engine RENAULT ZOE 2014 1.G Workshop Manual

5.18
WINDSCREEN WIPER BLADES
Replacing wiper blades 1
With the ignition on and the engine
switched off, lower the windscreen
wiper stalk completely: they stop
slightly away from the bonnet.
Lift wiper arm 3 , pull tab 2 (move-
ment A) and push the blade upwards.
To refit
Slide the blade along the arm until it
clips on. Make sure that the blade is
correctly locked in position. Return the
windscreen wiper stalk to the park po-
sition.
1
2
3
Keep monitoring the condition of the
wiper blades. How long they last de-
pends on you:
– clean the blades and the wind- screen regularly with soapy
water;
– do not use them when the wind- screen is dry;
– free them from the windscreen when they have not been used
for a long time.
A
– In frosty weather, make
sure that the wiper blades
are not stuck by ice (to
avoid the risk of the motor
overheating).
– Check the condition of the wiper
blades.
They should be replaced as soon
as they become less efficient: ap-
proximately once a year.
When changing the blade, when it
has been removed, do not let the
wiper arm fall against the window:
risk of breaking the window.Rear screen wiper blade 4
– Lift wiper arm 6;
– pivot blade 4 until some resistance is
met (movement C);
– depending on the vehicle, press tab 5, then remove the blade by pull-
ing it (movement B).
To refit
To refit the wiper blade, proceed in re-
verse order to removal. Make sure that
the blade is correctly locked in position.
4
5
B
C
6

5.19
Choice of breakdown service
In the event of an energy fault
In the event of a fully discharged trac-
tion battery, any type of towing is per-
mitted: towing on a flatbed truck or
towing on the road using the tow eye
(please see following pages). It is es-
sential to wait 5 minutes after locking
the doors to start towing.
All other cases
Only towing on a flatbed truck is per-
mitted.
TOWING, BREAKDOWN (1/3)
Before any recovery, unlock the steer-
ing column: with the clutch depressed,
engage first gear (lever in N position),
insert the card in the card reader, then
press the engine start button for two
seconds.
The regulations in force for breakdown
recovery must always be observed.Towing on a flatbed truck
Breakdown recovery must be per-
formed on a flat surface under all cir-
cumstances except where the vehicle
is immobilised following a full discharge
of the traction battery. In the event of a
total energy loss, please see the follow-
ing pages.

5.20
Once you have finished towing, press
the engine start button twice (risk of
running down the 12 V battery).
If the lever is stuck in P,
even though you are de-
pressing the brake pedal,
the lever can be released
manually.
To do this, unclip the cover at the
base of the lever.
Simultaneously press at the loca-
tion7 and the unlocking button 6 on
the lever.
TOWING, BREAKDOWN (2/3)
6
7
In the event of an energy
fault: towing
In the event of a fully discharged trac-
tion battery:
– the warning light 2
 flashes;
– the indicator 1 shows an empty bat-
tery.
It is possible to recover on a flatbed
truck or tow the vehicle using the tow
eye, following the instructions below.
When the engine is
stopped, steering and brak-
ing assistance are not op-
erational.
Before towing, unlock the steering
column: engage the lever 5 in position
N , insert the card in the reader 4 then
press the engine start button 3 for two
seconds.
The column is unlocked, the acces-
sory functions are supplied: the vehi-
cle lights can be used (hazard warn-
ing lights, brake lights etc.). The towed
vehicle’s lights must be switched on at
night.
The speed specified by current legis-
lation for towing must always be ob-
served.
3
5
4
1
2

5.23
OPERATING FAULTS (2/4)
FAULTSPOSSIBLE CAUSESWHAT TO DO
The programmable air conditioning
fails to work. One of the usage conditions is not
complied with (the traction battery
is not charged, etc).Please refer to the information on “Air-
conditioning: programming” in Section 3.
The remote control does not lock or
unlock the doors. The remote control battery is flat. Use the emergency key.
Use of appliances operating on
the same frequency as the remote
control (mobile phone, etc.).Stop using the devices or use the key.
Vehicle located in a high electro-
magnetic radiation zone.
Secondary 12 V battery dis-
charged. Replace the battery. You can still lock/unlock
and start your vehicle (refer to the information
on “Locking, unlocking the opening elements”
in Section 1 and “Starting, stopping the engine”
in Section 2).
The steering column remains
locked. Steering wheel locked.
Move the steering wheel while pressing the
engine start button (refer to Section 2 “Starting
the engine”).
Vibrations. Tyres not inflated to correct pres-
sures, incorrectly balanced or dam-
aged. Check the tyre pressures. If this is not the
problem, have them checked by an approved
Dealer.

6.1
Section 6: Technical specifications
Vehicle identification plates . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . 6.2
Engine identification plate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . 6.3
Engine specification. . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.3
Weights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.4
Dimensions . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .\
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.5
Replacement parts and repairs . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . 6.6
Service sheets . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 6.7
Anticorrosion check . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . . . . . . . . . . . . . . . . . 6.13

6.3
ENGINE IDENTIFICATION PLATE/ENGINE SPECIFICATION
The information on the engine plate
(or label) C should be quoted on all
your correspondence or orders.
(Location varies depending on engine)
1 Engine type.
2 Engine suffix.
3 Engine number.
C
2
3
1
Engine specification
Engine type 1: 5AM
C

