oil filter Seat Alhambra 2006 Owner's Manual

Checking and refilling levels209
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a Filter pre-heater
Your vehicle is fitted with a fuel filter pre-heater, making it well equipped for
operation in winter. This ensures that the fuel system remains operational to
approx. -24°C, provided you use winter-grade diesel which is safe to -15°C .
However, if the fuel has waxed to such an extent that the engine will not start
at temperatures of under -24°C, simply place the vehicle in a warm place for
a while.
Caution
Do not mix fuel additives (“thinners”, or similar additives) with diesel fuel.
Supplementary heating system
The supplementary heating system raises the calorific capacity of the heating
while the engine is running and outside temperatures are very low. The
supplementary heating system connects and disconnects automatically.
The exhaust fumes produced are eliminated through an exhaust pipe below
the vehicle.
Note
•For short journeys, very low outside temperatures and a percentage of
biodiesel fuel of over 50 % too much smoke may be produced.
•Every time the engine is switched off, the fan continues to operate for a
short time in order to more quickly cool the heater. When refuelling it is not
necessary to wait until the fan stops operating.
Working in the engine compartment
Safety instructions on working in the engine compartment
Any work carried out in the engine compartment or on the
engine must be carried out cautiously.
Before starting any work on the engine or in the engine compart-
ment:
1. Switch off the engine and remove the key from the ignition.
2. Apply the handbrake.
3. Move the gear stick to neutral or the selector lever to position P.
4. Wait for the engine to cool down.
5. Keep children away from the vehicle.
6. Raise the bonnet Ÿpage 97.
You should not do any work in the engine compartment unless you know
exactly how to carry out the jobs and have the correct tools! Have the work
carried out by a qualified workshop if you are uncertain.
All service fluids and consumables, e.g. coolant, engine oil, spark plugs and
batteries, are being constantly developed. SEAT provides a constant flow of
information to the Authorised Service Centres concerning modifications. For
this reason we recommend that you have service fluids and consumables
replaced by an Authorised Service Centre. Please observe the relevant
instructions Ÿpage 202. The engine compartment of any motor vehicle is a
hazardous area. Ÿ.

Checking and refilling levels213
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a
Oil properties
Viscosity
The viscosity class of the oil is selected according to the diagram.
When the ambient temperature falls outside the limits of the scale for a short
period, an oil change is not required.
Mono-grade oil
Single grade oils are generally not suitable for all year round use, due to
ranges of viscosity
43).These oils are only useful in a climate that is constantly very cold or very
warm.
Engine oil additives
No type of additive should be mixed with the engine oil. The deterioration
caused by these additives is not covered by the warranty.
Fig. 141 Types of oil
according to temperature
Engine typeSpecification
PetrolVW 501 01/ VW 502 00/ VW 504 00
DieselVW 505 00/ VW 505 01/ VW 507 00/ VW 506 01
Diesel Injector Pump
a)
a)Only use recommended oils, otherwise you may damage the engine.
VW 505 01/ VW 507 00/ VW 506 01
Diesel Injector Pump Motor 118 kW
a)VW 506 01/ VW 507 00
Diesel Engines with Particulate filter (DPF)
a)VW 507 00
43)Viscosity: Ability to flow

Checking and refilling levels 216
•Before opening the bonnet, read and observe the warnings
Ÿpage 209, “Safety instructions on working in the engine compartment”
.
•Wait for the engine to cool down. Hot oil may cause burn injuries.
•Wear eye protection to avoid injuries caused by splashes of oil.
•When removing the oil drain plug with your fingers, keep your arm hori-
zontal to help prevent oil from running down your arm.
•Wash your skin thoroughly if it comes into contact with engine oil.
•Engine oil is poisonous! Used oil must be stored in a safe place out of
the reach of children until it is disposed of.
Caution
No additives should be used with engine oil. This could result in engine
damage. Any damage caused by the use of such additives would not be
covered by the factory warranty.
For the sake of the environment
•Because of the disposal problems, the necessary special tools and
specialist knowledge required, we recommend that you have the engine oil
and filter changed by an Authorised Service Centre.
•Never pour oil down drains or into the ground.
•Use a suitable container when draining the used oil. It has to be large
enough to hold all the engine oil
Coolant
Coolant specifications
Coolant is a mixture of water and at least 40% coolant addi-
tive.
The cooling system must be filled with a mixture of water and at least 40 % of
our coolant additive G 12+ or an additive with the specification TT-VW 774 F
(it is dyed purple). This mixture gives the necessary frost protection down to
-25°C and protects the alloy parts of the cooling system against corrosion. It
also prevents scaling and raises the boiling point of the coolant.
The concentration of coolant must always be at least 40% - even if frost
protection is not required.
If greater frost protection is required in very cold climates, the proportion of
the antifreeze additive G 12+ can be increased. However, the percentage of
coolant additives should not exceed 60%, as this would reduce the frost
protection. It would also reduce the cooling effect. A mixture with 60%
coolant additive will give frost protection to approx. -40°C.
WARNING
•The coolant additive is toxic. There is a toxic risk. Always keep the
coolant additive in the original container that should be stored out of the
reach of children. The same applies to coolant that you have drained off.
•The coolant additive G 12+ must be added in sufficient quantities to
provide anti-freeze protection at the coldest ambient temperatures that
can be expected. At extremely cold ambient temperatures, the coolant
could freeze, causing the vehicle to breakdown. As the heater would also
not work in this situation, there is a risk of suffering exposure!
WARNING (continued)

