warning PORSCHE 911 GT3 2004 5.G Owners Manual

j!\
Warning!
Hydrogen gasgenerated bythe battery
could cause anexplosion, resultinginsevere
personal injuries.

c> Charge battery inawell ventilated area.
c> Never charge afrozen battery. Itmay explode
because ofgas trapped inthe ice. Allow afro-
zen battery tothaw outfirst.
c> Ifyou getelectrolyte, whichisan acid, inyour
eyes oron your skin, immediately rinsewith
cold water forseveral minutes andcalladoc-
tor.
Slow
battery charging

1. Pay attention toallwarnings andfollow instruc-
tions thatcome withyour battery charger.
2. When charging, ensureadequate ventilation.
3. Remove battery.
Please observe thechapter "REMOVING THE
BATTERY" onPage 158.
4. Allvent caps should beopen.
The fluid level should meettheindicator mark
in each cell.
5. Ensure thatcharger isswitched off-danger of
short circuit!
6. Connect chargercables.

Charger cablesmustbeconnected
POSITIVE
(+1
toPOSITIVE
(+)
and
NEGATIVE (-)toNEGATIVE
(-I.

7. Switch oncharger.
Normally, abattery shouldbecharged atno
more than10percent ofits rated capacity.
Rated capacity ofthe battery inyour vehicle is
listed onthe battery housing.
8. After charging, turnoffcharger anddiscon-
nect charger cables.
9. Tighten thevent caps andreinstall battery
Please observe thechapter "INSTALLING THE
BATTERY" onPage 158. Winter
operation
During thewinter months, batterycapacity tends
to decrease astemperatures drop.
Additionally, morepower isconsumed whilestart-
ing, andtheheadlights, heater,rearwindow de-
fogger, etc.,areused more frequently.
c> let your Porsche dealertestthebattery's
capacity beforewintersetsin.
Replacing battery
The service lifeofthe battery issubject tonormal
wear; itdepends graetlyoncare, climatic condi-
tions, anddriving conditions (distances, loads).
c> Only useanoriginal Porsche battery,withthe
correct partnumber, asareplacement.
c> Please observe thedisposal instructions for
batteries.

c>c>c>

Practical Tips,Emergency Service

Removing thebattery

The requisite toolisinthe tool kit.
The battery islocated inthe luggage compart-
ment under ablack plastic lid.

A
Warning!
Risk ofdamage toalternator andelectronic
control units.

t> Donot disconnect thebattery whiletheengine
is running.
This also applies tocars equipped withabat-
tery main switch.
c> Never drivethecarwith adisconnected bat-
tery.

Risk ofcaustic burnsfromescaping acid.

c> Keep ventcaps ontoavoid spillage.

c>
Donot tiltthe battery whenremoving andin-
stalling
it.

158
PracticalTips,Emergency Service 1.
Switch offengine andallelectrical loads.
2. Open turn-locks
A.

Remove plasticlid.
3. Pull offcentral venthose
B.

4. Important: disconnect thenegative (-)ground
wire first, andthen thepositive (+lcable.
Danger ofshort circuit'
5. Unscrew fastening screwC.
6. Remove battery.
Installing
thebattery

1. Put battery in.
2. Screw infastening screwC.
3. Important: connectthepositive
(+)
cable first,
and then thenegative (-)ground wire.
Danger ofshort circuit
l

4. Push oncentral venthose
B.

5. Fitplastic lid.Lock turn-locks
A.

Emergency StartingwithJumper
Cables

If the battery isdischarged, e.g.inwinter orafter
the car has been parked foralong time, thebat-
tery ofanother carcan beused forstarting with
the help ofjumper cables.
Make surethevoltage ofboth batteries isthe
same.
The capacity (Ampere hours,Ah)ofthe booster
battery mustnotbesubstantially lessthan thatof
the discharged battery.
The discharged batterymustbecorrectly con-
nected tothe vehicle's electrical system.

I>
Please observe thechapter "BATTERY" on
Page 155.

I>
Please observe thechapter "EMERGENCY UN-
LOCKING OFTHE LUGGAGE COMPARTMENT
LID AND ENGINE COMPARTMENT LID"on
Page 154.