7.2
ALPHABETICAL INDEX (2/5)
E
»ECO» mode function ......................................................... 2.8
ECO driving ...............................................................2.6 → 2.8
ECO mode ........................................................................\
... 2.8
electric beam height adjustment ........................................ 1.81
»400 volt» electrical circuit ........................................1.2 → 1.6
electric vehicle vehicle range ...................................................... 2.9 – 2.10
noise ..................................................................\
............ 1.6
charge ................................................................1.8 → 1.15
driving .......................................................... 1.6, 2.9 – 2.10
presentation .........................................................1.2 → 1.6
important recommendations .......................................... 1.7
electric windows ..................................................... 3.16 – 3.17
Electronic Stability Program: ESP .........................2.15 → 2.18
emergency brake assist.........................................2.15 → 2.18
emergency braking ................................................2.15 → 2.18
emergency key ....................................................... 1.18 – 1.19
energy »ECO» mode ................................................................. 2.8
saving .................................................................\
........... 2.9
charge meter (function) .................................................. 2.6
range ..................................................................\
..2.6 → 2.8
energy saving ..........................................................2.6 → 2.10
energy consumption ............................. 1.63 – 1.64, 2.9 – 2.10
energy recovery ................................................................... 2.9
engine specifications ........................................................... 6.3
environment ............................................................\
........... 2.11
ESP: Electronic Stability Program .........................2.15 → 2.18
external temperature .............................................. 1.73 – 1.74
F
faults operating faults ................................................5.22 → 5.25
fitting a radio ...................................................................... 5.16
fittings ...............................................................\
.....3.19 → 3.21fragrance diffuser ............................................................... 3.13
fragrance ..............................................................\
............. 3.13
front passenger air bag deactivation ................................. 1.52
front seat adjustment ......................................................... 1.30
front seats adjustment .......................................................1.30 → 1.34
with manual controls .................................................... 1.30
fuses ....................................................................... 5.13 – 5.14
G
gear lever..............................................................\
...... 2.4 – 2.5
glove box ........................................................................\
... 3.21
H
handbrake...............................................................\
............. 2.5
hands-free telephone integrated control ............................ 3.29
hazard warning lights signal ..................................... 1.76, 1.78
headlight beam adjustment ............................................... 1.81
headlight flashers .............................................................. 1.76
headlight washer ............................................................... 1.83
headrest................................................................\
............. 3.23
heating and air conditioning system .................................. 3.15
heating, air conditioning: programming ..........2.10, 3.9 → 3.12
heating system ...................................... 3.4 → 3.7, 3.9 → 3.12
heating/air conditioning programming .....................3.9 → 3.12
horn ...................................................................\
................ 1.76
horn: flash ..................................................................\
........... 1.76
sounding the horn ........................................................ 1.76
hubcap tool ........................................................................\
.. 5.2
I
indicators .............................................................\
....... 1.76, 5.9
indicators: direction indicators ................................................ 1.76, 5.9
exterior temperature indicator ...................................... 1.73

7.4
ALPHABETICAL INDEX (4/5)
RENAULT cardbattery ................................................................\
.......... 5.15
use ............................................................1.18 → 1.24, 3.8
RENAULT card battery ...................................................... 5.15
replacement parts ................................................................ 6.6
reverse gear selecting ................................................................ 2.4 – 2.5
reversing sensor ..................................................... 2.26 – 2.27
S
screen wash/wipe .............................................................. 1.84
seat belt pretensioners ..........................................1.35 → 1.38
front seat belt ...................................................1.35 → 1.38
seat belts ..................................1.31 → 1.38, 1.40 – 1.41, 1.61
see-me-home lighting ............................................... 1.79, 1.81
service sheets..........................................................\
6.7 → 6.12
side protection devices ...................................................... 1.40
signals and lights ...................................................1.78 → 1.81
speakers location ...............................................................\
......... 5.16
speed control .............................................................. 2.4 – 2.5
speed limiter .................................................1.61, 2.19 → 2.21
spoiler ................................................................\
................ 3.27
starting ........................................................................\
2.2 – 2.3
starting the engine ...................................................... 2.2 – 2.3
steering wheel adjustment .............................................................\
...... 1.55
stopping the engine ............................................................. 2.3
storage compartment.............................................3.19 → 3.21
storage compartments ...........................................3.19 → 3.21
sun visor ........................................................................\
.... 3.18
T
tailgate ...............................................................\
................ 3.27
tanks and reservoirs brake fluid ...................................................................... 4.5 coolant ................................................................\
........... 4.4
tanks and reservoirs: windscreen washer ........................................................ 4.5
technical specifications ........................................................ 6.6
telephone ..............................................................\
............. 3.29
temperature regulation ..............................................3.4 → 3.7
tool kit ........................................................................\
.......... 5.2
towing in the event of energy failure ...........................5.19 → 5.21
breakdown .......................................................5.19 → 5.21
towing hitch...................................................... 5.2, 5.20 – 5.21
towing rings ................................................... 1.45 – 1.46, 3.28
traction battery ...........................................................1.2 → 1.6
traction battery charge .............................................1.8 → 1.15
traction control .......................................................2.15 → 2.18
transporting children ..........................1.42 – 1.43, 1.45 → 1.54
transporting objects in the luggage compartment ............................. 3.27 – 3.28
trip computer and warning system.........................1.65 → 1.72
tyre inflation kit......................................................\
.....5.3 → 5.5
tyre pressure............................................2.12 → 2.14, 4.8, 5.7
tyre pressure loss warning.....................................2.12 → 2.14
tyre pressures ...................................................................... 4.8
tyres .............................................. 2.12 → 2.14, 4.8, 5.6 → 5.8
U
unlocking the doors ................................................ 1.27 – 1.28
V
vehicle range ...........................................................2.6 → 2.10
ventilation ............................................................\
......3.4 → 3.7
W
warning buzzer ..................................... 1.25 – 1.26, 1.76, 1.79
warning lights.....................................1.60 → 1.62, 1.65 – 1.66
washing .................................................................... 4.9 – 4.10