light PEUGEOT 308 SW BL 2010 Workshop Manual

1
!
i
162
CHECKS
Avoid prolonged contact of used oil
or fl uids with the skin.
Most of these fl uids are harmful to
health or indeed very corrosive.
Do not discard used oil or fl uids
into sewers or onto the ground.
Take used oil to a PEUGEOT dealer
(France) or an authorised waste dis-
posal site.










Diesel additive level (Diesel
engine with particle emission
filter)
A low additive level is indicated by light-
ing of the service warning lamp, accom-
panied by an audible warning and a
message on the multifunction screen.








Used products
CHECKS

Unless otherwise indicated, check
these components in accordance with
the Maintenance and Warranty Guide
and according to your engine.
Otherwise, have them checked by a
PEUGEOT dealer.

Battery

The battery does not require
any maintenance.

However, check that the ter-
minals are clean and correctly
tightened, particularly in sum-
mer and winter.
When carrying out work on the battery,
refer to the "Practical information" sec-
tion for details of the precautions to be
taken before disconnecting the battery
and following its reconnection.

Air filter and passenger compartment filter


Refer to the Maintenance and
Warranty Guide for details of
the replacement intervals for
these components.
Depending on the environ-
ment (e.g. dusty atmosphere) and the
use of the vehicle (e.g. city driving),
replace them twice as often if neces-
sary
(refer to the "Engines" section).
A clogged passenger compartment fi lter
may have an adverse effect on the per-
formance of the air conditioning system
and generate undesirable odours.


Particle emission filter (Diesel)



It is imperative that the maintenance of
the particle emission fi lter is carried out
by a PEUGEOT dealer.


Oil filter

Replace the oil fi lter each time
the engine oil is changed.
Refer to the Maintenance and
Warranty Guide for details of
the replacement interval for
this component.
Following prolonged operation of
the vehicle at very low speed or at
idle, you may, in exceptional cir-
cumstances, notice the emission
of water vapour at the exhaust on
acceleration. This does not affect
the behaviour of the vehicle or the
environment.
Topping up
This additive must be topped up by a
PEUGEOT dealer without delay.

1
188
PRACTICAL INFORMATION


Fuse N°



Rating



Functions




G36



30 A

Driver and passenger heated seats.


G37



5 A

Driving position memory unit, lighting rheostat.


G38



30 A

Driver’s seat memory unit.


G39



30 A

Trailer fusebox supply.


G40



-

Not used.

Fuse N°



Rating



Functions




F12



15 A

Instrument panel, seat belt and passenger’s front
airbag warning lamps display, air conditioning,
driver’s seat memory unit, 2nd row rear seat
switches, driving school module.


F13



5 A

Engine fusebox, airbags, electronic gear control
gearbox gear lever, trailer fusebox.


F14



15 A

Multifunction screen, amplifi er, Bluetooth system,
rain/brightness sensor, parking sensors control
unit.


F15



30 A

Locking and deadlocking.


F17



40 A

Rear screen and door mirrors defrosting.


SH



-

PARC shunt.

1
i
i
!
197
PRACTICAL INFORMATION
TOWING A TRAILER,A CARAVAN, ETC.
Your vehicle is primarily designed for
transporting people and luggage, but it
may also be used for towing a trailer.

Driving advice

As the fan is electrically controlled, its
cooling capacity is not dependent on
the engine speed.


)
To lower the engine speed, reduce
your speed.
The maximum towing load on a long
slope depends on the gradient and the
ambient temperature.
In all cases, pay attention to the coolant
temperature.

Side wind


)
Take into account the increased
sensitivity to side wind.


Cooling
Towing a trailer on a slope increases
the temperature of the coolant.
Braking
Towing a trailer increases the braking
distance.

Tyres


)

Check the tyre pressures of the towing
vehicle and of the trailer, observing the
recommended pressures.



Lighting


)
Check the electrical lighting and
signalling on the trailer.
The rear parking sensors will be de-
activated automatically if a genuine
PEUGEOT towbar is used.


)
If the warning lamp and the
STOP
warning lamp come
on, stop the vehicle and
switch off the engine as
soon as possible.

Towbar suitable for the attachment of a
trailer or caravan with additional lighting
and signalling.

