brake Seat Leon 5D 2014 Repair Manual

Advice
Full-LED headlight system*
Full-LED headlights handle all light functions
(daylight, side light, turn signal, dipped
beam and route light) with light emitting di-
odes (LEDs) as a light source.
Full-LED headlights are designed to last the
lifetime of the car and light bulbs cannot be
replaced. In case of headlight failure, go to
an authorised workshop to have it replaced.
Bulbs (12 V)Halogen headlightsType
Daytime driving light/side lightP21W SLL
Dipped beam headlightsH7 LL
Main beam headlightsH7 LL
Turn signalPY21W LL
Full-LED main headlightsType
No bulbs may be replaced. All
functions are with LEDs
Front fog lightType
Fog/cornering lights*H8
Rear bulb lightType
Brake light/tail lightP21W LL
Side lights2x W5W LL
Rear bulb lightType
Turn signalPY21W LL
Retro fog lightH21W
Reverse lightsP21W LL
LED rear lightType
Turn signalPY21W LL
Retro fog lightH21W
Reverse lightsP21W LL
The remaining functions work
with LEDs WARNING
● Take particular care when working on com-
ponents in the engine compartment if the en-
gine is warm. Risk of burns.
● Bulbs are highly sensitive to pressure. The
glass can break when you touch the bulb,
causing injury.
● When changing bulbs, please take care not
to injure yourself on sharp edges, in particu-
lar on the headlight housing. CAUTION
● Remove the ignition key before working on
the electric system. Otherwise, a short circuit
could occur. ●
Switch off the lights and the parking light
before changing a bulb.
● Take good care to avoid damaging any com-
ponents. For the sake of the environment
Please ask your specialist retailer how to dis-
pose of used bulbs in the proper manner. Note
● Please check at regular intervals that all
lighting (especially the exterior lighting) on
your vehicle is functioning properly. This is
not only in the interest of your own safety,
but also that of all other road users.
● Before changing a bulb, make sure you
have the correct new bulb.
● Do not touch the glass part of the bulb with
your bare hands, use a cloth or paper towel
instead, since the fingerprints left on the
glass will vaporise as a result of the heat gen-
erated by the bulb, they will be deposited on
the reflector and will impair its surface. 234

Fuses and bulbs
Fog light, FR version Fig. 214
Fog light: access to the connector
and to the light bulb holder. Fig. 215
Fog light: access to the connector
and to the light bulb holder. –
Remove the 3 bolts 1
››› Fig. 214 from the
in s
ide of the wheel housing and the 2 bot-
tom bolts 2
››› Fig. 214 from the bumper
with the help of a screwdriver. –
Pull the wheel housing 3
››› Fig. 215 ac-
c e

ss the 2 hidden screws 4
››› Fig. 215 of
the b umper
.
– Remove the screws using a screwdriver.
– Pull the bumper to release it from its an-
chorages to access the connector and the
light bulb holder. Note
Due to the difficulty of accessing fog light
bulbs, have them replaced at a Technical
Service or specialised workshop. Remove the bulb holder
Fig. 216
Front fog light. –
Remove connector ››› Fig. 216 1 from the
bulb.
– Turn the bulb holder ››› Fig. 216
2 anti-
clockwise and pull. –
Remove the bulb by pressing on the bulb
holder and turning it anti-clockwise at the
same time.
– Installation involves all of the above steps
in reverse sequence.
– Check that the bulb works properly.
Changing tail light bulbs (on
side panel) Overview of tail lights Rear lights on the side panel
Turn signalPY21W NA LL
Side light and brake lightP21W LL
237
Technical specifications
Advice
Operation
Safety
The essentials

Technical specifications
Engine specifications Petrol engine 1.2 63 kW (85 PS)Power output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
63 (86)/4,300-5,300160/1,400-3,5004/1,197Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEONLEON SCLEON ST
Top speed (km/h)178 (V)178 (V)178 (V)
Acceleration from 0-80 km/h (seconds)7.67.57.8
Acceleration from 0-100 km/h (seconds)11.911.812.1
Weights (in kg)
Gross vehicle weight1,6901,7001,800
Weight in running order (with driver)1,1881,1681,233
Gross front axle weight880880890
Gross rear axle weight860870960
Permitted roof load757575
Maximum trailer weights (in kg)
Trailer without brakes590580610
Trailer with brakes, gradients up to 8%1,3001,3001,300
Trailer with brakes, gradients up to 12%1,1001,1001,100 245
Technical specifications
Advice
Operation
Safety
The essentials

