steering TOYOTA RAIZE 2023 Repair Manual

3917-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E ✽
: If equipped
When trouble arises
7
“Fasten Seat Belt”
Rear seat belt is not fastened
The warning buzzer will sound.
It will be displayed when the vehicle speed
exceeds approx. 20 km/h (12 mph) and the
seat belt is unfastened.
➞ Wear a seat belt
“Release Parking
Brake”
The parking brake is not released
If the vehicle speed exceeds approx. 5 km/h
(3 mph) with the parking brake being
applied, the warning buzzer will sound.
➞ Release the parking brake
“Sonar Sensor in Oper-
ation Pay Attention”―
Front corner sensors or reverse sensors is
activated
✽
The activated sonar is displayed.
The warning buzzer may sound.
➞ Check the situation around you and drive
accordingly such as stepping on the
brake pedal
“VSC in Operation”
(Flashing)
VSC is activated
➞Drive with extreme caution
“Turn Lights OFF”
The driver’s door was opened while the
front position lights are turned on
The warning buzzer will sound.
➞ Turn off the front position lights
“Steering Angle Left”
―
The steering wheel is mo ved to left or right
while the vehicle is stopped
➞ Check the tire direction and move the
vehicle safety
“Steering Angle Right”
“Roads may be Icy”―
The outside temperature has become
approx. 3°C (37 ℉) or below
➞ Since the road could be frozen, check the
road condition and drive with extreme
caution
Warning messages
Indicators/
Warning lights
Warning content/Action to take
RAIZE_OM_General_BZ358E.book 391 ページ ２０２２年５月１７日　火曜日　午後１時５９分

3957-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
*1If the engine does not start even when the electronic key is placed inside the
vehicle, it is possible that the key is running out of battery. ( ➞P. 344)
*2If the low battery state continues, the message also appears even when the
engine switch is turned to “ACC” or “ON”.
⬛Warning messages
➞ P. 3 9 2
⬛Warning message display
➞P. 3 9 2
⬛Warning buzzers
Depending on the situation, you ma y have difficulty hearing the buzzer
because of the noise outside or audio sound.
――
“Press Engine SW While
Turning Steering Right
and Left”
Unable to unlock the steering
wheel by pressing the engine
switch
➞ Step on the brake pedal and
press the engine switch while
turning the steering wheel right
and left
――“Shift to P and Turn Power
OFF”
You tried to turn “OFF” the engine
switch while the shift lever is placed
in a position other than P
✽
➞Set the shift lever to P
―1 time“Turn Power OFF”
When the engine switch was “ACC”
or “ON”, someone tried to lock the
doors using the lock/unlock switch
on the front or back door
➞ Turn the engine switch to “OFF”
and lock the doors
Internal
warning buzzerExternal
warning buzzer
Warning messagesWarning content/Action to take
RAIZE_OM_General_BZ358E.book 395 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4057-2. Steps to take in an emergency
RAIZE_OM_General_BZ358E
When trouble arises
7
If the engine does not start
If the engine does not start even though correct starting procedures
are being followed ( ➞P. 184), consider each of the following points:
The engine does not start even though the starter motor operates
normally
One of the following may be the cause of the problem:
⚫There may not be sufficient fuel in the vehicle’s tank.
Refuel the vehicle.
⚫The engine may be flooded.
Try to restart the engine again fo llowing correct starting procedures
( ➞ P. 1 8 4 ) .
⚫There may be a malfunction in th e engine immobilizer system. (➞P. 72)
The starter motor runs slowly, the interior light and headlights are
dim, or the horn does not so und or sounds at a low volume
One of the following may be the cause of the problem:
⚫The battery may be discharged. ( ➞P. 408)
⚫The battery terminal connections may be loose.
If the starter does not operat e (vehicles with key-free system)
⚫There may be an issue in the electrical system, such as a disconnected
electrical component or blown fuse. Depending on the cause, you may
be able to start the engine using temporary measures. ( ➞P. 406)
⚫There may be a malfunction in the steering wheel lock system.
The starter motor does not run, the interior light and headlights do
not turn on, or the horn does not sound
One of the following may be the cause of the problem:
⚫There may be a disconnected battery terminal.
⚫The battery may be discharged. ( ➞P. 408)
Contact your Toyota dealer if the procedures are not clear, or if the engine does not
start even after the measures have been taken.
RAIZE_OM_General_BZ358E.book 405 ページ ２０２２年５月１７日　火曜日　午後１時５９分

