belt TOYOTA IQ 2012 Service Manual

5
399 5-2. Steps to take in an emergency
When trouble arises
iQ_WE_74014E
Follow the correction procedures.
After taking the specified steps to correct the suspected problem,
check that the warning light turns off.
SRS warning light
Indicates a malfunction in:
• The SRS airbag system; or
• The seat belt pretensioner system.
ABS warning light
Indicates a malfunction in:
• The ABS; or
• The brake assist system.
Electric power steering warning light (warning buzzer)
Indicates a malfunction in the EPS (Electric Power Steer-
ing) system.
Slip indicator
The indicator comes on to indicates a malfunction in:
• The VSC system; or
• The TRC system.
Warning lightWarning light/DetailsCorrection procedure
Open door warning light
Indicates that a door is not fully
closed.Check that all doors are
closed.
(Flashing)Low fuel level warning light
*1
Indicates that remaining fuel is
about 5.9 L (1.6 gal., 1.3 Imp.
gal.) or less.Refuel the vehicle.
Warning lightWarning light/Details

400 5-2. Steps to take in an emergency
iQ_WE_74014E
*1: When filled with less than 10 L per refueling, the fuel gauge may not display
accurately.
*2: Driver’s and front passenger’s seat belt reminders:
The driver’s and front passenger’s seat belt reminder sounds to alert the
driver and front passenger that his or her seat belt is not fastened. The
buzzer sounds for 30 seconds after the vehicle has reached a speed of at
least 20 km/h (12 mph). Then, if the seat belt is still unfastened, the buzzer
will sound in a different tone for 90 more seconds. (On the instru-
ment cluster)Driver’s seat belt
reminder light
(warning buzzer)
*2
Warns the driver to fasten
his/her seat belt.Fasten the seat belt.
(On the center
panel)Front passenger’s seat belt
reminder light
(warning buzzer)
*2
Warns the front passenger to
fasten his/her seat belt.Fasten the seat belt.
(On the center
panel)Rear passenger’s seat belt
reminder light
(vehicles with rear
passenger’s seat)
(warning buzzer)
*3
Warns the rear passenger to
fasten his/her seat belt.Fasten the seat belt.
Warning lightWarning light/DetailsCorrection procedure
*4
*5
*4
*5
*6
*6

5
401 5-2. Steps to take in an emergency
When trouble arises
iQ_WE_74014E
*3: Rear passenger’s seat belt reminders:
The rear passenger’s seat belt reminder sounds to alert the rear passenger
that his or her seat belt is not fastened. The buzzer sounds for 30 seconds
after the vehicle has reached a speed of at least 20 km/h (12 mph). Then, if
the seat belt is still unfastened, the buzzer will sound in a different tone for
90 more seconds.
*4: Left-hand drive vehicles with audio system
*5: Right-hand drive vehicles with audio system
*6: Vehicles without audio system
Follow the correction procedures. (vehicles with smart entry & start system)
After taking the specified steps to correct the suspected problem,
check that the warning light turns off.
Interior
buzzerExterior
buzzerWarning
lightWarning light/DetailsCorrection
procedure
OnceSmart entry & start
system warning light
Indicates that the elec-
tronic key is not pres-
ent when the “ENGINE
START STOP” switch
is pressed.Confirm the
location of the
electronic key.
Once 3 timesSmart entry & start
system warning light
Indicates that a door
other than the driver’s
door has been opened
and closed with the
“ENGINE START
STOP” switch in any
mode other than OFF
and the electronic key
outside of the detec-
tion area.Confirm the
location of the
electronic key.