Technical specifications
Petrol engine 1.2 77 kW (105 PS)Power output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
77 (105)/4,500-5,500175/1,400-4,0004/1,197Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEON
ManualLEON
Start-StopLEON
AutomaticLEON SC ManualLEON SC
Start-StopLEON SC
AutomaticLEON ST ManualLEON ST
Start-StopLEON ST
Automatic
Top speed (km/h)191 (V)191 (V)191 (VI)191 (V)191 (V)191 (V)191 (V)191 (V)191 (VI)
Acceleration from 0-80 km/h (sec-
onds)6.86.86.86.76.76.76.96.87.0
Acceleration from 0-100 km/h (sec-
onds)10.210.210.210101010.410.310.3
Weights (in kg)
Gross vehicle weight1,7201,7201,7501,7101,7101,7301,8101,8201,850
Weight in running order (with driv-
er)1,1991,2091,2351,1791,1891,2151,2441,2541,280
Gross front axle weight890890920880890920880890920
Gross rear axle weight880880880880870860980980980
Permitted roof load757575757575757575
Maximum trailer weights (in kg)
Trailer without brakes590600610580590600620620640
Trailer with brakes, gradients up to
8%1,5001,5001,5001,5001,5001,5001,5001,5001,500
Trailer with brakes, gradients up to
12%1,3001,3001,3001,3001,3001,3001,3001,3001,300 246

Technical specifications
Petrol engine 1.2 TSI 81 kW (110 PS)Power output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
81 (110)/4,600-5,600175/1,400-4,0004/1,197Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEONLEON SCLEON ST
ManualStart-StopAutomaticManualStart-StopAutomaticManualStart-StopAutomatic
Top speed (km/h)194 (V)194 (V)194 (V)194 (V)194 (V)194 (VI)194 (V)194 (V)194 (VI)
Acceleration from 0-80 km/h (seconds)6.66.66.66.56.56.56.76.76.7
Acceleration from 0-100 km/h (seconds)9.99.99.99.79.79.710.110.110.1
Weights (in kg)
Gross vehicle weight1,7401,7401,7601,7101,7201,7501,7901,8001,820
Weight in running order (with driver)1,2061,2131,2411,1861,1931,2211,2401,2471,275
Gross front axle weight900900930890890920890890920
Gross rear axle weight890890880870880880950960950
Permitted roof load757575757575757575
Maximum trailer weights (in kg)
Trailer without brakes600600620590590610620620630
Trailer with brakes, gradients up to 8%1,5001,5001,5001,5001,5001,5001,5001,5001,500
Trailer with brakes, gradients up to 12%1,3001,3001,3001,3001,3001,3001,3001,3001,300 247
Technical specifications
Advice
Operation
Safety
The essentials

Technical specifications
Petrol engine 1.4 90 kW (122 PS) Start-StopPower output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
90 (122)/5,000-6,000200/1,400-4,0004/1,395Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEON
Start-StopLEON SC
Start-StopLEON ST
Start-Stop
Top speed (km/h)202 (V&VI)202 (V&VI)202 (V&VI)
Acceleration from 0-80 km/h (seconds)6.36.26.5
Acceleration from 0-100 km/h (seconds)9.39.19.6
Weights (in kg)
Gross vehicle weight1,7401,7101,840
Weight in running order (with driver)1,2241,2041,269
Gross front axle weight910910910
Gross rear axle weight880850980
Permitted roof load757575
Maximum trailer weights (in kg)
Trailer without brakes610600630
Trailer with brakes, gradients up to 8%1,7001,7001,700
Trailer with brakes, gradients up to 12%1,4001,4001,400 248

Technical specifications
Petrol engine 1.4 92 kW (125 PS) Start-StopPower output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
92 (125)/5,000-6,000200/1,400-4,0004/1,395Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEONLEON SCLEON ST
Top speed (km/h)203 (V&VI)203 (V&VI)203 (V&VI)
Acceleration from 0-80 km/h (seconds)6.26.16.4
Acceleration from 0-100 km/h (seconds)9.18.99.4
Weights (in kg)
Gross vehicle weight1,7701,7501,840
Weight in running order (with driver)1,2331,2131,267
Gross front axle weight920910910
Gross rear axle weight900890970
Permitted roof load757575
Maximum trailer weights (in kg)
Trailer without brakes610600630
Trailer with brakes, gradients up to 8%1,7001,7001,700
Trailer with brakes, gradients up to 12%1,4001,4001,400 249
Technical specifications
Advice
Operation
Safety
The essentials