4278-1. List of specifications
RAIZE_OM_General_BZ358E✽
: If equipped
Vehicle information
8
Clutch
Brakes
*1Minimum pedal clearance when depressed with a force of 294 N (30 kgf, 66
lbf) while the engine is running
*2Parking brake lever travel when pulled up wi th a force of 196 N (20 kgf, 44 lbf)
Steering
Pedal free play
▶WA-VE engine
19.0 - 30.0 mm (0.75 - 1.18 in.)
▶1KR-VET engine
5.9 - 18.3 mm (0.23 - 0.72 in.)
Fluid type✽FMVSS No. 116 DOT 3
Pedal clearance*188 mm (3.5 in.)
Pedal free play0.5 - 2.0 mm (0.02 - 0.08 in.)
Parking brake lever
travel*25 - 8 clicks
Fluid typeFMVSS No.116 DOT 3
Free playLess than 10 mm (0.4 in.)
RAIZE_OM_General_BZ358E.book 427 ページ ２０２２年５月１７日　火曜日　午後１時５９分

437What to do if... (Troubleshooting)
RAIZE_OM_General_BZ358E
If you think something is wrong
The engine does not start (vehicles without key-free system)
⚫Continuously variable transmission vehicles
Is the shift lever in P? (➞P. 180)
⚫Manual transmission vehicles
Did you turn the engine switch while firmly depressing the clutch pedal?
(➞ P. 1 8 0 )
⚫Isn’t the steering wheel locked? ( ➞P. 182)
⚫Isn’t the battery discharged? ( ➞P. 408)
The engine does not start (vehicles with key-free system)
⚫Continuously variable transmission vehicles
Did you press the engine switch while firmly depressing the brake
pedal? ( ➞P. 184)
⚫Manual transmission vehicles
Did you press the engine switch wh ile firmly stepping on the clutch
pedal? ( ➞P. 184)
⚫Continuously variable transmission vehicles
Is the shift lever in P? ( ➞P. 184)
⚫Is the key anywhere detectable inside the vehicle? ( ➞P. 122)
⚫Isn’t the steering wheel locked? ( ➞P. 187)
⚫Is the key battery weak or depleted?
In this case, the engine can be started in a temporary way. ( ➞P. 406)
⚫Isn’t the battery discharged? ( ➞P. 408)
RAIZE_OM_General_BZ358E.book 437 ページ ２０２２年５月１７日　火曜日　午後１時５９分

438What to do if... (Troubleshooting)
RAIZE_OM_General_BZ358E
✽: If equipped
The shift lever cannot be moved from P even if you depress
the brake pedal (continuously variable transmission vehicles)
⚫Is the engine switch “ON”?
If you cannot release the shift lever while depressing the brake pedal
with the engine switch “ON”, refer to ➞P. 191.
The steering wheel cannot be turned after the engine is
stopped
⚫Vehicles without key-free system
To prevent theft, it will be locked when the key is removed from the
engine switch. (➞ P. 181)
⚫Vehicles with key-free system
It is automatically locked to prevent theft of the vehicle. ( ➞P. 187)
The windows do not open or close by operating the power
window switches
⚫Isn’t the window lock switch pressed?
If the window lock switch is pressed, the power windows except for the
one at the driver’s seat cannot be operated. ( ➞P. 160)
The engine switch is turned off automatically
(vehicles with key-free system)
⚫The auto power OFF function will be operated if the vehicle is left “ACC”
or “ON” (the engine is not r unning) for a period of time. ( ➞P. 186)
A warning light or warning message
✽ comes on
⚫If a warning light or warning message comes on, refer to ( ➞P. 379, 387).
RAIZE_OM_General_BZ358E.book 438 ページ ２０２２年５月１７日　火曜日　午後１時５９分

