maintenance SUBARU OUTBACK 2016 6.G Manual PDF

&Cargo area light (Outback)
1. Remove the lens by prying the edge of
the lens with a flat-head screwdriver.
2. Pull the bulb out of the socket.
3. Install a new bulb.4. Reinstall the lens.
&Trunk light (Legacy)
CAUTION
Replacing the bulb could cause
burns since the bulb may be very
hot. Have the bulb replaced by your
SUBARU dealer.
&Other bulbs
It may be difficult to replace the bulbs.
We recommend that you have the bulbs
replaced by your SUBARU dealer if
necessary.
Replacing battery
The access key / transmitter battery may
be discharged under the following condi-
tions.
.The operation of the keyless access
function is unstable
.The operating distance of the remote
keyless entry system is unstable
.The transmitter does not operate prop-
erly when used within the standard dis-
tance
Replace the battery with a new one.
CAUTION
.Do not let dust, oil or water get on
or in the access key/transmitter
when replacing battery.
.Be careful not to damage the
printed circuit board in the ac-
cess key/transmitter when repla-
cing the battery.
.Be careful not to allow children to
touch the battery and any re-
moved parts; children could
swallow them.
.There is a danger of an explosion
if the battery is incorrectly re-
placed. Replace only with the
Maintenance and service/Replacing battery
–CONTINUED–11-49

Maintenance and service/Replacing battery
same or equivalent type of the
battery.
.Batteries shall not be exposed to
excessive heat such as bright
sunlight, fire or the like.
NOTE
.Replace only with the same or
equivalent type of battery recom-
mended by the manufacturer.
.Dispose of used batteries according
to the local laws.
.Mount the battery in the correct
orientation to prevent fluid leakage.
Be careful not to bend the terminals. It
may result in a malfunction.
.It is recommended that the battery
should be replaced by a SUBARU
dealer.
.Use a new battery.
.After replacing the battery, confirm
that the access key/transmitter func-
tions properly.
&Replacing battery of access
key
CAUTION
When removing or fitting the access
key cover, make sure that the plastic
part does not come off or become
misaligned.
Battery: Button battery CR2032
1) Release button
2) Mechanical key
1. Take out the mechanical key.
2. Wrap a flat-head screwdriver with vinyl
tape or a cloth, and insert it in the gap to
remove the cover.
3. Take out the battery using a flat-head
screwdriver with vinyl tape or a cloth.
11-50

4. Insert a new battery with its positive (+)
side facing upward as shown in the figure.
5. Attach the cover to the access key by
fitting the projections and recesses to-
gether.
&Replacing battery of trans-
mitter
1. Open the key head using a flat-head
screwdriver.
2. Remove the transmitter case from thekey head.
3. Open the transmitter case by releasing
the hooks.
1) Negative (−) side facing up
4. Replace the old battery with a new
Maintenance and service/Replacing battery
–CONTINUED–11-51

Maintenance and service/Replacing battery
battery (TypeCR1620or equivalent)
making sure to install the new battery with
the negative (−) side facing up.
5. Put together the transmitter case by
fitting the hooks on the case.
6. Reinstall the transmitter case in the
key head.
7. Refit the removed half of the key head.
After the battery is replaced, the trans-
mitter must be synchronized with the
remote keyless entry system’s control
unit. Press either the“
”or“”button
six times to synchronize the unit.
11-52

&Manual transmission, front differential and rear differential gear oil
Oil Manual transmission oil Front differential gear oil (CVT models) Rear differential gear oil
Oil grade.SUBARU Extra MT*3
.API classification GL-5 (75W-90)*4API classification GL-5
SAE viscosity
No. and applic-
able tempera-
ture—.75W-90*
.90
*: Recommended
Oil capacity*
13.5 US qt
(3.3 liters, 2.9 Imp qt)2.5 L models: 1.3 US qt (1.2 liters, 1.1 Imp qt)
3.6 L models: 1.5 US qt (1.4 liters, 1.2 Imp qt)0.8 US qt (0.8 liters, 0.7 Imp qt)
Remarks*
2“Manual transmission
oil”F11-18“Front differential gear oil (CVT models) and
rear differential gear oil”F11-19“Front differential gear oil (CVT models) and rear differ-
ential gear oil”F11-19
*1: The indicated oil quantity is only a guideline. The necessary quantity for replacement may differ slightly depending on the temperature and other
factors. After refilling the gearbox with oil, the oil level should be checked.
*2: For more details about maintenance and service, refer to the indicated section.
*3: The vehicle is filled at the factory with this type of manual transmission oil/front differential gear oil.
*4: You may use this type of manual transmission oil/front differential gear oil. However, using this type of oil will detract from driveability and fuel
efficiency.Specifications/Specifications
–CONTINUED–
12-7

