fuel pump TOYOTA LAND CRUISER 2012 Owners Manual

TABLE OF CONTENTSIndex
6
L/C200_EE (OM60G38E)
5-1. Essential information
Emergency flashers ............ 564
If your vehicle needs
to be towed ....................... 565
If you think something
is wrong ............................ 571
Fuel pump shut off
system (gasoline engine
only) .................................. 572
5-2. Steps to take in an emergency
If a warning light turns on
or a warning buzzer
sounds... ........................... 573
If a warning message is
displayed .......................... 579
If you have a flat tire
(vehicles with a standard
spare tire) ......................... 596
If you have a flat tire
(vehicles with
an emergency tire
puncture repair kit)............ 610
If the engine
will not start....................... 623
If the shift lever cannot
be shifted from P .............. 625
If you lose your keys ........... 626
If the electronic key
does not operate
properly............................. 627If the battery is
discharged ....................... 630
If your vehicle
overheats ......................... 634
If you run out of fuel and
the engine stalls
(diesel engine only) .......... 637
If the vehicle becomes
stuck................................. 638
If your vehicle
has to be stopped
in an emergency .............. 640
6-1. Specifications
Maintenance data
(fuel, oil level, etc.) ........... 644
Fuel information ................. 662
6-2. Customization
Customizable features ....... 665
6-3. Initialization
Items to initialize................. 674
5When trouble arises
6Vehicle specifications

517 4-3. Do-it-yourself maintenance
4
Maintenance and care
L/C200_EE (OM60G38E)
Fuel filter (diesel engine only)
You may drain the fuel filter yourself. However, as the operation is dif-
ficult, we recommend having it drained by your Toyota dealer. Even if
you decide to drain it yourself, contact your Toyota dealer.
The water in the fuel filter needs to be drained if the fuel system
warning light flashes and a buzzer sounds. (P. 574)
Turn the “ENGINE START STOP” switch OFF.
Place a small tray under the drain plug to catch the water and
any fuel that comes out.
Turn the drain plug counterclock-
wise about 2 to 2 1/2 turns.
Operate the priming pump until
fuel begins to run out.
After draining, tighten the drain plug by hand.
STEP1
STEP2
STEP3
STEP4
STEP5

536 4-3. Do-it-yourself maintenance
L/C200_EE (OM60G38E)
Fuse layout and amperage ratings
Engine compartment
FuseAmpereCircuit
1
A/F*115 A A/F heater
EFI MAIN2*2, *315 A*2
25 A*3VNT DRIVER, EFI, EDU
2HORN10 A Horn
3 EFI MAIN 25 A EFI, A/F heater, fuel pump
4 IG2 MAIN 30 A INJ, IGN, MET
5 RR A/C 50 A No circuit
6 SEAT-A/C LH 25 A Seat heaters and ventilators
7 RR S/HTR 20 A Rear seat heater
8 DEICER 20 A Windshield wiper de-icer
9 CDS FAN 25 A Condenser fan
10 TOW TAIL 30 A No circuit
12 34
5
39 18 19 20 21 22 23 24 25 26
40 41 42 43
44 45 46 47
48 27 28
33 34 31 3229 30 35 36 37
52 53 5455
49 50 515667
68
69
57585960
616263646566 6 7 8 9 10 11 12 13 14 15 16 17
38

538 4-3. Do-it-yourself maintenance
L/C200_EE (OM60G38E)
32A/PUMP
NO.1*150 A AI DRIVER
GLOW1
*2, *380 A Engine glow system
33A/PUMP
NO.2
*150 A No circuit
GLOW2
*2, *380 A Engine glow system
34 MAIN 40 AHeadlight, HEAD LL, HEAD RL,
HEAD LH, HEAD RH
35 ABS1 50 A ABS
36 ABS2 30 A ABS
37 ST 30 A Starter system
38 IMB 7.5 AID code box, smart entry & push
start system, GBS
39 AM2 5 A Main body ECU
40 DOME2 7.5 AVanity lights, overhead module,
rear interior light
41 ECU-B2 5 A Driving position memory system
42 AMP 2 30 A Audio system
43 RSE 7.5 A No circuit
44 TOWING 30 A Towing
45 DOOR NO.2 25 A Main body ECU
46 STR LOCK 20 A Steering lock system
47 TURN-HAZ 15 AMeter, front turn signal lights, side
turn signal lights, rear turn signal
lights, trailer
48EFI MAIN2*120 A Fuel pump
F/PMP*2, *320 A No circuit
FuseAmpereCircuit

5When trouble arises
563
L/C200_EE (OM60G38E)
5-1. Essential information
Emergency flashers .......... 564
If your vehicle needs
to be towed ..................... 565
If you think something
is wrong .......................... 571
Fuel pump shut off
system (gasoline engine
only) ................................ 5725-2. Steps to take in
an emergency
If a warning light turns on
or a warning buzzer
sounds... ......................... 573
If a warning message is
displayed ........................ 579
If you have a flat tire
(vehicles with
a standard spare tire) ..... 596
If you have a flat tire
(vehicles with
an emergency tire
puncture repair kit).......... 610
If the engine
will not start..................... 623
If the shift lever cannot
be shifted from P ............ 625
If you lose your keys ......... 626
If the electronic key
does not operate
properly........................... 627
If the battery is
discharged ...................... 630
If your vehicle
overheats ........................ 634
If you run out of fuel and
the engine stalls
(diesel engine only) ........ 637
If the vehicle becomes
stuck ............................... 638
If your vehicle
has to be stopped
in an emergency ............. 640