440
RAIZE_OM_General_BZ358E
Alphabetical index
Alphabetical index
A
ABS (Anti-lock Brake System)........ 232
Air conditioning system Automatic air conditioning system ......................................... 254
Changing the filter ...................... 338
Manual air conditioning system .......... ...................... 244, 248
Airbags .................................................. 37
Arrangement .................................. 37
Conditions for deployment ......... 43
SRS airbag warning light............ 380
Alarm ..................................................... 73
Antenna .............................................. 284
Anti-clip system Power windows ............................ 160
Assist grips ......................................... 281
Auto lighting (automatic light on/off function) .............................. 198
Auto lock and unlock function ..... 136
Automatic air conditioning system .............................................. 254
Automatic light control system .... 198
Automatic light off system ............ 200
Average fuel economy ...................... 90
B
Baby seats............................................ 49
Back door ........................................... 142
Back-up lights
Replacing light bulbs .................. 352
Watts .............................................. 428
Battery ................................................. 321
If the vehicle battery is discharged ................................. 408
Preparation and inspection
before winter ............................. 238 To prevent battery discharge ... 411
Battery replacement (key) ............. 344
Bottle holder ...................................... 268
Brake assist ........................................ 232
Function ......................................... 232
Slip indicator ................................. 380
Brake fluid .......................................... 427
Brakes Brake system warning light....... 379
Maintenance data ....................... 427
Parking brake ............................... 197
BSM (Blind Spot Monitor) .............. 211
Buzzer
Automatic light-off .. ...........200, 391
Brakes .......... ..................... ....379, 387
BSM (Blind Spot Monitor) .......... 211
Driver’s seat belt
reminder ...... ......................381, 390
Driving with the parking
brake not released ..........382, 391
Electric power steering .....380, 388
Front corner sens ors .........222, 391
Front passenger’s seat belt reminder ...... ......................381, 390
Key removal reminder ................ 182
Key-free system ... ...............123, 393
RCTA (Rear Cross Traffic Alert) ......... 218
Rear seat belt reminder ....381, 391
Reverse .......................................... 193
Reverse sensors...... ............222, 391
when a door is not fully
closed .......... .......................381, 390
RAIZE_OM_General_BZ358E.book 440 ページ ２０２２年５月１７日　火曜日　午後１時５９分

441Alphabetical index
RAIZE_OM_General_BZ358E
C
Carpet.................................................. 290
Cleaning......................................... 290
How to install floor mats.............. 28
Change lever (shift lever) Continuously variable
transmission .............................. 189
Manual transmission .................. 194
Reverse warning buzzer ............ 193
Shift lever cannot be shifted ..... 191
Child restraint system ....................... 49
How to install.................................. 60
How to select .................................. 49
Installing using ISOFIX attachment points ...................... 63
Securing it with a seat belt .......... 61
Child-protector lock ......................... 135
Clean air filter .................................... 338
Cleaning Seat belts....................................... 290
Vehicle exterior ............................ 284
Vehicle interior ............................. 289
Cleaning and protecting Seat belts....................................... 290
Vehicle exterior ............................ 284
Vehicle interior ............................. 289
Clips
Floor mats ....................................... 28
Clock ............................................... 86, 98
Clock adjustment ...................... 88, 105
Condenser .......................................... 320
Continuously variable transmission Shift lever cannot be shifted ..... 191
Coolant
Checking ........................................ 319
Maintenance data ....................... 425
Preparation and inspection before winter ............................. 238
Cruising distance ................................ 90
Cup holder ......................................... 268
Curtain shield airbag ......................... 37
Customizations ................................. 430
D
D assist switching steering
switch ................................................ 190
Daytime running lights ................... 198
Deck board ......................................... 271
Deck board under tray ................... 272
Defogger
Rear window defogger ......249, 256
Windshield .... .......................249, 256
Dimensions ........................................ 418
Do-it-yourself service precautions ..................................... 309
Door handle (outer handle) .......... 133
Door linked (Illuminated entry system) ......... 264
Door pocket ....................................... 270
Door windows ................................... 160
Doors ................................................... 133
Auto lock and unlock
function....................................... 136
Child-protector lock .................... 135
Door pockets ................................ 270
Door windows .............................. 160
Inside lock button (power door lock)...................... 134
Key-free system ........................... 121
Open door warning light ........... 381
Wireless remote control ............ 131
RAIZE_OM_General_BZ358E.book 441 ページ ２０２２年５月１７日　火曜日　午後１時５９分

