brake sensor Seat Cordoba 2005 Owner's Manual

133 Intelligent technology
Safety FirstControls and equipment Tips and Maintenance Technical Data
constantly compares them with the actual behaviour of the vehicle.
If the desired course is not being maintained (for instance, if the
car is starting to skid), then the ESP compensates automatically by
braking the appropriate wheel.
The forces acting on the braked wheel bring the vehicle back to a
stable condition. If the vehicle tends to oversteer, the system will
act on the front wheel on the outside of the turn.
N No
ot
te
e
•In order to ensure that ESP functions correctly, all four wheels must be
fitted with the same tyres. Any differences in the rolling radiusof the tyres
can cause the system to reduce engine power when this is not desired.
•Modifications to the vehicle (e.g. to the engine, the brake system, running
gear or any components affecting the wheels and tyres) could affectthe
efficiency of the ABS, EDL, ESP and TCS.
K
Anti-lock brake system (ABS)
The anti-lock brake system prevents the wheels locking during
braking
⇒chapter “Anti-lock brake system and traction control
ABS”.
K
Electronic differential lock (EDL)
The electronic differential lock helps prevent the loss of traction
caused if one of the driven wheels starts spinning.
EDL helps the vehicle to start moving, accelerate and climb a
gradient in slippery conditions where this may otherwise be
difficult or even impossible.
It uses the ABS sensors to monitor the speed of the driven wheels.
In case of an EDL fault the warning light for ABS lights up
⇒
chapter “Warning lamps”.
At speeds of up to approximately 80 km/h, it is able to balance out
differences in the speed of the driven wheels of approximately 100
rpm caused by a slippery road surface on one side of the vehicle. It
does this by braking the wheel which has lost traction and
distributing more driving force to the other driven wheel via the
differential.
To prevent the disc brake of the braked wheel from overheating,
the EDL cuts out automatically if subjected to excessive loads. The
vehicle will continue to function normally without EDL. For this
reason, the driver is not informed that the EDL has been switched
off.
The EDL will switch on again automatically when the brake has
cooled down.
• • IIt
t mmu
us
st
t bbe
e rre
em
me
em
mb
be
er
re
ed
d tth
ha
at
t TTC
CS
S cca
an
nn
no
ot
t dde
ef
fy
y tth
he
e lla
aw
ws
s oof
f pph
hy
ys
si
ic
cs
s.
. TTh
hi
is
s
s sh
ho
ou
ul
ld
d bbe
e kke
ep
pt
t iin
n mmi
in
nd
d,
, ppa
ar
rt
ti
ic
cu
ul
la
ar
rl
ly
y oon
n ssl
li
ip
pp
pe
er
ry
y aan
nd
d wwe
et
t rro
oa
ad
ds
s aan
nd
d wwh
he
en
n
t to
ow
wi
in
ng
g aa ttr
ra
ai
il
le
er
r.
.
• • AAl
lw
wa
ay
ys
s aad
da
ap
pt
t yyo
ou
ur
r ddr
ri
iv
vi
in
ng
g sst
ty
yl
le
e tto
o ssu
ui
it
t tth
he
e cco
on
nd
di
it
ti
io
on
n oof
f tth
he
e rro
oa
ad
ds
s aan
nd
d tth
he
e
t tr
ra
af
ff
fi
ic
c ssi
it
tu
ua
at
ti
io
on
n.
. DDo
o nno
ot
t lle
et
t tth
he
e eex
xt
tr
ra
a ssa
af
fe
et
ty
y aaf
ff
fo
or
rd
de
ed
d bby
y EES
SP
P tte
em
mp
pt
t yyo
ou
u iin
nt
to
o
t ta
ak
ki
in
ng
g aan
ny
y rri
is
sk
ks
s wwh
he
en
n ddr
ri
iv
vi
in
ng
g,
, tth
hi
is
s cca
an
n cca
au
us
se
e aac
cc
ci
id
de
en
nt
ts
s.
.
