ABS TOYOTA CAMRY 1994 XV10 / 4.G Wiring Diagrams Workshop Manual
[x] Cancel search | Manufacturer: TOYOTA, Model Year: 1994, Model line: CAMRY, Model: TOYOTA CAMRY 1994 XV10 / 4.GPages: 307, PDF Size: 5.48 MB
Page 11 of 307
11
FINDING A SHORT CIRCUIT
(a) Remove the blown fuse and disconnect all loads of the
fuse.
(b) Connect a test light in place of the fuse.
(c) Establish conditions in which the test light comes on.
Example:
± Ignition SW on
± Ignition SW and SW 1 on
± Ignition SW, SW 1 and Relay on (Connect the
Relay) and SW 2 off (or Disconnect SW 2)
(d) Disconnect and reconnect the connectors while
watching the test light.
The short lies between the connector where the test
light stays lit and the connector where the light goes
out.
(e) Find the exact location of the short by lightly shaking
the problem wire along the body.
CAUTION
(a) Do not open the cover or the case of the ECU unless
absolutely necessary. (If the IC terminals are touched,
the IC may be destroyed by static electricity.)
(b) When replacing the internet mechanism (ECU part) of
the digital meter, be careful that no part of your body or
clothing comes in contact with the terminals of leads
from the IC, etc. of the replacement part (spare part).
DISCONNECTION OF MALE AND FEMALE
CONNECTORS
To pull apart the connectors, pull on the connector itself, not the
wire harness.
HINT: Check to see what kind of connector you are disconnecting
before pulling apart.
Page 15 of 307
15
ABBREVIATIONS
ABBREVIATIONS
The following abbreviations are used in this manual.
ABS = Anti±Lock Brake System
ACIS = Acoustic Control Induction System
A/C = Air Conditioning
A/T = Automatic Transmission
COMB. = Combination
C/P = Coupe
ECU = Electronic Control Unit
EFI = Electronic Fuel Injection
EGR = Exhaust Gas Recirculation
ESA = Electronic Spark Advance
Ex. = Except
FL = Fusible Link
IAC = Idle Air Control
ISC = Idle Speed Control
J/B = Junction Block
LH = Left-Hand
MFI = Multiport Fuel Injection
M/T = Manual Transmission
O/D = Overdrive
R/B = Relay Block
RH = Right±Hand
RPM = Engine Speed
S/D = Sedan
SFI = Sequential Multiport Fuel Injection
SRS = Supplemental Restraint System
SW = Switch
TEMP. = Temperature
VSV = Vacuum Switching Valve
W/G = Wagon
w/ = With
w/o = Without
*The titles given inside the components are the names of the terminals (terminal codes) and
are not treated as being abbreviations.
Page 28 of 307
28
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[1MZ±FE]
A 2 A/C Triple Pressure SW (A/C Dual and Single Pressure F 1 Front Airbag Sensor LH
SW) F 2 Front Airbag Sensor RH
A 3 A/C Magnetic Clutch and Lock Sensor F 3 Front Clearance Light LH
A 4 ABS Actuator F 4 Front Clearance Light RH
A 5 ABS Actuator F 5 Front Side Marker LH
A 6 ABS Relay F 6 Front Side Marker RH
A 7 ABS Relay F 7 Front Turn Signal Light LH
A 8 ABS Speed Sensor Front LH F 8 Front Turn Signal Light RH
A 9 ABS Speed Sensor Front RH F 9 Front Wiper Motor
F 10 Fuse Box
B 2 Brake Fluid Level SW F 16 Fuse Box
F 18 Fuse Box
C 2 Cruise Control Actuator
C 17 Camshaft Position Sensor G 1 Generator (Alternator)
C 18 Crankshaft Position Sensor G 2 Generator (Alternator)
D 1 Data Link Connector 1 (Check Connector) H 1 Headlight Hi LH
D 2 Distributor H 2 Headlight Hi RH
H 3 Headlight Lo LH
E 1 EGR Gas Temp. Sensor H 4 Headlight Lo RH
E 2 Electronic Controlled Transmission Solenoid H 5 Horn LH
E 4 Engine Coolant Temp. Sensor (EFI Water Temp. H 6 Horn RH
Sensor) H 11 Heated Oxygen Sensor (Bank 1 Sensor 1)
E 5 Engine Coolant Temp. Sensor (Water Temp. Sensor) H 12 Heated Oxygen Sensor (Bank 2 Sensor 1)
(for Cooling Fan)
Page 30 of 307
30
ELECTRICAL WIRING ROUTING
Position of Parts in Engine Compartment
[5S±FE]
A 1 A/C Condenser Fan Motor E 1 EGR Gas Temp. Sensor
A 2 A/C Triple Pressure SW (A/C Dual and Single Pressure E 2 Electronic Controlled Transmission Solenoid
SW) E 3 Electronic Controlled Transmission Solenoid
A 3 A/C Magnetic Clutch and Lock Sensor E 4 Engine Coolant Temp. Sensor (EFI Water Temp.
