headlight TOYOTA HILUX 2019 Owner's Guide

5817-3. Do-it-yourself maintenance
HILUX_OM_OM0K375E_(EE)
7
Maintenance and care
Vehicles with LED headlights
To allow enough working
space, turn the steering
wheel to the opposite side
where the bulb to be
replaced is located.
Remove the screws and
clips.
Removing the clip
Installing the clip
1
1
2
Ty pe AType B

5887-3. Do-it-yourself maintenance
HILUX_OM_OM0K375E_(EE)
■Replacing the following bulbs
If any of the lights listed below has burnt out, have it replaced by
any authorized Toyota retailer or Toyota authorized repairer, or any
reliable repairer.
● Headlight low beams (vehicles with LED headlights)
● Front position lights/daytime running lights (vehicles with LED
headlights)
● Side turn signal lights
● LED front fog lights (if equipped)
● High mounted stoplight (if equipped)
■When installing the rubber cover of the headlight (vehicles with halogen
headlights)
Ensure the rubber cover is securely attached.
■ LED lights
The headlight low beams (vehicles with LED headlights), front position lights/
daytime running lights (vehicles with LED headlights), side turn signal lights
(mirror mounted type), LED front fo g lights (if equipped) and high mounted
stoplight (if equipped) consists of a number of LEDs. If any of the LEDs burn
out, take your vehicle to any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer to have the light replaced.
■ Condensation build-up on the inside of the lens
Temporary condensation build-up on the inside of the headlight lens does not
indicate a malfunction. Contact any authorized Toyota retailer or Toyota
authorized repairer, or any reliable repairer for more information in the follow-
ing situations:
● Large drops of water have built up on the inside of the lens.
● Water has built up inside the headlight.
Fit the rubber cover outer circumfer-
ence in firmly.
Fit the rubber cover around the light
bulb in until the light bulb plug can be
seen.
1
2

5897-3. Do-it-yourself maintenance
HILUX_OM_OM0K375E_(EE)
7
Maintenance and care
WARNING
■Replacing light bulbs
● Turn off the lights. Do not attempt to replace the bulb immediately after
turning off the lights.
The bulbs become very hot and may cause burns.
● Do not touch the glass portion of the light bulb with bare hands. When it is
unavoidable to hold the glass portion, use and hold with a clean dry cloth
to avoid getting moisture and oils on the bulb.
Also, if the bulb is scratched or dropped, it may blow out or crack.
● Fully install light bulbs and any parts used to secure them. Failure to do so
may result in heat damage, fire, or water entering the headlight unit. This
may damage the headlights or cause condensation to build up on the lens.
● Do not attempt to repair or disassemble light bulbs, connectors, electric
circuits or component parts.
Doing so may result in death or serious injury due to electric shock.
■ To prevent damage or fire
● Make sure bulbs are fully seated and locked.
● Check the wattage of the bulb before installing to prevent heat damage.

6418-2. Steps to take in an emergency
HILUX_OM_OM0K375E_(EE)
8
When trouble arises
■Starting the engine when the battery is discharged (vehicles with auto-
matic transmission)
The engine cannot be started by push-starting.
■ To prevent battery discharge
● Turn off the headlights and the audio system while the engine is off.
(Vehicles with Stop & Start system: Except when the engine is stopped due
to the Stop & Start system)
● Turn off any unnecessary electrical components when the vehicle is running
at a low speed for an extended period, such as in heavy traffic.
■ When the battery is removed or discharged
● Information stored in the ECU is cleared. When the battery is depleted, have
the vehicle inspected at any authorized Toyota retailer or Toyota authorized
repairer, or any reliable repairer.
● The power windows may not close normally. In this case, initialize the power
windows. (if equipped) ( P. 234)
■ Charging the battery
The electricity stored in the battery will discharge gradually even when the
vehicle is not in use, due to natural discharge and the draining effects of cer-
tain electrical appliances. If the vehicle is left for a long time, the battery may
discharge, and the engine may be unable to start. (The battery recharges
automatically during driving.)
■ When recharging or replacing the battery (vehicles with smart entry &
start system)
● In some cases, it may not be possible to unlock the doors using the smart
entry & start system when the battery is discharged. Use the wireless
remote control or the mechanical key to lock or unlock the doors.
● The engine may not start on the first attempt after the battery has recharged
but will start normally after the second attempt. This is not a malfunction.
● The engine switch mode is memorized by the vehicle. When the battery is
reconnected, the system will return to the mode it was in before the battery
was discharged. Before disconnecting the battery, turn the engine switch off.
If you are unsure what mode the engine switch was in before the battery dis-
charged, be especially careful when reconnecting the battery.
● Vehicles with Stop & Start system: For a while after the battery terminals
have been disconnected or reconnected, for a while after the battery has
been replaced, the Stop & Start system may not automatically stop the
engine for approximately 5 to 60 minutes.

