coolant TOYOTA xD 2009 (in English) User Guide

233
If you are a skilled do−it−yourself
mechanic, the Scion service manuals are
recommended. Please be aware that
do− it−yourself maintenance can affect your
warranty coverage. See “Owner ’s Warranty
Information Booklet” or “Owner ’s Manual
Supplement” for details.
General maintenance
Listed below are the general maintenance
items that should be performed as fre-
quently as specified. In addition to check-
ing the items listed, if you notice any
unusual noise, smell or vibration, you
should investigate the cause or take your
vehicle to your Scion dealer or a qualified
service shop immediately. It is recom-
mended that any problem you notice be
brought to the attention of your dealer or
the qualified service shop for their advice.
CAUTION
Make these checks only with ade-
quate ventilation if you run the en-
gine.
IN THE ENGINE COMPARTMENT
Items listed below should be checked
from time to time, e.g. each time when
refueling.
Washer fluid
Make sure there is sufficient fluid in the
tank. See page 263 for additional informa-
tion. Engine coolant level
Make sure the coolant level is between
the “FULL” and “LOW” lines on the see
−
through reservoir when the engine is cold.
See page 248 for additional information.
Radiator, condenser, and hoses
Check that the front of the radiator and
condenser are clean and not blocked with
leaves, dirt or insects. See page 249 for
additional information.
Battery electrolyte level
Your Scion has a maintenance free bat-
tery. You do not have to add distilled wa-
ter. For longer life of the battery, however,
see page 261 for additional information.
Brake fluid level
Make sure the brake fluid level is correct.
See page 249 for additional information.
Engine oil level
Check the level on the dipstick with the
engine turned off and the vehicle parked
on a level spot. See page 246 for addi-
tional information.

235
Tire inflation pressure
Check the pressure with a gauge ev-
ery two weeks, or at least once a
month. See page 250 for additional
information.
Tire surface and wheel nuts
Check the tires carefully for cuts,
damage or excessive wear. See page
252 for additional information. When
checking the tires, make sure no nuts
are missing, and check the nuts for
looseness. Tighten them if necessary.
Tire rotation
Rotate the tires
according to the
maintenance schedule. (For sched-
uled maintenance information, please
refer to the “Scheduled Maintenance
Guide” or “Owner ’s Manual Supple-
ment”.) See page 254 for additional
information.
Be on the alert for changes in perfor-
mance, sounds, and visual tip −offs that
indicate service is needed. Some impor-
tant clues are as follows:
Engine missing, stumbling, or pinging
Appreciable loss of power
Strange engine noises
A fluid leak under the vehicle (however,
water dripping from the air conditioning
after use is normal.)
Change in exhaust sound (This may
indicate a dangerous carbon monoxide
leak. Drive with the windows open and
have the exhaust system checked im-
mediately.)
Flat −looking tire; excessive tire squeal
when cornering; uneven tire wear
Vehicle pulls to one side when driving
straight on a level road
Strange noises related to suspension
movement
Loss of brake effectiveness; spongy
feeling brake or clutch pedal; pedal al-
most touches floor; vehicle pulls to one
side when braking
Engine coolant temperature continually
higher than normal If you notice any of these clues, take your
vehicle to your Scion dealer as soon as
possible. It probably needs adjustment or
repair.
CAUTION
Do not continue driving with the ve-
hicle unchecked. It could result in se-
rious vehicle damage and possibly
personal injury.
Does your vehicle need
repairing?