404 5-2. Steps to take in an emergency
iQ_WE_74014E
If the malfunction indicator lamp comes on while driving
The malfunction indicator lamp will come on if the fuel tank becomes com-
pletely empty. If the fuel tank is empty, refuel the vehicle immediately. The
malfunction indicator lamp will go off after several trips.
If the malfunction indicator lamp does not go off, contact any authorized
Toyota dealer or repairer, or another duly qualified and equipped
professional as soon as possible.
Front passenger detection sensor and passenger seat belt reminder
If luggage is placed on the front passenger seat, the front passenger
detection sensor may cause the warning light to flash, even if a passen-
ger is not sitting in the seat.
If a cushion is placed on the seat, the sensor may not detect a passen-
ger, and the warning light may not operate properly.
Electric power steering system warning light (warning buzzer)
When the battery charge becomes insufficient or the voltage temporarily
drops, the electric power steering system warning light may come on and
warning buzzer may sound.
Customization that can be configured at any authorized Toyota dealer
or repairer, or another duly qualified and equipped professional
The vehicle speed linked seat belt reminder buzzer can be disabled.
(Customizable features P. 459)
CAUTION
When the electric power steering system warning light comes on
The steering wheel may become extremely heavy.
If the steering wheel becomes heavier than usual when operating, hold
firmly and operate using more force than usual.

434 5-2. Steps to take in an emergency
iQ_WE_74014E
CAUTION
Battery precautions
In the event that battery fluid comes into contact with the skin or eyes,
immediately wash the affected area with water and seek medical attention.
Place a wet sponge or cloth over the affected area until medical attention
can be received.
Always wash your hands after handling the battery support, terminals, and
other battery-related parts.
Do not allow children near the battery.
NOTICE
To prevent damage to the vehicle (vehicles with manual transmission)
Do not pull- or push-start the vehicle, because the catalytic converter may
overheat and become a fire hazard.
When handling jumper cables
Be careful that the jumper cables do not become tangled in the cooling fan
or any of the belts when connecting or disconnecting them.

5
437 5-2. Steps to take in an emergency
When trouble arises
iQ_WE_74014E
CAUTION
To prevent an accident or injury when inspecting under the hood of
your vehicle
If steam is seen coming from under the hood, do not open the hood until
the steam has subsided. The engine compartment may be very hot, caus-
ing serious injuries such as burns.
Keep hands and clothing (especially a tie, a scarf or a muffler) away from
the fan and belts. Failure to do so may cause the hands or clothing to be
caught, resulting in serious injury.
Do not loosen the radiator cap and the coolant reservoir cap while the
engine and radiator are hot.
Serious injury, such as burns, may result from hot coolant and steam
released under pressure.
NOTICE
When adding engine coolant
Wait until the engine has cooled down before adding engine coolant.
When adding coolant, do so slowly. Adding cool coolant to a hot engine too
quickly can cause damage to the engine.
To prevent damage to the cooling system
Observe the following precautions:
Avoid contaminating the coolant with foreign matter (such as sand or dust
etc.).
Do not use commercially available coolant additives.

448 6-1. Specifications
iQ_WE_74014E
Drive belt tension1KR-FE engine
6.5 7.5 mm (0.26 0.29 in.)
*
10.0 12.0 mm (0.39 0.47 in.)*
Vehicles without air conditioning system:
Vehicles with air conditioning system:
1NR-FE engine
10.0 12.0 mm (0.39 0.47 in.)
*
*
: Drive belt deflection with 98 N (10 kgf, 22 lbf) thumb
force (used belt)
Generator
Water pump
Crankshaft55 mm (2.17 in.)
CrankshaftWater pumpGenerator
Air conditioning
compressor55 mm (2.17 in.)
CrankshaftWater pumpGenerator
Air conditioning
compressor

460 6-2. Customization
iQ_WE_74014E
Illumination
(
P. 286)Time elapsed before
lights turn off15 seconds7.5 seconds
30 seconds
Operation when the
doors are unlockedON OFF
Operation after the
“ENGINE START
STOP” switch turned
OFF (vehicles with
smart entry & start sys-
tem)
Operation after the
engine switch turned off
(vehicles without smart
entry & start system)ON OFF
Seat Belt
Reminder
Buzzer
(
P. 399)Vehicle speed linked
seat belt reminder
buzzerON OFF
ItemFunctionDefault settingCustomized
setting