W
WA
AR
RN
NI
IN
NG
G


187 If and when
Safety FirstControls and equipment Tips and Maintenance Technical Data
Layout of fuses
N
Nº
ºC
Co
om
mp
po
on
ne
en
nt
tA
Am
mp
pe
er
re
es
s
1 Free ---
2 ABS/ESP 10
3 Free ---
4 Brake light, clutch 5
5 Engine control unit (petrol) 5
6 Dipped beam, right 5
7 Dipped beam, left 5
8 Mirror heating control 5
9 Lambda probe 10
10 "S" signal1). Radio control 5
11 Free ---
12 Height adjustment headlights 5
13 Level sensor/oil pressure 5
14 Additional engine heating/Oil pump 10
15 Automatic gearbox control 10
16 Heated seats 15
17 Engine control unit 5
18
Instrument panel/Heating and ventilation, Navigation,Height adjustment headlights, Electric mirror 10
N Nº
ºC
Co
om
mp
po
on
ne
en
nt
tA
Am
mp
pe
er
re
es
s
19 Reverse light 15
20 Windshield washer pump 10
21 Main beam, right 10
22 Main beam, left 10
23 License plate light/pilot light for side light 5
24 Windshield wiper 10
25 Sprayers (petrol) 10
26 Brake light switch/ESP 10
27 Instrument panel/Diagnosis 5
28 Control: glove compartment light, boot light,
interior light sun roof 10
29 Climatronic 5
30 Free ---
31 Electronic window, left 25
32 Control central locking 15
33 Self-fed alarm horn 15
34 Current supply 15
35 Open roof 20
36 Engine electro-fan heating/Ventilation 25
37 Pump/headlight washers 20
38 Fog lights, rear fog lights 15
39 Control petrol engine unit 15
40 Control diesel engine unit 20
41 Fuel level indicator 15
42 Transformer ignition 15
43 Dipped beam, right 15
44 Electric window, rear left 25
1)The "S" signal is a system which incorporates steering wheel lock and ignition. Once
the ignition is switched off and without removing the key from the ignition this function
allows you to switch on some of the electrical equipment such as the car radio, the
courtesy light, etc. This function is deactivated once the key is removed from the
ignition.


238General index
Plastic parts and leatherette . . . . . . . . . . . . . 152
Polishing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Position of the ignition key . . . . . . . . . . . . . . . 119
Power steering* . . . . . . . . . . . . . . . . . . . 48, 134
Preparation work . . . . . . . . . . . . . . . . . . . . . . . 180
Proper sitting position for driver . . . . . . . . . . 32
Properties of RME . . . . . . . . . . . . . . . . . . . . . . 129
Protecting seat belts . . . . . . . . . . . . . . . . . . . . 10
R R
Radiator fan . . . . . . . . . . . . . . . . . . . . . . . . . . . 163
Radio-frequency remote control key* . . . . . . . 65
Rain sensor* . . . . . . . . . . . . . . . . . . . . . . . . . . 81
Raising the seat . . . . . . . . . . . . . . . . . . . . . . . 94
Raising the vehicle . . . . . . . . . . . . . . . . . . . . . 182
Rear body work lights . . . . . . . . . . . . . . . . . . . 196
Rear drink holder* . . . . . . . . . . . . . . . . . . . . . . 98
Rear seat . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 93
Rear tailgate lights . . . . . . . . . . . . . . . . . . . . . 195
Rear towing eye . . . . . . . . . . . . . . . . . . . . . . . . 203
Rear-view mirrors . . . . . . . . . . . . . . . . . . . . . . 83
Refuelling . . . . . . . . . . . . . . . . . . . . . . . . . . . . 127
Removing and fitting the wheel . . . . . . . . . . . 183
Removing and installing . . . . . . . . . . . . . . . . . 90
Renewing the brake fluid . . . . . . . . . . . . . . . . 164
Renewing wheels/tyres . . . . . . . . . . . . . . . . . 177
Revolutions counter* . . . . . . . . . . . . . . . . . . . 40RME fuel (“diester”) . . . . . . . . . . . . . . . . . . . . 128
Roof antenna* . . . . . . . . . . . . . . . . . . . . . . . . .199
Roof rack* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 94
Running-in . . . . . . . . . . . . . . . . . . . . . . . . . . . . 135
S
S
Safety for children . . . . . . . . . . . . . . . . . . . . . .25
Safety notes on using child seats . . . . . . . . . 25
Safety notes on using seat belts . . . . . . . . . . 11
Seat adjustments . . . . . . . . . . . . . . . . . . . . . . 88
Seat belt position . . . . . . . . . . . . . . . . . . . . . . 13
Seat belt release . . . . . . . . . . . . . . . . . . . . . . . 14
Seat belt warning lamp* . . . . . . . . . . . . . . . . 51
Seat belts . . . . . . . . . . . . . . . . . . . . . . . . . . . . 8
Seat heating* for left seat . . . . . . . . . . . . . . . 76
Seat heating* for right seat . . . . . . . . . . . . . . 76
Seats and luggage compartment . . . . . . . . . 87
Selector lever lock . . . . . . . . . . . . . . . . . . . . . .114
Selector lever position display* . . . . . . . . . . . 44
Selector lever positions . . . . . . . . . . . . . . . . . 115
Servicing and replacing . . . . . . . . . . . . . . . . . 171