238
Engine compartment overview
1. Windshield washer fluid tank
2. Engine oil filler cap
3. Brake fluid reservoir
4. Fuse block
5. Battery
6. Radiator
7. Condenser
8. Electric cooling fan
9. Engine coolant reservoir
10. Engine oil level dipstick

240
CAUTION
When the engine is running, keep
hands, clothing, and tools away
from the moving fan and engine
drive belts. (Removing rings,
watches, and ties is advisable.)
Right after driving, the engine
compartment—the engine, radiator,
exhaust manifold and spark plug
boots, etc.—will be hot. So be care-
ful not to touch them. Oil, fluids
and spark plugs may also be hot.
If the engine is hot, do not remove
the radiator cap or loosen the drain
plugs to prevent burning yourself.
Do not leave anything that may
burn easily, such as paper or rags,
in the engine compartment.
Do not smoke, cause sparks or al-
low open flames around fuel or the
battery. Their fumes are flammable.
Be extremely cautious when work-
ing on the battery. It contains poi-
sonous and corrosive sulfuric acid.
Do not get under your vehicle with
just the body jack supporting it. Al-
ways use automotive jack stands or
other solid supports.
Be sure that the engine switch is
off if you work near the electric
cooling fans or radiator grille. With
the engine switch on, the electric
cooling fans will automatically start
to run if the engine coolant temper-
ature is high and/or the air condi-
tioning is on.
Use eye protection whenever you
work on or under your vehicle
where you may be exposed to flying
or falling material, fluid spray, etc.
Used engine oil contains potentially
harmful contaminants which may
cause skin disorders such as in-
flammation or skin cancer, so care
should be taken to avoid prolonged
and repeated contact with it. To re-
move used engine oil from your
skin, wash thoroughly with soap
and water.
Do not leave used oil within the
reach of children.
Dispose of used oil and filter only
in a safe and acceptable manner.
Do not dispose of used oil and fil-
ter in household trash, in sewers or
onto the ground. Call your dealer or
a service station for information
concerning recycling or disposal.
Take care when filling the brake and
clutch reservoirs because brake or
clutch fluid can harm your hands or
eyes. If fluid gets on your hands or
in your eyes, flush the affected area
with clean water immediately. If you
still feel uncomfortable with your
hands or eyes, go to the doctor.

241
NOTICE
Remember that battery and ignition
cables carry high currents or volt-
ages. Be careful of accidentally
causing a short circuit.
 Add only “Toyota Super Long Life
Coolant” or similar high quality eth-
ylene glycol based nonsilicate,
nonamine, nonnitrite, and nonbo-
rate coolant with longlife hybrid
organic acid technology to fill the
radiator. “Toyota Super Long Life
Coolant” is a mixture of 50% cool-
ant and 50% deionized water.
 If you spill some of the coolant, be
sure to wash it off with water to
prevent it from damaging the parts
or paint.
 Do not allow dirt or anything else
to fall through the spark plug holes.
 Use only spark plugs of the speci-
fied type. Using other types will
cause engine damage, loss of per-
formance or radio noise.
 Do not overfill automatic transmis-
sion fluid and power steering fluid,
or the transmission and power
steering could be damaged.
Do not drive with the air cleaner
filter removed, or excessive engine
wear could result. Also backfiring
could cause a fire in the engine
compartment.
 Be careful not to scratch the glass
surface with the wiper frame.
 When closing the engine hood,
check to see that you have not for-
gotten any tools, rags, etc.
Parts and tools
Here is a list of parts and tools you will
need to perform do −it−yourself mainte-
nance. Remember all Scion parts are de-
signed in metric sizes, so your tools must
be metric.
CHECKING THE ENGINE OIL LEVEL
Parts (if level is low):
“Genuine Motor Oil” or equivalent. See
page 247 for details about engine oil
selection.
Tools:
Rag or paper towel
Funnel (only for adding oil)
CHECKING THE ENGINE COOLANT
LEVEL
Parts (if level is low):
“Toyota Super Long Life Coolant” or
similar high quality ethylene glycol
based non −silicate, non −amine, non− ni-
trite, and non −borate coolant with long −
life hybrid organic acid technology.
“Toyota Super Long Life Coolant” is a
mixture of 50% coolant and 50% deion-
ized water.
Tools:
Funnel (only for adding coolant)

245
DOITYOURSELF MAINTENANCE
Engine and Chassis
Checking the engine oil level246
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the engine coolant level 248
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking the radiator and condenser 249
. . . . . . . . . . . . . . . . . . . . . . . . .
Checking brake fluid 249
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . .
Checking tire inflation pressure 250
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Checking and replacing tires 252
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Rotating tires 254
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . . . . . .
Installing snow tires and chains 255
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Replacing wheels 256
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . \
. . . . . . .
SECTION 7 2