A 4 ABS Actuator Sensor)
A 5 ABS Actuator E 5 Water Temp. SW (for Cooling Fan)
A 6 ABS Relay
A 7 ABS Relay F 1 Front Airbag Sensor LH
A 8 ABS Speed Sensor Front LH F 2 Front Airbag Sensor RH
A 9 ABS Speed Sensor Front RH F 3 Front Clearance Light LH
F 4 Front Clearance Light RH
B 1 Back±Up Light SW (M/T) F 5 Front Side Marker LH
B 2 Brake Fluid Level SW F 6 Front Side Marker RH
F 7 Front Turn Signal Light LH
C 2 Cruise Control Actuator F 8 Front Turn Signal Light RH
F 9 Front Wiper Motor
D 1 Data Link Connector 1 (Check Connector) F 10 Fuse Box
D 2 Distributor F 16 Fuse Box
F 17 Fuse Box
F 18 Fuse Box
G 1 Generator (Alternator)
G 2 Generator (Alternator)
Page 31 of 307
31
Position of Parts in Engine Compartment
[5S±FE]
H 1 Headlight Hi LH O 1 Oil Pressure SW
H 2 Headlight Hi RH O 2 Oxygen Sensor (Sub)
H 3 Headlight Lo LH O 3 Oxygen Sensor (Main)
H 4 Headlight Lo RH
H 5 Horn LH P 1 Park/Neutral Position SW (Neutral Start SW) (A/T)
H 6 Horn RH
R 1 Radiator Fan Motor
I 1 Idle Air Control Valve (ISC Valve)
I 2 Igniter S 3 Starter
I 3 Ignition Coil S 4Starter
I 4 Injector No. 1
I 5 Injector No. 2 T 1 Throttle Position Sensor
I 6 Injector No. 3
I 7 Injector No. 4 V 1 VSV (for A/C Idle±Up)
I 10 Intake Air Temp. Sensor (In±Air Temp. Sensor) V 2 VSV (for EGR System)
V 3 VSV (for Fuel Pressure Up)
K 1 Knock Sensor V 5 Vehicle Speed Sensor (Speed Sensor)
M 1 Manifold Absolute Pressure Sensor (Vacuum Sensor) W 1 Washer Motor
W 2 Water Temp. Sender
N 1 Noise Filter (for Ignition System)
Page 32 of 307
32
ELECTRICAL WIRING ROUTING
Position of Parts in Instrument Panel
A 10 A/C Amplifier C 12 Combination SW
A 11 A/C Evaporator Temp. Sensor C 13 Combination SW
A 12 A/C SW C 14 Cooling Fan ECU
A 13 ABS ECU C 15 Cruise Control Clutch SW (M/T)
A 14 ABS ECU C 16 Cruise Control ECU
A 15 Airbag Squib (Steering Wheel Pad)
A 16 Air Inlet Control Servo Motor D 3 Data Lik Connector 2 (TDCL (Toyota Diagnostic
A 17 Air Vent Mode Control Servo Motor Communication Link))
A 18 Ashtray Illumination D 4 Daytime Running Light Relay (Main)
A 22 Airbag Squib (Front Passenger Airbag Assembly) D 5 Diode (for Cruise Control)
D 6 Diode (for Idle±Up)
B 3 Back Door Lock Control SW D 7 Diode (for Courtesy)
B 4 Blower Motor D 8 Door Lock Control Relay)
B 5 Blower Resistor D 24 Date Link Connector 3
B 6 Blower SW D 25 Diode (for Tension Reducer)
B 7 Buckle SW LH (w/ Power Seat)
B 8 Buckle SW LH (w/o Power Seat) E 6 Electronic Controlled Transmission Pattern Select SW
B 10 Buckle SW RH E 7 Engine Control Module (Engine and Electronic
Controlled Transmission ECU) (A/T)
C 3 Center Airbag Sensor Assembly E 8 Engine Control Module (Engine and Electronic
C 4 Cigarette Lighter Controlled Transmission ECU) (A/T)
C 5 Cigarette Lighter Illumination E 9 Engine Control Module (Engine and Electronic
C 6 ClockControlled Transmission ECU) (A/T)
C 7 Clutch Start SW (M/T) E 10 Engine Control Module (Engine and Electronic
C 8 Combination Meter Controlled Transmission ECU) (A/T)
C 9 Combination Meter E 11 Engine Control Module (Engine ECU) (M/T)
