oil Peugeot 307 CC 2003 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2003, Model line: 307 CC, Model: Peugeot 307 CC 2003Pages: 173, PDF Size: 2.12 MB
Page 15 of 173
22-09-2003
PEUGEOT SERVICING
18
PEUGEOT SERVICING
Your vehicle benefits from extended service intervals.
Ð For 2 litre 180 bhp engine vehicles: every 12,000 miles (20,000 km) or every two years.
Ð For 1.6 litre and 2 litre engine vehicles: every 20,000 miles (30,000 km) or every two years.
Your service indicator indicates when the services are due; the point at which a service is due is calculated from the last ind i-
cator reset (see corresponding section).The point at which a service is due is determined by two parameters:
Ð the distance travelled,
Ð the time elapsed since the last service. Note: the distance remaining may be weighted by the time factor, in accordance with the user's driving habits.
The extension of the service intervals means that the engine oil level must be checked regularly: topping up of the oil between oil changes is normal. It is for this reason that the PEUGEOT network invites you to an intermediate visit between each regular Service. The service indicator does not show when this service is due. It must be carried out every 10,000 miles (15,000 km) maximum for the 1.6 litre and 2 litre engines and every 6,000 miles (10,000 km) maximum for the 2 litre 180 bhpengines.
A PEUGEOT dealer will carry out a quick check, and will top up the levels if necessary (oil, coolant, screen-wash up to 2 litres). If the oil level is too low there is a risk of serious damage to the engine: check the engine oil level at least every 2,000 to 3,000 miles (3,000 to 5,000 km), depending on the conditions of use. This extended servicing has been made possible by modifications to our vehicles and to the lubricants:
THUS IT IS ESSENTIAL TO ONLY USE LUBRICANTS WHICH ARE SUITED TO YOUR ENGINE AND RECOMMENDED
BY THE MANUFACTURER (see "Lubricants" pages). * Whichever comes first.
Page 19 of 173
These services are to be carried out with 10W40 synthetically based oilminimum.
They can also be carried out with 5W30 Fuel Economy oilor with 5W40 synthetic oil .
Arduous conditions of use (see corresponding section).
* Whichever comes first.
PEUGEOT SERVICING
22
TYPES OF SERVICE Each vehicle has its own servicing cycle, based upon the engine type.
This cycle consists of alternating two types of service, A and C, intermediate visits and a few additional operations depending on your vehicle; these correspond to key stages in the life of your vehicle. When the first service is carried out and at each subsequent service, your dealer will advise you of the type and content of the next service due. THE MAINTENANCE CYCLE FOR YOUR 1.6 LITRE AND 2 LITRE 307 CC
Service every 20,000 miles (30,000 km) or 2 years.
1st service at 6,000 miles
(10,000 km) or 6 months*.
This is necessary in order
to benefit from the warranty. MILES (KM) 20,000 (30,000) 40,000 (60,000) 60,000 (90,000)
80,000 (120,000) 100,000 (150,000) 120,000 (180,000) 140,000 (210,000) 160,000 (240,000)
Intermediate top-upvisit incorporatedin the Servicing Schedule.
22-09-2003
Page 20 of 173
These services are to be carried out with 10W40 synthetically based oilminimum.
They can also be carried out with 5W30 Fuel Economy oilor with 5W40 synthetic oil .
Arduous conditions of use (see corresponding section).
* Whichever comes first.
PEUGEOT SERVICING
22
TYPES OF SERVICE Each vehicle has its own servicing cycle, based upon the engine type.
This cycle consists of alternating two types of service, A and C, intermediate visits and a few additional operations depending on your vehicle; these correspond to key stages in the life of your vehicle. When the first service is carried out and at each subsequent service, your dealer will advise you of the type and content of the next service due. THE MAINTENANCE CYCLE FOR YOUR 1.6 LITRE AND 2 LITRE 307 CC
Service every 20,000 miles (30,000 km) or 2 years.
1st service at 6,000 miles
(10,000 km) or 6 months*.
This is necessary in order
to benefit from the warranty. MILES (KM) 20,000 (30,000) 40,000 (60,000) 60,000 (90,000)
80,000 (120,000) 100,000 (150,000) 120,000 (180,000) 140,000 (210,000) 160,000 (240,000)
Intermediate top-upvisit incorporatedin the Servicing Schedule.