572
5-1. Essential information
L/C200_EE (OM60G38E)
Fuel pump shut off system (gasoline engine only)
Follow the procedure below to restart the engine after the system is
activated.
Turn the “ENGINE START STOP” switch to ACCESSORY mode
or OFF.
Restart the engine.
NOTICE
Before starting the engine
Inspect the ground under the vehicle.
If you find that fuel has leaked on to the ground, the fuel system has been
damaged and is in need of repair. Do not restart the engine.
To minimize the risk of fuel leakage when the engine stalls or an air-
bag inflates upon collision, the fuel pump shut off system stops sup-
plying fuel to the engine.
STEP1
STEP2

5
595 5-2. Steps to take in an emergency
When trouble arises
L/C200_EE (OM60G38E)
After changing the engine oil (Diesel engine)
Make sure to reset the oil maintenance data. (P. 507)
NOTICE
While the engine oil level warning is displayed
Continued engine operation with low engine oil will damage the engine.
Engine oil maintenance message (Diesel engine only)
The warning message is based on the projected driving range after engine
oil maintenance message is reset.
The system does not monitor the purity of the engine oil.
If the “DRAIN WATER FROM FUEL FILTER” warning message is dis-
played
Never drive the vehicle if the warning message is displayed. Continued driv-
ing with water accumulated in the fuel filter will damage the fuel injection
pump.

5
637
5-2. Steps to take in an emergency
When trouble arises
L/C200_EE (OM60G38E)
If you run out of fuel and the engine stalls (diesel engine only)
NOTICE
When restarting the engine
Do not crank the engine before refueling and operating the priming pump.
This may damage the engine and fuel system.
If you run out of fuel and the engine dies:
Refuel your vehicle.
Operate the priming pump
until you feel more resistance
to bleed the fuel system.
Start the engine. (
P. 190)
If the engine does not start after the above steps have been per-
formed, wait for 10 seconds and try step 2 and 3 again. If the
engine still does not start, contact any authorized Toyota dealer or
repairer, or another duly qualified and equipped professional.
After starting the engine, depress the accelerator pedal lightly until
the engine runs smoothly.
STEP1
STEP2
STEP3

663 6-1. Specifications
6
Vehicle specifications
L/C200_EE (OM60G38E)
Fuel tank opening for unleaded gasoline
To help prevent incorrect fueling, your Toyota has a fuel tank opening that
only accommodates the special nozzle on unleaded fuel pumps.
If you plan to drive in foreign countries
Low sulfur diesel fuel may not be available, so please confirm the availability
with your distributor.
If your engine knocks
Consult any authorized Toyota dealer or repairer, or another duly quali-
fied and equipped professional.
You may occasionally notice light knocking for a short time while acceler-
ating or driving uphill. This is normal and there is no need for concern.
NOTICE
Notice on fuel quality
Do not use improper fuels. If improper fuels are used the engine will be
damaged.
Gasoline engine: Do not use leaded gasoline.
Leaded gasoline will cause the three-way catalytic converter to lose its
effectiveness and emission control system to function improperly.
Diesel engine: Do not use a fuel that contains more than 50 ppm of sulfur.
Use of such a high sulfur fuel may damage the engine.

682 Alphabetical index
L/C200_EE (OM60G38E)
First-aid kit holder ................... 484
Floor mats ................................ 482
Fluid
Brake..................................... 657
Power steering ...................... 658
Suspension ........................... 658
Washer.................................. 515
Fog lights
Replacing light bulbs ............. 546
Switch ................................... 222
Wattage................................. 661
Four-wheel drive system......... 259
Front fog lights
Replacing light bulbs ............. 546
Switch ................................... 222
Wattage................................. 661
Front passenger’s seat belt
reminder light ........................ 576
Front position lights
Switch ................................... 218
Front seats
Adjustment .............................. 75
Driving position memory ......... 86
Front turn signal lights
Replacing light bulbs ............. 546
Wattage................................. 661
Fuel
Capacity ................................ 648
Fuel gauge ............................ 203
Fuel pump shut off system .... 572
Gas station information ......... 692
If you run out of fuel and
the engine stalls.................. 637
Information ............................ 662
Refueling ............................... 116
Type ...................................... 648Fuel door .................................. 116
Fuel filler door.......................... 116
Fuel pump shut off system ..... 572
Fuses ........................................ 531
Gas station information .......... 692
Gauges ..................................... 203
Glove box ................................. 453
Glove box light......................... 453
Hands-free system
(for cellular phone)
*............. 418
Hazard lights
Switch ................................... 564
Head restraints
Adjusting ................................ 91
Headlight cleaner..................... 232
Headlights
Daytime running light ............ 219
Replacing light bulbs............. 546
Switch ................................... 218
Wattage ................................ 661
Heaters
Heated steering .................... 474
Seat heater ........................... 476
Side mirror ............................ 356
Height select ............................ 248
Hill-start assist control............ 300
Hood ......................................... 501
F
G
H