Note

I>
Donot trytostart thecarbypushing ortow-
ing. Damage tothe catalytic converters and
other components ofthe car may result.

160
PracticalTips,Emergency Service
A

Warning!
Risk ofdamage andserious personal injury
due toshort circuit.

I>
Use only jumper cablesofadequate diameter
cross-section andfitted withcompletely insu-
lated alligator clips.

I>
Follow allwarnings andinstructions ofthe
jumper cablemanufacturer.

I>
When connecting jumpercables, makesure
that they cannot getcaught inany moving
parts inthe engine compartment.
The jumper cablesmustbelong enough so
that neither vehicles norcables touchanother.

I>
The vehicles mustnotbeincontact, otherwise
current mightflowassoon asthe positive ter-
minals areconnected.

I>
The cable clamps mustnotbeallowed tocon-
tact each other whenoneendofthe jumper ca-
bles areconnected toabattery.

I>
Ensure thattools orconductive jewellery
(rings, chains, watchstraps) donot come into
contact withliveparts ofthe vehicle.

I>
Improper hook-upofjumper cablescanruin
the alternator.
Danger
ofcaustic burns.

I>
Donot lean over thebattery.

Danger ofgas explosion.

I>
Improper useofbooster batterytostart a
vehicle maycause anexplosion, resultingin
severe personal injuries.

I>
Keep sources ofignition awayfromthebat-
tery, e.g.open flame, burning cigarettes or
sparking duetocable contact orwelding work.

I>
Adischarged batterycanfreeze evenat

WFj-lOoC.

Before connecting Jumpercables, afrozen bat-
tery must bethawed out.

Lights, Replacing Bulbs

A
Warning!
Risk ofshort circuit.

c>
Always switchoffthe relevant consumer when
changing bulbs.

Risk ofinjury. Theheadlights areunder high
voltage wheninstalled.

c>
Becareful duringallwork inthe area ofthe
headlights.

Risk ofdamage. Bulbsofahigher wattage
can damage thelamp housing.

c>
Only thebulbs shown inthe chart maybeused.

c>
New bulbs mustbeclean andfree from
grease.
Therefore, nevertouch bulbswith
your barehands.

Use acloth orsoft paper whilereplacing bulbs.

c>
For reasons oftraffic safety, werecommend
that youalways carryspare bulbssothat you
can have acorrectly illuminated caratall
times. In certain countries, thecarrying ofspare
bulbs ismandatory.
Practical Tips,Emergency Service
A

Caution!
Risk ofdamage toheadlights duetoexces-
sive temperatures andabrasion.

c>
Attach nocoverings (e.g.films, "stone
guards") inthe area ofthe headlights.

c>
Use soapy wateronlytoclean lightlenses and
plastic headlight lenses.
In no case maychemical cleanersorother vol-
atile cleaning fluidsbeused.

c>
Toprevent scratches, donot rubwith adry or
merely moistcloth,tissue orinsect sponges.

Tires,Rims,Tracks

Tire RimRimoffset
Track
Summer tires
front
235/40ZR18(91 Y)
8.5Jx 18 H2 40mm
58.6in/1488 mm
rear 295/30ZR18(98Y)
11Jx 18 H2
63mm 58.6in/1488 mm

Snow tires
front
225/40R18 92V M+S XL 8Jx 18 H2
50mm 57.8in/1468 mm
rear 265/35R18 97V M+S XL
*

10Jx18H2 65mm 58.4in/1484 mm
The load capacity coefficient (e.g."92") andmaximum speedcodeletter (e.g."V")areminimum requirements.

/i\
Warning!
Installation ofsizes notauthorized by
Porsche mayhave adangerous effecton
the driving stability andcould result in
severe personal injuryordeath.
I>
Before mounting newtires, check withyour
Porsche dealeraboutthecurrent release
status.

Tire andrimsizes
Extensive testsareperformed beforespecific tiresandwheels areapproved byPorsche. YourPorsche dealerhasinfor-
mation aboutapproved tiresandwheels andishappy toassist you.
If aftermarket tiresand/or wheels areinstalled whicharenotapproved byPorsche, thevehicle's roadability andhandling
characteristics mightbeimpaired. SincePorsche hasnodata onsuch combinations, Porschecannotstandbehind the
safety ordurability ofthese aftermarket combinations.

