Peugeot iOn 2012 Owner's Manual
Manufacturer: PEUGEOT, Model Year: 2012, Model line: iOn, Model: Peugeot iOn 2012Pages: 168, PDF Size: 4.63 MB
Page 121 of 168
9
Checks
119
Checking levels Check all of these levels regularly and top them up if necessary, unless other wise indicated.
If a level drops significantly, have the corresponding system checked by a PEUGEOT dealer or a qualified workshop.
Never do anything in the compar tmentswhen the "Ready" lamp is on or whenyour vehicle is being charged. Take care when carrying out checks in the front and rear compartments assome parts of the compartments canbe very hot (risk of burns): wait at leastone hour after stopping the motor or the end of the charging procedure beforecarrying out any work.
Brake fluid level
The brake fluid level should be
between the "MIN" and "MA X"
marks. If it is not, check the brakepad wear.
Changing the fl uid
Refer to the ser vicing booklet for details of theinterval for this operation.
Fluid specifi cation
The brake fluid must conform to the
manufacturer's recommendations and meet the DOT4 standard.
Front compartment
Heatin
g system fluid level
Changing the fl uid
The fluid does not have to be changed.
Fluid specifi cation
The fluid must conform to the manufacturer's
recommendations. Th
e level of this fluid should be between the "L"MIN and "F" MA X marks.
Screenwash fluid level
Top up the level when necessary.
Fluid specifi cation
For optimum cleaning and to avoid freezing,
this fluid must not be topped up or replaced
with plain water.
Page 122 of 168
Checks
120
The coolant level should be between
the MIN "L" and MA X "F" marks.
Coolant level
Avoid prolonged contact of used fluids with the skin.
Most of these fluids are harmful tohealth and some are very corrosive.
Do not discard used fluids into sewers or onto the ground.
Ta k e u s e d fluids to a PEUGEOT dealer or a qualified workshop (France) or toan authorised waste disposal site.
Used products
Rear compartment
Changing the coolant
The coolant does not have to be changed.
Coolant specifi cation
The coolant must conform to the
manufacturer's recommendations.
As the coolin
g system is pressurised, wait at least one hour after switching off the motor and/
or the end of the charge cycle before carryingout any work.
To a v o i d a ny risk of scalding, unscrew the cap by two turns to allow the pressure to drop.
When the pressure has dropped, remove the cap and top up the level.
Ancillaries battery
electrolyte level
Remove the battery protective cover to check
this level
(see § "ancillaries battery").The electrolyte level should be between theMIN "LOWER LEVEL" and MA X "UPPER LEVEL".
If necessary, top up using distilled water byremoving the individual battery caps.
Check the electrolyte level at least onceper month.
Page 123 of 168
9
Checks
121
Checks
Unless other wise indicated, check these components in accordance with the ser vicing booklet.
Other wise, have them checked by a PEUGEOT dealer or a qualified workshop.
Passenger compartment filter
Refer to the ser vicing booklet for
details of the replacement inter vals
f
or this filter.
Depending on the environment (e.g.
dusty atmosphere) and the use of the vehicle (e.g. city driving), replace it twice as often if necessary.y A dirty passenger compartment filter may have
an adverse effect on the performance of the air conditioning system and generate undesirableodours.
Brake wear depends on the style
o
f driving, par ticularly in the case
of vehicles used in town, over shor t
distances. It ma
y be necessary tohave the condition of the brakes checked, evenbetween vehicle services.
Unless there is a leak in the circuit, a drop in
the brake fluid level indicates that the brake
pads are worn.
Brake pads
Only use products recommended by PEUGEOT or products of equivalent quality and specifications. In order to optimise the operationof units as impor tant as the braking system, PEUGEOT selects and offers very specific products.
Parking brake
If a loss of effectiveness of thissystem is noticed, the parking brakemust be checked, even between two services.
This system must be checked by a PEUGEOT
dealer or a qualified workshop.
Brake disc / drum wear
For information on checking the
brake disc or drum wear, contact
a PEUGE
OT dealer or a qualified
workshop.
Page 124 of 168
Technical data
122
Motor and main battery
Model type code:1 N ZK Z Z
Electric motorY4F1
Technology Synchronous with neodymium permanent magnets
Max. power: EU standard
(kW)
49
Max. power speed
(rpm)
2 500 to 8 000
Max. torque: EU standard (Nm)
18 0
Max. torque speed (rpm)
0 to 2 500
Main batteryLithium-Ion
Ener
gy capacity (kWh)
14.5
Normal charge
Volt age (V) AC
230
Charging time (*)(**):
- 16 A
- 10 A
- 8 A
5 hours 30 minutes 8 hours
11 hours
Fast char
ge
Volt age (V) DC 300
Charging time (80% charge) ** 30 minutes
Ran
ge varies according to the exterior climatic conditions, the driver's style of driving, the use of electrical equipment, the frequency of normal or fast charges and ageing of the main battery.