442Alphabetical index
RAIZE_OM_General_BZ358E
Driving................................................. 166
Correct driving posture................ 30
Eco-friendly driving ..................... 169
Procedures ................................... 166
Winter driving tips ....................... 238
Driving on flooded roads ............... 176
E
eCall....................................................... 68
Electric power steering ................... 232
Electronic key
Not working properly ................. 406
Operating range .......................... 122
Running out of the key battery......................................... 406
Emergency brake signal (emergency stop signal) .............. 232
Emergency flashers (hazard lights) ................................ 366
Replacing light bulbs .................. 352
Switch ............................................. 366
Watts .............................................. 428
Emergency key
(mechanical key) ............................ 118
Emergency seat belt fixing mechanism ....................................... 33
Emergency stop signal (emergency brake signal) ........... 232
Ending screen ................................... 103
Engine Compartment ............................... 315
Engine switch ......... ............. 180, 184
Hood............................................... 311
How to start ......... ................ 180, 184
Identification number................. 420
Ignition switch ..... ................ 180, 184
Malfunction indicator lamp ....... 379
Overheating .................................. 412
The engine does not start ......... 405
Engine oil ............................................ 420
Checking ........................................ 316
Engine oil deterioration warning light.............................. 382
Engine oil deterioration warning reset ..................... 94, 112
Low engine oil pressure
warning indicator ..................... 379
Maintenance data ....................... 420
Preparation and inspection before winter ............................. 238
Engine switch Operation method .. ...........180, 184
Event Data Recorder (EDR) ................ 7
Exhaust gas .......................................... 47
Exterior light bulbs .......................... 352
Replacement procedure ............ 352
Watts .............................................. 428
F
Fire extinguisher .............................. 369
Floor jack ............................................ 314
Floor mats ............................................ 28
Fluid Brake .............................................. 427
Clutch ............................................. 427
Continuously variable
transmission .............................. 426
Manual transmission .................. 426
Fog lights ............................................ 201
Replacing light bulbs .................. 352
Switch ............................................. 201
Watts .............................................. 428
Front corner sensors ....................... 221
Front passenger’s seat belt
reminder warning light ............... 381
RAIZE_OM_General_BZ358E.book 442 ページ ２０２２年５月１７日　火曜日　午後１時５９分

446Alphabetical index
RAIZE_OM_General_BZ358E
Meter (gauges and meters)............ 84
Display change button .......... 87, 99
Indicators ........................................ 81
Multi-information display............. 86
TFT color mult i-information
display ........................................... 98
Warning lights .............................. 379
Mirrors
Inside rear view mirror............... 156
Outside rear view mirrors ......... 157
Vanity mirror................................. 276
Multi-information display ................ 86
O
Oils....................................................... 418
Capacity and brand of oils ......... 418
Open tray ........................................... 270
Opener Back door ...................................... 142
Fuel tank cap ................................ 209
Hood............................................... 311
Opening screen ................................ 103
Outer handle (door handle) .......... 133
Outside rear view mirrors ............. 157
Adjustment ................................... 157
Automatic mode .......................... 158
BSM (Blind Spot Monitor) .......... 211
Operation ...................................... 157
Outside temperature indication .... 91
Overheating ....................................... 412
P
Parking brake .................................... 197
Maintenance data ....................... 427
Non-release
warning buzz er ................382, 391
Operation ...................................... 197
Parking brake non release
warning light.............................. 382
Power door lock
(inside lock button) ....................... 134
Power mode ...................................... 190
Power outlet ...................................... 277
Power steering system Electric power steering system warning light.............................. 380
Power windows ................................ 160
Jam protection function ............. 160
Operation ...................................... 160
Unable to close ............................ 161
Window lock switch (Power window OFF switch).... 160
Preparation before winter (Winter driving tips) ...................... 238
Procedure to connect the jumper
cables ................................................ 408
Push-button start switch ................ 184
R
Radiator
Overheating .................................. 412
Radiator (cooling system) .............. 320
Maintenance data ....................... 425
Overheating .................................. 412
Rear seat belt reminder warning
light ................................................... 381
RAIZE_OM_General_BZ358E.book 446 ページ ２０２２年５月１７日　火曜日　午後１時５９分