6729-1. Specifications
HILUX_OM_OM0K375E_(EE)
Vehicles with maintenance type battery
Vehicles with maintenance-free type battery
Ignition system (gasoline engine)
Spark plug
MakeDENSO FK20HR-A8
Gap0.8 mm (0.031 in.)
NOTICE
■Iridium-tipped spark plugs
Use only iridium-tipped spark plugs. Do not adjust the spark plug gap.
Electrical system
Battery
Specific gravity reading
at 20 C (68F):
1.25 or higher
If the specific gravity is lower than the standard
value, charge the battery.
Charging rates
Quick charge
Slow charge
15 A max.
5 A max.
Battery
Open voltage at 20 C
(68 F):
12.3 V or higher
If the voltage is lower than the standard value,
charge the battery.
(After charging the battery, turn on the high
beam headlights for 30 seconds with the engine
switch in the “LOCK” position [vehicles without
smart entry & start system] or off [vehicles with
smart entry & start system], and turn the head-
lights off.)
Charging rates 5 A max.

679
9
9-1. Specifications
Vehicle specifications
HILUX_OM_OM0K375E_(EE)
*1: If equipped
*2: The wattage differs depending on the specification. When replacing, use a
light bulb with the same wattage as the original bulb.
Light bulbs
Light bulbsWTyp e
Exterior
Headlights
High/low beams (halogen headlights)
High beams (LED headlights)
60/55
60
A
B
Halogen front fog lights*119 C
Front position lights (halogen headlights)
Without daytime running lights
With daytime running lights
5
21/5
D
D
Front turn signal lights
Halogen headlights
LED headlights
21
21
E
F
Rear turn signal lights 21 E
Back-up lights 21 G
Rear fog light*121 G
License plate light 5 D
Stop/tail lights 21/5 G
Interior Interior light*18H
Personal/interior lights 5 or 8*2D
A: H4 halogen bulbs
B: HB3 halogen bulbs
C: H16 halogen bulbs
D: Wedge base bulbs (clear)
E: Single end bulbs (amber)
F: Wedge base bulbs (amber)
G: Single end bulbs (clear)
H: Double end bulbs

701Alphabetical index
HILUX_OM_OM0K375E_(EE)
Gauges...................................... 132
Glove box ................................. 507
Grocery bag hooks .................. 518
Hands-free system
(for cellular phone)*.............. 447
Head restraints......................... 223
Headlights ................................ 292
Light switch ........................... 292
Replacing light bulbs ............. 577
Wattage................................. 679
Heated steering wheel ............. 501
Heaters
Automatic air conditioning
system ................................ 492
Heated steering wheel .......... 501
Manual air conditioning
system ................................ 484
Seat heaters.......................... 501
Outside rear view mirrors ...... 494
High mounted stoplight
Replacing .............................. 588
Hill-start assist control ............ 387
Hood.......................................... 537
Hooks
Coat hooks ............................ 519
Grocery bag hooks................ 518
Retaining hooks (floor mat) ..... 36
Horn .......................................... 227
Identification
Engine................................... 658
Vehicle .................................. 656
Ignition switch (engine
switch) ............................ 266, 269
Auto power off function ......... 273
Changing the engine
switch modes...................... 272
Changing the engine
switch position .................... 267
If your vehicle has to be
stopped in an
emergency.......................... 593
Starting the engine........ 266, 269
Ignition switch light
(engine switch light) ............. 503
Illuminated entry system ........ 505
Immobilizer system ................... 95
Indicators ................................. 124
Initialization
Engine oil maintenance
data .................................... 543
Item to initialize ..................... 690
Inside rear view mirror ............ 228
Instrument panel light
control .................................... 134
Intercooler ................................ 545
Interior lights............................ 503
Switch ................................... 504
Wattage ................................ 679
Jack
Vehicle-equipped jack........... 617
Jack handle .............................. 622
Jam protection function
Power windows ..................... 233
G
H
I
J
*: Refer to “Navigation and multimedia system Owner’s manual”.