248
Look at the seethrough coolant reser-
voir when the engine is cold. The cool-
ant level is satisfactory if it is between
the “FULL” and “LOW” lines on the
reservoir. If the level is low, add cool-
ant. (For the coolant type, see “Coolant
type selection” described below.)
The coolant level in the reservoir will vary
with engine temperature. However, if the
level is on or below the “LOW” line, add
coolant. Bring the level up to the “FULL”
line.
If the coolant level drops within a short
time after replenishing, there may be a
leak in the system. Visually check the
radiator, hoses, engine coolant filler cap,
radiator cap and drain cock and water
pump.
If you can find no leak, have your Scion
dealer test the cap pressure and check
for leaks in the cooling system.
CAUTION
To prevent burning yourself, do not
remove the radiator cap when the en-
gine is hot.
Coolant type selection
Use of improper coolants may damage
your engine cooling system.
Only use “Toyota Super Long Life Coolant”
or similar high quality ethylene glycol
based non−silicate, non −amine, non −nitrite,
and non −borate coolant with long −life hy-
brid organic acid technology. (Coolant with
long− life hybrid organic acid technology is
a combination of low phosphates and or-
ganic acids.)
“Toyota Super Long Life Coolant” is a mix-
ture of 50% coolant and 50% deionized
water. This coolant provides protection
down to about –35 C (–31 F).
NOTICE
Do not use plain water alone.
Scion recommends “Toyota Super Long
Life Coolant”, which has been tested to
ensure that it will not cause corrosion nor
result in malfunction of your engine cool-
ant system with proper usage. “Toyota Su-
per Long Life Coolant” is formulated with
long −life hybrid organic acid technology
and has been specifically designed to
avoid engine cooling system malfunction
on Scion vehicles.
Please contact your Scion dealer for fur-
ther details.
Checking the engine coolant
level

271
Service specifications
ENGINE
Valve clearance:Automatic adjustment
Spark plug type: DENSO SC20HR11
Spark plug gap, mm(in.): 1.1 (0.043)
ENGINE LUBRICATION
Oil capacity (drain and refill), L (qt.,
Imp.qt.): With filter 4.2 (4.4, 3.7)
Without filter 3.9 (4.1, 3.4)
“Toyota Genuine Motor Oil” is used in
your Scion vehicle. Use Scion approved
“Toyota Genuine Motor Oil” or equivalent
to satisfy the following grade and viscos-
ity. Oil grade:
ILSAC multigrade engine oil
Please contact your Scion dealer for fur-
ther details.
Recommended oil viscosity:
SAE 5W −20 or 0W −20
OIL016
Outside temperature COOLING SYSTEM
Total capacity, L (qt., Imp.qt.):
Manual transmission 5.0 (5.3, 4.4)
Automatic transmission 4.9 (5.2, 4.3)
Coolant type:
“Toyota Super Long Life Coolant” is
used in your Scion vehicle at factory fill.
In order to avoid technical problems,
only use “Toyota Super Long Life Cool-
ant” or similar high quality ethylene gly-
col based non −silicate, non− amine, non−
nitrite, and non −borate coolant with
long− life hybrid organic acid technology.
(Coolant with long −life hybrid organic
acid technology is a combination of low
phosphates and organic acids.)
Do not use plain water alone.
Please contact your Scion dealer for fur-
ther details.
BATTERY
Open voltage* at 20 C (68 F):
12.6 – 12.8 V Fully charged
12.2 – 12.4 V Half charged
11.8 – 12.0 V Discharged
*: Voltage that is checked 20 minutes af-
ter the key is removed with all the lights
turned off
Charging rates: 5 A max.

