battery TATA SAFARI 2015 User Guide
[x] Cancel search | Manufacturer: TATA, Model Year: 2015, Model line: SAFARI, Model: TATA SAFARI 2015Pages: 161, PDF Size: 2.55 MB
Page 129 of 161
129
VEHICLE C VEHICLE CVEHICLE C VEHICLE C
VEHICLE C
ARE AREARE ARE
ARE
W WW W
W
A AA A
A
XING : XING :XING : XING :
XING :
Waxing and polishing is recommended to maintain the gloss
and wet-look appearance of your paint finish.
1. Use a good quality polish and wax for your vehicle.
2. Re-wax your vehicle when the water does not slip off the
surface and collects over the surface in patches.
Further tips for the care of your new vehicle finish : Further tips for the care of your new vehicle finish :Further tips for the care of your new vehicle finish : Further tips for the care of your new vehicle finish :
Further tips for the care of your new vehicle finish :
If your vehicle is washed in an automatic car wash, please
remember that the paint can be scratched by type of brushes,
unfiltered washing water or the washing process itself.
Scratching reduces paint durability and gloss, especially on
darker colours. It is suggested to wash the vehicle by hand with
cool and clean water using a soft cloth or sponge. Please do not
use soap but a car shampoo recommended by your dealer.
Please take the following precautions : Please take the following precautions :Please take the following precautions : Please take the following precautions :
Please take the following precautions :
1. Always wash your vehicle in shade, avoiding direct exposure
to sunlight during washing.
2. Dry wiping your vehicle may lead to the formation of
scratches and hence always use a soft cloth and clean water
while wiping your vehicle.
3. Always keep your vehicle parked in a well ventilated shade.
Exposure to heat with entrapped moisture promotes corrosion.4. Avoid driving on gravel roads, as the possibility of paint
chip off due to the impact of stones is high. If you are
driving on freshly tarred road, check immediately
afterwards for any stains & clean them.
5. External contamination in the form of sap or industrial
fall-out may mar or develop spots on a new finish. Hence
avoid parking your vehicle near trees, which are known
to drop sap, or near factories, which give out heavy smoke.
6. The acid content in bird droppings may damage the newly
painted finish and hence any bird dropping must be
immediately washed off.
7. The paint finish is susceptible to damage in case petrol,
brake fluid, liquid from car battery, oil, antifreeze,
transmission fluid or windshield solvent spills onto the
painted surface. In case of such a spillage immediately
rinse the affected area with water. Avoid wiping the area
far as possible, however if wiping is required, ensure that
you wipe the area gently with soft cotton cloth.
8. Avoid using sharp objects to scrap off tar or mud from a
painted surface as it may develop scratches or may peel
off the paint.
M A I N T E N A N C E
ProCarManuals.com
Page 136 of 161
136
( These tips are given for your guidance and preliminary jobs to be done in an emergency situation. In normal case, the problems
should be attended in an Authorised Workshop by following the repair procedures given in Workshop Manual)
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
CAUSE CAUSECAUSE CAUSE
CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
ENGINE ENGINEENGINE ENGINE
ENGINE
1 . Engine not cranking Dead battery loose or dirty
•Get battery checked&/or changed
battery connections
•Clean and tighten battery
connections
2 . Engine cranks but does not start Air in the fuel system
•Press pear pump for air removal
•Check leakages
Service lamp should glow
•Get defect rectified
EMS fuse blown
•Replace the fuse
3. Engine overheatsCoolant level low
•Top up coolant, check and
correct leakages
Hose collapse / torn
•Get the hose replaced
Low engine oil level
•Add oil
Radiator cap not sealing properly
•Fit the radiator cap correctly
A.C. condensers fans not working
•Get defect rectified
Brakes binding
•Get defect rectified
Electric fan not working
•Get defect rectified
High delivery pressure in A.C.
•Get defect rectified
refrigerant circuit
4 . Charging indicator continuouslyBattery not getting charged
•Get the belt tension adjusted
remains ‘ON’due to loose belt drive Replace if broken
PRELIMINARY TROUBLE SHOOTING
ProCarManuals.com
Page 140 of 161
140
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
ANTI-LOCK BRAKING SYSTEM ANTI-LOCK BRAKING SYSTEMANTI-LOCK BRAKING SYSTEM ANTI-LOCK BRAKING SYSTEM
ANTI-LOCK BRAKING SYSTEM
1. ABS warning lamp stays ‘ON’ ABS unit faulty
No supply to ABS unit • Check wiring connections &
battery condition.
