service PORSCHE 911 GT3 2010 5.G Repair Manual

228
Practical Tips, Emergency Service
Adjusting HeadlightsfPlease see the chapter “LIGHTS, REPLACING
BULBS” on Page 219.
Adjustment
The adjustment is made with the vehicle ready to
drive and the fuel tank completely filled.
The driver’s seat must be loaded by a person or a
165 lbs. (75 kg) weight and the tire pressures
must meet the prescribed values.
After being loaded, the car must be rolled a few
meters so that the suspension can settle.
For checking the headlight adjustment, the
vertical position of the cutoff of the low beam (see
fig.) has to be projected on a vertical screen (wall)
in distance of 24.6 ft. (7.5 m) from the front lens
of the headlamp.
The correct position of the cutoff is 2.0 in. (5 cm)
at 24.6 ft. or 7.5 m (0.4°) below a horizontal line,
x cm from ground to the center of the headlamp
lens.Lateral adjustment of the headlights should be
carried out at a specialist workshop with an optical
adjustment unit.
Distance
Visual aim shall be performed at not less than
24.6 ft. (7.5 m) (this value is a rounded down
conversion from the 25-foot distance typical of
field aim using a screen). The 24.6 ft. (7.5 m)
distance is measured from the headlamp lens to
the viewing screen.
10_GT3_21.book Seite 228 Donnerstag, 4. Juni 2009 12:48 12

Practical Tips, Emergency Service
229
Floor
The surface upon which the vehicle rests is flat
and approximately level.
Screen
The screen upon which headlamp beams are
projected is perpendicular to the floor and the
vehicle’s longitudinal axis, flat, uniformly light in
color, unobstructed, and wide and high enough to
accommodate the vehicle beam patterns to be
aimed.
The screen should be wide enough to provide at
least 3.3 ft. (1 m) of space outboard of the
vehicle’s headlamp spacing.
Adjustment screws
fDetach side carpeting in luggage compart-
ment.
Unscrew plastic nut A.
Open the cover of the appropriate adjustment
screw.
The setting is adjusted by turning the hexagon
socket screws right or left, as appropriate. Halogen headlights and Bi-Xenon headlights:
B - Height adjustment
Note
fDo not alter the lateral adjustment.
10_GT3_21.book Seite 229 Donnerstag, 4. Juni 2009 12:48 12

230
Practical Tips, Emergency Service
Towing Certain state statutes and local ordinances
prohibit towing with a chain, rope or even a tow
bar.
In addition, damage to your vehicle may result
from improper procedures.
Consult your authorized Porsche dealer for
details. Vehicle towing Flat bed towing is the preferred type of towing to
be used on Porsche vehicles.
Under certain circumstances, wheel lifts may be
used when the vehicle will not roll.
The vehicle must be towed with all four
wheels off the ground, otherwise damage to
the vehicle may result.
Towing hook The towing hook A is contained in the tool box in
the luggage compartment.
Caution!
Risk of damage to the vehicle.
fUse the towing hook only for an emergency to
remove the vehicle off the road. The towing
hook is to be used only to pull the vehicle onto
the flat bed, tractor or towing aparatus if the
vehicle will roll freely. Under no circumstances
is the vehicle to be secured using the towing
hook.
fNever use the towing hook to tow this or any
other vehicle.
fBear in mind the limited ground clearance of your car on uneven surfaces.Fitting towing hook
When fitting on the rear of the vehicle, the license
plate must be removed.
1. Press the lower edge of the appropriate
plastic cover into the bumper until the cover
disengages.
2. Pull cover out of the bumper and let it hang by
its thread.
3. Completely screw in the towing hook A.
10_GT3_21.book Seite 230 Donnerstag, 4. Juni 2009 12:48 12

Practical Tips, Emergency Service
231
Removing towing hook
1. Unscrew the towing hook A.
2. Insert plastic cover at the lower edge of the
opening.
3. Fold the cover up and press on its upper edge
to engage it in the bumper.
When removing on the rear of the vehicle, the
license plate must be mouted.
Pulling vehicle onto flat bed 1. Position wooden ramps at the base of the flat
bed to reduce the angle of the pull.
2. Reel in the hoist cable and check the underside
of the vehicle for any interference.
Tying down vehicle on flat bed 1. Carefully feed towing straps through the
opening in the rear wheels.
Make sure metal parts of straps do not
damage rim.
Make sure the strap is flat over the rim bead.
Make sure brake backing plate is not
damaged.
2. Secure straps to rear of flat bed.
3. Reel in hoist cable only far enough to tension
tie-down straps.
10_GT3_21.book Seite 231 Donnerstag, 4. Juni 2009 12:48 12

