steering TOYOTA RAIZE 2023 Service Manual

2324-5. Using the driving support systems
RAIZE_OM_General_BZ358E
Driving assist systems
The following devices automatically operate according to the driving
conditions to improve driving safety and performance. However,
these systems are supplementary and you should be careful not to
over-rely on them while driving.
◆ABS (Anti-lock Brake System)
Helps to prevent wheel lock when the brakes are applied suddenly, or if
the brakes are applied while driving on a slippery road surface.
◆Brake assist
Generates an increased level of braking force when the system detects a
panic stop situation.
◆VSC (Vehicle Stability Control)
Helps the driver to control skidding when swerving suddenly or turning on
slippery road surfaces.
◆TRC (Traction Control)
Helps to maintain drive power and pr event the drive wheels from spinning
when starting the vehicle or accelerating on slippery roads.
◆Hill-start assist control
Prevents the vehicle from moving backwards when starting on an uphill.
◆EPS (Electric Power Steering)
Uses an electric motor to assist steering operation.
◆Emergency brake signal
Emergency flashers automatically fl ash when braking suddenly, alerting
the following vehicle and reducing the possibility of a collision.
RAIZE_OM_General_BZ358E.book 232 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2344-5. Using the driving support systems
RAIZE_OM_General_BZ358E
⬛Activation of ABS/VSC
ABS/VSC does not work at low speeds. The operation is the same as the nor-
mal brake.
⬛Activation sound and vibration of the ABS, brake assist, VSC, TRC, and hill-
start assist control
⚫A sound may be heard from the engine compartment when the brake pedal
is depressed repeatedly, when the engine is started or just after the vehicle
begins to move. This sound does not indicate that a malfunction has
occurred in any of these systems.
⚫Any of the following conditions may occur when the above systems are oper-
ating. None of them indicates that a malfunction has occurred.
⦁ Vibrations may be felt through th e vehicle body and steering wheel
⦁ A motor sound may be heard even after the vehicle has come to a stop
⦁ The brake pedal may pulsate slightly after the ABS is activated
⦁ The brake pedal may move down slightly after the ABS is activated
⬛EPS motor operation sound
When the steering wheel is operated, a motor sound (whirring sound) may be
heard, but this does not indicate a malfunction.
⬛Automatic reactivation of VSC and TRC
After turning the TRC and VSC systems off, the systems will return to the ready
state in the following situations:
⚫When the engine switch is turned to “OFF”
⚫If only the TRC system is turned off, when vehicle speed increases
If both the TRC and VSC systems are tu rned off, automatic reactivation will
not occur when vehicle speed increases.
⬛Reduced effectiveness of the EPS system
The effectiveness of the EPS system is reduced to prevent the system from
overheating when there is frequent steering input over an extended period of
time. The steering wheel ma y feel heavy as a result.
Should this occur, refrain from excessive steering input or stop the vehicle and
turn the engine off. It should re turn to normal within 10 minutes.
RAIZE_OM_General_BZ358E.book 234 ページ ２０２２年５月１７日　火曜日　午後１時５９分

238
RAIZE_OM_General_BZ358E
4-6. Driving tips
Winter driving tips
Carry out the necessary preparations and inspections before driving
the vehicle in winter. Always drive the vehicle in a manner appropri-
ate to the prevailing weather conditions.Preparation for winter
⚫Use fluids that are appropriate to the prevailing outside temperatures.
⦁ Engine oil
⦁ Coolant
⦁ Washer fluid
⚫Have a service technician inspec t the condition of the battery.
Before driving
Perform the following according to the driving conditions:
⚫Do not try to forcibly open a window or move a windshield wiper that is
frozen. Pour warm water over the frozen area to melt the ice. Wipe away
the water immediately to prevent it from freezing.
⚫To ensure proper operation of the air conditioning system fan, remove
any snow that has accumulated on the air inlet vents in front of the
windshield.
⚫Check for and remove any excess ice or snow that may have accumu-
lated on the exterior lights, vehicle’s roof, around the tires or on the
brakes.
⚫Look under the vehicle and check that there are no ice blocks around
the ground. Remove any attached ice blocks with great care to avoid
damaging vehicle components. Also check that the pedals and steering
wheel move smoothly.
⚫Remove any snow or mud from the bottom of your shoes before getting
in the vehicle.
RAIZE_OM_General_BZ358E.book 238 ページ ２０２２年５月１７日　火曜日　午後１時５９分