Electrical circuit problem : • Check wiring harness
Intermittent contact, Wiring connections
connections / connections loose/
faulty
Component and sensor failure : • Check gap between sensor &
RPM sensors/toner rings fitting toner ring
loose, gap disturbances, Sensor
signal that deviates from the specified
levels
Circuit / bulb failure • Replace bulb
Leakage from hydraulic unit ports • Eliminate leakage by tightening
Hydraulic unit fluid level low • Check reservoir fluid level and
bleed properly.
Unusual response and malfunction • Check sensor condition &
in the actuators replace if necessary.
PRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TING
PRELIMINARY TROUBLE SHOOTING
ProCarManuals.com
Page 141 of 161
141
PRELIMINAR PRELIMINARPRELIMINAR PRELIMINAR
PRELIMINAR
Y Y Y Y
Y
TR TRTR TR
TR
OUBLE SHOO OUBLE SHOOOUBLE SHOO OUBLE SHOO
OUBLE SHOO
TING TINGTING TING
TING
SR. NO. SR. NO.SR. NO. SR. NO.
SR. NO.
PROBLEM OBSERVED PROBLEM OBSERVEDPROBLEM OBSERVED PROBLEM OBSERVED
PROBLEM OBSERVED
PROBABLE CAUSE PROBABLE CAUSEPROBABLE CAUSE PROBABLE CAUSE
PROBABLE CAUSE
A AA A
A
CTION CTION CTION CTION
CTION
T TT T
T
O BE O BE O BE O BE
O BE
T TT T
T
AKEN AKENAKEN AKEN
AKEN
STEERING SYSTEM STEERING SYSTEMSTEERING SYSTEM STEERING SYSTEM
STEERING SYSTEM
1. Hard steeringLess fluid in the power steering • Get the fluid topped up to
tankcorrect level
Air in the system • Get the air removed by bleeding
the system
Loose pump belt • Get the belt correctly adjusted
ELECTRICAL ELECTRICALELECTRICAL ELECTRICAL
ELECTRICAL
1. No lights on the dash board after Battery terminal got disconnected• Get the battery properly
turning on the ignition key Battery completely dead connected
• Get the battery charged
• Get the alternator & charging
circuit checked
• Check for parking lamp fuse
2. Non functioning electricalBlown fuse in the circuit • Replace the fuse if blown
accessories such as powerLoose connectors • Get the connection properly
windows, head lamps, fueltightened
tank flap, wiper and washer etc. Circuit relay loose • Tighten the relay correctly
in the mounting
Defective components • Get the defective component
replaced from Authorised
Workshop
PRELIMINARY TROUBLE SHOOTING
ProCarManuals.com
Page 146 of 161
146
S E R V I C E S C H E D U L ESERVICE SCHEDULE SERVICE SCHEDULESERVICE SCHEDULE SERVICE SCHEDULE
SERVICE SCHEDULE
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
GENERAL GENERALGENERAL GENERAL
GENERAL
1 Wash the vehicle & Clean the condenser with compressed air Every Service x x x x x x x x
2 Check & Top up Fluids if required: Coolant, Brake / Clutch Fluid, Battery Electrolyte, Power Every Service x x x x x x x x
Steering Oil, Gear Box Oil, Transfer Case & Front Axle (4X4) / Rear Axle Oil
3 Drain water accumulated in Sedimenter (OR Whenever warning lamp glows) Every Service x x x x x x x x
4 Check Engine Compartment for loose Fasteners, Low pressure fuel lines, Coolant hoses, air hoses, Every Service x x x x x x x x
Vacuum hoses, hydraulic line connections for leakages if any, Attend if necessary
5 Check Underbody for loose Fasteners, hydraulic line connections, Exhaust system / Fuel Pipes for Every Service x x x x x x x x
Damages / Leakages if any. Attend if necessary
6 Apply grease on door latches, door lock, door check stop, striker, bonnet opening lever & lock Every Service x x x x x x x
plate, tailgate hinges & door lock inner ratchet.
