checking oil Peugeot Boxer 2018 Owner's Manual
[x] Cancel search | Manufacturer: PEUGEOT, Model Year: 2018, Model line: Boxer, Model: Peugeot Boxer 2018Pages: 232, PDF Size: 9.09 MB
Page 12 of 232
10
Warning/indicator lampStateCause Actions/Comments
Red warning/indicator lamps Coolant
temperature On H in the red zone. The coolant temperature is too
high
and/or
an abnormal increase. Park and switch off the ignition.
Allow the system to cool sufficiently.
Check the level visually.
For more information on Checking levels
, refer to the
corresponding section.
If the level is low, top it up.
If the level is correct, contact a
PEUGEOT dealer or
a
qualified workshop.
Fixed, with the needle
in the red zone.
Engine oil pressure Flashing for a
few
seconds, with
a
message in the
screen. A high level of deterioration of the
engine oil.
Have the engine oil changed as soon as possible.
After the second level of alert, engine per formance will
be limited.
Lit temporarily or
fixed, with the engine
running. Low oil level
or
a major fault. Park and switch off the ignition.
Check the level manually.
For more information on Checking levels
, refer to the
corresponding section.
If the level is low, top it up.
If the level is correct, contact a
PEUGEOT dealer or
a
qualified workshop.
Battery charge Fixed. A fault with the charging system
or the battery. Check the battery terminals.
For more information on the Battery
, refer to the
corresponding section.
Fixed or flashing,
despite the checks. A fault with the ignition or
injection system. Have it checked by a
PEUGEOT dealer or a qualified
workshop.
Opening detection Fixed. One of the vehicle access
openings is not properly closed. Check that the cab doors, the rear and side doors and
the bonnet are closed.
Dashboard instruments
Page 20 of 232
18
Indicators
Service information
For a few seconds after the ignition is
s witched on, the spanner symbolising ser vice
information comes on: the screen informs you
when the next ser vice is due, in accordance
with the ser vicing schedule indicated in the
manufacturer's service schedule.
Engine oil level
Depending on the engine, the engine oil level
then appears, graduated from 1 (Min.) to 5
( M a x .) .
If no graduation is displayed, the oil level is
too low; it is essential that you top up to avoid
damaging the engine.
For the oil level reading to be accurate, the
vehicle must be parked on level ground, with
the engine off for more than 30
minutes.
This information is determined in relation to the
distance travelled since the previous service. If in doubt, check the level with the
dipstick.
For more information on Checking levels
,
refer to the corresponding section.
Engine oil condition
This warning lamp flashes and,
if your vehicle has this function,
a message is displayed at every
engine start: the system has
detected deterioration of the engine
oil. Have the oil changed as soon as
possible.
This 2nd warning lamp, coupled with the
1st, comes on in the instrument panel
when the oil has not been changed and
the deterioration of the oil has gone
beyond a
new threshold. If this warning
comes on at regular inter vals, have the
oil changed as soon as possible.
For 3.0 litre HDi engines, the engine
s peed is restricted to 3,000 rpm, then
1,500
rpm until the oil is changed. Have
the engine oil changed to avoid any risk of
damage.
After a
few seconds, the display returns to its
usual functions.
Resetting the servicing
information
Refer to the list of checks in the
manufacturer's service schedule which
was given to you on handover of the
vehicle.
Continuous flashing of the indicator is stopped
by a
qualified workshop using a diagnostic tool,
after each service.
If you have ser viced your vehicle personally,
you must reset the ser vice indicator as follows:
F
i
nsert the ignition key into the switch,
F
t
urn it to the MAR position,
F
s
imultaneously press the brake and
accelerator pedals for more than
15
seconds.
Dashboard instruments
Page 128 of 232
126
Diesel engines
1.Windscreen/headlamp wash fluid
reservoir.
2. Power steering fluid reservoir.
3. Coolant tank.
4. Brake and clutch fluid reser voir.
5. Diesel fuel filter.
6. Fusebox.
7. A i r f i l t e r.
8. Dipstick.
9. Engine oil filler cap.
Battery connections:
+ Positive terminal.
- Negative terminal (earth). The Diesel circuit is under very high
pressure.
All work on this circuit must be carried out
only by a
PEUGEOT dealer or a qualified
workshop.
Checking levels
Check all of these levels regularly, in line with
the manufacturer's service schedule. Top them
up if necessary, unless other wise indicated.
If a
level drops significantly, have the
corresponding system checked by a
PEUGEOT
dealer or a
qualified workshop.
If you have to remove/refit the engine
cover, handle it with care to avoid
damaging the fixing clips.
Used products
Avoid prolonged contact of used oil or
fluids with the skin.
Most of these fluids are harmful to health
or indeed very corrosive. Do not discard used oil or fluids into
sewers or onto the ground.
Take used oil to a
PEUGEOT dealer or
a qualified workshop and dispose of it in
the containers reser ved for this purpose.
Engine oil level
Check this regularly and top up as
necessary between two oil changes
(the maximum consumption is 0.5
litres
for 620
miles (1,000 km)). Make the
check with the vehicle standing level,
engine cold, using the dipstick.
Checking using the dipstick
2 marks on the dipstick:
A = MA X
B = MIN
Practical information
Page 133 of 232
131
Brake disc wear
For information on checking brake
disc wear, contact a PEUGEOT
dealer or a
qualified workshop.