22-09-2003
Page 21 of 173
PEUGEOT SERVICING23
72,000 (120,000) 84,000 (140,000) 96,000 (160,000) 108,000 (180,000) 120,000 (200,000) 132,000 (220,000) 144,000 (240,000)
THE MAINTENANCE CYCLE FOR YOUR 2 LITRE 180 BHP 307 CC
Service every 12,000 miles (20,000 km) or 2 years.
1st service at 6,000 miles
(10,000 km) or 6 months*.
This is necessary in order
to benefit from the warranty.
These services are to be carried out with 5W40 synthetic based oilonly.
Arduous conditions of use (see corresponding section).
* Whichever comes first. Intermediate top-up visit included in the Servicing Schedule.
MILES (KM)
12,000 (20,000) 24,000 (40,000) 36,000 (60,000) 48,000 (80,000) 60,000 (100,000)
22-09-2003
Page 23 of 173
PEUGEOT SERVICING25
TYPE A AND C SERVICES AND THE INTERMEDIATE VISIT
Level
Operations Operation descriptions1st service visitA C Intermediate
DRAIN AND REFILLÐ Engine oil
Ð Oil filter Ð Fuel filter* REPLACEÐ Air filter element Ð Spark plugs Ð Engine oil (check + top-up) Ð Manual gearbox oil (check + top-up) Ð Battery (check + top-up) if removable cap LEVELSÐ Front windscreen wash (check + top-up) Ð Coolant (check + top-up) Ð Brake fluid (check + top-up) Ð Power steering fluid (check + top-up according to specification) Ð Operation of lights and indicators Ð Condition of glass, headlamp and light lenses and mirrors Ð Horn Ð Windscreen jets Ð Condition of wiper blades Ð Condition and tension of the ancillary drive belts Ð Handbrake Ð Condition of hydraulic circuits (hoses and covers) and check for leaks CHECKÐ Condition of rubber boots and gaiters Ð Brake pad wear Ð Play in hubs, link rods, ball joints, flexible mountings Ð Shock absorbers: check for leaks Ð Rear drum brake lining wear Ð Condition and pressure of tyres (including spare tyre) Ð Emission control check according to current legislation Ð Passenger compartment filter (according to specification) Ð Visual check of the whole vehicle by a PEUGEOT dealer
SERVICE*Ð Courtesy vehicle
ROAD TEST
: All driving conditions : If there are specific conditions * According to destination.22-09-2003
Page 24 of 173
22-09-2003
PETROLPETROL
(1) Minimum quality standard: Petrol engines: ACEA A3 and API SH/SJ
ACEA = Association des Constructeurs EuropŽens Automobiles (Association of European
Automobile Manufacturers) - API =American Petroleum Institute.
If oil is used which does not conform to the ACEA A3-B3 standards, this requires the "Arduous Conditions" servicing schedule to be followed, which involves shorter intervals between services.
TRADE NAMES OF RECOMMENDED ENGINE LUBRICANTS IN EUROPE (1)
26
Page 25 of 173
22-09-2003
PEUGEOT SERVICING27
Recommended lubricants The oils which appear in the table opposite are suitable for most pur-poses. The diagram opposite states the optimum range of viscosity depend-ing on the temperatures at which theoils are to be used. It is also possible to use 'superior quality' synthetic oils. In the absence of semi-synthetic or
synthetic oils, oils of API SH/SJ qualitymay be used by following the 'arduousconditions' servicing schedule whichspecifies shorter service intervals. Do not hesitate to ask for advice
from an approved PEUGEOT dealerto maintain driving pleasure and tominimise the maintenance cost ofyour vehicle. For vehicles outside Europe, please
contact a local PEUGEOT dealer.
ONLY ONLY
Manual ESSO GEAR OIL BVTOTAL TRANSMISSION BVgearbox 75W-80 PR 9736.41 75W-80 PR 9730.A2
ONLY
Automatic ESSO ATF 4HP20-AL4
gearbox PR 9736.22
Power steering FLUIDE DA PR 9730.A1
Brake fluid PEUGEOT DOT4Coolant
PROCOR TM108/GLYSANTIN G33 or REVKOGEL 2000ONLY Protection to minus 35 ¡C
Other recommended products
Page 26 of 173
22-09-2003
INSTRUMENTS AND CONTROLS
28
PETROL INSTRUMENT PANEL DIALS: MANUAL GEARBOX
1 - Rev counter.