7 Check & ensure normal working of engine using Diagnostic Equipment. Every Service x x x x x x x x
2.2L DICOR ENGINE 2.2L DICOR ENGINE2.2L DICOR ENGINE 2.2L DICOR ENGINE
2.2L DICOR ENGINE
1 *Clean air cleaner filter element, Change if red band appears on service indicator even after Every Service x x x x x x x
cleaning
2 *Change engine Oil and Oil filter. Use APICH4+MB228.3 or Higher grade Engine Oil.Every Service x x x x x x x x
OR 1 Year whichever is earlier
3 Check All accessory Drive belts, adjust tension if required, change if damaged Every Service x x x x x x x
OR 1 Year whichever is earlier
4 Change fuel filterEvery Service x x x x x x x
OR 2 Years whichever is earlier
5 *Replace air filter element (OR if RED band appears on Service Indicator) 45,000 km x x
6 Change coolant in the cooling system 60,000 km x
OR 2 Years whichever is earlier
7 Change Sedimenter / Water seperator1,05,000 km x
8 Change Timing Belt & Timing Belt Idler1,05,000 km x
ProCarManuals.com
Page 148 of 161
148
S E R V I C E S C H E D U L ESER SERSER SER
SER
VICE SCHEDULE VICE SCHEDULEVICE SCHEDULE VICE SCHEDULE
VICE SCHEDULE
ADDITIONAL MAINTENANCE SCHEDULE UNDER SEVERE DRIVING CONDITIONS :
A.. Driving in conditions such as Patrolling, Taxi, Pickup Van, Vehicle Towing, with Trailer Towing
B. Driving on Dusty / Sandy roads
C. More than 50% (in terms of kms) driving in heavy city traffic
D. Frequently operating in mountainous area
ITEMINTERVAL CONDITION
AB CD
1. Engine Oil & Oil Filter Change every 7500 kms.
z z z z
z
z z z z
z
z z z z
z
z z z z
z
2. Air Filter Element Clean at every 7500 kms. &
z z z z
z
replace at 30,000 kms.
3. Front (for 4X4) & Rear Axle Change First at 15000 kms
z z z z
z
z z z z
z
z z z z
z
z z z z
z
Oil Change & thereafter at 45,000 kms.
SR SRSR SR
SR
x 1000 km x 1000 kmx 1000 km x 1000 km
x 1000 km
NO NONO NO
NO
OPER OPEROPER OPER
OPER
A AA A
A
TIONS TIONSTIONS TIONS
TIONS
FREQUENCY FREQUENCYFREQUENCY FREQUENCY
FREQUENCY
1-1.5 1-1.51-1.5 1-1.5
1-1.5
15 1515 15
15
30 3030 30
30
45 4545 45
45
60 6060 60
60
75 7575 75
75
90 9090 90
90
105 105105 105
105
ELECTRICALS ELECTRICALSELECTRICALS ELECTRICALS
ELECTRICALS
1 Check headlamp focussing & functioning of other electrical equipment 15,000 km x x x x x x x
2 Check specific gravity of battery electrolyte 30,000 km x x x
HV HVHV HV
HV
A AA A
A
C CC C
C
1 Check the HVAC System for Satisfactory Performance & attend if required Every Service x x x x x x x x
WHEELS & WHEELS & WHEELS & WHEELS &
WHEELS &
T TT T
T
YRES YRESYRES YRES
YRES
1 Tyre rotation15,000 km x x x x x x x
* Under severe driving conditions, additional maintenance is required. Please Refer to “Additional Maintenance Schedule under severe driving conditions”:
P PP P
P
r rr r
r
ec ecec ec
ec
autions t autions tautions t autions t
autions t
o b o bo b o b
o b
e tak e take tak e tak
e tak
en while cleaning engine c en while cleaning engine cen while cleaning engine c en while cleaning engine c
en while cleaning engine c
ompar omparompar ompar
ompar
tmen tmentmen tmen
tmen
t : t :t : t :
t :
I I I I
I
t is r t is rt is r t is r
t is r
ec ecec ec
ec
ommended t ommended tommended t ommended t
ommended t
o use dr o use dro use dr o use dr
o use dr
y lo y loy lo y lo
y lo
w pr w prw pr w pr
w pr
essur essuressur essur
essur
e air e aire air e air
e air
.. ..
.
D D D D
D
o not use pr o not use pro not use pr o not use pr
o not use pr
essur essuressur essur
essur
ised isedised ised
ised
w ww w
w
a aa a
a
t tt t
t
er erer er
er
.. ..
.