Technical Data 264
Weights
Trailer weights
Engine oil capacity
Petrol engine 2.0l 85 kW (115 bhp). Automatic
General engine dataGross vehicle weightin kg 2430
Weight in working order (with driver)in kg 1653/1973
Gross axle weight, frontin kg 1210
Gross axle weight, rearin kg 980
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%1800
Approximate engine oil capacity with oil filter change 4,0 litres
Power output in kW (bhp)rpm 85 (115)/ 5200
Maximum torquein Nm at rpm 170/ 2600-4200
No. of cylinders, capacity
in cm
34/ 1984
Compression 10
Fuel
Super 95 RON
a)/Normal 91 RONb)
a)Research-Octane-Number = Measure of the predetonation power of the petrol.b)With a slight power loss

Technical Data265
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a Performance figures
Consumption (litres/100 km)/ CO
2 (g/km)
Weights
Trailer weights
Engine oil capacityMaximum speedin km/h 173
Acceleration from 0-49.71 mi/h in sec. 11,3
Acceleration from 0-100 km/hin sec. 17,2
Urban cycle14,2/341 14,4/346 14,6/350 14,8/355
Extra urban cycle8,1/194 8,3/199 8,5/204 8,7/209
Combined10,4/250 10,6/254 10,8/259 11,0/264
Gross vehicle weightin kg 2450
Weight in working order (with driver)in kg 1673/1993
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1280
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%1800
Approximate engine oil capacity with oil filter change4,0 litres

Technical Data267
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a Weights
Trailer weights
Engine oil capacity
Petrol engine 1.8l 110 kW (150 bhp). Automatic
General engine dataGross vehicle weightin kg 2450
Weight in working order (with driver)in kg 1674/1994
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1280
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%1900
Approximate engine oil capacity with oil filter change 4.3 litres
Power output in kW (bhp)rpm 110 (150)/ 5500
Maximum torquein Nm at rpm 210/ 1850-4500
No. of cylinders, capacity
in cm
34/ 1780
Compression 9,5
Fuel
95 super RON
a)
a)Research-Octane-Number = Measure of the predetonation power of the petrol.

Technical Data 268
Performance figures
Consumption (litres/100 km)/ CO
2 (g/km)
Weights
Trailer weights
Engine oil capacityMaximum speedin km/h 195
Acceleration from 0-49.71 mi/hin sec. 8,3
Acceleration from 0-100 km/hin sec. 12,1
Urban cycle14,1/338 14,3/343 14,5/348 14,7/353
Extra urban cycle8,0/192 8,2/197 8,4/202 8,6/206
Combined10,2/245 10,4/250 10,6/254 10,8/259
Gross vehicle weightin kg 2480
Weight in working order (with driver)in kg 1707/2005 1707/2027
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1280
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%1900
Approximate engine oil capacity with oil filter change4.3 litres

Technical Data 270
Weights
Trailer weights
Engine oil capacity
Petrol engine 2.8l VR6 150 kW (204 bhp) Automatic
General engine dataGross vehicle weightin kg 2470
Weight in working order (with driver)in kg 1694/2014
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1280
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%2000
Approximate engine oil capacity with oil filter change 5,5 litres
Power output in kW (bhp)rpm 150 (204)/6200
Maximum torquein Nm at rpm 265/3400
No. of cylinders, capacity
in cm
36/ 2792
Compression 10,75 ± 0,25
Fuel
Super 98 RON
a)/Super 95 RONb)
a)Research-Octane-Number = Measure of the predetonation power of the petrol.b)With a slight power loss

Technical Data271
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a Performance figures
Consumption (litres/100 km)/ CO
2 (g/km)
Weights
Trailer weights
Engine oil capacityMaximum speedin km/h 217
Acceleration from 0-49.71 mi/h in sec. 7,4
Acceleration from 0-100 km/hin sec. 10,4
Urban cycle16,2/389 16,4/394 16,6/398 16,8/403
Extra urban cycle8,6/206 8,8/211 9,0/216 9,2/221
Combined11,4/274 11,6/278 11,8/283 12,0/288
Gross vehicle weightin kg 2470
Weight in working order (with driver)in kg 1727/2020 1727/2025
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1280
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%2000
Approximate engine oil capacity with oil filter change5,5 litres

Technical Data273
Safety FirstOperating instructionsTips and MaintenanceTe c h n i c a l D a t a Weights
Trailer weights
Engine oil capacity
Diesel engine 1.9 litre TDI 66 kW (90 bhp) 6 gears
General engine dataGross vehicle weightin kg 2500
Weight in working order (with driver)in kg 1786/2047 1786/2084
Gross axle weight, frontin kg 1240
Gross axle weight, rearin kg 1330
Permitted roof loadin kg 75
With no brakes, gradients up to 12%700
With brakes, gradients up to 12%2000
Approximate engine oil capacity with oil filter change 5,5 litres
Power output in kW (bhp)rpm 66 (90)/ 4000
Maximum torquein Nm at rpm 240/1900
No. of cylinders, capacity
in cm
34/1896
Compression 18 ± 0,5
Fuel
Diesel Min. 51 Cetane Number
a) or Biodiesel (RME)
a)Cetane-Number (cetane index) = Measure of the combustion power of the diesel