light TOYOTA AYGO 2011 Owners Manual

296SPECIFICATIONS
COOLING SYSTEM
Total capacity, L (qt., Imp. qt.):
0Q07
∗
4.4 (4.6, 3.9)
0Q01, 0Q02∗
4.0 (4.2, 3.5)
∗: The identification code are stamped on
the locations shown in the below il-
lustration.
MS81013
On the back side
Coolant type:
Your Toyota vehicle is filled with “Toyota
Super Long Life Coolant” at the factory.
In order to avoid technical problems,
only use “Toyota Super Long Life
Coolant” or similar high quality ethylene
glycol based non−silicate, non−amine,
non−nitrite, and non−borate coolant with
long−life hybrid organic acid technology.
(Coolant with long−life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
BATTERY
Open voltage
∗at 20_C(68_F):
12.6—12.8 V Fully charged
12.2—12.4 V Half charged
11.8—12.0 V Discharged
∗: Voltage that is checked 20 minutes af-
ter the key is removed with all the
lights turned off
Charging rates:
5Amax.
CLUTCH
Pedal free play, mm (in.):
18—28 (0.7—1.1)
AYGO WE 99E37E11 02.18

SPECIFICATIONS301
Fuses (type A)
1. H−LP RH (HI) 10 A (with daytime
running light system):Right−hand
headlights
2. H−LP LH (HI) 10 A (with daytime run-
ning light system):Left−hand head-
lights, gauges and meters
3. H−LP RH (LO) 10 A (with daytime
running light system):Right−hand
headlights
4. H−LP LH (LO) 10 A (with daytime
running light system):Left−hand
headlights, gauges and meters
5. DIMMER 20 A (with daytime running
light system):“H−LP LH (HI)”, “H−LP
RH(HI)”, “H−LP LH (LO)”, “H−LP RH
(LO)” fuses, daytime running light sys-
tem
H−LP LH 10 A (without daytime run-
ning light system):Left−hand head-
lights
6. ABS NO.2 25 A (without vehicle sta-
bility controlsystem):Anti−lock brake
systemand vehicle stability control sys-
tem
VSC NO.2 30 A (with vehicle stability
control system):Anti−lock brake sys-
tem and vehicle stability control system
7.AM230A:Starting system, “IG1”,
“IG2”, “STA” fuses
8. HAZARD 10 A:Turn signal lights,
emergency flashers, gauges and meter-
s
9. H−LP RH 10 A (without daytime run-
ning light system):Right−hand head-
lights
10. DOME 15 A:Gauges and meters, inte-
rior light, audiosystem, tachometer
11 . E F I 1 5 A :Electric cooling fan, multi-
port fuel injection system/sequential
multiport fuel injection system
12. HORN 10 A:Horn
13. SPARE 7.5 A:Spare fuse
14. SPARE 10 A:Spare fuse15. SPARE 15 A:Spare fuse
16. STA 7.5 A:Multi−mode manual trans-
mission, multiport fuel injection system/
sequential multiport fuel injection
system
17. EFI NO.2 7.5 A:Multiport fuel injection
system/sequential multiport fuel injec-
tion system, multi−mode manual trans-
mission
18. STOP 10 A:Stop lights, high mounted
stoplight, anti−lock brake system, mul-
ti−mode manual transmission
19. D/L 25 A:Power door locksystem,
wireless remote control system
20. DEF 20 A:Rear window defogger
21. TAIL 7.5 A:Daytime running light sys-
tem, tail lights, license plate lights,
position lights, headlight beam level
control system, instrumentpanel lights
22. OBD 7.5 A:On−board diagnosis sys-
tem
23. ECU−B7.5A:Multi−mode manual
transmission, daytime running light sys-
tem, vehicle stability control system,
gauges and meters, rear fog light
24. ECU−IG 7.5 A:Anti−lock brake system,
vehicle stability control system, electric
power steering system, electric cooling
fan
25. BACK UP 10 A:Back−up lights, power
door locksystem, wireless remote con-
trol system, power windows, rear win-
dow defogger, tachometer, air condition-
ing system,heatersystem
26. WIP 20 A:Windshield wiper and wash-
er, rear window wiper and washer
27. ACC 15 A:Power outlet, audiosystem
AYGO WE 99E37E11 02.18

