spare wheel TOYOTA HILUX 2022 Owners Manual

2764-5. Using the driving support systems
HILUX_OM_OM0K513E_(EE)
WARNING
QWhen to disable the pre-collision system
In the following situations, disable the system, as it may not operate prop-
erly, possibly leading to an accident resulting in death or serious injury:
O When the vehicle is being towed
O When your vehicle is towing another vehicle
O When transporting the vehicle via truck, boat, train or similar means of
transportation
O When the vehicle is raised on a lift with the engine running and the tires
are allowed to rotate freely
O When inspecting the vehicle using a drum tester such as a chassis
dynamometer or speedometer tester , or when using an on vehicle wheel
balancer
O When a strong impact is applied to the front bumper or front grille, due to
an accident or other reasons
O If the vehicle cannot be driven in a stable manner, such as when the vehi-
cle has been in an accident or is malfunctioning
O When the vehicle is driven in a sporty manner or off-road
O When the tires are not properly inflated
O When the tires are very worn
O When tires of a size other than specified are installed
O When tire chains are installed
O When a compact spare tire or an emergency tire puncture repair kit is used
O If equipment (snow plow, etc.) that may obstruct the radar sensor or front
camera is temporarily installed to the vehicle

5087-3. Do-it-yourself maintenance
HILUX_OM_OM0K513E_(EE)
Rotate the tires in the order shown.
To equalize tire wear and help extend tire life, Toyota recommends that tire
rotation is carried out approximately every 10000 km (6000 miles).
Q When to replace your vehicle’s tires
Tires should be replaced if:
O The treadwear indicators are showing on a tire.
O You have tire damage such as cuts, splits, cracks deep enough to expose
the fabric, and bulges indicating internal damage
O A tire goes flat repeatedly or cannot be properly repaired due to the size or
location of a cut or other damage
If you are not sure, consult with any authorized Toyota retailer or Toyota
authorized repairer, or any reliable repairer.
Q Tire life
Any tire over 6 years old must be checked by a qualified technician even if it
has seldom or never been used or damage is not obvious.
Q If the tread on snow tires wears down below 4 mm (0.16 in.)
The effectiveness of the tires as snow tires is lost.
Tire rotation
Vehicles with spare tire of a dif-
ferent wheel type from the
installed tires
Vehicles with spare tire of the
same wheel type as the
installed tires
FrontFront

5818-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
If you have a flat tire
OStop the vehicle in a safe place on a hard, flat surface.
O Set the parking brake.
O Shift the shift lever to P (automatic transmission) or R (manual
transmission).
O Stop the engine.
O Turn on the emergency flashers. (P. 554)
Your vehicle is equipped with a spare tire. The flat tire can be
replaced with the spare tire.
For details about tires: P. 5 0 7
WARNING
QIf you have a flat tire
Do not continue driving with a flat tire.
Driving even a short distance with a flat tire can damage the tire and the
wheel beyond repair, which could result in an accident.
Before jacking up the vehicle
Location of the spare tire

5878-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
Assemble the jack handle end,
jack handle extensions and
wheel nut wrench.
To assemble the jack handle
extension and wheel nut wrench,
push in the projection on the jack
handle extension.
Insert the jack handle end into
the lowering screw.
Lower the spare tire completely
to the ground.
Remove the holding bracket
and pull out the spare tire.
Taking out the spare tire
1
2
3
4

5918-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
WARNING
QReplacing a flat tire
O Observe the following precautions.
Failure to do so may result in serious injury:
• Lower the spare tire completely to the ground before removing it from
under the vehicle.
• Do not try to remove the wheel ornament by hand. Take due care in
handling the ornament to avoid unexpected personal injury.
• Do not touch the disc wheels or the area around the brakes immediately
after the vehicle has been driven.
After the vehicle has been driven the disc wheels and the area around
the brakes will be extremely hot. Touching these areas with hands, feet
or other body parts while changing a tire, etc. may result in burns.
O Failure to follow these precautions could cause the wheel nuts to loosen
and the tire to fall off, resulting in death or serious injury.
• Have the wheel nuts tightened with a torque wrench to 105 N•m
(10.7 kgf•m, 77 ft•lbf) as soon as possible after changing wheels.
• Do not attach a heavily damaged wheel ornament, as it may fly off the
wheel while the vehicle is moving.
• When installing a tire, only use wheel nuts that have been specifically
designed for that wheel.
• If there are any cracks or deformations in the bolt screws, nut threads or
bolt holes of the wheel, have the vehicle inspected by any authorized
Toyota retailer or Toyota authoriz ed repairer, or any reliable repairer.
• When installing the wheel nuts, be sure to install them with the tapered
ends facing inward.