C 10 Combination Meter E 12 Engine Control Module (Engine ECU) (M/T)
C 11 Combination Meter E 14 Engine Control Module (Engine ECU) (M/T)
Page 34 of 307
34
ELECTRICAL WIRING ROUTING
Position of Parts in Body
[Sedan]
A 19 ABS Speed Sensor Rear LH L 3 Luggage Compartment Light
A 20 ABS Speed Sensor Rear RH L 4 Luggage Compartment Light SW
A 21 Auto Antenna Motor and Relay
M 2 Moon Roof Control Relay
D 10 Door Courtesy Light Front LH M 3 Moon Roof Control SW and Personal Light (w/ Moon
D 11 Door Courtesy Light Front RH Roof)
D 12 Door Courtesy SW Front LH M 4 Moon Roof Limit SW
D 13 Door Courtesy SW Front RH M 5 Moon Roof Motor
D 14 Door Courtesy SW Rear LH
D 15 Door Courtesy SW Rear RH P 9 Power Window Control SW Front RH
D 16 Door Key Cylinder Light and SW P 10 Power Window Control SW Rear LH
D 17 Door Key Lock and Unlock SW LH P 11 Power Window Control SW Rear RH
D 18 Door Key Lock and Unlock SW RH P 12 Power Window Master SW and Door Lock Control SW
D 19 Door Lock Control SW RH LH
D 20 Door Lock Motor and Door Unlock Detection SW Front P 13 Power Window Motor Front LH
LHP 14 Power Window Motor Front RH
D 21 Door Lock Motor and Door Unlock Detection SW Front P 15 Power Window Motor Rear LH
RHP 16 Power Window Motor Rear RH
D 22 Door Lock Motor Rear LH
D 23 Door Lock Motor Rear RH R 8 Rear Combination Light LH
R 9 Rear Combination Light LH
F 11 Front Door Speaker LH R 10 Rear Combination Light RH
F 12 Front Door Speaker RH R 11 Rear Combination Light RH
F 13 Front Tweeter (Speaker) LH R 12 Rear Speaker LH
F 14 Front Tweeter (Speaker) RH R 13 Rear Speaker RH
F 15 Fuel Pump and Sender R 16 Rear Window Defogger (+)
R 17 Rear Window Defogger (±)
H 10 High Mount Stop Light R 20 Remote Control Mirror LH
R 21 Remote Control Mirror RH
I 14 Interior Light
V 8 Vanity Light LH
L 1 License Plate Light V 9 Vanity Light RH
L 2 Light Failure Sensor
Page 35 of 307
35
Position of Parts in Body
[Coupe]
A 19 ABS Speed Sensor Rear LH M 2 Moon Roof Control Relay
A 20 ABS Speed Sensor Rear RH M 3 Moon Roof Control SW and Personal Light
A 21 Auto Antenna Motor and Relay (w/ Moon Roof)
M 4 Moon Roof Limit SW
D 10 Door Courtesy Light Front LH M 5 Moon Roof Motor
D 11 Door Courtesy Light Front RH
D 12 Door Courtesy SW Front LH P 9 Power Window Control SW Front RH
D 13 Door Courtesy SW Front RH P 12 Power Window Master SW and Door Lock Control
D 16 Door Key Cylinder Light and SW SW LH
D 19 Door Lock Control SW RH P 13 Power Window Motor Front LH
D 26 Door Lock Motor, Door Unlock Detection SW P 14 Power Window Motor Front RH
Door Key Lock and Unlock SW LH
D 27 Door Lock Motor, Door Unlock Detection SW R 8 Rear Combination Light LH
Door Key Lock and Unlock SW RH R 9 Rear Combination Light LH
D 28 Door Lock Control SW LH (w/o Power Window) R 10 Rear Combination Light RH
R 11 Rear Combination Light RH
F 11 Front Door Speaker LH R 12 Rear Speaker LH
F 12 Front Door Speaker RH R 13 Rear Speaker RH
F 13 Front Tweeter (Speaker) LH R 16 Rear Window Defogger (+)
F 14 Front Tweeter (Speaker) RH R 17 Rear Window Defogger (±)
F 15 Fuel Pump and Sender R 20 Remote Control Mirror LH