2 - Seat belt not fastened warning light.
3 - Engine diagnostics warninglight.
4 - Handbrake and low brake fluidlevel warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator.
7 - Battery charge warning light. 8 -
Central (STOP) warning light.
9 - Low fuel level warning light.
10 - Engine oil pressure warning light.
11 - Fuel gauge.
12 - Right-hand direction indicator.
13 - ABS warning light.
14 -
Air bags and rear, protective,pop-up roll-over hoops warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light.
21 - Front fog lamps indicator light.
22 - Low coolant level warning light*.
23 - Main beam headlampsindicator light.
24 - Dipped beam headlampsindicator light.
25 - Lighting rheostat.
26 - Engine oil temperature gauge.
* According to engine.
Page 27 of 173
22-09-2003
INSTRUMENTS AND CONTROLS29
PETROL INSTRUMENT PANEL DIALS: AUTOMATIC GEARBOX
1 - Rev counter.
2 - Seat belt not fastened warning light.
3 - Engine diagnostics warninglight.
4 - Handbrake and low brake fluidlevel warning light.
5 - Left-hand direction indicator.
6 - Coolant temperature indicator.
7 - Battery charge warning light. 8 -
Central (STOP) warning light.
9 - Low fuel level warning light.
10 - Engine oil pressure warning light.
11 - Fuel gauge.
12 - Right-hand direction indicator.
13 - ABS warning light.
14 -
Air bags and rear, protective,pop-up roll-over hoops warning light.
15 - Passenger air bag disarming indicator light.
16 - Speedometer.
17 - Service indicator, oil level and
total distance recorder.
18 - Trip recorder zero reset.
19 - Rear fog lamp indicator light.
20 - ESP/ASR warning light.
21 - Front fog lamps indicator light.
22 - Main beam headlamps indicator light.
23 - Dipped beam headlampsindicator light.
24 - Lighting rheostat.
25 - Engine oil temperature gauge.
26 - Snow programme indicatorlight.
27 - Gear lever position indicator.
28 - Sport programme indicator light.
Page 28 of 173
22-09-2003
INSTRUMENTS AND CONTROLS
30
INSTRUMENTS AND CONTROLS
A permanently lit warning light or one that flashes with the engine run-ning, indicates an operating fault inthe relevant unit. Some warninglights may be linked to buzzers anda message on the multi-function dis-
play. Do not ignore this warning:contact a PEUGEOT dealer as soonas possible.
If the Central STOP warning light comes on when you are driving,stop immediately where it is safeto do so.
Central STOP warning light
This light comes on each time the ignition is switched on. It is linked to the "engine oil pres- sure", ''coolant level low'', ''brakefluid level'' and "electronic brakeforce distribution fault'' warning lightsand the ''coolant temperature'' and"engine oil temperature" gauges. Stop immediately if it flashes with the engine running.
Contact a PEUGEOT dealer. Engine oil pressure warning light
Linked to the central STOPwarning
light. If it comes on with the engine running, it is accompanied by an audible signaland the message "Oil pressure
insufficient" or "Top up engine oil
level" on the multi-function display.
Stop immediately. If there is a lack of oil in the lubrication circuit, top up the level.
Contact a PEUGEOT dealer without
delay.
Low coolant level warning light*
Linked to the central STOPwarning
light. This comes on for approximately
3 seconds each time the ignition isswitched on. This warning light is accompanied by an audible signal and the message
"Top up engine coolant level" on
the multi-function display.
Stop immediately.
* According to engine. Warning:
Allow the engine to cool
before topping up. The cooling system is pressurised.
To prevent the risk of scalding, unscrew the cap by two turns toallow the pressure to drop. Once the pressure has dropped, remove the cap and top up the level.
Contact a PEUGEOT dealer.
Handbrake and low brake fluid levelwarning light Linked to the central STOP
warning light. This comes on each time the ignition is switched on. Illumination of this light is accompa- nied by an audible signal and a mes-sage on the multi-function displayindicating the cause of the warning: Ð "Handbrake on" , if the handbrake
is applied or has not been released
correctly,
Ð "Brake fluid level low" if there is
an excessive drop in the brake fluid(if the light remains on even with thehandbrake released),
Ð "Braking fault" is displayed simul-
taneously with the ABS light, indi-cating a malfunction of the elec-tronic brake force distribution.
Stop immediately.
Contact a PEUGEOT dealer.