fuel TOYOTA AVENSIS 2003 Service User Guide
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 2003, Model line: AVENSIS, Model: TOYOTA AVENSIS 2003Pages: 2234, PDF Size: 56.95 MB
Page 47 of 2234
APPENDIX
Vehicle GradeBody Type
Min. Running Ground Clearance mm (in.)
Angle of Approach degrees
Angle of Departure degrees
Item Area
Model Code
Overall Length mm (in.)
Width mm (in.)
Height mm (in.)
Wheel Base mm (in.)
Tread Front mm (in.)
Rear mm (in.)
Room Front mm (in.)
Rear mm (in.)
Overhang
Curb Weight
Gross Vehicle Weight Front kg (lb)
Rear kg (lb)
Total kg (lb)
Front kg (lb)
Rear kg (lb)
Total kg (lb)
Fuel Tank Capacity (Imp.gal.)
Luggage Compartment Capacity m
3 (cu.ft.)
Max. Speed km / h (mph)
Max. Cruising Speed km / h (mph)
Acceleration
Max. Permissible
Speed
Min. Turning Radius 0 to 100 km / h sec.
0 to 400 m sec.
1st Gear km / h (mph)
2nd Gear km
/h (mph)
3rd Gear km / h (mph)
4th Gear km / h (mph)
Tire m (ft.)
Body m (ft.)
Engine Type
Valve Mechanism
Bore x Stroke mm (in.)
Displacement cm
3 (cu.in.)
Compression Ratio
Carburetor Type or Injection Pump Type (Diesel)Research Octane No. or Cetane No. (Diesel)
Max. Output (EEC) kW / rpm
Max. Torque (EEC) N
.m / rpm
Battery Capacity (5HR) Voltage & Amp. hr.
Alternator Output Watts
Starter Output kW
Clutch Type
Transaxle Type
Transmission Gear
Ratio
Counter Gear Ratio
Differential Gear Ratio (Final)
Brake Type
Parking Brake Type
Brake Booster Type and Size in.
Proportioning Valve Type
Suspension Type
Stabilizer Bar
Steering Gear Type
Steering Gear Ratio (Overall)
Power Steering Type In First
In Second
In Third
In Fourth
In Fifth
In Reverse
Front
Rear
Front
Rear
Front
Rear
5
10
15
20
25
30
35
40
45
50
55
60
65
70
Major Dimension & Vehicle Weights
Performance
Engine
Engine
Chassis Electric
EUROPE
5-Door Wagon
MID ELEGANT
Length mm (in.)
Width mm (in.)
Height mm (in.) MID ELEGANT
MID TECHNICAL
AP-16
ZZT251L-AWMGKW ZZT251L-AWPGKW AZT250L-AWPEKWAZT250L-AWPGKW
4700 (185.0) 4700 (185.0)4700 (185.0)4700 (185.0)
1760 (69.3) 1760 (69.3)1760 (69.3)1760 (69.3)
1525 (60.0) 1525 (60.0)1525 (60.0)1525 (60.0)
2700 (106.3) 2700 (106.3)2700 (106.3)2700 (106.3)
1506 (59.3) 1506 (59.3)1506 (59.3)1506 (59.3)
1510 (59.4) 1510 (59.4)1510 (59.4)1510 (59.4)
2090 (82.3) 2090 (82.3)2090 (82.3)2090 (82.3)
1485 (58.5) 1485 (58.5)1485 (58.5)1485 (58.5)
1210 (47.6), 1160 (45.7)*
11210 (47.6), 1160 (45.7)*11210 (47.6), 1160 (45.7)*11210 (47.6), 1160 (45.7)*1