232
Practical Tips, Emergency Service 4. Carefully feed towing straps through the
opening in the front wheels.
Make sure metal parts of straps do not
damage rim.
Make sure the strap is flat over the rim bead.
Make sure brake backing plate is not
damaged.
5. Secure straps to front of flat bed.
6. Release tension on hoist cable, but do not
disconnect.
Use hoist cable as a safety cable.
10_GT3_21.book Seite 232 Donnerstag, 4. Juni 2009 12:48 12

244
Index Brake fluid
Changing............................................ 163
Checking level .................................... 162
Level.................................................. 162
Warning light ...................................... 163
Brakes ....................................................... 162
Brake circuit division warning light ........ 163
Brake warning light ............................. 116
Fluid........................................... 162, 239
Fluid warning light ............................... 163
Function ............................................... 54
New brake pads or linings ..................... 56
Pads .................................................... 13
Parking brake ....................................... 53
Porsche Ceramic Composite Brake
(PCCB) ................................................... 6
Service brake ......................................... 6
Test stand ............................................ 61
Break in brakes ............................................ 13
Break in hints ............................................... 13
Bulbs, replacing.......................................... 219
CCapacities .................................................. 239
Car care .................................................... 174
Car telephone ............................................... 91
Car washes ................................................ 175
Carpet ....................................................... 180
Catalytic converters .................................... 169
Cautions ............................................ 157, 183Central locking...................................... 22, 208
Automatic relocking............................... 22
Emergency operation ............................ 23
Fault indication ...................................... 24
Overload protection....................... 24, 208
Central locking button................................... 24
Central vents .............................................. 101
Central warning light ................................... 116
Changing bulb............................................. 227
Check engine
Warning light....................................... 116
Check engine warning light .......................... 116
Opening the oil filler cap ...................... 161
Checking pressure ...................................... 203
Child restraint systems .................................. 47
Anchorages .......................................... 52
Direction of installation .......................... 48
Child seat bracket ......................................... 51
Chime .......................................................... 73
CHRONO Stopwatch .................................... 127
Cigarette lighter ............................................ 82
Circulating-air button..................................... 99
Clock ................................................. 114, 146
Clothes hook ................................................ 83
Clutch .................................................. 53, 155
Clutch pedal ................................................. 53
Combination filter........................................ 172
Coming home mode ...................................... 74
Communication management ......................... 89
Compact disc
Player .................................................. 90
Storage ................................................ 84
Compartment monitoring ............................... 26
Compressor .................................................87
Coolant ..............................................112, 158
Checking ............................................158
Level ..................................................158
Temperature gauge .............................112
Topping off .........................................158
Warning light .......................................112
Cooling system ...................................112, 158
Warning light .......................................112
Cornering light
Functional description ............................74
Indicator light ......................................111
Crankcase ventilation ..................................169
Cruise control .................................78, 79, 115
Cupholder.....................................................80DData bank ...................................................234
Daytime running lights ...................................73
Changing bulbs ...................................227
On-board computer .............................146
Decals........................................................175
Defrosting windows .................................32, 99
Diagnostic socket .........................................14
Diagram
Engine diagram ...................................242
Dimensions.................................................241
Door ............................................................21
Handles ................................................21
Locks ...........................................21, 176
Mirror ...................................................31
Mirror heating .......................................32
Mirrors .................................................30
Windows .................................21, 29, 177
10_GT3_21.book Seite 244 Donnerstag, 4. Juni 2009 12:48 12