Technical specifications
Petrol engine 1.4 103 kW (140 PS) Start-StopPower output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
103 (140)/4,500-6,000250/1,500-3,5004/1,395Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEON
Start-StopLEON
AutomaticLEON SC
Start-StopLEON SC
AutomaticLEON ST
Start-StopLEON ST
Automatic
Top speed (km/h)211 (VI)211 (VI)211 (VI)211 (VI)211 (VI)211 (VI)
Acceleration from 0-80 km/h (seconds)5.75.75.65.65.95.9
Acceleration from 0-100 km/h (seconds)8.28.28.18.18.48.4
Weights (in kg)
Gross vehicle weight1,7301,7301,7401,7401,8401,860
Weight in running order (with driver)1,2311,2461,2111,2261,2751,291
Gross front axle weight920930910930910930
Gross rear axle weight860850880860980980
Permitted roof load757575757575
Maximum trailer weights (in kg)
Trailer without brakes610620600610630640
Trailer with brakes, gradients up to 8%1,7001,7001,8001,7001,8001,700
Trailer with brakes, gradients up to 12%1,5001,5001,5001,5001,5001,500 250

Technical specifications
Petrol engine 1.4 TSI 110 kW (150 hp) ACT ®Power output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm
3
)Fuel
110 (150)/5,000-6,000250/1,500-3,5004/1,395Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEONLEON SCLEON ST
manualautomaticmanualautomaticmanualautomatic
Top speed (km/h)215 (V&VI)215 (V&VI)215 (V&VI)215 (V&VI)215 (V&VI)215 (V&VI)
Acceleration from 0-80 km/h (seconds)5.65.65.55.55.55.5
Acceleration from 0-100 km/h (seconds)887.97.97.97.9
Weights (in kg)
Gross vehicle weight1,7601,7801,7401,7601,8301,840
Weight in running order (with driver)1,2411,2631,2231,2431,2771,297
Gross front axle weight920940920940920940
Gross rear axle weight890890870870960950
Permitted roof load757575757575
Maximum trailer weights (in kg)
Trailer without brakes620630610620630640
Trailer with brakes, gradients up to 8%1,7001,7001,7001,7001,8001,700
Trailer with brakes, gradients up to 12%1,5001,5001,5001,5001,5001,500 251
Technical specifications
Advice
Operation
Safety
The essentials

Technical specifications
Petrol engine 1.8 132 kW (180 PS) Start-StopPower output in kW (PS) at rpmMaximum torque (Nm at rpm)No. of cylinders/displacement (cm 3
)Fuel
132 (180)/5,100-6,200250/1,250-5,0004/1,798Super 95 RON/Normal 91 RON a)
a)
Slight power loss.
PerformanceLEON
ManualLEON
AutomaticLEON
Without
Start-StopLEON SC ManualLEON SC
AutomaticLEON SC Without
Start-StopLEON ST ManualLEON ST
AutomaticLEON ST Without
Start-Stop
Top speed (km/h)226 (VI)224 (VI)224 (VI)226 (VI)224 (VI)224 (VI)226 (VI)224 (VI)224 (VI)
Acceleration from 0-80 km/h (seconds)5.55.35.35.45.25.25.75.65.6
Acceleration from 0-100 km/h (seconds)7.57.27.27.47.17.17.87.77.7
Weights (in kg)
Gross vehicle weight1,8301,8501,8501,8301,8501,8501,8701,8901,880
Weight in running order (with driver)1,3101,3271,3221,2901,3071,3021,3551,3721,367
Gross front axle weight970980980960980980960970980
Gross rear axle weight910920920920920920960970950
Permitted roof load757575757575757575
Maximum trailer weights (in kg)
Trailer without brakes650660660640650650670680680
Trailer with brakes, gradients up to 8%1,7001,7001,7001,8001,8001,8001,8001,8001,800
Trailer with brakes, gradients up to 12%1,5001,5001,5001,5001,5001,5001,5001,5001,500 252