,000 miles (60,000 km) or every 2 years.
The passenger compartment filter must be checked at each visitto the PEUGEOT dealer (intermediate visits and regu-
lar services).The timing belt: contact a PEUGEOT dealer.
Arduous conditions of use If the vehicle is used under certain particularly arduous conditions: Ð Continuous door-to-door use.
Ð Town use.
Ð Repeated short journeys, with the engine cold in low temperatures.
Or prolonged stay under the following conditions: Ð Countries with temperatures often above +30 ¡C.
Ð Countries with temperatures often below minus 15 ¡C.
Ð Countries with a dusty atmosphere.
Ð Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous conditions" service schedule which includes: Ð shorter service intervals:¥ Every 10,000 miles (15,000 km) or every year for the 2 litre 180 bhp engine vehicles. ¥ Every 12,000 miles (20,000 km) or every year for the 1.6 litre and 2 litre engine vehicles.
Ð special operations: ¥ Replacement of the air filter every 10,000 miles (15,000 km) for the 2 litre 180 bhp engine vehicles.
Page 22 of 173
22-09-2003
PEUGEOT SERVICING19
SPECIAL FEATURES Some of your vehicle's vital components have specific servicing schedules. The brake fluid must be replaced every every 40,000 miles (60,000 km) or every 2 years.
The passenger compartment filter must be checked at each visitto the PEUGEOT dealer (intermediate visits and regu-
lar services).The timing belt: contact a PEUGEOT dealer.
Arduous conditions of use If the vehicle is used under certain particularly arduous conditions: Ð Continuous door-to-door use.
Ð Town use.
Ð Repeated short journeys, with the engine cold in low temperatures.
Or prolonged stay under the following conditions: Ð Countries with temperatures often above +30 ¡C.
Ð Countries with temperatures often below minus 15 ¡C.
Ð Countries with a dusty atmosphere.
Ð Countries whose lubricants or fuels do not conform to our recommendations.
It is necessary to follow an "Arduous conditions" service schedule which includes: Ð shorter service intervals:¥ Every 10,000 miles (15,000 km) or every year for the 2 litre 180 bhp engine vehicles. ¥ Every 12,000 miles (20,000 km) or every year for the 1.6 litre and 2 litre engine vehicles.
Ð special operations: ¥ Replacement of the air filter every 10,000 miles (15,000 km) for the 2 litre 180 bhp engine vehicles.
Page 23 of 173
PEUGEOT SERVICING25
TYPE A AND C SERVICES AND THE INTERMEDIATE VISIT
Level
Operations Operation descriptions1st service visitA C Intermediate
DRAIN AND REFILLÐ Engine oil
Ð Oil filter Ð Fuel filter* REPLACEÐ Air filter element Ð Spark plugs Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if removable cap LEVELSÐ Front windscreen wash (check + top-up) Ð Coolant (check + top-up) Ð Brake fluid (check + top-up) Ð Power steering fluid (check + top-up according to specification) Ð Operation of lights and indicators Ð Condition of glass, headlamp and light lenses and mirrors Ð Horn Ð Windscreen jets Ð Condition of wiper blades Ð Condition and tension of the ancillary drive belts Ð Handbrake Ð Condition of hydraulic circuits (hoses and covers) and check for leaks CHECKÐ Condition of rubber boots and gaiters Ð Brake pad wear Ð Play in hubs, link rods, ball joints, flexible mountings Ð Shock absorbers: check for leaks Ð Rear drum brake lining wear Ð Condition and pressure of tyres (including spare tyre) Ð Emission control check according to current legislation Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle by a PEUGEOT dealer
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions : If there are specific conditions * According to destination.22-09-2003
Page 26 of 173
22-09-2003
INSTRUMENTS AND CONTROLS
28
PETROL INSTRUMENT PANEL DIALS: MANUAL GEARBOX
1 - Rev counter.
2 - Seat belt not fastened warning light.
3 - Engine diagnostics warninglight.
4 - Handbrake and low brake fluidlevel warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator.
7 - Battery charge warning light. 8 -
Central (STOP) warning light.
9 - Low fuel level warning light.
10 - Engine oil pressure warning light.
11 - Fuel gauge.
12 - Right-hand direction indicator.
13 - ABS warning light.
14 -
Air bags and rear, protective,pop-up roll-over hoops warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light.
21 - Front fog lamps indicator light.
22 - Low coolant level warning light*.