702Alphabetical index
HILUX_OM_OM0K375E_(EE)
Keyless entry
Smart entry & start system.... 174
Wireless remote control ........ 154
Keys .......................................... 152
Electronic key........................ 152
Engine switch ........................ 266
If the electronic key does
not operate properly ........... 635
If you lose your keys ............. 156
Key number plate .................. 152
Keyless entry ........................ 154
Keys ...................................... 152
Replacing the battery ............ 567
Wireless remote
control key .......................... 154
Lever
Auxiliary catch lever .............. 537
Hood lock release lever ........ 537
Shift lever ...................... 277, 284
Turn signal lever ................... 290
Wiper lever ............................ 302
LDA (Lane Departure Alert) .... 334
License plate light
Light switch ........................... 292
Replacing light bulbs ............. 587
Wattage................................. 679
Light
Engine switch light ................ 503
Fog light switch ..................... 299
Headlight switch .................... 292
Illuminated entry system ....... 505
Interior lights ......................... 504
Interior light list ...................... 503
Personal/interior lights .......... 504
Replacing light bulbs ............. 575
Turn signal lever ................... 290
Wattage................................. 679
Light bulbs
Replacing .............................. 575
Wattage ................................ 679
Lock steering column ..... 268, 274
Maintenance
Do-it-yourself maintenance ... 535
Maintenance data ................. 652
Maintenance requirements ... 532
Malfunction indicator lamp ..... 603
Manual headlight
leveling dial............................ 294
Manual transmission ............... 284
Master warning light................ 606
Meter
Indicators .............................. 124
Instrument panel light
control................................. 134
Meters ................................... 132
Multi-information
display ........................ 137, 141
Warning lights ....................... 602
Microphone .............................. 450
Mirrors
Inside rear view mirror .......... 228
Outside rear view mirror
defoggers ................... 485, 494
Outside rear view mirrors...... 229
Vanity mirror ......................... 514
MP3 disc*................................. 424
Multimedia system*
Multi-information display
LDA (Lane Departure
Alert)................................... 337
Switching the display ............ 138
Trip information ..................... 138
K
L
M

704Alphabetical index
HILUX_OM_OM0K375E_(EE)
Rear view mirror
Inside rear view mirror .......... 228
Outside rear view mirrors ...... 229
Rear view monitor system ...... 352
Rear window defogger .... 485, 494
Refueling .................................. 304
Capacity ................................ 660
Fuel types ............................. 660
Opening the fuel tank cap ..... 304
Replacing
Electronic key battery............ 567
Fuses .................................... 570
Light bulbs............................. 575
Tires ...................................... 616
Wireless remote control
battery................................. 567
Reset the maintenance data ... 543
Road Sign Assist ..................... 343
RSA (Road Sign Assist) .......... 343
Seat belts .................................... 40
Adjusting the seat belt............. 41
Child restraint system
installation............................. 65
Cleaning and maintaining the
seat belt .............................. 530
Emergency Locking
Retractor............................... 42
How to wear your seat belt ..... 38
How your child should
wear the seat belt ................. 42
Pregnant women, proper
seat belt use ......................... 43
Reminder light and
buzzer................................. 606
Seat belt pretensioners ........... 42
SRS warning light ................. 603
Seat heaters ............................. 501
Seats
Adjustment ............................ 218
Adjustment precautions ........ 219
Child seats/child restraint
system installation ................ 65
Cleaning................................ 529
Head restraint ....................... 223
Properly sitting in the seat ...... 38
Raising the bottom
cushion ............................... 220
Removing the rear seat
cushions ............................. 220
Seat heaters ......................... 501
Sensor
Automatic headlight
system ................................ 296
LDA (Lane Departure
Alert)................................... 334
Service reminder
indicators ............................... 124
Shift lever
Automatic transmission......... 277
If the shift lever cannot be
shifted from P ..................... 282
Manual transmission ............. 284
Shift lock system ..................... 281
Side airbags ............................... 45
Side doors ................................ 174
Side mirrors ............................. 229
Adjusting and folding ............ 229
Heaters ......................... 485, 494
Side turn signal lights
Replacing light bulbs............. 588
Turn signal lever ................... 290
Smart entry & start system ..... 184
Antenna location ................... 184
Entry functions ...................... 174
Starting the engine................ 269
Warning message ................. 610
S