Distribution of loads


)
Distribute the load in the trailer so
that the heaviest items are as close
as possible to the axle and the nose
weight approaches the maximum
permitted without exceeding it.
Air density decreases with altitude, thus
reducing engine performance. Above
1 000 metres, the maximum towing load
must be reduced by 10 % and so on for
every 1 000 metres of altitude.
Refer to the "Technical Data" section for
details of the weights and towing loads
which apply to your vehicle. Driving with a trailer subjects the towing
vehicle to more signifi cant stress and its
driver must be particularly careful.
We recommend the use of genuine
PEUGEOT towbars and their har-
nesses that have been tested and
approved from the design stage
of your vehicle, and that the fi t-
ting of the towbar is entrusted to a
PEUGEOT dealer.
If the trailer is not fi tted by a
PEUGEOT dealer, it is imperative
that it is fi tted using the electrical
pre-equipment installed at the rear
of the vehicle, in accordance with
the manufacturer's instructions.
If your vehicle is fi tted with the
1.6 THP 200 hp engine, you can-
not fi t a towbar. The space occu-
pied by the sport exhaust system
prevents this.

1
205
TECHNICAL DATA
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


1.4 litre VTi 16V
95 hp



1.4 litre VTi 16V
98 hp



1.6 litre VTi 16V 120 hp



Gearboxes


Manual



Manual



Manual



Auto.



Model codes:
4C...


8FS-C



8FR-0



5FW-C



5FS-0



5FW-F



5FS-9




- Unladen weight
1 271
1 271
1 287
1 287
1 312
1 312


- Kerb weight
1 346
1 346
1 362
1 362
1 387
1 387


- Payload
489
509
528
528
512
523


- Gross vehicle weight (GVW)
1 760
1 780
1 815
1 815
1 824
1 835


- Gross train weight (GTW)
on a 12 % gradient
2 960
2 980
3 215
3 315
3 094
3 085


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 200
1 200
1 400
1 500
1 270
1 250


- Braked trailer * (with load transfer
within the GTW limit)
1 450
1 450
1 650
1 500
1 520
1 500


- Unbraked trailer
670
670
680
680
690
690


- Recommended nose weight
58
60
76
76
61
60

*
The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

1
206
TECHNICAL DATA


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


1.6 litre 16V
108 hp



1.6 litre THP 16V
150 hp


1.6 litre THP 16V
140 hp



1.6 litre THP 16V 156 hp



Gearboxes


Manual



Manual



Auto.



Manual



Auto.



Model codes:



4C...


N6A-B
N6A-C



5FX-H



5FT-F



5FV-8



5FV-A




- Unladen weight
1 302
1 340
1 355
1 315
1 368


- Kerb weight
1 377
1 415
1 430
1 390
1 443


- Payload
518
500
500
525
502


- Gross vehicle weight (GVW)
1 820
1 840
1 855
1 840
1 870


- Gross train weight (GTW)
on a 12 % gradient
3 020
3 290

3 255
3 390
3 470


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 200
1 450
1 400
1 550
1 600


- Braked trailer * (with load transfer
within the GTW limit)
1 450
1 700
1 650
1 650
1 650


- Unbraked trailer
685
705
715
695
720


- Recommended nose weight
60
68
66
70
70
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load. *

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

1TECHNICAL DATA


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


1.6 litre THP 16V 200 hp



2 litre 16V 140 hp



Gearboxes


Manual



Manual



Auto.



Model codes:
4C...


5FU-8



RFJ-B
RFJ-C



RFJ-E
RFJ-F




- Unladen weight
1 399
1 323
1 348


- Kerb weight
1 474
1 398
1 423


- Payload
451
502
502


- Gross vehicle weight (GVW)
1 850
1 825
1 850


- Gross train weight (GTW)
on a 12 % gradient
1 850
3 225
3 250


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
X
1 400

1 400


- Braked trailer * (with load transfer
within the GTW limit)
X
1 650
1 650


- Unbraked trailer
X
695
710


- Recommended nose weight
X
70
70
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load. *

The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

1
208
TECHNICAL DATA

* The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

WEIGHTS AND TOWED LOADS (in kg)



BioFlex engines


1.6 litre 16V 110 hp



2 litre 16V 140 hp



Gearboxes


Manual



Manual



Model codes:
4C...


