tow TOYOTA BZ4X 2022 (in English) Repair Manual

541
8
Owners Manual_Europe_M42D76_en
8-2. Steps to take in an emergency
When trouble arises
1Open the hood.
2 Pull the ring section of the emer-
gency release lever and
remove.
3 Pull the ring section horizontally
toward the inside of the vehicle.
After the unlocking operation is com- pleted, push the ring part back to its
original position until it clicks into place.
Emergency release lever
■When unlocking with the emer- gency release lever
Be sure to observe the following.
If you lose your keys
New genuine keys can be
made by any authorized
Toyota retailer or Toyota
authorized repairer, or any reli-
able repairer using another key
and the key number stamped
on your key number plate.
Keep the plate in a safe place
such as your wallet, not in the
vehicle.
NOTICE
■When an electronic key is lost
If the electronic key remains lost, the
risk of vehicle theft increases signifi- cantly. Visit any authorized Toyota retailer or Toyota authorized repairer,
or any reliable repairer immediately with all remaining electronic keys that were provided with your vehicle.
If the charging port lids
cannot be opened
If the charging port lids cannot
be opened when using the nor-
mal procedure, the following
procedure can be used to open
the charging port lids.
Opening the charging port
lids

547
8
Owners Manual_Europe_M42D76_en
8-2. Steps to take in an emergency
When trouble arises
order from which they were con-
nected.
10 Close the positive (+) battery
terminal cover.
Once the EV system starts, have
the vehicle inspected at any autho-
rized Toyota retailer or Toyota
authorized repairer, or any reliable
repairer as soon as possible.
■Starting the EV system when the 12-volt battery is discharged
The EV system cannot be started by push-starting.
■To prevent 12-volt battery dis-charge
●Turn off the headlights, the air condi-tioning system, the audio system, etc.
while the EV system is off.
●Turn off any unnecessary electrical
components when the vehicle is run- ning at a low speed for an extended period, such as in heavy traffic.
■Charging the 12-volt battery
The electricity stored in the 12-volt bat- tery will discharge gradually even when the vehicle is not in use, due to natural
discharge and the draining effects of certain electrical appliances. If the vehi-cle is left for a long time, the 12-volt bat-
tery may discharge, and the EV system may be unable to start. (The 12-volt bat-tery recharges automatically while the
EV system is operating.)
■When the 12-volt battery is removed or discharged
●Information stored in the ECU is cleared. When the 12-volt battery is depleted, have the vehicle inspected
at any authorized Toyota retailer or Toyota authorized repairer, or any reli-able repairer.
●In some cases, it may not be possible to unlock the doors using the smart
entry & start system when the 12-volt
battery is discharged. Use the wire-
less remote control or the mechanical key to lock or unlock the doors.
●The EV system may not start on the first attempt after the 12-volt battery has recharged but will start normally
after the second attempt. This is not a malfunction.
●The power switch mode is memorized by the vehicle. When the 12-volt bat-tery is reconnected, the system will
return to the mode it was in before the 12-volt battery was discharged. Before disconnecting the 12-volt bat-
tery, turn the power switch off. If you are unsure what mode the power switch was in before the 12-volt
battery discharged, be especially careful when reconnecting the 12-volt battery.
●If the 12-volt battery discharges, it may not be possible to shift the shift
position to other positions. In this case, the vehicle cannot be towed without lifting both front wheels
because the front wheels will be locked.
●The power back door (if equipped) must be initialized. ( P.198)
■When replacing the 12-volt battery
●Use a 12-volt battery that conforms to European regulations.
●Use a 12-volt battery that the case size is same as the previous one (LN1), 20 hour rate capacity (20HR) is
equivalent (45Ah) or greater, and per- formance rating (CCA) is equivalent (286A) or greater.
• If the sizes differ, the 12-volt battery cannot be properly secured.• If an improper 12-volt battery is used,
battery performance may decrease and the EV system may not be able to restart.
• If the 20 hour rate capacity is low, even if the time period where the vehi-cle is not used is a short time, the 12-
volt battery may discharge and EV system may not be able to start.