280
A
Adding washer fluid263
. . . . . . . . . . . . . . . .
Adjustment Front seats 24
. . . . . . . . . . . . . . . . . . . . . . .
Seat belt 32
. . . . . . . . . . . . . . . . . . . . . . . . .
Air conditioning system 136
. . . . . . . . . . . . .
Airbags 46
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −glare inside rear view mirror 88 . . . . .
Anti −lock brake system warning
light 105
. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Anti −theft steering column lock 116 . . . . . .
Appearance care
Cleaning the interior 227
. . . . . . . . . . . . . .
Protecting your Scion from corrosion 224
. . . . . . . . . . . . . . . . .
Washing and waxing 225
. . . . . . . . . . . . . .
Audio remote controls 149
. . . . . . . . . . . . . .
Automatic transmission Driving with an
automatic transmission 117
. . . . . . . . .
Shift pattern 117
. . . . . . . . . . . . . . . . . . . . .
Shift speed 117
. . . . . . . . . . . . . . . . . . . . . .
AUX jack 149
. . . . . . . . . . . . . . . . . . . . . . . . . .
Auxiliary box 151
. . . . . . . . . . . . . . . . . . . . . .
Auxiliary catch, Engine hood 20
. . . . . . . . .
B
Battery
Checking battery condition 260 . . . . . . . .
Gas caution 260 . . . . . . . . . . . . . . . . . . . . .
Handling safety 260 . . . . . . . . . . . . . . . . . .
Recharging precautions 261 . . . . . . . . . . .
Winter driving tips 193 . . . . . . . . . . . . . . . .
Before starting the engine 190 . . . . . . . . . . .
Bottle holders 153 . . . . . . . . . . . . . . . . . . . . . .
Brake pad wear limit indicators 166 . . . . . .
Brake system 163 . . . . . . . . . . . . . . . . . . . . . .
Brake system warning light 105 . . . . . . . . . .
Brake −in tips 156 . . . . . . . . . . . . . . . . . . . . . .
Brakes Fluid level 249 . . . . . . . . . . . . . . . . . . . . . . .
Pad wear indicators 166 . . . . . . . . . . . . . .
Brightness control 94 . . . . . . . . . . . . . . . . . . .
C
Carbon monoxide caution 159
. . . . . . . . . . .
Cargo and luggage
Capacity 183
. . . . . . . . . . . . . . . . . . . . . . . .
Distribution 185
. . . . . . . . . . . . . . . . . . . . . .
Stowage precautions 184
. . . . . . . . . . . . .
Certification label 166
. . . . . . . . . . . . . . . . . .
Charging system warning light 105 . . . . . . .
Checking and replacing fuses 262 . . . . . . . . Checking and replacing tires 252
. . . . . . . .
Checking brake fluid 249
. . . . . . . . . . . . . . . .
Checking the engine oil level 246 . . . . . . . .
Checking the radiator and condenser 249
. . . . . . . . . . . . . . . . . . . . . . .
Child restraint Child restraint system 67
. . . . . . . . . . . . .
Installation 69
. . . . . . . . . . . . . . . . . . . . . . .
Precautions 66
. . . . . . . . . . . . . . . . . . . . . .
Types of child restraint system 68 . . . . . .
Cleaning the interior 227
. . . . . . . . . . . . . . . .
Clock 148
. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Cold weather operation 193
. . . . . . . . . . . . .
Controls, Instrument panel 2
. . . . . . . . . . . .
Cooling system Coolant level 248
. . . . . . . . . . . . . . . . . . . .
Engine overheating 205
. . . . . . . . . . . . . . .
Radiator and reservoir 249
. . . . . . . . . . . .
Radiator cap 249
. . . . . . . . . . . . . . . . . . . . .
Winter driving tips 193
. . . . . . . . . . . . . . . .
Corrosion prevention 224
. . . . . . . . . . . . . . .
Cruise control 131
. . . . . . . . . . . . . . . . . . . . .
Cup holders 152
. . . . . . . . . . . . . . . . . . . . . . .

