check engine PEUGEOT 4008 2017 Owner's Manual

184
4008_en_Chap07_info-pratiques_ed01-2016
Coolant level
the coolant level should be between
the two marks.In addition, as the cooling system is
pressurised, wait at least one hour after
switching off the engine before carrying out any
work.
to a

void any risk of scalding, unscrew the cap
by two turns to allow the pressure to drop.
When the pressure has dropped, remove the
cap and top up the level.Fluid specification
the coolant must conform to the
manufacturer's recommendations.
th

e brake fluid level should be close
to the "MA X" mark. If it is not, check
the brake pad wear.
Brake fluid level
Changing the fluid
Refer to the warranty and maintenance record
for details of the interval for this operation.
Fluid specification
the brake fluid must conform to the
manufacturer's recommendations and meet the
DO
t3 o

r DO
t4 s
tandard.
The cooling fan may star t after switching
off the engine; take care with ar ticles and
clothing that might become caught by the
fan blades. When the engine is warm, the temperature of
the coolant is regulated by the fan.
Practical information

185
4008_en_Chap07_info-pratiques_ed01-2016
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to
health or indeed very corrosive.
Do not discard used oil or fluids into
sewers or onto the ground.
ta

ke used oil to a P
e
uge
Ot
dealer or
a qualified workshop (France) or to an
authorised waste disposal site.
Used products
Topping up
the reservoir must be topped up without delay
by a Pe ugeOt dealer or a qualified workshop.
Additive level
(1.6 HDi 110 Diesel versions
with particle filter)
the additive reservoir low level is indicated by
the display of this message.
Fluid specification
For optimum cleaning, this fluid must not be
topped up with or replaced with plain water.
Screenwash and headlamp
wash fluid
to check or top up the fluid, stop the
vehicle, apply the parking brake and
switch off the engine.
F

O

pen the bonnet and secure it with the
st ay.
F

O

pen the filler cap for the screenwash
reservoir.
F

C

heck the level using the gauge, then top
up if necessary.
F

R

efit the cap on the reservoir and close the
bonnet. In wintry conditions, the use of fluid with
an ethyl alcohol or methanol base is
recommended.
7
Practical information

186
4008_en_Chap07_info-pratiques_ed01-2016
Checking components
12 V battery
Electrolyte level
For access to the 12 V Battery, refer
to the corresponding section. Refer to the warranty and
maintenance record for details of
the replacement intervals for these
components.
Air filter and passenger compartment filter
Replace the oil filter each time the
engine oil is changed.
Refer to the warranty and
maintenance record for details of
the replacement interval for this
component.
Oil filter
If necessary, top up using distilled water,
removing the battery cap from each cell.
Check the electrolyte level at least
once a month.
When carrying out work on the 12 V Battery
,
refer to the corresponding section for
details of the precautions to be taken before
disconnecting the battery and following its
reconnection.
un

less other wise indicated, check these components in accordance with the warranty and maintenance record and according to your engine.
Other wise, have them checked by a P
e

uge
Ot

dealer or a qualified workshop.
th

e electrolyte level must be between the
"LOW
eR LeVeL

" and "
uP

P
eR LeVeL

" marks.
Depending on the environment (e.g. dusty
atmosphere) and the use of the vehicle
(e.g. city driving), replace them twice as often
if necessary
.
A clogged passenger compartment filter may
have an adverse effect on the per formance
of the air conditioning system and generate
undesirable odours.
Practical information

187
4008_en_Chap07_info-pratiques_ed01-2016
Manual gearbox
Refer to the warranty and
maintenance record for servicing of
the gearbox.
"CVT" gearbox
For servicing of the "CVt" gearbox,
refer to the manufacturer's service
schedule for details of the interval for
checking this component.
Particle filter (Diesel)
the start of saturation of the particle filter is
indicated by the temporary illumination of this
warning lamp, accompanied by a message in
the instrument panel screen. As soon as the traffic conditions permit,
regenerate the filter by driving at a
speed of at least 25 mph (40 km/h) for
about 20 minutes (with the 1.6 litre HDi
engine, the minimum speed is 37 mph
(60 km/h)).
If the warning lamp stays on, this
indicates a low additive level.
For more information on Checking
levels
and the Diesel additive level in
particular, refer to the corresponding
section.
On a new vehicle, the first particle
filter regeneration operations may be
accompanied by a "burning" smell,
which is per fectly normal.
Following prolonged operation of the
vehicle at very low speed or at idle,
you may, in exceptional circumstances,
notice the emission of water vapour at
the exhaust on acceleration.
t
h
is does
not affect the behaviour of the vehicle
or the environment.
7
Practical information