910 (35.8) 910 (35.8)910 (35.8)910 (35.8)
1095 (43.1) 1095 (43.1)1095 (43.1)1095 (43.1)
135 (5.3), 155 (6.1)*
2135 (5.3), 155 (6.1)*2135 (5.3), 155 (6.1)*2135 (5.3), 155 (6.1)*2
13.1 , 14.5 *213.1, 14.5 *213.1, 14.5 *213.1, 14.5 *2
18, 19.2 *218, 19.2 *218, 19.2 *218, 19.2 *2
715 - 750 (1576 - 1653) 745 - 775 (1642 - 1709) 795 - 830 (1753 - 1830) 795 - 830 (1753 - 1830)
580 - 595 (1279 - 1312) 580 - 600 (1279 - 1323) 570 - 590 (1257 - 1301) 570 - 590 (1257 - 1301)
1295 - 1345 (2855 - 2965) 1325 - 1375 (2921 - 3032) 1365 - 1420 (3009 - 3131) 1365 - 1420 83010 - 3131) 840 (1852) 840 (1852)915 (2017)915 (2017)
980 (2161) 980 (2161)975 (2150)975 (2150)
1820 (4013) 1820 (4013)1890 (4167)1890 (4167)
60 (15.9, 13.2) 60 (15.9, 13.2)60 (15.9, 13.2)60 (15.9, 13.2)
0.520 (18.4) 0.520 (18.4)0.520 (18.4)0.520 (18.4)
195 (121) 180 (112)185 (115)185 (115)
ÐÐÐÐ
10.5 11.811.311.3
17.2 18.017.717.7
51 (31) 59 (36)62 (38)62 (38)
95 (59) 109 (67) 111 (68)111 (68)
139 (86) 169 (105) 174 (108)174 (108)
176 (109) ÐÐÐ
5.4 (17.7) 5.4 (17.7)5.6 (18.4)5.6 (18.4)
5.75 (18.9) 5.75 (18.9)5.995 (19.7) 5.995 (19.7)
1ZZ-FE 1ZZ-FE1AZ-FE 1AZ-FE
16-Valve, DOHC 16-Valve, DOHC16-Valve, DOHC16-Valve, DOHC
79.0 x 91.5 (3.11 x 3.60) 79.0 x 91.5 (3.11 x 3.60) 86.0 x 86.0 (3.39 x 3.39) 86.0 x 86.0 (3.39 x 3.39)
1794 (109.5) 1794 (109.5)1998 (121.9)1998 (121.9)
10.0 10.0 9.89.8
EFI EFIEFIEFI
95 or higher 95 or higher95 or higher95 or higher
95 / 6000 95 / 6000108 / 6000 108 / 6000
170 / 4200 170 / 4200192 / 4000192 / 4000
12 - 32, 48*
312 - 32, 48*312 - 32, 48*312 - 32, 48*3
960, 1080*3960, 1080*31200 1200
1.3 1.31.31.3
Dry, Single Plate ÐÐÐ
C250 U341E U241EU241E
3.545 2.8473.9433.943
1.904 1.5522.1972.197
1.310 1.0001.4131.413
1.031 0.7001.0201.020
0.815 ÐÐÐ
3.250 2.3433.1453.145
ÐÐÐ
3.941 4.2372.9232.923
Ventilated Disc Ventilated DiscVentilated DiscVentilated Disc
Solid Disc Solid DiscSolid DiscSolid Disc
Drum DrumDrumDrum
Tandem 8º + 9º Tandem 8º + 9ºTandem 8º + 9ºTandem 8º + 9º
ÐÐÐÐ
MacPherson Strut. MacPherson Strut.MacPherson Strut.MacPherson Strut.
Double Wishbone Double WishboneDouble WishboneDouble Wishbone
STD STDSTDSTD
STD STDSTDSTD
Rack and Pinion Rack and PinionRack and PinionRack and Pinion
17.5 17.516.116.1
EPS EPSIntegral Type Integral Type
*
1: With Sun Roof *4: Snow Mord Type
*2: Rough Road Pack
*3: Option
http://vnx.su
Page 49 of 2234
APPENDIX
Vehicle GradeBody Type
Min. Running Ground Clearance mm (in.)