5928-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
Remove any dirt or foreign mat-
ter from the wheel contact sur-
face.
If foreign matter is on the wheel
contact surface, the wheel nuts
may loosen while the vehicle is in
motion, causing the tire to come
off.
Install the tire and loosely tighten each wheel nut by hand by
approximately the same amount.
Steel wheels
Tighten the wheel nuts until the
tapered portion comes into
loose contact with the disc
wheel seat.
Aluminum wheels
Turn the wheel nuts until the
washers come into contact with
the disc wheel.
Installing the spare tire
1
2
Tapered portion
Disc wheel
seat
Tapered portion
Washer
Wheel nut
Disc wheel

5938-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
8
When trouble arises
Lower the vehicle.
Firmly tighten each wheel nut
two or three times in the order
shown in the illustration.
Tightening torque:
105 N•m (10.7 kgf•m, 77 ft•lbf)
Vehicles with spare tire of the same wheel type as the installed
tires: Reinstall the wheel ornament.
Type A
Align the cutout of the wheel
ornament with the valve stem
as shown.
Type B
3
4
5

5948-2. Steps to take in an emergency
HILUX_OM_OM0K513E_(EE)
Type C
Lay down the tire with the valve
stem facing up and install the
holding bracket, inserting the
claw into the wheel lug nut hole.
Turn the jack handle extension
clockwise to take up slack in
the chain.
Then, check to ensure the claw is
in the wheel lug nut hole and the
holding bracket is centered in the
wheel hub.
Holding bracket
Claw
WARNING
Q Stowing the flat tire
Failure to follow steps listed under stowing the tire may result in damage to
the spare tire carrier and loss of the tire, which could result in death or seri-
ous injury.
Stowing the flat tire, jack and all tools
incorrect
correct
1
1
2

669Alphabetical index
HILUX_OM_OM0K513E_(EE)
Seats
Adjustment ............................ 170
Adjustment precautions ........ 171
Child seats/child restraint
system installation ................ 65
Cleaning ................................ 476
Head restraint ....................... 175
Properly sitting in the seat....... 38
Raising the bottom
cushion ............................... 172
Removing the rear seat
cushions ............................. 172
Seat heaters.......................... 450
Sensor
Automatic headlight
system ................................ 252
LDA (Lane Departure
Alert with Yaw Assist
Function)............................. 284
Toyota parking
assist-sensor ...................... 321
Toyota safety sense .............. 267
Service reminder
indicators ............................... 122
Shift lever
Automatic transmission ......... 231
If the shift lever cannot be
shifted from P ..................... 237
Manual transmission ............. 239
Shift lock system ..................... 236
Side airbags ............................... 45
Side doors ................................ 153
Side mirrors.............................. 182
Adjusting and folding............. 182
Heaters ......................... 435, 444
Side turn signal lights
Replacing light bulbs............. 549
Turn signal lever ................... 246
Smart entry & start system ..... 163
Antenna location ................... 163
Entry functions ...................... 153
Starting the engine................ 223
Warning message ................. 575
Snow tires ................................ 374
“SOS” button ..................... 98, 110
Spare tire
Inflation pressure .................. 639
Storage location .................... 581
Spark plug ................................ 635
Specifications .......................... 620
Speedometer ............................ 131
Steering
Column lock release ..... 222, 228
Fluid ...................................... 639
Steering wheel
Adjustment ............................ 178
Audio switches ...................... 379
Heated steering wheel .......... 450
Meter control switches .......... 136
Stop & Start system ................ 345
Stop lights
Replacing light bulbs..... 542, 549
Wattage ................................ 642
Storage feature ........................ 456
Storage precautions ................ 456
Stuck
If your vehicle becomes
stuck ................................... 615
Sun visors ................................ 464

670Alphabetical index
HILUX_OM_OM0K513E_(EE)
Switch
Audio remote control
switches*............................ 379
Cruise control switch ............. 317
Door lock switch .................... 155
Driving mode select
switches...................... 233, 240
Emergency flashers switch ... 554
Engine switch ................ 220, 223
Fog light switch ..................... 255
Front-wheel drive control
switch.................................. 331
Heated steering wheel
switch.................................. 450
Ignition switch ............... 220, 223
LDA (Lane Departure
Alert with Yaw Assist
Function)............................. 290
Light switches ....................... 248
Meter control switches .......... 136
Outside rear view mirror
switches.............................. 182
Power door lock switch ......... 155
Power heater switch...... 436, 444
Power window switch ............ 185
Rear differential lock
switch.................................. 341
Rear window and outside
rear view mirror
defoggers switch......... 435, 444
Seat heater switches............. 450
“SOS” button ................... 98, 110
Telephone switches*............ 413
Toyota parking
assist-sensor ...................... 322
VSC OFF switch ................... 357
Window lock switch ............... 186
Windshield wipers and
washer switch ..................... 258
Tachometer .............................. 131
Tailgate ..................................... 160
Tail lights
Light switch ........................... 248
Replacing light bulbs..... 542, 549
Wattage ................................ 642
Talk switch*
Telephone switches*.............. 413
Theft deterrent system
Alarm .................................... 117
Engine immobilizer system ... 115
Tire inflation pressure
Maintenance data ................. 639
Tires .......................................... 507
Chains................................... 375
Checking ............................... 507
If you have a flat tire ............. 581
Inflation pressure .......... 510, 639
Replacing .............................. 581
Rotating tires......................... 508
Size ....................................... 639
Snow tires ............................. 374
Spare tire .............................. 581
Tools ......................................... 584
Towing
Emergency towing ................ 559
Towing hook ......................... 561
Trailer towing ................ 206, 207
Toyota parking
assist-sensor ......................... 321
Toyota Safety Sense ............... 266
Traction control ....................... 355
Trailer towing ................... 206, 207
Transmission
Automatic transmission......... 231
If the shift lever cannot be
shifted from P ..................... 237
Manual transmission ............. 239
T