brake rotor PONTIAC FIREBIRD 1996 Owners Manual

NOTICE:
L
ImproperIy tightened wheel nuts can.lead to
brake pulsation and rotor damage.
To avoid
expensive brake repairs,
evenly tighten the wheel
nuts
in the proper sequence and to the proper
torque specification.
Don't try to put a c'enter cap on your compact spare tire.
It won't fit. Store the center cap in the rear area until
you have the flat tire repaired or replaced.
NOTICE:
Center caps won't fit on your compact spare.
If you try to put a center cap on your compact
spare,
you could damage the cover or the spare.
Storing a Flat Tire or Spare Tire and Tools
Storing a jack, a tire or other equipment m the
passenger compartment
of the vehicle could
cause injury. In
a sudden stop or collision, loose
equipment could strike someone. Store
all these
in the proper place.
5-38
ProCarManuals.com

Part C: Periodic Maintenance
Inspections
Listed below are inspections and services which should
be performed at least twice a year (for instance, each
spring and fall). You should let your GM dealer’s
service department or other qualified service center do
these jobs. Make sure any necessary repairs are
completed at once.
Proper procedures to perform these services may be
found in a Pontiac Service Manual. See “Service and
Owner Publications’’ in the Index.
Steering and Suspension Inspection
inspect the front and rear suspension and steering
system for damaged, loose or missing parts, signs of
wear or lack of lubrication. Inspect
the power steering
lines and hoses for proper hook-up, binding, leaks,
cracks, chafing, etc.
Exhaust System Inspection
Inspect the complete exhaust system. Inspect the body near
the exhaust system. Look for broken, damaged, missing or
0~t~€-pii60n parts as well as open seams, holes, loose
connections or other conditions which could cause a heat
build-up in
the floor pan or could let exhaust fumes into
the vehicle. See “Engine Exhaust” in the Index.
Radiator and Heater Hose Inspection
Inspect the hoses and have them replaced if they are
cracked, swollen
or deteriorated. Inspect all pipes,
fittings and clamps; replace as needed.
Throttle Linkage Inspection
Inspect the throttle linkage for interference or binding, and
for damage or missing parts. Replace parts as needed.
Replace any cables that have high effort
or excessive wear.
Do not lubricate accelerator and cruise control cables.
Rear Axle Service
Check the gear lubricabt level in the rear axle and add if I
needed. See “Rear Axle” in the Index. A fluid loss may
indicate a problem. Check
the axle and repair it if needed.
Brake System Inspection
Inspect the complete system. Inspect brake lines and
hoses for proper hook-up, binding, leaks, cracks,
chafing, etc. Inspect disc brake pads for wear and rotors
for surface condition.
Also inspect drum brake linings
for wear and cracks. Inspect other brake parts, including
drums, wheel cylinders, calipers, parking brake, etc. The
parking brake is self-adjusting and no manual
adjustment
is required. You may need to have your
‘brakes inspected more often
if your driving habits or
conditions result in frequent braking.
7-43
ProCarManuals.com