302SPECIFICATIONS
28. IG1 7.5 A:Windshield wiper and wash-
er, rear window wiper and washer,
anti−lock brake system, electric power
steering system, electric cooling fan,
back−up lights, power door lock sys-
tem, wireless remote control system,
power windows, rear window defogger,
tachometer, air conditioningsystem,
heatersystem
29.IG215A:Multiport fuel injection sys-
tem/sequential multiport fuel injection
system, SRS airbag system,gauges
and meters, daytime running light sys-
tem, multi−mode manual transmission
30. A/C 7.5 A:Air conditioningsystem,
power heater
Fuses (type B)
31. AM1 40 A:“ACC”, “WIP”, “ECU−IG”,
“BACK UP” fuses
32. PWR 30 A:Power windows
33. HTR 40 A:Heater system, air condi-
tioning system, “A/C” fuse
34. AMT 50 A:Multi−mode manual trans-
mission
35. RADIATOR 30 A or 40 A
∗:Electric
cooling fan
∗:Replace the fuse with one of the same
ampere rating as the original.
36. ABS NO.1 40 A (without vehicle sta-
bility controlsystem):Anti−lock brake
system and vehicle stability control
system
VSC NO.1 50 A (with vehicle stability
control system):Anti−lock brake sys-
tem and vehicle stability control system
37. EMPS 50 A:Electric power steering
system
Fuse (type C)
38. ALTERNATOR 120 A:Charging sys-
tem, “EPS”, “ABS (without vehicle sta-
bility control system)”, “VSC (with ve-
hicle stability control system)”,
“RADIATOR”, “AM1”, “HTR”, “PWR”,
“D/L”, “DEF”, “TAIL”, “STOP”, “OBD”,
“ECU−B” fuses
AYGO WE 99E37E11 02.18

304INDEX
A
Adding washer fluid 282..................
Adjustment
Front seats 42.........................
Seat belts 48..........................
Air conditioning filter 184.................
Air conditioningsystem 175..............
Airbag manual on−off system 78..........
Airbags 55,62,68........................
Aluminum wheel precautions 275.........
Anti−glare inside rear view mirror 114.....
Anti−lock brake system warning
light 127..............................
Anti−theft steering column lock 138.......
Appearance care
Cleaning the interior 250...............
Protecting your Toyota from
corrosion 246.......................
Washing and waxing 247...............
Audio system 161.......................
Auxiliary catch, Engine hood 36..........
B
Back door 33............................
Battery
Checking battery condition 278.........
Gas caution 278.......................
Handling safety 278....................
Recharging precautions 280............
Winter driving tips 215.................
Before starting the engine 210............
Brake system 200.......................
Brake system warning light 127...........
Brakes
Parking 160...........................
Break−in tips 194........................
C
Carbon monoxide caution 198............
Charging system warning light 127........
Checking and replacing fuses 280........
Checking the engine oil level 264.........
Checking the radiator and
condenser 268........................
Child restraint
Child restraint system 81...............
Installation 90.........................Installation with ISOFIX rigid
anchor 109..........................
ISOFIX child restraint system 109.......
Precautions 80........................
Types of child restraint system 82.......
Using a top strap 106..................
Cleaning the interior 250.................
Clock 188...............................
Cold weather
Operation 215.........................
Compact disc player 162.................
Condenser
Checking the condenser 268...........
Controls, Instrument panel 2.............
Cooling system
Coolant level 267......................
Engine overheating 225................
Radiator 268..........................
Radiator and reservoir 267.............
Radiator cap 225......................
Winter driving tips 215.................
Corrosion prevention 246................
Cup holders 189.........................
D
Defogger
Rear window 121......................
Dimmer switch, Headlight 116............
Directional signals 116...................
Do−it−yourself maintenance
Service precautions 260...............
Does your vehicle need repairing? 255....
Doors
Side doors 28.........................
Driver ’s seat belt reminder buzzer 127....
Driver ’s seat belt reminder light 127.......
Driving
Driving tips 213,215....................
Manual transmission 156...............
Driving in the rain 214....................
Driving tips
Driving in the rain 214..................
Driving tips in various conditions 213....
Driving with a manual
transmission 156....................
Economical driving 216................
Good driving practice 156..............
Pre−trip safety check 211..............
Winter driving tips 215.................
AYGO WE 99E37E11 02.18