*
Depending on the power supply in the country. **
Time measured for ambient temperatures between 20 and 25° C.
Page 125 of 168
10
Technical data
123
Electric motorY4 F1
Main batteryLithium-Ion
Model type code:1 N ZK Z Z
Unladen weight
1 055
Kerb weight
1 130
Gross vehicle weight (GV W) 1 450
Gross train wei
ght (GTW)1 450
Maximum load on the roo
f (including the roof bars)43
Your vehicle cannot be fitted with a towbar. It cannot tow a trailer.
Weights (in kg)
Page 126 of 168
Technical data
124
Dimensions (in mm)
Page 127 of 168
10
Technical data
125
Identifi cation markings
Various visible markings for the identification of your vehicle.
A. Ser vice - Replacement Par ts
identification plate.
This plate is riveted to the underside of thebonnet.
Tyre pressures must be checked whenthe tyres are cold, at least once amonth.
Low tyre pressures increase the
electrical power consumption of your vehicle, which reduces its range. B. Tyre identification label
.This label is affixed to the driver's centre pillar.
It bears the
following information:
- the tyre pressures (in bars),
- the tyre specification,
- the type of tyre.C. Manufacturer's
plate This plate is riveted to the left hand centre pillar.
D. Vehicle identification number (VIN).
This number is is engraved on the inner wheel
arch, inside the boot, right hand side.
For information on fitting snow chains, contact a PEUGEOT dealer or aqualified workshop.
It bears in par ticular the
following information:
- the vehicle model,
- the paint code,
- the type, variant, version.
Page 128 of 168
126
Page 129 of 168
127
EMERGENCY OR ASSISTANCE CALL
Page 130 of 168
128
EMERGENCY OR ASSISTANCE CALL
In an emergency, press this button for more than2 seconds. Flashing of the green LED and a voice
message confi rm that the call has been made to the
PEUGEOT CONNECT SOS call centre * .
The
green LED remains on (without fl ashing) when communication is established. It goes off at the end of communication.
When the i
gnition is switched on, the green
LED comes on for 3 seconds indicating that
the system is operating correctly.
Pressing this button again immediately cancels the request.
The cancellation is con
fi rmed by a voice message.
Press this button
for more than 2 seconds to requestassistance if the vehicle breaks down.
A voice message confi rms that the call has been made **
.
OPERATION OF THE SYSTEM
Pressing this button again immediately cancels the request. The green LED goes off. Cancellation is confi rmed by a voice message.
To cancel a call, tell the PEU
GEOT CONNECT SOS call centre that thecall was a mistake.
PEU
GEOT CONNECT SOS immediately locates you vehicle, starts communication with you in your language ** , and where necessary sends
the appropriate public emergency services ** . In countries where theservice is not available, or when the locating service has been expresslydeclined, the call sent directly to the emergency services (11 2) without the
vehicle location.
I
f an impact is detected by the airbag control unit, and
independently of the deployment of any airbags, an emergency call
is made automatically.
*
Sub
ject to the general conditions for the service available from dealersand to technological and technical limitations. **
Depending on the geographical cover of PEUGEOT CONNECT SOS,
PEUGEOT CONNECT ASSISTANCE and the offi cial national languageselected by the owner of the vehicle.
The list of countries covered and PEUGEOT CONNECT services are available from dealers or at www.peugeot.co.uk.
I
f the orange LED fl ashes: there is asystem fault.
I
f the orange LED is on continuously: the
backup battery must be replaced.
In either case, contact a PEUGE
OT dealer.
If
you purchased your vehicle outside the PEUGEOT dealer network,
we invite you to have a dealer check the confi guration of these services
and, if desired, modifi ed to suit your wishes. In a multi-lingual country,confi guration is possible in the offi cial national language of your choice.
For technical reasons and in particular to improve the qualit
y of PEUGEOT CONNECT services to customers, the manufacturer reserves
the right to carry out updates to the vehicle's on-board telematic system. I
f you benefi t from the PEUGEOT Electric offer, you have other servicesavailable to you in your MyPeugeot personal space via the PEUGEOT
website in your country, accessible on www.peugeot.co.uk.