Angle of Approach degrees
Angle of Departure degrees
Item Area
Model Code
Overall Length mm (in.)
Width mm (in.)
Height mm (in.)
Wheel Base mm (in.)
Tread Front mm (in.)
Rear mm (in.)
Room Front mm (in.)
Rear mm (in.)
Overhang
Curb Weight
Gross Vehicle Weight Front kg (lb)
Rear kg (lb)
Total kg (lb)
Front kg (lb)
Rear kg (lb)
Total kg (lb)
Fuel Tank Capacity (Imp.gal.)
Luggage Compartment Capacity m
3 (cu.ft.)
Max. Speed km / h (mph)
Max. Cruising Speed km / h (mph)
Acceleration
Max. Permissible
Speed
Min. Turning Radius 0 to 100 km / h sec.
0 to 400 m sec.
1st Gear km / h (mph)
2nd Gear km
/h (mph)
3rd Gear km / h (mph)
4th Gear km / h (mph)
Tire m (ft.)
Body m (ft.)
Engine Type
Valve Mechanism
Bore x Stroke mm (in.)
Displacement cm
3 (cu.in.)
Compression Ratio
Carburetor Type or Injection Pump Type (Diesel)Research Octane No. or Cetane No. (Diesel)
Max. Output (EEC) kW / rpm
Max. Torque (EEC) N
.m / rpm
Battery Capacity (5HR) Voltage & Amp. hr.
Alternator Output Watts
Starter Output kW
Clutch Type
Transaxle Type
Transmission Gear
Ratio
Counter Gear Ratio
Differential Gear Ratio (Final)
Brake Type
Parking Brake Type
Brake Booster Type and Size in.
Proportioning Valve Type
Suspension Type
Stabilizer Bar
Steering Gear Type
Steering Gear Ratio (Overall)
Power Steering Type In First
In Second
In Third
In Fourth
In Fifth
In Reverse
Front
Rear
Front
Rear
Front
Rear
5
10
15
20
25
30
35
40
45
50
55
60
65
70
Major Dimension & Vehicle Weights
Performance
Engine
Engine
Chassis Electric
EUROPE
5-Door Wagon
MID ELEGANT
Length mm (in.)
Width mm (in.)
Height mm (in.) ENTRY
AP-18
AZT250R-AWPGHW AZT250L-AWPGHW CDT250R-AWMNYW CDT250L-AWMNYW
4700 (185.0) 4700 (185.0)4700 (185.0)4700 (185.0)
1760 (69.3) 1760 (69.3)1760 (69.3)1760 (69.3)
1525 (60.0) 1525 (60.0)1525 (60.0)1525 (60.0)
2700 (106.3) 2700 (106.3)2700 (106.3)2700 (106.3)
1506 (59.3) 1506 (59.3)1506 (59.3)1506 (59.3)
1510 (59.4) 1510 (59.4)1510 (59.4)1510 (59.4)
2090 (82.3) 2090 (82.3)2090 (82.3)2090 (82.3)
1485 (58.5) 1485 (58.5)1485 (58.5)1485 (58.5)
1210 (47.6), 1160 (45.7)*
11210 (47.6), 1160 (45.7)*11210 (47.6), 1160 (45.7)*11210 (47.6), 1160 (45.7)*1
910 (35.8) 910 (35.8)910 (35.8)910 (35.8)
1095 (43.1) 1095 (43.1)1095 (43.1)1095 (43.1)
135 (5.3), 155 (6.1)*
2135 (5.3), 155 (6.1)*2135 (5.3), 155 (6.1)*2135 (5.3), 155 (6.1)*2
13.1 , 14.5 *213.1, 14.5 *213.1, 14.5 *213.1, 14.5 *2