ProCarManuals.com
Page 155 of 161
155
A L P H A B E T I C A L I N D E X ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX ALPHABETIC INDEX
ALPHABETIC INDEX
A AA A
A
Air Bags 2 2
Aggregate Numbers-Location 1 2
Air Conditioning52, 134
Air Filter & Filter Element 105
Analog Clock 66
Anti Lock Brake System 7 9
Ashtray 6 1
Audio Warning 2 1
Automatic Hub Lock 8 2
B BB B
B
Battery 118
Belt Tension 135
Bonnet Opening / Closing 7 0
Brake Fluid 115
Brakes 7 9
Branded Lubricants 9 5
C CC C
C
Catalytic Converter 132
Central Locking System 13
Child Lock 20
Cigarette Lighter 60
Clutch Fluid 115
Collapsible Steering column 2 1
Combi-Switch 33
Coolants 9 4
D DD D
D
Door Locks 20
Driving Controls 28
Driving in adverse conditions 85
Driving Safety 89
E
ECU 1 1 7
EGR System 132
Engine Compartment 104
Engine Coolant 73
Engine Cooling System 106
Engine oil 72
Engine Oil & Oil Filter 108
Environment Protection 8
F FF F
F
Flat tyre replacement 120
Follow Me Home Headlamp 64
Front & Rear Fog Lights 38
Front / Rear Axle Oil 112
Front Seat 56
Front Windshield / Door Glass Demister 5 4
Fuel 92
Fuel Economy 84
Fuel Gauge 50
Fuel level 72
Fuel Tank Flap Switch 38
Fuel Tank Flap 61
Fuses 130
G GG G
G
Gauges 4 7
Gear Box 78
Gear Box Oil 1 1 0
Gear Shift Lever 32
Glove Box 62
H HH H
H
Hazard Warning 39
Head Lamps & Headlamp Adjustment 113
Headlamp Leveling Switch 40
Headrest 57
Headrest adjustment 1 8
High mounted stop lamp 67
I II I
I
Ignition Switch 29
Immobiliser- Anti Theft Security System 31
Important Information 6,7
Indicators 43
Instrument Cluster 42
J JJ J
J
Jack & Tools 59
Jump Seats 59
ProCarManuals.com
Page 161 of 161
161
VEHICLE IDENTIFIC VEHICLE IDENTIFICVEHICLE IDENTIFIC VEHICLE IDENTIFIC
VEHICLE IDENTIFIC
A AA A
A
TION & TION & TION & TION &
TION &
VEHICLE REC VEHICLE RECVEHICLE REC VEHICLE REC
VEHICLE REC
ORD ORDORD ORD
ORD
Owner’s Name :
Address :
Selling Dealer Code :
Date of Delivery :
Date of Registration :
Registration No.:
Chassis No.:
Engine No.:
Gear Box No.:
Transfercase No.:
Rear Axle No.:
Front Axle No.:
THE THE THE THE
THE
W WW W
W
ARR ARRARR ARR
ARR
ANT ANTANT ANT
ANT
Y ON Y ON Y ON Y ON
Y ON
THIS THIS THIS THIS
THIS
VEHICLE IS VEHICLE IS VEHICLE IS VEHICLE IS
VEHICLE IS
V VV V
V
ALID ONL ALID ONLALID ONL ALID ONL
ALID ONL
Y Y Y Y
Y
WHEN ABOVE WHEN ABOVEWHEN ABOVE WHEN ABOVE
WHEN ABOVE
INFORMA INFORMAINFORMA INFORMA
INFORMA
TION IS FILLED TION IS FILLEDTION IS FILLED TION IS FILLED
TION IS FILLED
,, ,,
,
SIGNED AND ST SIGNED AND ST SIGNED AND ST SIGNED AND ST
SIGNED AND ST
AMPED BY AMPED BY AMPED BY AMPED BY
AMPED BY
THE SELLING DEALER THE SELLING DEALERTHE SELLING DEALER THE SELLING DEALER
THE SELLING DEALER
DEALER DEALERDEALER DEALER
DEALER
’S SIGNA ’S SIGNA’S SIGNA ’S SIGNA
’S SIGNA
TURE AND ST TURE AND STTURE AND ST TURE AND ST
TURE AND ST
AMP AMPAMP AMP
AMP
Following items are provided in your Following items are provided in yourFollowing items are provided in your Following items are provided in your
Following items are provided in your
T TT T
T
a aa a
a
ta S ta Sta S ta S
ta S
afar afarafar afar
afar
i : i :i : i :
i :
1. 1.1. 1.
1. Owner’s Manual & Service Book
2. 2.2. 2.
2. Battery Warranty Card
3. 3.3. 3.
3. First Aid Kit
4. 4.4. 4.
4. Advance Warning Triangle
5. 5.5. 5.
5. Jack and Handle
6. 6.6. 6.
6. Spare Headlamp bulbs - 2 Nos
7. 7.7. 7.
7. Spare Fuses - (Provided in fuse box)
8. 8.8. 8.
8. Tool Kit
a. Wheel Spanner
b. Screw Driver
c. Ring spanner (8-9)
d. Socket Handle
(Part No. 2654 5890 35 24)
9. 9.9. 9.
9. Manufacturer’s manual for
a. Music System (if fitted)
b. Immobiliser (if fitted)
ProCarManuals.com