INDEX305
During
Break−in 194..........................
E
Economical driving
Saving money on both fuel and
repairs 216..........................
Electric power steering system 204.......
Electric power steering system warning
light 127..............................
Electrical system
Battery 278,280.......................
Fuse locations 259....................
Fuses 280............................
Emergency flasher switch 118............
Emergency, In case of
Blown fuse 280........................
Emergency flasher switch 118..........
Flat tire 226...........................
If you lose your keys 243...............
If your engine stalls while driving 224....
If your vehicle has to be stopped in
an emergency 244...................
If your vehicle needs to be
towed 236...........................
If your vehicle will not start 220.........
Jump starting 221.....................
Overheating 225.......................
Towing 236............................
Engine
Before starting the engine 210..........
Checking the coolant level 267..........
Emission control device 197............
Engine compartment 258...............
Exhaust gas caution 198...............
Hood release 36.......................
Identification number 206..............
Oil consumption 199...................
Oil level 264...........................
Overheating 225.......................
Starting procedure 209.................
Three−way catalytic converter 197......
Engine coolant
Temperature warning lights 125.........
Winter driving tips 215.................
Engine coolant temperature warning
lights 125.............................
Engine immobilizer system 13............
Engine oil
Winter driving tips 215.................Exhaust gas caution 198.................
F
Facts about engine oil
consumption 199......................
Flasher, Headlight 116...................
Flat tire
After changing wheels 235.............
Changing tire 231......................
If you have a flat tire 226...............
Jack point 230.........................
Jacking precautions 226...............
Jacking up 230........................
Loosening wheel bolts 229.............
Lowering vehicle 233..................
Reinstalling wheel ornament 234........
Removing wheel ornament 229.........
Wheel block 228.......................
Wheel bolts 232.......................
Floor mat 190...........................
Fluid level
Washer fluid 282......................
Fog light switch, Rear 119................
Fold−down rear seat 46..................
Foreign countries, Operation in 196.......
Front passenger ’s seat belt
reminder buzzer 127...................
Front passenger ’s seat belt
reminder light 127.....................
Front seat
Rear seat entry 45.....................
Front seats 42..........................
Fuel
Filler door opener 38...................
Fuel economy 216.....................
Fuel pump shut off system 196..........
Gauge 124............................
Operation in foreign countries 196......
Tank cap 38...........................
Fuel information 194.....................
Fuel pump shut off system 196............
Fuse
Fuse box 280..........................
Fuse locations 259......................
G
Gauge
Fuel 124..............................
Good driving practice 156................
AYGO WE 99E37E11 02.18