18, 19.2 *218, 19.2 *218, 19.2 *218, 19.2 *2
800 - 825 (1764 - 1819) 800 - 825 (1764 - 1819) 850 - 900 (1874 - 1984) 850 - 900 (1874 - 1984)
585 - 595 (1290 - 1312) 585 - 595 (1290 - 1312) 580 - 590 (1279 - 1301) 580 - 590 (1279 - 1301)
1385 - 1420 (3054 - 3131) 1385 - 1420 (3054 - 3131) 1430 - 1490 (3153 - 3285) 1430 - 1490 (3153 - 3285) 915 (2017) 915 (2017)985 (2172)985 (2172)
980 (2161) 980 (2161)985 (2172)985 (2172)
1895 (4178) 1895 (4178)1970 (4344)1970 (4344)
60 (15.9, 13.2) 60 (15.9, 13.2)60 (15.9, 13.2)60 (15.9, 13.2)
0.520 (18.4) 0.520 (18.4)0.520 (18.4)0.520 (18.4)
190 (118) 190 (118)190 (118)190 (118)
ÐÐÐÐ
11.3 11.311.411.4
17.7 17.717.817.8
63 (39) 63 (39)45 (27)45 (27)
114 (71) 114 (71) 84 (52)84 (52)
177 (110) 177 (110) 128 (79)128 (79)
Ð Ð176 (109) 176 (109)
5.6 (18.4) 5.6 (18.4)5.6 (18.4)5.6 (18.4)
5.995 (19.7) 5.995 (19.7)5.995 (19.7)5.995 (19.7)
1AZ-FSE 1AZ-FSE1CD-FTV 1CD-FTV
16-Valve, DOHC 16-Valve, DOHC16-Valve, DOHC16-Valve, DOHC
86.0 x 86.0 (3.39 x 3.39) 86.0 x 86.0 (3.39 x 3.39) 82.2 x 94.0 (3.24 x 3.70) 82.2 x 94.0 (3.24 x 3.70)
1998 (121.9) 1998 (121.9)1995 (121.7)1995 (121.7)
11.0 11.017.8 17.8
EFI EFICommon-Rail Type Common-Rail Type
95 or higher 95 or higher48 or higher48 or higher
108 / 5700 108 / 5700 85 / 360085 / 3600
196 / 4000 196 / 4000280 / 2000 - 2200 280 / 2000 - 2200
12 - 48 12 - 4812 - 6012 - 60
1200 120012001200
1.6 1.62.02.0
Ð ÐDry, Single Plate Dry, Single Plate
U241E*
4U241E*4E357 E357
3.943 3.9433.5383.538
2.197 2.1971.9131.913
1.413 1.4131.2581.258
1.020 1.0200.9180.918
Ð Ð0.690 0.690
3.145 3.1453.5833.583
ÐÐÐÐ
2.923 2.9233.6843.684
Ventilated Disc Ventilated DiscVentilated DiscVentilated Disc
Solid Disc Solid DiscSolid DiscSolid Disc
Drum DrumDrumDrum
Tandem 8º + 9º Tandem 8º + 9ºTandem 8º + 9ºTandem 8º + 9º
ÐÐÐÐ
MacPherson Strut. MacPherson Strut.MacPherson Strut.MacPherson Strut.
Double Wishbone Double WishboneDouble WishboneDouble Wishbone
STD STDSTDSTD
STD STDSTDSTD
Rack and Pinion Rack and PinionRack and PinionRack and Pinion
16.1 16.116.116.1
Integral Type Integral TypeIntegral TypeIntegral Type
*
1: With Sun Roof *4: Snow Mord Type
*2: Rough Road Pack
*3: Option
http://vnx.su
Page 82 of 2234
D01556
WRONG
D01563
01±16
±
INTRODUCTION REPAIR INSTRUCTION
AVENSIS REPAIR MANUAL (RM1018E)
(±) terminal cable is disconnected. If necessary, be
sure to initialize the system.