Snow chains
Canbemounted onlyonthe rear wheels;
maximum speed30mph/50 km/h.

Use only Porsche authorized fine-linkcross-type oredge chains.

Snow chain clearance canbeguaranteed onlyonthe tire
+
rim combination marked*.

Technical Data

Index

A

ABS (antilock brakesystem) 44,45,54,56
Warning light 54,56
Acoustic warningsignal. 69
Aerodynamic components 9
Air compressor 100
Air conditioning system 90
Air distribution 88,90
Air filter 128
Airbag 38,39
Switching offpassenger airbag 36
Warning light 54,56
Alarm System 24,107
Alcantara 136
Antenna 107,131
Antifreeze 113
Antilock brakesystem (ABS) 44,45
Ashtray 94
Assembly aidsforwheel changes 150
Audio operation 105,106
Auto-button airconditioning system 90,91
Automatic
Airconditioning 90
Car washes 131
Door locking 21
Headlight adjustment... 82
Locking retractor 34
Speed control 54,56,58,86, 87
Average consumption 68
Average speed 68,72

190
Index
B

Backrest Adjustment 30
Release 30,31
Battery 100,155
Warning light.. 54,56,58
Before driving off 14,15
Belt tensioner 32
Belts 32,136
Warning light... 54,56
Blower adjustment 88,90, 93
Brakes 40,119
Distribution warninglight... 54,56
Fluid 119,185
Fluid level 54,56
Fluid warning light 119
Lights 165,171
Pad wear warning light 54,56
Pads 16,43
Parking brakewarning light... 54,56
Break inhints 16
Bulbs Chart 163
Replacing 162

C

Canholder 95
Capacities, overview 185
Car care 130
Car washes 131Cassette
tape
Holder 97
Player
l
06
Catalytic converters 125
Cautions 112,140
Central locking 22
emergency operation 23
Changing wheels 150
Check engine
Warning light.. 54,56,66
Child restraint
Anchorages ,35
Switching offpassenger airbag 37
Syste m 36
Cigarette lighter 94
Circulating airbutton 91
Circulating airsetting 89,91
Clock 54,56,64
Clothes hook 96
Clutch pedal .40
Compact disc
Changer 106
Holder 97
Player
l
06
Compartment monitoring 24
Compressor 91,92
Coolant 62,113
Level 113
Temperature gauge 62
Warning light 62
Cooling system 62,113

Temperaturgauge 54,56
Warning light 54,56
Cruise contro!. 58,86,87
Curb light 172
D
Dashboard 48
Defrosting windows 29,90, 91
Diagnostic socket 17,153
Diagrams 187
Dimensions 186
Door 21
Guard 172
Handles 21
Locks 21,132
Windows 21,26,27,133
Door mirror 28
Heating 29
Driving hints 14
Driving performance 182
E
Electrical system 152
Emergency flasher 81
Emergency operation
Central locking 23
Lids 154
Tank flap 121
Emergency service 140
Emergency startingwithjumper cables160,161
Emission controlsystem 7,66, 124, 125
Engine Checking oillevel 71,115 Dipstick
116
Exhaust 10
Number 180
Oil consumption 16,114
Oillevel 116
Oil level gauge 71
Oil pressure gauge 54,56,65
Oil pressure warninglight.. 54,56,65
Oils 114,185
Speeds 16,182
Starting 52
Stopping 53
Engine compartment
Blower 53,62
Lid 98,99
Lid warning light.. 54,56,98
Light 172

F

Fog lights 82,169, 171
F ootbrake 41
Footweillights 47
Fresh airintake 93
Front hood 99
Fuel 4,63, 121
Containers 10
Economy 120
Evaporation control 126
Level gauge 54,56,63
Level warning light 63
Recommendation 122,123
Tank 122
Warning light... 54,56
Fuses 153
G