281
D
Defogger, Rear window97
. . . . . . . . . . . . . .
Dimmer switch, Headlight 92
. . . . . . . . . . . .
Dinghy towing 194
. . . . . . . . . . . . . . . . . . . . .
Directional signals 92
. . . . . . . . . . . . . . . . . .
Do −it−yourself maintenance
Parts and tools 241
. . . . . . . . . . . . . . . . . . .
Service precautions 239
. . . . . . . . . . . . . .
Does your vehicle need repairing? 235
. . . . . . . . . . . . . . . . . .
Driving Automatic transmission 117
. . . . . . . . . . .
Driving tips 191, 193
. . . . . . . . . . . . . . . . .
Manual transmission 120
. . . . . . . . . . . . .
Driving in the rain 192
. . . . . . . . . . . . . . . . . .
Driving tips Driving tips in various conditions 191
. . . . . . . . . . . . . . . . . . . . .
Driving with a
manual transmission 120
. . . . . . . . . . . .
Driving with an automatic transmission 117
. . . . . . . . .
Economical driving 196
. . . . . . . . . . . . . . .
Good driving practice 117, 120
. . . . . . . . .
Winter driving tips 193
. . . . . . . . . . . . . . . .
During, Break −in 156
. . . . . . . . . . . . . . . . . . .
E
Economical driving, Saving money
on both fuel and repairs 196 . . . . . . . . . . .
Electrical system Battery 260 . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuse locations 239 . . . . . . . . . . . . . . . . . . .
Fuses 262 . . . . . . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 93 . . . . . . . . . . . .
Emergency, In case of Blown fuse 262 . . . . . . . . . . . . . . . . . . . . . .
Emergency flasher switch 93 . . . . . . . . . .
Flat tire 206 . . . . . . . . . . . . . . . . . . . . . . . . .
If you cannot shift automatic transmission selector lever 221 . . . . . .
If you lose your keys 222 . . . . . . . . . . . . . .
If your engine stalls while driving 204 . . . . . . . . . . . . . . . . . . .
If your vehicle needs to be towed 217 . . . . . . . . . . . . . . . . . . . .
If your vehicle will not start 200 . . . . . . . .
Jump starting 201 . . . . . . . . . . . . . . . . . . . .
Overheating 205 . . . . . . . . . . . . . . . . . . . . .
Towing 217 . . . . . . . . . . . . . . . . . . . . . . . . . .
Emissions inspection and maintenance (I/M) programs 236 . . . . . . . Engine
Before starting the engine 190 . . . . . . . . .
Checking the coolant level 248 . . . . . . . .
Emission control device 158 . . . . . . . . . . .
Engine compartment 238 . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . .
Hood release 20 . . . . . . . . . . . . . . . . . . . . .
Identification number 166 . . . . . . . . . . . . .
Oil level 246 . . . . . . . . . . . . . . . . . . . . . . . . .
Overheating 205 . . . . . . . . . . . . . . . . . . . . .
Engine coolant Winter driving tips 193 . . . . . . . . . . . . . . . .
Engine oil Winter driving tips 193 . . . . . . . . . . . . . . . .
Engine switch 116 . . . . . . . . . . . . . . . . . . . . . .
Exhaust gas caution 159 . . . . . . . . . . . . . . . .
F
Facts about engine oil
consumption 160 . . . . . . . . . . . . . . . . . . . . .
Flasher, Headlight 92 . . . . . . . . . . . . . . . . . . .
Flat tire
After changing wheels 216 . . . . . . . . . . . .
Changing tires 212 . . . . . . . . . . . . . . . . . . .
If you have a flat tire 206 . . . . . . . . . . . . . .
Jack point 211 . . . . . . . . . . . . . . . . . . . . . . .
Jacking precautions 206 . . . . . . . . . . . . . .
Jacking up 211 . . . . . . . . . . . . . . . . . . . . . .
Loosing wheel nuts 211 . . . . . . . . . . . . . . .
Lowering vehicle 214 . . . . . . . . . . . . . . . . .
Wheel block 210 . . . . . . . . . . . . . . . . . . . . .
Wheel nuts 213 . . . . . . . . . . . . . . . . . . . . . .