(b) HANDLING OF ELECTRONIC PARTS (1) Do not open the cover or case of the ECU unlessabsolutely necessary (If the IC terminals are
touched, the IC may be rendered inoperative by
static electricity).
(2) To disconnect electronic connectors, pull the con- nector itself, not the wires.
(3) Be careful not to drop electronic components, such as sensors or relays. If they are dropped on a hard
floor, they should be replaced and not be reused.
(4) When cleaning the engine with steam, protect the electronic components, air filter and emission±re-
lated components from water.
(5) Never use an impact wrench to remove or install temperature switches or temperature sensors.
(6) When checking the continuity at the wire connector, insert the tester probe carefully to prevent terminals
from bending.
4. REMOVAL AND INSTALLATION OF FUEL CONTROL PARTS
(a) PLACE FOR REMOVING AND INSTALLING OF FUEL SYSTEM PARTS (1) Work in a place with good air ventilation and without anything that could ca\
use combustionaround you such as a welder, grinder, drill, electric motor or stove.
(2) Never work in a place such as a pit or nearby a pit, as there is a possi\
bility that vaporized fuel will collect in those places.
(b) REMOVING AND INSTALLING OF FUEL SYSTEM PARTS (1) Prepare a fire extinguisher before starting operations.
(2) To prevent static electricity, install a ground on the fuel changer, vehicle and fuel tank, and donot spray much water so as to prevent slipping.
(3) Never use any electric equipment like an electric motor or a working lig\
ht, as they may create
sparks or a high temperature.
(4) Never use an iron hammer, as it may create sparks.
(5) Dispose of shop rags containing fuel deposits separately.
5. REMOVAL AND INSTALLATION OF ENGINE INTAKEPARTS
(a) If any metal tip is mixed in the inlet pass, this may give a bad effect to the engine and turbocharger.
(b) When removing and installing the inlet system parts,
close the opening of the removed inlet system parts and
the engine with a clean waste cloth or gum tape.
(c) When installing the inlet system parts, check that there is no mixing of a metal tip.
http://vnx.su
Page 84 of 2234
01±18
±
INTRODUCTION REPAIR INSTRUCTION
AVENSIS REPAIR MANUAL (RM1018E)
NOTICE:
Confirm that the VSC warning light blinks.
VSC system will be reset when the engine is re-
started.
Fasten the vehicle with lock chains.
(b) NOTICES OF RELATED OPERATIONS TO VSC (1) Do not carry out unnecessary installation and re-
moval as it might disorder the adjustment of related
parts to VSC.
(2) Be sure to carry out the preparation for operation and the confirmation of operation completion in ac-
cordance with the instruction of the text and when
the related operations to VSC are performed.
10. FOR VEHICLES EQUIPPED WITH CATALYTIC CONVERTER
CAUTION:
If a large amount of unburned gasoline flows into the converter, it may cause overheating and is a
fire hazard. To prevent this, observe the following precautions.
(a) Use only unleaded gasoline.
(b) Avoid prolonged idling. Avoid idling the engine for more than 20 minutes.
(c) Avoid a spark jump test. (1) Perform a spark jump test only when absolutely necessary. Perform this test as rapidly as pos-sible.
(2) While testing, never race the engine.
(d) Avoid a prolonged engine compression measurement. Engine compression measurements must be performed as rapidly as possible\
.
(e) Do not run the engine when the fuel tank is nearly empty. This may cause the engine to misfire and create an extra load on the converter.