23 - Main beam headlampsindicator light.
24 - Dipped beam headlampsindicator light.
25 - Lighting rheostat.
26 - Engine oil temperature gauge.
* According to engine.
Page 27 of 173
22-09-2003
INSTRUMENTS AND CONTROLS29
PETROL INSTRUMENT PANEL DIALS: AUTOMATIC GEARBOX
1 - Rev counter.
2 - Seat belt not fastened warning light.
3 - Engine diagnostics warninglight.
4 - Handbrake and low brake fluidlevel warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator.
7 - Battery charge warning light. 8 -
Central (STOP) warning light.
9 - Low fuel level warning light.
10 - Engine oil pressure warning light.
11 - Fuel gauge.
12 - Right-hand direction indicator.
13 - ABS warning light.
14 -
Air bags and rear, protective,pop-up roll-over hoops warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light.
21 - Front fog lamps indicator light.
22 - Main beam headlamps indicator light.
23 - Dipped beam headlampsindicator light.
24 - Lighting rheostat.
25 - Engine oil temperature gauge.
26 - Snow programme indicatorlight.
27 - Gear lever position indicator.
28 - Sport programme indicator light.
Page 29 of 173
22-09-2003
INSTRUMENTS AND CONTROLS31
Electronic stability programme (ESP/ASR)warning light
This comes on for 3 seconds each time the ignition is switched on. If the light remains on or comes on when the engine is running and thevehicle is moving, it is accompaniedby an audible signal and the mes-sage "ESP/ASR not functioning"
on the multi-function display; contact
a PEUGEOT dealer. When the engine is running and the vehicle is moving, it flashes if thesystem is activated. It is lit permanently when it is disarmed.
Battery charge warning light
This comes on each time the ignition is switched on. If it comes on with the engine run- ning, it is accompanied by an audiblesignal and a message "Battery
charge fault" on the multi-function
display. It can indicate:
Ð faulty operation of the charging circuit,
Ð loose battery or starter terminals,
Ð a cut or slack alternator belt,
Ð an alternator fault.
Contact a PEUGEOT dealer.
Engine diagnostics warning light This comes on each time
the ignition is switched on. If it flashes when the engine is run- ning, accompanied by an audiblesignal and the message "Catalytic
converter fault" on the multi-func-
tion display, it indicates a malfunctionin the injection or ignition system.There is a risk of damage to the
catalytic converter.
Contact a PEUGEOT dealer as soon as possible. Passenger air bag disarmed indicatorlight
Illumination of this warning light is accompanied by an audible signaland the message "Passenger air
bag deactivated" on the multi-func-
tion display. If the passager air bag is disarmed, the indicator light comes on whenthe ignition is switched on andremains on. In all cases, if the warning light flashes,
contact a PEUGEOT dealer.
Air bags and rear, protective, pop-uproll-over hoopswarning light
This light comes on for a few seconds when the ignition is switched on. Illumination of this warning light, with the engine running, is accompaniedby an audible signal and a messageon the multi-function display: Ð "Air bag fault" , indicates a fault in
the front air bags or side air bags,
Ð "Roll-over hoops fault" , indicates
a fault in the pop-up roll-over hoops (located in the rear head restraints).
Contact a PEUGEOT dealer.
or
ABS warning light This light comes on for 3 seconds each time the ignition is switched on. If it remains on or comes on above
8 mph (12 kmh), this indicates a mal-
function of the ABS.
However, the vehicle retains conven- tional servo-assisted braking. Illumination of this light is accompa-nied by an audible signal and themessage
"ABS fault" on the multi-
function display.
Contact a PEUGEOT dealer.
Page 30 of 173
22-09-2003
INSTRUMENTS AND CONTROLS
32
Low fuel level warning light
The warning light comes on for three seconds when the ignition isswitched on. When this light comes on with the engine running, it is accompanied byan audible signal and the message"Fuel level low" on the multi-function
display. When the warning light comes on, you have enough fuel to driveapproximately 30 miles (50 km) .
The tank capacity is approximately
60 litres. This light flashes to indicate a mal- function of the fuel gauge.
Contact a PEUGEOT dealer. Coolant temperature indicator When the needle is in zone
A, the
temperature is correct. When the needle is in zone B, the
temperature is too high. The central
STOP warning light flashes, accom-
panied by an audible signal and themessage "Engine coolant temper-
ature high" on the multi-function
display.