Servobrake . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Side indicators . . . . . . . . . . . . . . . . . . . . . . . .195
Side light bulbs . . . . . . . . . . . . . . . . . . . . . . . .192
Snow chains . . . . . . . . . . . . . . . . . . . . . . . . . .180
Spark plugs . . . . . . . . . . . . . . . . . . . . . . . . . . . 172
Speedometer . . . . . . . . . . . . . . . . . . . . . . . . . .41Starting after running out of fuel . . . . . . . . . . 121
Starting the engine . . . . . . . . . . . . . . . . . . . . . 120
Steel wheels . . . . . . . . . . . . . . . . . . . . . . . . . .153
Stopping the engine . . . . . . . . . . . . . . . . . . . . 121
Storing speed . . . . . . . . . . . . . . . . . . . . . . . . . 123
Stowage box . . . . . . . . . . . . . . . . . . . . . . . . . .96
Stowage compartment on the front passenger
side . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 96
Stowing luggage . . . . . . . . . . . . . . . . . . . . . . . 91
Sun visors . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Switch on interior light . . . . . . . . . . . . . . . . . . 79
Switches in driver’s door . . . . . . . . . . . . . . . . 76
Switches in the central console . . . . . . . . . . . 77
Switching lights on and off . . . . . . . . . . . . . . 74
Switching on . . . . . . . . . . . . . . . . . . . . . . . . . . 123
Switching system off temporarily . . . . . . . . . . 124
Switching the system off completely . . . . . . . 125
Synchronization . . . . . . . . . . . . . . . . . . . . . . . 67
T
T
TCS . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 131
Tailgate . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 62
Technical data . . . . . . . . . . . . . . . . . . . . . . . . . 234
The danger of not using the seat belt . . . . . . 9
The first 1,500 km – and afterwards . . . . . . . 135
The importance of correct seat adjustment . . 87
Topping up coolant . . . . . . . . . . . . . . . . . . . . . 162

239 General index
Topping up engine oil . . . . . . . . . . . . . . . . . . . 160
Tow loads . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
Tow start/towing . . . . . . . . . . . . . . . . . . . . . . .202
Traction Control System (TCS)* . 51, 77, 131, 134
Trailer indicators* . . . . . . . . . . . . . . . . . . . . . 53
Trailer towing . . . . . . . . . . . . . . . . . . . . . . . . . . 140
Trolley jack . . . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Turn signal bulb . . . . . . . . . . . . . . . . . . . . . . . 193
Tyre life . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 176
Tyre pressure . . . . . . . . . . . . . . . . . . . . . . . . . . 208
U
U
Undercoating . . . . . . . . . . . . . . . . . . . . . . . . .154
Up to 1,000 kilometres . . . . . . . . . . . . . . . . . . 135
Upholstery cloth and textile trim . . . . . . . . . . 152
Using air conditioner economically . . . . . . . . 108
Using the handbrake . . . . . . . . . . . . . . . . . . . 118
V V
Valid for all versions with catalytic
converter* . . . . . . . . . . . . . . . . . . . . . . . . . . . . 122
Vehicle hoist . . . . . . . . . . . . . . . . . . . . . . . . . . 204
Vehicle identification data . . . . . . . . . . . . . . . 210
Vehicle tools . . . . . . . . . . . . . . . . . . . . . . . . . . 173
Vents . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 112
Visibility . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 77
Volumetric sensor* . . . . . . . . . . . . . . . . . . . . . 64
W W
Warning lamps . . . . . . . . . . . . . . . . . . . . . . . . 47
Warnings on handling the battery . . . . . . . . . 165
Washing . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 149
Washing the vehicle by hand . . . . . . . . . . . . . 150
Washing vehicle with high pressure cleaner . 150Ways to secure a child seat . . . . . . . . . . . . . . 26
Weights . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 208
What can have a negative effect on the
brakes? . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 130
What do you need to bear in mind when
towing a trailer? . . . . . . . . . . . . . . . . . . . . . . . 140
Wheel bolts . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Wheel trims . . . . . . . . . . . . . . . . . . . . . . . . . . . 181
Wheels . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 175
When are the Air Bags activated? . . . . . . . . . 19
Windows . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 151
Windscreen washer . . . . . . . . . . . . . . . . . 80, 169
Winter tyres . . . . . . . . . . . . . . . . . . . . . . . . . . . 179
Wiper blades . . . . . . . . . . . . . . . . . . . . . . . . . .81
Y
Y
Your vehicle and the environment . . . . . . . . . 135