551
8
Owners Manual_Europe_M42D76_en
8-2. Steps to take in an emergency
When trouble arises
1Stop the EV system. Set the
parking brake and shift the shift
position to P.
2 Remove the mud, snow or sand
from around the front wheels.
3 Place wood, stones or some
other material under the front
wheels to help provide traction.
4 Restart the EV system.
5 Shift the shift position to D or R
and release the parking brake.
Then, while exercising caution,
depress the accelerator pedal.
■When it is difficult to free the vehi-
cle
Press the switch to turn off TRC.
( P.407)
If the vehicle becomes
stuck
Carry out the following proce-
dures if the tires spin or the
vehicle becomes stuck in mud,
dirt or snow:
Recovering procedure
WARNING
■When attempting to free a stuck vehicle
If you choose to push the vehicle back and forth to free it, make sure the surrounding area is clear to avoid
striking other vehicles, objects or peo- ple. The vehicle may also lunge for-ward or lunge back suddenly as it
becomes free. Use extreme caution.
■When shifting the shift position
Be careful not to shift the shift position with the accelerator pedal depressed.This may lead to unexpected rapid
acceleration of the vehicle that may cause an accident resulting in death or serious injury.
NOTICE
■To avoid damage to the transmis-sion and other components
●Avoid spinning the tires and depressing the accelerator pedal more than necessary.
●If the vehicle remains stuck even
after these procedures are per- formed, the vehicle may require towing to be freed.

554
Owners Manual_Europe_M42D76_en
9-1. Specifications
9-1.Spec ific ations
*1: Unladen vehicle
*2: 2WD models
*3: AWD models
*4: Vehicles with towing packages
■Vehicle identification number
The vehicle identification number
(VIN) is the legal identifier for your
vehicle.
This is the primary identification
number for your Toyota. It is used in
registering the ownership of your
vehicle.
Right-hand drive vehicles only: This
number is on the top left of the
instrument panel.
Maintenance data
Dimensions and weights
Overall length4690 mm (184.6 in.)
Overall width1860 mm (73.2 in.)
Overall height*11650 mm (65.0 in.)
Wheelbase2850 mm (112.2 in.)
TreadFront1600 mm (63.0 in.)
Rear1610 mm (63.4 in.)
Gross vehicle mass2465 kg (5435 lb.)*2
2550 kg (5623 lb.)*3
Maximum permissi-
ble axle capacity
Front1355 kg (2987 lb.)
Rear1355 kg (2987 lb.)*2
1400 kg (3087 lb.)*3
Drawbar load*475 kg (165 lb.)
Towing capacity*4750 kg (1653 lb.)
Vehicle identification

560
Owners Manual_Europe_M42D76_en
9-1. Specifications
■When towing a trailer
Add 20.0 kPa (0.2 kgf/cm2 or bar, 3 psi) to the recommended tire inflation pressure
and drive at speeds below 100 km/h (62 mph).