Specifications/Specifications
&Fluids
Fluid
Fluid type*1Fluid capacity*2Remarks*3
Continuously variable transmission
fluid (CVT models)Consult your SUBARU dealer.2.5 L models: 12.0 US qt (11.4 liters,
10.0 Imp qt)
3.6 L models: 13.4 US qt (12.7
liters, 11.2 Imp qt)“Continuously variable trans-
mission fluid”F11-19
Brake fluid
FMVSS No. 116, fresh DOT 3 or DOT 4
brake fluid–“Brake fluid”F11-19
Clutch fluid (MT models)
FMVSS No. 116, fresh DOT 3 or DOT 4
brake fluid–“Clutch fluid (MT models)”F11 -
21
*1: Use one of the indicated types of fluid.
*2: The indicated fluid quantity is only a guideline. The necessary quantity for replacement may differ slightly depending on the temperature and other
factors.
*3: For more details about maintenance and service, refer to the indicated section.
&Engine coolant
Vehicle model Coolant capacity Coolant type
2.5 L models
MT models 8.0 US qt (7.6 liters, 6.7 Imp qt)
SUBARU Super Coolant CVT models 8.2 US qt (7.8 liters, 6.9 Imp qt)
3.6 L models7.4 US qt (7.0 liters, 6.2 Imp qt)
The indicated coolant quantity is only a guideline. The necessary quantity for replacement may differ slightly depending on the temperature and other
factors. For more details about maintenance and service, refer to“Cooling system”F11-14.
12-8

For U.S.A............................................................ 13-2
Tire information.................................................. 13-2
Tire labeling....................................................... 13-2
Recommended tire inflation pressure.................. 13-4
Glossary of tire terminology............................... 13-5
Tire care–maintenance and safety practices...... 13-9
Vehicle load limit–how to determine................ 13-10
Determining compatibility of tire and vehicle
load capacities............................................... 13-13Adverse safety consequences of overloading
on handling and stopping and on tires........... 13-13
Steps for Determining Correct Load Limit......... 13-13Uniform tire quality grading standards.......... 13-14Treadwear....................................................... 13-14
Traction AA, A, B, C......................................... 13-14
Temperature A, B, C......................................... 13-15
Reporting safety defects (USA)...................... 13-15
Consumer information and Reporting safety defects
13

Table 1—Occupant loading and distribution for vehicle normal load for
various designated seating capacities
Designated seating
capacity, number of
occupantsVehicle normal load,
number of occupantsOccupant distribution in a
normally loaded vehicle
2 through 4 2 2 in front.
5 through 10 32 in front, 1 in second
seat.
11 through 15 52 in front, 1 in second
seat, 1 in third seat, 1 in
fourth seat.
16 through 22 72 in front, 2 in second
seat, 2 in third seat, 1 in
fourth seat.&Tire care–maintenance and
safety practices
.Check on a daily basis that the
tires are free from serious damage,
nails, and stones. At the same time,
check the tires for abnormal wear.
.Inspect the tire tread regularly
and replace the tires before their
tread wear indicators become visi-
ble. When a tire’s tread wear
indicator becomes visible, the tire
is worn beyond the acceptable limit
and must be replaced immediately.
With a tire in this condition, driving
at even low speeds in wet weather
can cause the vehicle to hydro-
plane. Possible resulting loss of
vehicle control can lead to an
accident.
Consumer information and Reporting safety defects/Tire information
–CONTINUED–13-9