http://vnx.su
Page 87 of 2234
010B9±11
±
INTRODUCTION TERMS
01±37
AVENSIS REPAIR MANUAL (RM1018E)
TERMS
ABBREVIATIONS USED IN THIS MANUAL
AbbreviationsMeaning
ABSAnti±Lock Brake System
A/CAir Conditioner
ACAlternating Current
ACCAccessory
ACISAcoustic Control Induction System
ACSDAutomatic Cold Start Device
A.D.D.Automatic Disconnecting Differential
A/FAir±Fuel Ratio
AHCActive Height Control Suspension
ALRAutomatic Locking Retractor
ALTAlternator
AMPAmplifier
ANTAntenna
Approx.Approximately
ASSYAssembly
A/T, ATMAutomatic Transmission (Transaxle)
AT FAutomatic Transmission Fluid
AUTOAutomatic
AUXAuxiliary
AV GAverage
AV SAdaptive Variable Suspension
B+Battery Voltage
BABrake Assist
BACSBoost Altitude Compensation System
BATBattery
BDCBottom Dead Center
B/LBi±Level
B/SBore±Stroke Ratio
BTDCBefore Top Dead Center
BVSVBimetallic Vacuum Switching Valve
CANController Area Network
CBCircuit Breaker
CCoCatalytic Converter For Oxidation
CDCompact Disc
CFCornering Force
CGCenter Of Gravity
CHChannel
CKDComplete Knock Down
COMB.Combination
CPECoupe
CPSCombustion Pressure Sensor
CPUCentral Processing Unit
CRSChild Restraint System
CTRCenter
C/VCheck Valve
CVControl Valve
CWCurb Weight
DCDirect Current
http://vnx.su
Page 88 of 2234
01±38
±
INTRODUCTION TERMS
AVENSIS REPAIR MANUAL (RM1018E) Abbreviations Meaning
DEFDefogger
DFLDeflector
DIFF.Differential
DIFF. LOCKDifferential Lock
D/INJDirect Injection
DLCData Link Connector
DLIDistributorless Ignition
DOHCDouble Overhead Camshaft
DPDash Pot
DSDead Soak
DSPDigital Signal Processor
DTCDiagnostic Trouble Code
DVDDigital Versatile Disc
EBDElectric Brake Force Distribution
ECAMEngine Control And Measurement System
ECDElectronic Controlled Diesel
ECDYEddy Current Dynamometer
ECTElectronic Control Transmission
ECUElectronic Control Unit
EDElectro±Deposited Coating
EDUElectronic Driving Unit
EDICElectric Diesel Injection Control
EFIElectronic Fuel Injection
E/GEngine
EGRExhaust Gas Recirculation
EGR±VMEGR±Vacuum Modulator
ELREmergency Locking Retractor
EMPSElectric Motor Power Steering
ENGEngine
ESAElectronic Spark Advance
ETCS±iElectronic Throttle Control System±intelligent
EVAPEvaporative Emission Control
EVPEvaporator
E±VRVElectric Vacuum Regulating Valve
EXExhaust
FEFuel Economy
FFFront±Engine Front±Wheel±Drive
F/GFuel Gauge
FIPGFormed In Place Gasket
FLFusible Link
F/PFuel Pump
FPUFuel Pressure Up
FrFront
F/WFlywheel
FW/DFlywheel Damper
FWDFront±Wheel±Drive
GASGasoline
GNDGround
GPSGlobal Positioning System
HACHigh Altitude Compensator
H/BHatchback
http://vnx.su
Page 90 of 2234
01±40
±
INTRODUCTION TERMS
AVENSIS REPAIR MANUAL (RM1018E) Abbreviations Meaning
OEMOriginal Equipment Manufacturing
OHCOverhead Camshaft
OHVOverhead Valve
OPTOption
ORVROn±board Refilling Vapor Recovery
O/SOversize
P & BVProportioning And Bypass Valve
PCSPower Control System
PCVPositive Crankcase Ventilation
PKBParking Brake
PPSProgressive Power Steering