R 21 Remote Control Mirror RH
H 10 High Mount Stop Light
T 2 Tension Reducer Solenoid LH
I 14 Interior Light T 3 Tension Reducer Solenoid RH
L 1 License Plate Light V 8 Vanity Light LH
L 2 Light Failure Sensor V 9 Vanity Light RH
L 3 Luggage Compartment Light
L 4 Luggage Compartment Light SW
Page 36 of 307
36
ELECTRICAL WIRING DIAGRAM
Position of Parts in Body
[Wagon]
A 19 ABS Speed Sensor Rear LH F 13 Front Tweeter (Speaker) LH P 11 Power Window Control SW Rear
A 20 ABS Speed Sensor Rear RH F 14 Front Tweeter (Speaker) RH RH
A 21 Auto Antenna Motor and Relay F 15 Fuel Pump and Sender P 12 Power Window Master SW and
Door Lock Control SW LH
D 10 Door Courtesy Light Front LH H 10 High Mount Stop Light P 13 Power Window Motor Front LH
D 11 Door Courtesy Light Front RH P 14 Power Window Motor Front RH
D 12 Door Courtesy SW Front LH I 14 Interior Light P 15 Power Window Motor Rear LH
D 13 Door Courtesy SW Front RH P 16 Power Window Motor Rear RH
D 14 Door Courtesy SW Rear LH L 1 License Plate Light
D 15 Door Courtesy SW Rear RH L 2 Light Failure Sensor R 8 Rear Combination Light LH
D 16 Door Key Cylinder Light and SW L 3 Luggage Compartment Light R 9 Rear Combination Light LH
D 17 Door Key Lock and Unlock SW LH L 4 Luggage Compartment Light SW R 10 Rear Combination Light RH
D 18 Door Key Lock and Unlock SW RH R 11 Rear Combination Light RH
D 19 Door Lock Control SW RH M 2 Moon Roof Control Relay R 12 Rear Speaker LH
D 20 Door Lock Motor and Door Unlock M 3 Moon Roof Control SW and R 13 Rear Speaker RH
Detection SW Front LH Personal Light (w/ Moon Roof) R 16 Rear Window Defogger (+)
D 21 Door Lock Motor and Door Unlock M 4 Moon Roof Limit SW R 17 Rear Window Defogger (±)
Detection SW Front RH M 5 Moon Roof Motor R 20 Remote Control Mirror LH
D 22 Door Lock Motor Rear LH R 21 Remote Control Mirror RH
D 23 Door Lock Motor Rear RH P 9 Power Window Control SW Front
RH V 8 Vanity Light LH
F 11 Front Door Speaker LH P 10 Power Window Control SW Rear V 9 Vanity Light RH
F 12 Front Door Speaker RH LH
Page 52 of 307
52
POWER SOURCE (Current Flow Chart)
The chart below shows the route by which current flows from the battery to each electrical source (Fusible Link,
Circuit Breaker, Fuse, etc.) and other parts.
The next page and following pages show the parts to which each electrical source outputs current.
Starter Battery
FL MAIN 2.0L30A AM2Ignition SW
(AM2)
Headlight Relay
(Point Side)
40A DEFOG 100A ALTGenerator
(Alternator) 7.5A SRS
Taillight Relay
(Coil Side) 40A MAIN
(Canada) 7.5A OBD
7.5A ALT±S
10A HAZ
10A HORN
15A ECU±B
15A EFI
20A DOMEHeadlight Relay
(Coil Side)
60A ABS 15A STOP
40A HEATER
Taillight Relay
(Point Side)
Engine Main
Relay (Point Side)
15A TEL
Daytime Running
Light Relay No. 2
(Coil Side)
Daytime Running
Light Relay No. 2
(Point Side)Starter Relay
(Point Side)
(5S±FE)
30A POWER
40A AM1
Daytime Running
Light Relay (Main)
15A HEAD (UPR±LH)
15A HEAD (UPR±RH)
[LOCATION](1): J/B No. 1 (See page 20)(2): J/B No. 2 (See page 19)
(3): R/B No. 1 (See page 20)(7): R/B No. 7 (See page 19) 2022
25
27