Parking brake
If excessive travel or a loss of
e ffectiveness of this system is
noticed, the parking brake must
be checked, even between two
services.
This system must be checked by a
PEUGEOT
dealer or a
qualified workshop.
Diesel fuel filter
The Diesel fuel filter is located under the
bonnet, close to the brake fluid reser voir. If this warning lamp comes on, the
filter must be purged to remove
water.
You can also purge the fuel filter
regularly, every time the engine oil
is changed.
Purging water from the filterThe HDi engines use advanced technology.
All work must be done by personnel that
have had special training, which can be
ensured by going to a
PEUGEOT dealer or
a
qualified workshop.
Only use products recommended by
PEUGEOT or products of equivalent
quality and specification.
In order to optimise the operation of
components as important as those in the
braking system, PEUGEOT selects and
offers very specific products.
After washing the vehicle, dampness, or
in wintry conditions, ice can form on the
brake discs and pads: braking efficiency
may be reduced. Make light brake
applications to dry and defrost the brakes.
F
C
onnect a
transparent pipe to the head of
the purge screw 1 .
F
P
lace the other end of the transparent pipe
in a
container.
F
L
oosen the purge screw 2 .
F
S
witch the ignition on.
F
W
ait until the supply pump stops running.
F
S
witch the ignition off.
F
T
ighten the purge screw 2 .
F
R
emove and then empty the transparent
pipe and the container.
F
S
tart the engine.
F
C
heck that there are no leaks.
7
Practical information
Page 225 of 232
185
Accessories .................................................... 67
AdBlue® .................................................. 13 2-13 3
Adjusting the date ........................................... 28
Adjusting the seat angle
................................. 37
Adjusting the seat belt height
.................... 7
2-73
Adjusting the time
........................................... 28
Advice on driving
...................................... 87- 8 9
Airbags
...............................
.............................78
Airbags, curtain
............................................... 76
Airbags, front ....................................... 75 -76, 79
Airbags, lateral
................................................ 76
Air conditioning
......................................... 46 - 47
Air conditioning, additional
....................... 4
6 - 47
Air conditioning, automatic
.......................44, 50
Air conditioning, manual
........................... 4
3, 50
Alarm
............................................................... 35
Anti-lock braking system (ABS)
..........12, 68 - 69
Armrest, front
.................................................. 38
Anti-slip regulation (ASR)
.........................68-69
Assistance, emergency braking
...............68-69
Audio streaming (Bluetooth)
..........................7- 8
Audio system
..................................................... 1
Battery
............................................. 91, 129, 153
BlueHDi
................................................... 21, 132
Bluetooth (hands-free)
........................... 1
2-13, 5
Bluetooth (telephone)
............................. 1
2-13, 5
Bonnet
........................................................... 125
Brake discs
............................................. 12 9 -131
Brakes
........................................................... 131
Brightness
......................................................... 8
Bulbs (changing)
.................................... 143 -14 4
Bulbs (changing, type)
.................................. 14 4Cable, audio
..................................................
7, 4
Cable, Jack ...................................................7, 4
Capacity, fuel tank
..................................20, 116
CD
.....................................................................7
CD, MP3
............................................................7
Centre console
..................................................4
Changing a
bulb
.....................................14
3 -14 4
Checking the levels
................................126 -128
Checks
...................................................12 9 -131
Checks, routine
.....................................129, 131
Child seats
..............................
...........74, 77, 85
Cigarette lighter
..............................................58
Configuration, vehicle
............................... 2
2, 27
Control, heated seats
......................................38
Control stalk, lighting
................................15, 61
Control stalk, wipers
.......................................65
C
ourtesy lamp, front ...........................52-54, 56
Courtesy lamp, rear
........................................58
Courtesy lamps
...............................................58
Cruise control
.........................................101-105
DAB (Digital Audio Broadcasting) – Digital radio
..........................5
Dashboard
.........................................................4
Daytime running lamps
...................................61
Daytime running lamps, LED
..........................62
Deactivating the passenger airbag
.....75, 78 -79
Dimensions
..............................
.....................162
Direction indicators
...................................15, 61
Display screen, instrument panel
...............7, 92
Driving abroad ................................................. 61
Dynamic stability control (DSC)
................68-69 Emergency braking assistance (EBA)
......
68-69
Electric windows .............................................36
Electronic brake force distribution (EBFD)
....68-69
Engine compartment
.................................... 12
6
Engine, Diesel
...............................118, 126, 158
Engines
..................................................157-15 8
Filling the AdBlue
® tank ................................ 132
Filling the fuel tank ................................ 11 6 , 11 8
Filter, air
........................................................ 12 9
Filter, Diesel fuel
................................... 126, 131
Filter, oil
................
......................................... 12 9
Filter, particle
......................................... 12 9 -13 0
Filter, passenger compartment
..................... 12 9
Fittings, front
............................................. 52-56
Fittings, interior
......................................... 5
2-56
Flap, fuel filler
................................................ 11 6
Fluid, brake
............................................ 126 -128
Fluid, engine coolant
.............................. 126 -128
Fluid, power steering
............................. 12
6 -128
Foglamps, front
............................................... 61
Foglamps, rear
................................................ 61
Fr
ont doors
...................................................... 33
Fu
el ................................................................ 11 8
Fuel tank ........................................................ 11 6
A
B
C
D
E
F
.
Alphabetical index