PTCPositive Temperature Coefficient
PSPower Steering
PTOPower Take±Off
P/WPower Window
R & PRack And Pinion
RAMRandom Access Memory
R/BRelay Block
RBSRecirculating Ball Type Steering
R/FReinforcement
RFSRigid Front Suspension
RHRight±Hand
RHDRight±Hand Drive
RLYRelay
ROMRead Only Memory
RrRear
RRSRigid Rear Suspension
RWDRear±Wheel Drive
SDNSedan
SENSensor
SICSStarting Injection Control System
SOCState Of Charge
SOHCSingle Overhead Camshaft
SPECSpecification
SPISingle Point Injection
SRSSupplemental Restraint System
SSMSpecial Service Materials
SSTSpecial Service Tools
STDStandard
STJCold±Start Fuel Injection
SWSwitch
SYSSystem
T/ATransaxle
TACHTachometer
TBIThrottle Body Electronic Fuel Injection
TCTurbocharger
TCCSTOYOTA Computer±Controlled System
TCVTiming Control Valve
TDCTop Dead Center
TEMP.Temperature
TEMSTOYOTA Electronic Modulated Suspension
http://vnx.su
Page 92 of 2234
![TOYOTA AVENSIS 2003 Service User Guide 010BA±14
01±42
±
INTRODUCTION TERMS
AVENSIS REPAIR MANUAL (RM1018E)
GLOSSARY OF SAE AND TOYOTA TERMS
This glossary lists all SAE±J1930 terms and abbreviations used in this ma\
nual in compliance](/img/14/57444/w960_57444-91.png "TOYOTA AVENSIS 2003 Service User Guide 010BA±14
01±42
±
INTRODUCTION TERMS
AVENSIS REPAIR MANUAL (RM1018E)
GLOSSARY OF SAE AND TOYOTA TERMS
This glossary lists all SAE±J1930 terms and abbreviations used in this ma\
nual in compliance")
010BA±14
01±42
±
INTRODUCTION TERMS
AVENSIS REPAIR MANUAL (RM1018E)
GLOSSARY OF SAE AND TOYOTA TERMS
This glossary lists all SAE±J1930 terms and abbreviations used in this ma\
nual in compliance with SAE rec-
ommendations, as well as their TOYOTA equivalents.
SAE
ABBREVIATIONSSAE TERMSTOYOTA TERMS
( )±±ABBREVIATIONS
A/CAir ConditioningAir Conditioner
ACLAir CleanerAir Cleaner, A/CL
AIRSecondary Air InjectionAir Injection (AI)
APAccelerator Pedal±
B+Battery Positive Voltage+B, Battery Voltage
BAROBarometric PressureHAC
CACCharge Air CoolerIntercooler
CARBCarburetorCarburetor
CFIContinuous Fuel Injection±
CKPCrankshaft PositionCrank Angle
CLClosed LoopClosed Loop
CMPCamshaft PositionCam Angle
CPPClutch Pedal Position±
CTOXContinuous Trap Oxidizer±
CTPClosed Throttle PositionLL ON, Idle ON
DFIDirect Fuel Injection (Diesel)Direct Injection (DI/INJ)
DIDistributor Ignition±
DLC1
DLC2
DLC3Data Link Connector 1
Data Link Connector 2
Data Link Connector 31: Check Connector
2: Total Diagnosis Communication Link (TDCL)
3: OBD II Diagnostic Connector
DTCDiagnostic Trouble CodeDiagnostic Trouble Code
DTMDiagnostic Test Mode±
ECLEngine Control Level±
ECMEngine Control ModuleEngine ECU (Electronic Control Unit)
ECTEngine Coolant TemperatureCoolant Temperature, Water Temperature (THW)
EEPROMElectrically Erasable Programmable Read Only Memory
Electrically Erasable Programmable Read Only Memory
(EEPROM),
Erasable Programmable Read Only Memory (EPROM)
EFEEarly Fuel EvaporationCold Mixture Heater (CMH), Heat Control Valve (HCV)