J
Jack-up point............................................................... 9-5
Jump starting............................................................. 9-11
K
Key ............................................................................ 2-3
Number.................................................................. 2-3
Reminder chime....................................................... 3-4
Replacement........................................................... 2-5
Keyless access with push-button start system ............... 2-10
Disabling keyless access functions........................... 2-18
Locking and unlocking doors................................... 2-13
Opening rear gate.................................................. 2-16
Opening trunk........................................................ 2-16
Warning chimes and warning indicator...................... 3-24
When access key does not operate properly............. 9-18
Keyless entry system................................................. 2-23
L
LCA ......................................................................... 7-54
Leather seat materials................................................ 10-5
License plate light..................................................... 11-47
Light
Backup................................................................ 11-45
Cargo area.................................................... 6-3, 11-49
Control switch........................................................ 3-43
Daytime running..................................................... 3-46
Dome........................................................... 6-2, 11-48
Door step............................................................. 11-48
Front fog...................................................... 3-49, 11-42
Front side marker................................................... 3-44Ignition switch......................................................... 3-4
License plate....................................................... 11-47
Map .............................................................. 6-2, 11-48
Rear combination................................................. 11-43
Rear side marker light........................................... 11-43
Rear turn signal.................................................... 11-43
Trunk.................................................................. 11-49
Turn signal........................................ 3-47, 11-42, 11-43
Vanity mirror........................................................... 6-5
Loading your vehicle................................................... 8-12
Low fuel warning light................................................. 3-21
Low tire pressure warning light..................................... 3-16
Lower and tether anchorage........................................ 1-35
M
Maintenance
Precautions........................................................... 11-3
Schedule............................................................... 11-3
Seatbelt................................................................. 1-24
Tips ...................................................................... 11-5
Tools...................................................................... 9-3
Malfunction indicator light (check engine warning light) .... 3-15
Manual
Climate control system............................................. 4-6
Mode (continuously variable transmission)................. 7-29
Seat....................................................................... 1-4
Transmission......................................................... 7-23
Transmission oil........................................... 11-18, 12-7
Map light........................................................... 6-2, 11-48
Maximum load limits
................................................... 8-21
Meters and gauges...................................................... 3-7
Index14-7

Wiper and washer switch........................................ 3-53
Wiper blades........................................................ 11-35
Recommended
Brake fluid............................................................. 12-8
Clutch fluid............................................................ 12-8
Continuously variable transmission fluid.................... 12-8
Engine oil.............................................................. 12-4
Front differential gear oil......................................... 12-7
Manual transmission oil.......................................... 12-7
Rear differential gear oil.......................................... 12-7
Spark plugs........................................................... 12-9
Refueling.................................................................... 7-4
Remote engine start system........................................ 7-15
Remote keyless entry system...................................... 2-23
Replacement
Brake pad and lining............................................. 11-24
Wiper blades........................................................ 11-33
Replacing
Access key battery................................................ 11-50
Air cleaner element............................................... 11-15
Lost transmitters (remote keyless entry system)......... 2-27
Remote engine start transmitter battery..................... 7-21
Remote keyless entry transmitter battery.................. 11-51
Replacing bulbs.............................................. 11-40, 12-14
Backup light......................................................... 11-45
Cargo area light.................................................... 11-49
Dome light........................................................... 11-48
Door step light...................................................... 11-48
Front fog light....................................................... 11-42
Front side marker light........................................... 11-42
Front turn signal light............................................. 11-42Halogen headlight................................................. 11-40
HID headlight....................................................... 11-40
License plate light................................................. 11-47
Map light............................................................. 11-48
Rear combination light.......................................... 11-43
Rear side marker light........................................... 11-43
Rear turn signal light............................................. 11-43
Trunk light........................................................... 11-49
Rocking the vehicle.................................................... 8-12
Roof rails with integrated cross bars............................. 8-14
Rope hook................................................................. 8-18
S
Safety
Precautions when driving............................................. 4
Symbol...................................................................... 2
Warnings................................................................... 2
Seat
Fabric................................................................... 10-5
Front...................................................................... 1-2
Heater.................................................................... 1-9
Height adjustment.................................................... 1-4
Memory function...................................................... 1-6
Power
.................................................................... 1-5
Rear..................................................................... 1-11
Seatbelt................................................................. 4, 1-16
Fastening.............................................................. 1-17
Maintenance.......................................................... 1-24
Pretensioners......................................................... 1-24
Safety tips............................................................. 1-16
Warning light and chime.......................................... 3-12
Index14-9