205
4008_en_Chap08_en-cas-de panne_ed01-2016
Changing a fuse
the extraction tweezer and spare fuses are
located in the engine compartment fusebox.
to g

ain access to them:
F

O
pen the bonnet.
F

or more information about the Bonnet ,
refer to the corresponding section.
F
u
n
clip and remove the cover.
F

R
emove the tweezer.
F

C
arefully close the cover to ensure correct
sealing of the fusebox.
Access to the tools
Before changing a fuse, the cause of the failure
must be identified and rectified.
F

C
heck that the switch is in the " LOCK"
position or that the vehicle mode is " OFF".
F

I
dentify the faulty fuse by checking the
condition of its filament.
F
u
s
e the special tweezer to extract the fuse
from its location.
F

A
lways replace the faulty fuse with a fuse
of the same rating.
F

C
heck that the number etched on the box,
the rating etched on the top and the tables
below all agree.
Changing a fuse
Good Failed
P
e
uge
Ot
will not accept responsibility
for the cost incurred in repairing your
vehicle or for rectifying malfunctions
resulting from the installation of
accessories not supplied and not
recommended by P
e

uge
Ot
and
not installed in accordance with its
instructions, in particular when the
consumption of all of the additional
equipment connected exceeds
10


milliamperes.
Your vehicle's electrical system is
designed to operate with standard or
optional equipment.
Before installing other electrical
equipment or accessories on your
vehicle, contact a P
e

uge
Ot
dealer or
a qualified workshop.
th
e replacement of a fuse not
mentioned in the following tables may
cause a serious fault on your vehicle.
Contact a P
e
uge
Ot
dealer or a
qualified workshop.
8
In the event of a breakdown

212
4008_en_Chap08_en-cas-de panne_ed01-2016
Check the electrolyte level and top up if
necessary.
For more information on Checking levels ,
refer to the corresponding section.
Starting using another
battery
F Connect the red cable to the (+) terminal of the flat battery A , then to the (+) terminal of
the slave battery B . F
C onnect one end of the green or black
cable to the (-) terminal of the slave
battery


B.
F

C
onnect the other end of the green or black
cable to the earth point C on your vehicle
(engine mounting).
F

O
perate the starter, let the engine run.
F

W
ait until the engine returns to idle and
disconnect the cables.
F

R

aise the protective cover on the (+)
terminal.
Some functions are not available if the
battery is not sufficiently charged.
In the event of a breakdown

213
4008_en_Chap08_en-cas-de panne_ed01-2016
If you intend to charge your vehicle's
battery yourself, use only a charger
compatible with lead batteries, with a
nominal voltage of 12 V. F

D
isconnect the battery from the vehicle, if
necessary.
F

F
ollow the instructions for use provided by
the manufacturer of the charger.
F

R
econnect, starting with the (-) terminal.
F

C
heck that the terminals and connectors
are clean. If they are covered with sulphate
(whitish or greenish deposit), remove them
and clean them.Charging the battery using
a battery charger
Follow the instructions for use provided
by the manufacturer of the charger.
Never invert the polarities.
Never start the engine by connecting a
battery charger.
Never use a battery booster of 24 V or
higher.
Check first that the slave battery has a
nominal voltage of 12 V and a capacity
at least equal to that of the discharged
battery.th
e two vehicles must not touch.
Switch off all power-consuming
equipment on the two vehicles (audio
system, wipers, lamps, etc.).
en

sure that the slave cables do not
pass near the moving parts of the
engine (fan, belt, etc.).
Do not disconnect the (+) terminal while
the engine is running.
8
In the event of a breakdown

214
4008_en_Chap08_en-cas-de panne_ed01-2016
Do not invert the polarities and use only a 12 V charger.
Do not disconnect the terminals while the engine is running.
Do not charge the batteries without disconnecting the terminals first.
Do not push the vehicle to start the engine if it is fitted with a CV
t

gearbox.
Disconnecting the battery
to maintain a sufficient level of charge
to start the engine, it is advisable to
disconnect the battery if the vehicle is not
going to be used for a very long period.
Before disconnecting the battery:
F

