engine overheat Ram ProMaster 2017 User Guide

WARNING!(Continued)
•A hot exhaust system can start a fire if you park over
materials that can burn. Such materials might be
grass or leaves coming into contact with your exhaust
system. Do not park or operate your vehicle in areas
where your exhaust system can contact anything that
can burn.
CAUTION!
• The catalytic converter requires the use of unleaded
fuel only. Leaded gasoline will destroy the effective-
ness of the catalyst as an emissions control device
and may seriously reduce engine performance and
cause serious damage to the engine.
• Damage to the catalytic converter can result if your
vehicle is not kept in proper operating condition. In
the event of engine malfunction, particularly involv-
ing engine misfire or other apparent loss of perfor-
mance, have your vehicle serviced promptly. Contin-
ued operation of your vehicle with a severe
malfunction could cause the converter to overheat,
resulting in possible damage to the converter and
vehicle. Under normal operating conditions, the catalytic converter
will not require maintenance. However, it is important to
keep the engine properly tuned to assure proper catalyst
operation and prevent possible catalyst damage.
NOTE:
Intentional tampering with emissions control sys-
tems can result in civil penalties being assessed against
you.
In unusual situations involving grossly malfunctioning
engine operation, a scorching odor may suggest severe and
abnormal catalyst overheating. If this occurs, stop the
vehicle, turn off the engine and allow it to cool. Service,
including a tune-up to manufacturer’s specifications,
should be obtained immediately.
To minimize the possibility of catalytic converter damage:
• Do not shut off the engine or interrupt the ignition,
when the transmission is in gear and the vehicle is in
motion.
• Do not try to start the engine by pushing or towing the
vehicle.
• Do not idle the engine with any spark plug wires
disconnected or removed, such as when diagnostic
testing, or for prolonged periods during very rough idle
or malfunctioning operating conditions.7
MAINTAINING YOUR VEHICLE 285

WARNING!
•Do not open hot engine cooling system. Never add
engine coolant (antifreeze) when the engine is over-
heated. Do not loosen or remove the cap to cool an
overheated engine. Heat causes pressure to build up
in the cooling system. To prevent scalding or injury,
do not remove the pressure cap while the system is
hot or under pressure.
• Do not use a pressure cap other than the one speci-
fied for your vehicle. Personal injury or engine
damage may result.
Disposal Of Used Engine Coolant
Used ethylene glycol-based engine coolant (antifreeze) is a
regulated substance requiring proper disposal. Check with
your local authorities to determine the disposal rules for
your community. To prevent ingestion by animals or
children, do not store ethylene glycol-based engine coolant
in open containers or allow it to remain in puddles on the
ground. If ingested by a child or pet, seek emergency
assistance immediately. Clean up any ground spills imme-
diately.
Coolant Level
The coolant expansion bottle provides a quick visual
method for determining that the coolant level is adequate.
With engine off and cold, the level of the engine coolant
(antifreeze) in the bottle should be between the “MIN” and
“MAX” marks.
Points To Remember
NOTE: When the vehicle is stopped after a few miles/
kilometers of operation, you may observe vapor coming
from the front of the engine compartment. This is normally
a result of moisture from rain, snow, or high humidity
accumulating on the radiator and being vaporized when
the thermostat opens, allowing hot engine coolant (anti-
freeze) to enter the radiator.
If an examination of your engine compartment shows no
evidence of radiator or hose leaks, the vehicle may be
safely driven. The vapor will soon dissipate.
• Do not overfill the coolant expansion bottle.
• Check the coolant freeze point in the radiator and in the
coolant expansion bottle. If engine coolant (antifreeze)
needs to be added, the contents of the coolant expansion
bottle must also be protected against freezing.
7
MAINTAINING YOUR VEHICLE 293

Flooded, Starting........................ .176
Fuel Requirements ....................223, 315
Jump Starting .......................... .267
Oil ........................... .281, 315, 316
Oil Filter .............................. .283
Oil Selection ........................ .282, 315
Oil Synthetic ........................... .283
Overheating ........................... .242
Starting .............................. .176
Engine Oil Viscosity ........................ .282
Engine Oil Viscosity Chart ....................282
Enhanced Accident Response Feature ............274
Entry System, Illuminated .....................14
Ethanol ................................. .224
Exhaust Gas Caution .....................50, 226
Exhaust System ........................ .50, 284
Exterior Lighting ............................74
Exterior Lights .............................53
Filters Air Cleaner ............................ .284
Air Conditioning .....................164, 287
Engine Oil ......................... .283, 316
Engine Oil Disposal ...................... .283Flashers
Hazard Warning ........................ .242
Turn Signal ......................... .53, 118
Flooded Engine Starting ..................... .176
Fluid Capacities ........................... .315
Fluid Leaks ...............................53
Fluid Level Checks Automatic Transmission ....................296
Brake ................................ .294
Cooling System ......................... .290
Power Steering ......................... .189
Fluids, Lubricants And Genuine Parts ............316
Fog Lights ................................76
Four-Way Hazard Flasher .....................242
Freeing A Stuck Vehicle ..................... .271
Fuel ................................... .223
Adding .............................. .227
Additives ............................. .225
Clean

Air ............................. .223
Ethanol .............................. .224
Filler Cap (Gas Cap) ..................... .227
Gasoline .............................. .223
Materials Added ........................ .225
Methanol ............................. .224
Octane Rating ....................... .223, 316
Requirements ....................... .223, 315
10
INDEX 337

Maintenance Procedures..................... .281
Maintenance Schedule ...................... .320
Malfunction Indicator Light (Check Engine) .....115,279
Manual, Service ........................... .330
Methanol ............................... .224
Mirrors ..................................58
Electric Remote ...........................59
Exterior Folding ..........................58
Heated .................................59
Outside ................................58
Rearview ...............................58
Modifications/Alterations, Vehicle ................7
Monitor, Tire Pressure System ..................219
MOPAR Parts ......................... .280, 329
MTBE/ETBE ............................. .224
Multi-Function Control Lever ...................74
New Vehicle Break-In Period ...................49
Occupant Restraints .........................20
Octane Rating, Gasoline (Fuel) .................223
Oil Change Indicator ....................... .124
Oil Change Indicator, Reset ...................124
Oil, Engine ........................... .281, 316
Capacity .............................. .315Change Interval
........................ .282
Checking ............................. .281
Disposal .............................. .283
Filter ............................. .283, 316
Filter Disposal .......................... .283
Identification Logo ...................... .282
Materials Added To ...................... .283
Pressure Warning Light ....................109
Recommendation .....................282, 315
Synthetic ............................. .283
Viscosity .......................... .282, 315
Oil Filter, Change ......................... .283
Oil Filter, Selection ......................... .283
Oil Pressure Light ......................... .109
Onboard Diagnostic System ...................278
Operator

Manual (Owner’s Manual) ...............4
Outside Rearview Mirrors .....................58
Overhead Console ...........................91
Overheating, Engine ....................... .242
Owner’s Manual (Operator Manual) ...........4,330
Paint Care ............................... .297
Parking Brake ............................ .189
ParkSense System, Rear .......................85
Passing Light ..............................76
340 INDEX