EGRExhaust Gas RecirculationExhaust Gas Recirculation (EGR)
EIElectronic IgnitionDistributorless Ignition (DLI)
EMEngine ModificationEngine Modification (EM)
EPROMErasable Programmable Read Only MemoryProgrammable Read Only Memory (PROM)
EVAPEvaporative EmissionEvaporative Emission Control (EVAP)
FCFan Control±
FEEPROMFlash Electrically Erasable Programmable
Read Only Memory±
FEPROMFlash Erasable Programmable Read Only Memory±
FFFlexible Fuel±
FPFuel PumpFuel Pump
GENGeneratorAlternator
GNDGroundGround (GND)
http://vnx.su
Page 93 of 2234
±
INTRODUCTION TERMS
01±43
AVENSIS REPAIR MANUAL (RM1018E)
HO2S
Heated Oxygen SensorHeated Oxygen Sensor (HO2S)
IACIdle Air ControlIdle Speed Control (ISC)
IATIntake Air TemperatureIntake or Inlet Air Temperature
ICMIgnition Control Module±
IFIIndirect Fuel InjectionIndirect Injection (IDL)
IFSInertia Fuel±Shutoff±
ISCIdle Speed Control±
KSKnock SensorKnock Sensor
MAFMass Air FlowAir Flow Meter
MAPManifold Absolute PressureManifold Pressure Intake Vacuum
MCMixture Control
Electric Bleed Air Control Valve (EBCV)
Mixture Control Valve (MCV)
Electric Air Control Valve (EACV)
MDPManifold Differential Pressure±
MFIMultiport Fuel InjectionElectronic Fuel Injection (EFI)
MILMalfunction Indicator LampCheck Engine Lamp
MSTManifold Surface Temperature±
MVZManifold Vacuum Zone±
NVRAMNon±Volatile Random Access Memory±
O2SOxygen SensorOxygen Sensor, O2 Sensor (O2S)
OBDOn±Board DiagnosticOn±Board Diagnostic System (OBD)
OCOxidation Catalytic ConverterOxidation Catalyst Convert (OC), CCo
OPOpen LoopOpen Loop
PAIRPulsed Secondary Air InjectionAir Suction (AS)
PCMPowertrain Control Module±
PNPPark/Neutral Position±
PROMProgrammable Read Only Memory±
PSPPower Steering Pressure±
PTOXPeriodic Trap OxidizerDiesel Particulate Filter (DPF)
Diesel Particulate Trap (DPT)
RAMRandom Access MemoryRandom Access Memory (RAM)
RMRelay Module±
ROMRead Only MemoryRead Only Memory (ROM)
RPMEngine SpeedEngine Speed
SCSuperchargerSupercharger
SCBSupercharger BypassE±ABV
SFISequential Multiport Fuel InjectionElectronic Fuel Injection (EFI), Sequential Injection
SPLSmoke Puff Limiter±
SRIService Reminder Indicator±
SRTSystem Readiness Test±
STScan Tool±
TBThrottle BodyThrottle Body
TBIThrottle Body Fuel InjectionSingle Point Injection
Central Fuel Injection (Ci)
TCTurbochargerTurbocharger
TCCTorque Converter ClutchTorque Converter
http://vnx.su
Page 112 of 2234
022J5±01
±
PREPARATION ENGINE CONTROL SYSTEM
02±3
AVENSIS REPAIR MANUAL (RM1018E)
ENGINE CONTROL SYSTEM
PREPARATION
SST
09268±21010Fuel Hose PullerKNOCK SENSOR(1AZ±FE)
Recomended Tools
09082±00040TOYOTA Electrical TesterSFI SYSTEM(1AZ±FE)
SFI SYSTEM(1AZ±FSE)
SFI SYSTEM(1ZZ±FE/3ZZ±FE)
(09083±00150)Test Lead SetSFI SYSTEM(1AZ±FE)
SFI SYSTEM(1AZ±FSE)
SFI SYSTEM(1ZZ±FE/3ZZ±FE)
Equipment
Ohmmeter
Radiator cap tester
Service Wire Harness
Torque wrench
Vernier calipers
Voltmeter
http://vnx.su