243
5
RAIZE_OM_General_BZ358E
Interior features
5-1. Using the air conditioning system and defogger
Manual air conditioning system
(Type A) ..................................... 244
Manual air conditioning system (Type B) ..................................... 248
Automatic air conditioning system ....................................... 254
5-2. Using the audio system
Steering switches ...................... 262
5-3. Using the interior light
Interior lights list ....................... 263
5-4. Storage features
List of storage features ............ 266
Luggage compartment features..................................... 271
5-5. Using the other interior features
Other interior features ............. 276
RAIZE_OM_General_BZ358E.book 243 ページ ２０２２年５月１７日　火曜日　午後１時５９分

262
RAIZE_OM_General_BZ358E✽
: If equipped
5-2. Using the audio system
Steering switches✽
The audio system can be operated with the switches on the steering
wheel.
The operation may differ dependin g on the audio your vehicle has.
For details, refer to the in cluded instruction manual.
Locations of the switches vary acco rding to the vehicle grade level, etc.
WARNING
⬛To prevent an accident
Take extra care when operating the steering switches while driving.
KBRO520101E
RAIZE_OM_General_BZ358E.book 262 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2886-1. Maintenance and care
RAIZE_OM_General_BZ358E
NOTICE
✽: If equipped
⬛When using a high pressure car wash
⚫Do not splash water directly to the cameras✽ or their surrounding area using
a high-pressure washer during a car wash. The high water pressure adds
stress and may prevent the equipment from working properly.
⚫Do not bring the nozzle tip close to the coupling parts, boots (rubber or resin
covers) and connectors of the following parts.
The parts may be damaged if they come into contact with high pressure
water.
⦁ Drive system parts
⦁ Steering parts
⦁ Suspension parts
⦁ Brake parts
⚫Resin parts, such as moldings and bumpers, may be deformed and dam-
aged, so keep the cleaning nozzle at le ast 30 cm (11.9 in.) away from the
vehicle body. Also, do not continuous ly spray water in the same place.
⚫Do not spray the lower part of the windshield continuously. If water enters
the air conditioning system intake loca ted there, the air conditioning system
may not operate correctly.
RAIZE_OM_General_BZ358E.book 288 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2966-2. Maintenance
RAIZE_OM_General_BZ358E
FUEL AND EMISSION CONTROL SYSTEMS
12Fuel filter*3R96
13Air cleaner filterIRIRI: 24
R: 48
14
Fuel tank cap, fuel
lines, connections
and fuel vapor con-
trol valve*
2
II24
15Charcoal canisterII24
CHASSIS AND BODY
16Clutch pedal
(1KR-VET engine)IIIIIIII12
17Clutch pedal
(WA-VE engine)IIIIIIII12
18Brake pedal and
parking brakeIIIIIIII6
19
Brake linings and
drums (include park-
ing brake linings and
drums)
IIII12
20Brake pads and discsIIII6
21Brake fluidIIIRIIIRI: 6
R: 24
22Clutch fluid
(1KR-VET engine)IIIRIIIRI: 6
R: 24
23Brake pipes and
hosesIIII12
24
Steering wheel, link-
age and steering
gear box
IIII12
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 1 1020304050607080
x1000 miles 1 6 12 18 24 30 36 42 48
RAIZE_OM_General_BZ358E.book 296 ページ ２０２２年５月１７日　火曜日　午後１時５９分