Index
245
Driving
Hints .................................................... 11
Driving performance ................................... 240
Drop-center rim .......................................... 194
Dynamic cornering light
Functional description............................ 74
Dynamic engine mounting.............................. 63EElectrical system ........................................ 207
Emergency flasher switch.............................. 72
Emergency operation
Central locking...................................... 23
Ignition key ........................................... 69
Lids ................................................... 210
Tank flap ............................................ 165
Emergency service ..................................... 183
Emergency starting with jumper cables 217, 218
Emission control system ............. 116, 168, 169
Engine
Checking the oil level........................... 143
Exhaust .................................................. 8
Number .............................................. 235
Oil consumption ............................ 13, 159
Oil level .............................................. 160
Oil level indicator................................ 143
Oil pressure ........................................ 115
Oil temperature................................... 108
Oils ............................................ 159, 239
Speeds ........................................ 13, 240
Starting ................................................ 70
Stopping .............................................. 71Engine compartment
Blower .........................................71, 112
Blower fan ..........................................112
Care...................................................177
Lid .................................................85, 86
Lid warning light ....................................85
Engine oil
Choosing the right oil ..........................160
Consumption ........................................13
Topping off .........................................160
Viscosity.............................................160
Exhaust
Pipes .....................................................8
Tailpipes, stainless steel ......................178
External antenna ...........................................91
External audio source, AUX ............................93
FFiller flap ....................................................165
Filling pressure, tire.....................................237
Fire extinguisher ...........................................94
Flat tire ......................................................203
Floor mats ..................................................180
Fluids and fuels ...........................................239
FM reception ................................................89
Fog light, rear ...............................................73
Footbrake.....................................................54
Fresh air intake ...........................................101
Front axle lift system
Functional description ............................64
Lowering front axle................................65
Raise front axle .....................................64
Front lid .................................................85, 86Fuel................................................... 113, 165
Containers ..................................... 7, 167
Economy ........................................... 164
Evaporation control ............................ 167
Fuels containing ethanol ...................... 167
Level gauge ....................................... 113
Level warning light.............................. 113
Recommendation ....................... 166, 167
Recommendations.............................. 166
Tank.................................................. 166
Fuses, replacing......................................... 209
GGarage
Door ................................................... 71
Door opener ........................................ 95
Lift .................................................... 206
Glove compartment ...................................... 84
Gong ....................................... 17, 68, 73, 120
Ground clearance ........................................... 8HHalogen headlights
Changing bulb for low beam ................ 222
Handbrake ................................................... 53
Head restraints ............................................ 33
Headlights ................................................. 220
Adjusting ................................... 228, 229
Beam adjustment ................................. 74
Cleaning system ................... 76, 170, 239
Flasher ................................................ 75
Heated rear window..................................... 32
Heated rear window/Door mirror heating ..... 102
10_GT3_21.book Seite 245 Donnerstag, 4. Juni 2009 12:48 12

248
Index Seat
Adaptive sports seat ............................. 34
Adjustment ........................................... 33
Heating ................................................ 36
Position................................................ 33
Sports bucket seat............................... 35
Sports seat .......................................... 34
Service ...................................................... 124
Service brake ................................................. 6
SET Basic setting on on-board computer ...... 145
Shifting gears
Manual transmission............................ 155
Side lights, front ......................................... 227
Side marker light .................................. 73, 226
Side vents .................................................. 101
Snow chains ............................................... 192
Snow tires.................................................. 191
Socket ....................................................... 207
Spare key .................................................... 18
Speed code letter ....................................... 193
Speed control............................................... 79
Automatic............................................. 78
Indicator light...................................... 108
Speed limit ......................................... 120, 193
Speedometer ............................................. 110
Sport button ................................................. 62
Sport Chrono Plus package
CHRONO stopwatch............................ 127
Sport mode .................................................. 62
Sport tires...................................................... 5
Sports bucket seat ....................................... 35
Sports seat .................................................. 34
Stability Control (SC)..................................... 60
Stability management system (PSM) ............... 59Starter switch ............................................... 67
Starting ........................................................ 68
Starting engine ............................................. 70
Steam cleaners .......................................... 174
Steering column
Locking ................................................ 68
Steering lock ................................................ 67
Steering wheel
Adjustment ........................................... 36
Lock .................................................... 68
Stopping engine............................................ 71
Stopwatch .................................................. 127
Storage options ............................................ 83
Storage possibilities ...................................... 83
Storing your Porsche.................................. 181
Sun visors .................................................... 37
Suspension management............................... 63
Suspension setup ....................................... 241
TTachometer ................................................ 111
Tail light ..................................................... 227
Tank .......................................... 165, 166, 239
Ventilation system ............................... 167
Technical data ............................................ 236
TEL Telephone information .......................... 124
Telephone .................................................... 91
Temperature setting................................ 98, 99
Temperature, outside indicator .................... 114
Test stand
Measurements ...................................... 61
Theft protection ............................................ 17Tire
Care...................................................188
Damage .............................................188
Designations .......................................192
Pressure plate ....................................186
Replacements .....................................189
Traction..............................................187
Wear ..................................................187
Tire filling compressor ...................................87
Tire pressure
Compressor..........................................87
Tire pressure monitoring
Warning light .......................................141
Wheels ...............................................190
Tire pressure monitoring (TPM) ....................134
Tires ............................................13, 184, 238
Care...................................................184
Checking pressure ..............................203
Inscription...........................................193
Loading information .............................195
New tires ..............................................13
Pressure.....................................185, 237
Pressure monitoring............................134
Pressure plate ....................................235
Removing and storing ..........................191
Sealant .................................87, 203, 204
Sidewall ..............................................193
Size ...................................................193
Snow tires ..........................................191
Sport......................................................5
Tool kit .........................................................87
Tools ...........................................................87
Towing ...............................................230, 231
Towing hook ...............................................230
10_GT3_21.book Seite 248 Donnerstag, 4. Juni 2009 12:48 12