Garage lift 148
Gearshifting 109
Glove compartment. 96
Gong 18,51, 69, 79
Ground clearance 9,186
H
Headlights 82,83,164
Adjusting 175,176
Cleaning system 84,126, 185
Heated rearwindow 29
Heating 88
High beam
Indicator light... 54,56,61
Lever 82
Hoods 98,99
Horn 17,22, 23

I

Identification number 100,180
Ignition lock 50
Immobilizer 19
Indicator lights 54
Infrared passenger compartment monitoring..24
Instrument panel 48
Instruments 54
Lights 59,82
Interior light 46,173
Interior mirror 28
Intermittent operationswitch 84
Index

J

Jumper cables "145,160

K

Keys 19,20

L

Leather care 135
License platelight.. 82,172
Lids 99
Emergency unlocking 154
Light
Flasher 61,82, 83
Low beam 82,83
Switch 82,83
Light sensor forinstrument illumination 54,56
Load switch-off 152
Locking "22
Conditions 23
Luggage carrier 186
Luggage compartment.. 100,172
Lid 98
Lid warning light 54,56,98

M

Maintenance 112
Make-up mirror 103
Maximum permitted enginespeeds 16
Mirrors 28
Monitoring 24

192
Index
N

Notes on
Car care "130
Maintenance 112
Number platelight "82,172

o

Octane rating 122,123
Odometer 59
Oil 114,185
Consumption 16
Dipstick 116
Level checks
ll,
115
Level gauge
II

Pressure gauge 54,56,65
Pressure warninglight.. 54,56,65
On-board computer 54,56,67
Basic setting 68,73
Language selection 73
On-board literature 2
Orientation light 46
Outside-temperature display 68

p

Paint Care 130
Data 180
Parking
Brake 40,41
Brake warning light... 54,56
Light 82,168, 171
Particle filter 128Passenger
airbag,switching off 37
Passenger compartment monitoring,infrared..24
Plastic parts 134
Platform lift. 148
Power measurements 112
Power steering fluidlevel 127,185
Power windows 21,26,27
Practical tips 140

R

Radiator fan 53,114
Radio reception 105
Rear foglight... 82,
III

Rear spoiler 104
Rear viewmirrors 28
Rear window defogger 29
Relays 152
Remote control 20
Replacement key 19
Replacing bulbs 162
Replacing wiperblades 129
Roof Transport System 108,186
Running in 16

S

Safety belts 32,136
Warning light... 54,56
Safety compliance sticker 181
Seals 134
Side marker light... 82,170,
III

Side member panels 104
Snow chains 147
Snow tires 146

Sparekey 19,20
Speed Control 58,86, 87
Gong 69
Speedometer 54,60
analogue display 56
digital display 54,56
Spoiler 104
Starting engine 52
Steering lock 50
Steering wheel
Adjustment 31
Lock 51
Stopping engine 53
Storage options 96,97
Storage tray 97
Storing yourPorsche 137
Sun visors 103

T
Tachometer 54,56,61
Taillight 171
Tank 121,122,185
Ventilation system 126
Technical data 182
Temperature setting 88,90
Theft protection 18
Tires 16,141,184
Pressure 5,143, 183
Pressure compressor 100
Repair kit.. 149
Tires andtirecare 141
Tool kit 100
Towing 177,178 Tracks
184
Transmission 109,183
Fluid 185
Thpwu~r ~
Trunk entrapment 101
Turn signals 61,83,168,171
Indicator lights 54,56

U

Undercoating 124,133

V

Valves 145
Vanity mirror 103
Vehicle Care 130
Data 180,181
Identification label 180
Identification number 100,180
Washing 131
Ventilation 88
Vents 93
Voltmeter 54,56,58

w

Warning lampsandmessages 75
Washer fluid 126,185
Level warning light 54,56
Washing 131
Weights 186
Wheel Bolts 19,150 Changing
149
Wheels 135,184
Windows 26,27, 133
Washer nozzles 84
Washer system 84,126, 185
Windshield wiper/washer lever 84
Windshield wipers 84,85,129
Replacing 129

Winter operation

Battery "157
Coolant. 113
Engine oil 114
Jumper cables 160,161
Locks 132
Seals 134
Snow chains 147
Tires 146,184
Washer fluid 126
Wiper blades 129
Wiper Blades 129
Interval 84,85
Index