2986-2. Maintenance
RAIZE_OM_General_BZ358E
Additional maintenance schedule (except for Mexico)
Refer to the following table for normal maintenance schedule items
requiring more frequent service specific to the type of severe conditions.
(For outline, see “Maintenan ce schedule requirements”.)
A-1: Operating on rough or muddy roads, or roads with melted snow
Inspection*1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection*1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 of brake pipes and hosesEvery 10000 km (6000 miles) or 6
months
Inspection*1 of steering wheel, linkage
and steering gear boxEvery 5000 km (3000 miles) or 3
months
Inspection*1 of suspension ball joint and
dust coverEvery 10000 km (6000 miles) or 6
months
Inspection*1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection*1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body*
2
Every 10000 km (6000 miles) or 6
months
A-2: Operating on dusty ro ads (Roads in areas where their pavement rate is
low, or a cloud of dust ofte n arises and the air is dry.)
Replacement of engine oil
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Replacement of engine oil filter
(WA-VE engine)Every 5000 km (3000 miles) or 3
months
Replacement of engine oil filter
(1KR-VET engine)Replace when the maintenance
reminder appears.*
3
Inspection*1 or replacement of air cleaner
filter
I: Every 2500 km (1500 miles) or 3 months
R: Every 20000 km (12000 miles) or 48 months
RAIZE_OM_General_BZ358E.book 298 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3026-2. Maintenance
RAIZE_OM_General_BZ358E
CHASSIS AND BODY
13
Brake linings and
drums (include park-
ing brake linings and
drums)
IIII12
14Brake pads and discsIIII6
15Brake fluidIIIRIIIRI: 6
R: 24
16Clutch fluidIIIRIIIRI: 6
R: 24
17Brake pipes and
hosesIIII12
18
Steering wheel, link-
age and steering
gear box
IIII12
19Drive shaft bootsIIIIIIII6
20Suspension ball joint
and dust coverIIII12
21
Manual transmis-
sion oil (including
front differential)
IRI: 48
R: 96
22
Continuously varia-
ble transmission
fluid (including front
differential)
Inspect every 12 months, Replace every
100000 km (60000 miles)―
23Front and rear sus-
pensionIIII12
24Front wheel align-
ment (toe-in)II48
25Air conditioning filterRRRR24
SERVICE
INTERVAL:ODOMETER READING
MONTHS
(Odometer reading or months,
whichever
comes first.) x1000
km 10 20 30 40 50 60 70 80
x1000 miles 6 12182430364248
RAIZE_OM_General_BZ358E.book 302 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3036-2. Maintenance
RAIZE_OM_General_BZ358E
Maintenance and care
6
REMARKS: See page 306 for general maintenance items.
*1Replace both the engine oil and oil filter, even when the maintenance
reminder does not appear, after 6 mont hs have passed, since the last oil
change.
*2After 80000 km (48000 miles) or 48 months inspection, inspect every 20000
km (12000 miles) or 12 months.
*3Including the filter in fuel tank.
Additional maintenance schedule (For Mexico)
Refer to the following table for normal maintenance schedule items
requiring more frequent service specific to the type of severe conditions.
(For outline, see “Maintenan ce schedule requirements”.)
A-1: Operating on rough or muddy roads, or roads with melted snow
Inspection*
1 of brake linings and drums
(include parking brake linings and drums)Every 10000 km (6000 miles) or 6
months
Inspection* 1 of brake pads and discsEvery 10000 km (6000 miles) or 3
months
Inspection*1 of brake pipes and hosesEvery 10000 km (6000 miles) or 6
months
Inspection*1 of steering wheel, linkage
and steering gear boxEvery 5000 km (3000 miles) or 3
months
Inspection* 1 of suspension ball joint and
dust coversEvery 10000 km (6000 miles) or 6
months
Inspection* 1 or replacement of continu-
ously variable transmission fluid (includ-
ing front differential)I: Every 5000 km (3000 miles) or 3 months
R: Every 50000 km (30000 miles)
Inspection* 1 of front and rear suspensionEvery 10000 km (6000 miles) or 6
months
Tightening of bolts and nuts on chassis
and body
*2Every 10000 km (6000 miles) or 6
months
A-2: Operating on dusty ro ads (Roads in areas where their pavement rate is
low, or a cloud of dust ofte n arises and the air is dry.)
Replacement of engine oilReplace when the maintenance
reminder appears.
*
3
RAIZE_OM_General_BZ358E.book 303 ページ ２０２２年５月１７日　火曜日　午後１時５９分