You must stop immediately.
Warning: wait for the engine to cool
before topping up the level.The cooling system is pressurised.In order to avoid any risk of scalding, unscrew the cap two turns to allowthe pressure to drop. When the pressure has dropped, remove the cap and top up the level.
Contact a PEUGEOT dealer. Engine oil temperature indicator When the engine is running, this indicates the oil temperature. The temperature is too high if the maximum graduation is reached.The central
STOPwarning light
flashes, accompanied by an audiblesignal.
You must stop immediately.
Contact a PEUGEOT dealer.
Seat belt not fastened warning light
With the engine running, this indica- tor light comes on when the driver'sseat belt is not fastened.
Page 31 of 173
22-09-2003
INSTRUMENTS AND CONTROLS
32
Low fuel level warning light
The warning light comes on for three seconds when the ignition isswitched on. When this light comes on with the engine running, it is accompanied byan audible signal and the message"Fuel level low" on the multi-function
display. When the warning light comes on, you have enough fuel to driveapproximately 30 miles (50 km) .
The tank capacity is approximately
60 litres. This light flashes to indicate a mal- function of the fuel gauge.
Contact a PEUGEOT dealer. Coolant temperature indicator When the needle is in zone
A, the
temperature is correct. When the needle is in zone B, the
temperature is too high. The central
STOP warning light flashes, accom-
panied by an audible signal and themessage "Engine coolant temper-
ature high" on the multi-function
display.
You must stop immediately.
Warning: wait for the engine to cool
before topping up the level.The cooling system is pressurised.In order to avoid any risk of scalding, unscrew the cap two turns to allowthe pressure to drop. When the pressure has dropped, remove the cap and top up the level.
Contact a PEUGEOT dealer. Engine oil temperature indicator When the engine is running, this indicates the oil temperature. The temperature is too high if the maximum graduation is reached.The central
STOPwarning light
flashes, accompanied by an audiblesignal.
You must stop immediately.
Contact a PEUGEOT dealer.
Seat belt not fastened warning light
With the engine running, this indica- tor light comes on when the driver'sseat belt is not fastened.
Page 87 of 173
22-09-2003
YOUR 307 CC IN DETAIL
86
GENERAL POINTS RELATING TO CHILD SEATS Although one of PEUGEOT's main criteria when designing your vehicle, the safe- ty of your children also depends on you.
For maximum safety, please follow these precautions:
Ð Since 1992,
all children under the age of 10 must travel in approved child
seats* suited to their weight , on seats fitted with a seat belt.
Ð A child weighing less than 9 kg must travel in the rearwards facing position
both in the front and in the rear. PEUGEOT recommends that childrenshould travel in the "rearwards facing" position up to the age of two.
Ð Statistically, the safest seats in your vehicle for the transportation ofchildren are the rear seats. PEUGEOT recommends that children travel in the rear even when a "rearwards facing" child seat is used.
Ð If a child is travelling on a booster seat, check that the lap section of the seat belt passes over the child's thighs correctly. The chest section of the seat beltmust be positioned on the child's shoulder without touching the neck.PEUGEOT recommends that you use a booster seat with a back, fitted with a
seat belt guide.
Ð Remember to fasten the seat belt or the child seat harness keeping the slack
in relation to the child's body to a minimum , even for short journeys.
Rules for transporting children on the front passenger seat** Children under the age of 10 must not travel in the forwards facing position, unless the rear seats are already occupied by other children or the rear seatscannot be used (absent or folded). In this case, adjust the front passenger seatto the intermediate position and leave the passenger air bag armed. The transportation of children in the rearwards facing position is permitted. In this position, it is essential to disarm the passenger air bag. Otherwise, the childwould risk being killed or seriously injured if the air bag were to inflate.
* According to current legislation in the country.
** Consult the relevant administration in your country for information regarding the rules for transporting children on the front passenger seat.
"ISOFIX" MOUNTINGS The two rear seats of your vehicle are fitted with ISOFIX mountings .
These are two rings located betweenthe seat back and the seat cushion. The ISOFIX child seats are fitted
with two locks which are secured easily on these rings. Incorrect installation of a child seat in a vehicle compromises the protec-tion of the child in the event of a col-lision. This ISOFIX securing system guar- antees reliable, safe and fast fittingof the child seat in your vehicle. For information regarding the ISOFIX child seats approved for yourvehicle, contact your PEUGEOT
dealer.