306INDEX
H
Hazard switch 118.......................
Head restraints 47.......................
Headlight beam level control switch 117...
Headlight switch 116.....................
High speed operation
During break−in 194...................
Hood release, Engine 36.................
How to start the engine 210...............
I
Identification
Engine 207............................
Vehicle 206...........................
Ignition switch 138.......................
Indicator symbols 7.....................
Instrument panel
Fuel gauge 124........................
Indicator symbols 7....................
Odometer 126.........................
Tachometer 126.......................
Trip meter 126.........................
Instrument panel overview 2.............
Interior light 119.........................
Installation with ISOFIX rigid anchor 109..
J
Jack
Location 227..........................
Jump starting 221.......................
K
Keys 10,243............................
L
Light bulbs
Back−up lights 286....................
Front turn signal lights 285.............
Headlights 283........................
High−mounted stoplight 288............
License plate lights 289................
Position lights 285.....................
Rear fog light 286......................
Rear turn signal lights 286..............
Side turn signal lights 286..............
Stop/tail lights 286.....................
Light bulbs, Replacing 282...............Light, Interior
Interior light 119.......................
Light reminder buzzer 127................
Lock
Back door 33..........................
Side doors 28.........................
Steering column 138...................
Low engine oil pressure warning light 127..
Low fuel level warning light 127...........
Luggage cover 189......................
Luggage stowage precautions 205........
M
Maintenance
Do−it−yourself maintenance 260........
Does your vehicle need
repairing? 255.......................
Maintenance facts 254.................
Where to go for service 254.............
Malfunction indicator lamp 127...........
Manual transmission
Driving with a manual
transmission 156....................
Shift pattern 156.......................
Maximum allowable speed
Manual transmission 156...............
Multi−mode manual transmission 139.....
Mirror
Anti−glare inside rear view 114.........
Remote controlled rear view 113........
Mirrors
Folding rear view 113..................
Outside rear view 112..................
Vanity 114............................
Multi−mode manual transmission
Driving with a multi−mode
manual transmission 139.............
Shift pattern 140.......................
N
New vehicle break−in 194................
AYGO WE 99E37E11 02.18

INDEX307
O
Odometer 126...........................
Oil
Consumption 199......................
Viscosity and grade 265................
Oil consumption 199.....................
Operation in foreign countries 196........
Outside rear view mirrors
Rear view mirror remote control 113.....
Overheating, Engine 225.................
Overheating, Engine coolant 125.........
Overview
Engine compartment 258...............
Instrument cluster 6...................
Instrument panel 2....................
P
Parking brake
Operation 160.........................
Reminder light 160....................
Polishing 247...........................
Positioning a floor jack 261...............
Power outlet 188........................
Power window switches 30...............
Pre−trip safety check 211................
Pretensioners
(seat belt pretensioners) 51............
Protecting your Toyota from
corrosion 246.........................
R
Radiator
Checking the radiator 268..............
Coolant, Engine 267...................
Radio 162...............................
Rear fog light switch 119.................
Rear seat
Fold−down 46.........................
Rear view mirror remote control 113.......
Rear view mirror, Anti−glare inside 114....
Rear view mirror, Remote controlled 113..
Rear view mirrors, Folding 113...........
Rear view mirrors, Outside 112...........
Rear window defogger switch 121.........
Rear window wiper and washer
switch 120............................
Rear windows 31........................
S
Safety check, Pre−trip 211...............
Seat adjustment precautions
Front seats 44.........................
Seat belts
Cleaning 250..........................
Fastening 49..........................
Seat belt precautions 48...............
Seat belt pretensioners 51.............
Seats 42................................
Service and maintenance 254............
Service reminder indicators 127..........
Side door locks 28.......................
Side doors 28...........................
Side vents 183..........................
Spare fuse 280..........................
Spare tire 227...........................
Specifications 291.......................
SRS driver and front passenger
airbags 55............................
SRS side airbags 62.....................
SRS side airbags and curtain shield
airbags 68............................
SRS warning light 127...................
Starting
Cold weather 215......................
Engine 209............................
Jump starting 221.....................
Steering
Adjusting steering wheel 112...........
Column lock 138.......................
“STOP” warning light 127.................
Suspension and chassis 208.............
Switch
Airbag manual on−off 78...............
Emergency flasher 118................
Headlight, dimmer and turn
signal 116...........................
Headlight beam level control 117........
Ignition 138...........................
Rear fog light 119......................
Rear window defogger 121.............
Rear window wiper and washer 120.....
Power window 30......................
Windshield wiper and washer 120.......
AYGO WE 99E37E11 02.18