NFU-C/FF



RFJ-C/FF




- Unladen weight
1 307
1 307


- Kerb weight
1 382
1 382


- Payload
447
447


- Gross vehicle weight (GVW)
1 754
1 754


- Gross train weight (GTW)
on a 12 % gradient
2 954
3 154


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 200
1 400


- Braked trailer * (with load transfer
within the GTW limit)
1 450
1 650


- Unbraked trailer
690
690


- Recommended nose weight
60
66
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.

1
209
TECHNICAL DATA


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines




1.4 litre VTi 16V
95 hp


1.4 litre VTi 16V
98 hp



1.6 litre VTi 16V 120 hp



1.6 litre 16V
108 hp



Gearboxes


Manual



Manual



Manual



Auto.



Manual



Model codes: 4E...


8FS-C



8FR-0



5FW-C


5FS-0



5FW-F



5FS-9



N6A-B
N6A-C




- Unladen weight
1 351
1 320
1 362
1 320
1 388
1 356
1 374


- Kerb weight
1 426
1 395
1 437
1 395
1 463
1 431
1 449


- Payload
569
600
560
602
560
592
576


- Gross vehicle weight (GVW)
1 920
1 920
1 922
1 922
1 948
1 948
1 950


- Gross train weight (GTW)
on a 12 % gradient
2 970
3 020
3 172
3 272
3 098
3 298
3 150


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 050
1 100
1 250
1 350
1 150
1 350
1 200


- Braked trailer * (with load transfer
within the GTW limit)
1 350
1 100
1 550
1 500
1 450
1 500
1 400


- Unbraked trailer
710
695
715
695
730
715
720


- Recommended nose weight
60
60
65
65
60
60
75
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.
* The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

1TECHNICAL DATA


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines




1.6 litre THP 16V
150 hp


1.6 litre THP 16V
140 hp



1.6 litre THP 16V 156 hp



BioFlex 2 litre
16V 140 hp


Gearboxes


Manual



Auto.



Manual



Auto.



Manual



Model codes: 4E...


5FX-H



5FT-F



5FV-8



5FV-A



RFJ-C/FF




- Unladen weight
1 384
1 400
1 400
1 428
1 374


- Kerb weight
1 459
1 475
1 475
1 503
1 449


- Payload
560
560
540
537
561


- Gross vehicle weight (GVW)
1 944
1 960
1 940
1 965
1 935


- Gross train weight (GTW)
on a 12 % gradient
3 394
3 160
3 390
3 515
3 285


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 450
1 200
1 450
1 550
1 350


- Braked trailer * (with load transfer
within the GTW limit)
1 700
1 500
1 600
1 550
1 550


- Unbraked trailer
725
735
735
750
720


- Recommended nose weight
70
60
65
65
75
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.
* The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.

1
211
TECHNICAL DATA


WEIGHTS AND TOWED LOADS (in kg)



Petrol engines


1.6 litre VTi 16V 120 hp



1.6 litre 16V
108 hp



Gearboxes


Manual



Auto.



Manual



Model codes: 4H...


5FW-C



5FS-0



5FW-F



5FS-9



N6A-B
N6A-C




- Unladen weight
1 440
1 406
1 466
1 430
1 462


- Kerb weight
1 515
1 481
1 541
1 505
1 537


- Payload
660
694
659
700
648


- Gross vehicle weight (GVW)
2 100
2 100
2 125
2 130
2 110


- Gross train weight (GTW)
on a 12 % gradient
3 200
3 300
3 095
3 080
3 110


- Braked trailer (within GTW limit)
on a 10 % or 12 % gradient
1 100
1 200
970
950
1 000


- Braked trailer * (with load transfer
within the GTW limit)
1 500
1 400
1 370
1 100
1 350


- Unbraked trailer
750
740
750
750
750


- Recommended nose weight
60
60
55
55
75

* The weight of the braked trailer can be increased, within the GTW limit, if the GVW of the towing vehicle is reduced by an
equal amount; warning, towing using a lightly loaded towing vehicle may have an adverse effect on its road holding.
The GTW and towed load values indicated are valid up to a maximum altitude of 1 000 metres; the towed load mentioned
must be reduced by 10 % for each additional 1 000 metres of altitude.
The speed of a towing vehicle must not exceed 60 mph (100 km/h) (comply with the legislation in force in your country).
High ambient temperatures may result in a reduction in the performance of the vehicle to protect the engine; if the ambient
temperature is above 37 °C, limit the towed load.