C
lose all the doors and windows, the
tailgate and the roof.
F

S
witch off all power-consuming
equipment (audio system, wipers,
lamps, etc.).
F

S
witch off the ignition and wait
4


minutes.
Once you have gained access to the
battery, start by disconnecting the (-)
terminal.
Following reconnection of the
battery
Following reconnection of the battery,
switch on the ignition and wait 1 minute
before starting to permit initialisation of the
electronic systems.
However, if problems remain following this
operation, contact a P
e

uge
Ot
dealer or a
qualified workshop.
Referring to the corresponding section, you
must reinitialise certain equipment yourself,
such as:
-
t
h
e remote control key or the electronic
key (depending on version).
-
t
h
e electric blind(s).
-
t
h
e electric windows.
-
t
h
e date and time.
-
t
h
e stored radio stations. Some functions are not available if the
battery is not sufficiently charged.
Never try to charge a frozen battery.
If the battery has been frozen, have it
checked by a Pe
ugeOt dealer or a
qualified workshop, who will check that
the internal components have not been
damaged and the casing is not cracked,
which could cause a leak of toxic and
corrosive acid.
th

e Stop & Start system may not be
operational during the trip following the
first engine start.
In this case, the system will only be
available again after a continuous
period of immobilisation of the vehicle,
a period which depends on the exterior
temperature and the state of charge of
the battery (up to about 8 hours).
In the event of a breakdown

337
4008_en_Chap11_index-alpha_ed01-2016
ABS and eBFD systems ...............................143
Accessories .................................................. 141
Access to bulbs


............................................. 200
Active stability control (ASC)
........................145
Adjusting headlamps


.................................... 13 3
Adjusting head restraints


................................73
Adjusting the date


........................................... 46
Adjusting the height and reach of the steering wheel


....................................78
Adjusting the seat


..................................... 71, 72
Adjusting the seat belt height


.......................147
Adjusting the temperature
.............................. 83
A

djusting the time

.............................. 44, 46, 48
Advice on driving


............................................ 97
Airbag, knee


.......................................... 153, 155
Airbags


.......................................................... 151
Airbags, curtain
..................................... 15

4, 155
Airbags, front ......................................... 151, 155
Airbags, lateral


...................................... 153, 155
Air conditioning


............................................... 10
Air conditioning, automatic


.......................80, 83
Air conditioning, manual


...........................80, 81
Air filter
.......................................................... 18 6
Air intake


......................................................... 83
Air vents


.......................................................... 79
Alarm


............................................................... 65
Anti-lock braking system (ABS)
....................143
Anti-theft


....................................................... 102
Armrest, front
...................................... 73, 89, 92
Armrest, rear
................................................... 75
A

shtray, portable

....................................... 89, 91
Audio- CD system

.................................. 3

13 - 3 3 6
Audio streaming (Bluetooth)
................ 333

, 334
Audio- CD system, touch screen
............2 8 9 - 311
Audio-telematic system, touch screen


........................................ 247-2 8 8Battery
...........................................
186, 211, 214
Battery, charging ...................................211, 214
Battery, remote control
............................. 6

0, 61
Blind, panoramic roof


......................................70
Bluetooth (telephone)


............................2 3 5 - 2 41
Bluetooth telephone with voice recognition


.........................236 -246
Bonnet


...........................................................180
Bonnet stay


...................................................180
Boot


.................................................................63
Bottle holder


....................................................89
Brake discs
.................................................... 18

8
Brake lamps
...............................

...................203
Brake pads


....................................................188
Brakes


...........................................................188
Braking assistance system

...........................14

3
AB
Child lock .......................................................171
Children ............................... ..........................165
Child seats

..............................
....150, 15 6, 157,
161-163, 170
Child seats, ISOFIX

......................16

5, 167, 169
Cigar lighter


..................................................... 91
Closing the boot
........................................ 54, 63
Closing the doors


...................................... 54, 57
Control, emergency boot release


...................63
Controls for air conditioning


............................83
Control stalk, lighting
.................................... 12

7
Control stalk, wipers
.............................13 4, 13 6
Coolant level


................................................. 18 4
Courtesy lamp, front
..................................... 13 8
Courtesy lamp, rear
...................................... 13 8
Cruise control
................................................ 12

0
Cup holder

...............................
........................89
CV
t g

earbox

................................................. 187
Capacity, fuel tank
..............................

.......... 173
Card, SD

...................................... 263, 279, 280
CD changer
...............................

.................... 328
Central locking


.......................................... 54, 57
Changing a bulb


........................... 199, 203, 204
Changing a fuse


............................................ 205
Changing a wheel


................................. 193, 19 4
Changing a wiper blade


................................ 176
Changing the remote control battery


.............. 60
Checking levels
...................................... 18

3 -185
Checking the engine oil level


........................ 183
Checking tyre pressures (using the kit)

........ 189
Checks
...............