583
Owners Manual_Europe_M42D76_en
Alphabetical Index
Driving range ................................ 172
Driving support system information
display ......................................... 177
Dynamic radar cruise control .... 307,
316
Approach warning ...................... 313
Curve speed reduction function . 313
Road Sign Assist (RSA) ............. 314
Warning lights ............................ 520
E
eCall ................................................. 65
ECB (Electronically Controlled Brake
System) ....................................... 406
Warning light .............................. 515
Eco mode ...................................... 252
Elapsed time ................................. 178
Electric motor (traction motor)
Identification number.................. 555
Location ....................................... 82
Electric Power Steering (EPS)
Function ..................................... 406
Warning light .............................. 517
Electric Vehicle system features ... 82
Electric Vehicle system precautions
....................................................... 86
Electronic key
Battery-saving function .............. 204
If the electronic key does not operate
properly.................................... 542
Replacing the battery ................. 499
Electronic sunshade .................... 442
Operation ................................... 442
Electronically Controlled Brake Sys-
tem (ECB) .................................... 406
Warning light .............................. 515
Emergency brake signal .............. 406
Emergency Driving Stop System 321
Emergency flashers ..................... 506
Emergency tire puncture repair kit
..................................................... 528
Storage location ......................... 530
Emergency, in case of
If a warning buzzer sounds ........ 515
If a warning light turns on ........... 515
If a warning message is displayed
................................................. 523
If the 12-volt battery is discharged
................................................. 544
If the electronic key does not operate
properly .................................... 542
If the EV system will not start ..... 539
If the vehicle is submerged or water
on the road is rising..................507
If you have a flat tire ................... 528
If you lose your keys ..................541
If you think something is wrong .. 513
If your vehicle becomes stuck .... 551
If your vehicle has to be stopped in
an emergency .......................... 506
If your vehicle needs to be towed
................................................. 509
If your vehicle overheats ............549
EPS (Electric Power Steering)
Function ..................................... 406
Warning light .............................. 517
EV system........................................ 82
Acoustic Vehicle Alerting System . 84
Battery Electric Vehicle driving tips
................................................... 91
Brake Override System .............. 230
Drive-start control .......................234
Driving range ................................ 93
Electric Vehicle system precautions
................................................... 86
Emergency shut off system .......... 90
Features ....................................... 82
How to use AC charging............. 121
How to use DC charging ............129
If the EV system will not start ..... 539
If your vehicle has to be stopped in
an emergency .......................... 506

591
Owners Manual_Europe_M42D76_en
Alphabetical Index
Tire inflation pressure display func-
tion ........................................... 477
Warning buzzers ........................ 518
Warning light .............................. 518
Tire pressure warning system..... 477
Function ..................................... 477
Installing tire pressure warning
valves and transmitters ............ 479
Registering ID codes.................. 484
Registration of the position of each
wheel ....................................... 480
Selecting wheel set .................... 486
Setting the tire pressure ............. 481
Warning buzzers ........................ 518
Warning light .............................. 518
Tires ............................................... 476
Chains ........................................ 412
Checking .................................... 476
Emergency tire puncture repair kit
................................................. 528
If you have a flat tire................... 528
Inflation pressure ....................... 494
Replacing ................................... 488
Rotating tires .............................. 477
Size ............................................ 559
Snow tires .................................. 411
Tire inflation pressure display func-
tion ........................................... 477
Tire pressure warning system .... 477
Warning buzzers ........................ 518
Warning light .............................. 518
Tools ...................................... 489, 530
Top strap ......................................... 63
Top tether anchorages ................... 63
To w i n g
Emergency towing ............. 509, 511
Towing eyelet ............................. 512
Trailer towing ............................. 237
Toyota parking assist-sensor ...... 333
Enabling/disabling the system ... 334
Function ..................................... 333
Warning lights.............................519
Toyota Safety Sense ..................... 275
AHB (Automatic High Beam)...... 265
AHS (Adaptive High-beam System)
................................................. 262
Driver monitor.............................282
Dynamic radar cruise control ..... 307
Emergency Driving Stop System321
LDA (Lane Departure Alert) ........ 299
LTA (Lane Tracing Assist)........... 294
PCS (Pre-Collision System) ....... 283
RSA (Road Sign Assist) ............. 304
Software update ......................... 273
Toyota Teammate Advanced Park365
Memory function......................... 386
Parallel exiting function .............. 384
Parallel parking function ............. 381
Perpendicular exiting (for-
ward/reverse) function ............. 379
Perpendicular parking (for-
ward/reverse) function ............. 376
Remote control function ............. 391
Traction battery ...............................82
Charging............................. 121, 129
Location........................................ 82
Specification ............................... 556
Traction battery cooler................ 115
Traction battery heater ............... 114
Warning messages..................... 160
Traction battery charge
Warning light .............................. 517
Traction Control (TRC) ................. 406
Trailer towing ................................ 237
Transmission................................. 247
TRC (Traction Control) ................. 406
Trip meters .................................... 174
Turn signal lights
Replacing light bulbs ..................504
Turn signal lever ......................... 253