464 Alphabetical index
iQ_WE_74014E
Care
Exterior.................................. 306
Interior ................................... 310
Seat belts .............................. 311
CD player .................................. 265
Chains ....................................... 233
Child restraint system
Baby seats, definition ............ 137
Baby seats, installation ......... 148
Child seats, definition ............ 137
Child seats, installation ......... 148
Installing CRS with ISOFIX
rigid anchors ....................... 154
Installing CRS with
seat belts ............................ 149
Installing CRS with
top straps ............................ 155
Junior seats, definition .......... 137
Junior seats, installation........ 148
Child safety
Airbag precautions ................ 132
Battery precautions ....... 344, 433
Child restraint system ........... 137
How your child should wear
the seat belt .......................... 89
Installing child restraints........ 148
Power window lock switch .... 100
Power window precautions ... 102
Removed key battery
precautions ......................... 360
Seat belt precautions .............. 89
Seat heater precautions ........ 297
Cleaning
Exterior.................................. 306
Interior ................................... 310
Seat belts .............................. 311
Clock ......................................... 209
Condenser ................................ 342Cooling system
Engine overheating ............... 435
CRS ........................................... 137
Cup holders.............................. 289
Curtain shield airbags ............. 124
Customizable features ............ 459
Daytime running light
system .................................... 214
Defogger
Rear window ................. 252, 254
Side mirrors .......................... 254
Dimension ................................ 444
Display
Audio..................................... 257
Trip information ..................... 205
Do-it-yourself maintenance .... 316
Doors
Back door................................ 75
Door glasses ......................... 100
Door lock..................... 39, 62, 73
Side doors............................... 72
Side mirrors ............................ 95
Double locking system ........... 117
Driver’s seat belt reminder
light......................................... 399
Driving
Break-in tips .......................... 167
Correct posture ..................... 122
Procedures ........................... 164
Winter driving tips ................. 231C
D

465 Alphabetical index
iQ_WE_74014E
Eco driving indicator
light ......................... 167, 201, 209
Electric power steering ........... 224
Emergency flashers
Switch ................................... 386
Emergency, in case of
If the electronic key does not
operate properly ................. 427
If the engine will not start ...... 423
If the shift lever cannot be
shifted from P ..................... 425
If the vehicle battery
is discharged ...................... 430
If the warning buzzer
sounds ................................ 397
If the warning light turns
on........................................ 397
If you have a flat tire ............. 405
If you lose your keys ............. 426
If you think something is
wrong .................................. 395
If your vehicle becomes
stuck ................................... 438
If your vehicle has to
be stopped in an
emergency .......................... 440
If your vehicle needs to be
towed .................................. 388
If your vehicle overheats ....... 435
Emergency tire puncture
repair kit ................................. 405
Engine
Compartment ........................ 334
Engine switch ................ 176, 179
Hood ..................................... 319
How to start the
engine ......................... 176, 179
Identification number............. 445
If the engine will not start ...... 423
Ignition switch .............. 176, 179
Overheating .......................... 435Engine coolant
Capacity ................................ 452
Checking ............................... 340
Preparing and checking
before winter....................... 231
Engine immobilizer system .... 108
Engine oil
Capacity ................................ 449
Checking ............................... 336
Preparing and checking
before winter....................... 231
Engine switch .................. 176, 179
EPS ........................................... 224
First-aid kit holder ................... 301
Floor mat .................................. 299
Fluid
Washer ................................. 346
Fog lights
Replacing light bulbs............. 373
Switch ................................... 216
Wattage ................................ 456
Front fog lights
Replacing light bulbs............. 373
Switch ................................... 216
Wattage ................................ 456
Front passenger’s seat belt
reminder light ........................ 399
Front position lights
Replacing light bulbs............. 373
Switch ................................... 211
Wattage ................................ 456
Front seats
Adjustment .............................. 79E
F