................... 181, 182, 18 6, 188 DAB (Digital Audio Broadcasting) -
Digital radio


........................ 275, 303, 304, 325
Date (setting)
...............................

....................46
Daytime running lamps


.........................13 0, 201
Deactivating ASC


.......................................... 145
Deactivating the passenger airbag


.......151, 15 8
Deactivating the passenger and rear window control switches


.......................68
Deadlocking


.............................................. 55, 57
Defrosting


.................................................. 87, 88
Defrosting, front
.............................................. 87
C
D
.
Alphabetical index

340
4008_en_Chap11_index-alpha_ed01-2016
Regeneration of the particle emissions filter ............................................................. 187
Reminder, key in ignition
.................................98
Reminder, lighting on


.................................... 129
Remote control
........................ 5

2, 54, 56, 57, 61
Removing the mat


........................................... 90
Repair kit, puncture


....................................... 189
Replacing bulbs


........................... 199, 203, 204
Replacing fuses
..............................

..............205
Replacing the air filter


...................................18 6
Replacing the oil filter
................................... 18

6
Replacing the passenger compartment filter


............................................................. 18 6
Rev counter


..................................................... 12
Reversing camera


......................................... 126
Reversing lamps


.................................. 203, 204
Roof bars
....................................................... 17

9
Routine checks


..................................... 18 6, 188
Running out of fuel (Diesel)

..........................2

18Screenwash, front
.........................................
13 5
Screen-wash reservoir .................................185
Seat belts
.............................................. 14

9, 15 0
Seat, rear bench


.............................................74
Seats, electric


.................................................72
Seats, front
...............................

..................71-73
Seats, heated


..................................................73
Seats, rear


.......................................................74
Serial number, vehicle
.................................. 23

3
Service indicator


.............................................33
Servicing
...............................

....................10, 33
Sidelamps


.....................................199, 201, 203
Side repeater
..............................

..................202
Ski flap
..............................

..............................75
Snow chains
.................................................. 17

5
Socket, 12 V accessory

......................8

9, 91, 92
Sockets, audio


............93, 278, 281, 306, 307, 330, 331
Sockets, auxiliary


....................93, 281, 307, 330
Spare wheel
...............................

...........193, 19 4
Speedometer


..................................................12
Spotlamps, side


............................................202
Starting the engine


...................................98, 99
Station, radio
................................. 3

00, 302-304
Steering mounted controls, audio


...........................................249, 291, 316
Steering wheel, adjustment


............................78
Stop & Start system (Auto Stop &
g
o
).........................................111
Storage


................................................75, 90, 95
Stowing rings


............................................95, 96
Sun visor


.........................................................90
Switching off the engine
........................... 9

8, 99
System, ABS
.................................................143
Radio


............ 268, 272, 300, 301, 303, 319, 321
Range


........................................................ 32, 35
RDS


...................................................... 302, 304
Reader, SD card

.......................... 263, 279, 280
Rear foglamp ........................................ 203, 204
Rear screen, demisting


................................... 88
Recharging the battery
......................... 21

1, 214
Recirculation / exterior air intake

.......................................... 83
R
P
Pairing a telephone ...............................2 8 8, 310
Panoramic glass sunroof ................................70
Parcel shelf, rear
............................................. 96
P

arking brake

........................................ 102, 188
Parking sensors, front


...................................125
Parking sensors, rear ............................123, 124
Particle filter


.......................... 180, 18 4, 185, 187
Passenger compartment filter


......................18 6
Plates, identification ...................................... 233
Player, Apple
® .............................. ........280, 308
Player, MP3 CD ............................................. 305
Player,
u
S

B

.......... 278, 280, 306, 308, 309, 331
Pockets, seat back
.......................................... 94
Port,
u
S

B

............................... 9

3, 278, 306, 331
Pressures, tyres


.................................... 114 , 2 3 3
Pre-tensioning seat belts


.............................. 150
Priming the fuel system
................................ 218
Protecting children


................ 156, 157, 161, 163,
165, 167, 169 -171
Puncture


................................................ 189, 193
Safety, children
..................... 15

6 -15 8, 161, 163,
165, 167, 169, 170
Screen (audio system)

.......................4

4, 46, 48
Screen, colour


.......................248, 251, 290, 293
Screen, instrument panel


..........................19, 32
Screen menu


................................294, 296, 298
Screen menu map


........................294, 296, 298
Screenwash fluid level
..................................185
S
Alphabetical index