battery VAUXHALL MOVANO_B 2016 Owner's Guide

154Vehicle careGeneral Information
Accessories and vehicle modifications
We recommend the use of genuine
parts and accessories and factory
approved parts specific for your
vehicle type. We cannot assess or guarantee reliability of other products
- even if they have a regulatory or
otherwise granted approval.
Do not make any modifications to the electrical system, e.g. changes of
electronic control units (chip tuning).Caution
When transporting the vehicle on
a train or on a recovery vehicle, the
mud flaps might be damaged.
Vehicle storage
Storage for a long period of time
If the vehicle is to be stored for several months:
● Wash and wax the vehicle.
● Have the wax in the engine compartment and underbody
checked.
● Clean and preserve rubber seals.
● Change engine oil.
● Drain washer fluid reservoir. ● Check coolant antifreeze and corrosion protection.
● Adjust tyre pressure to the value specified for full load.
● Park vehicle in a dry, well ventilated place. Engage first or
reverse gear. Prevent the vehicle
from rolling.
● Do not apply parking brake.● Open bonnet, close all doors and
lock the vehicle.
● Disconnect the clamp from the negative terminal of the vehicle
battery. Beware that all systems
are not functional, e.g. anti-theft
alarm system.
Putting back into operation When the vehicle is to be put back into
operation:
● Connect the clamp to the negative terminal of the vehicle
battery. Activate the electronics
of the power windows.
● Check tyre pressure.
● Fill up the washer fluid reservoir. ● Check the engine oil level.
● Check the coolant level.
● Fit the number plate, if necessary.

Vehicle care159Washer fluid
Fill with clean water mixed with a
suitable quantity of windscreen
washer fluid which contains
antifreeze.
Caution
Only washer fluid with a sufficient
antifreeze concentration provides
protection at low temperatures or
a sudden drop in temperature.
Use of washer fluid containing
isopropanol can damage exterior
lamps.
Brakes
In the event of minimum thickness ofthe brake lining, a squealing noise
sounds during braking.
Continued driving is possible but
have the brake linings replaced as
soon as possible.
Once new brake linings are installed,
do not brake unnecessarily hard for
the first few journeys.
Brake fluid9 Warning
Brake fluid is poisonous and
corrosive. Avoid contact with eyes, skin, fabrics and painted surfaces.
The brake fluid level must be betweenthe MIN and MAX marks.
When topping up, ensure maximum cleanliness as contamination of the
brake fluid can lead to brake system
malfunctions. Have the cause of the
loss of brake fluid remedied by a
workshop.
Only use brake fluid approved for
your vehicle.
Brake and clutch fluid 3 196.
Vehicle battery
The vehicle battery is maintenance-
free provided that the driving profile
allows sufficient charging of the

160Vehicle carebattery. Short-distance-driving and
frequent engine starts can discharge
the battery. Avoid the use of
unnecessary electrical consumers.
Batteries do not belong in household
waste. They must be disposed of at
an appropriate recycling collection
point.
Laying up the vehicle for more than
4 weeks can lead to battery
discharge. Disconnect the clamp from the negative terminal of the vehicle
battery.
Ensure the ignition is switched off
before connecting or disconnecting
the vehicle battery.
The anti-theft alarm siren must be
deactivated as follows: Switch the ignition on then off, disconnect the
vehicle's battery within 15 seconds.
Battery access
The battery is located behind a panel in the front left-hand door step.
Remove the panel to access the
battery.
Charging the vehicle battery
9 Danger
Ensure adequate ventilation when
charging the battery. There is a
risk of explosion if gases
generated during charging are
allowed to accumulate!
Jump starting 3 188.
Warning label
Meaning of symbols:
● No sparks, naked flames or smoking.
● Always shield eyes. Explosive gases can cause blindness or
injury.
● Keep the vehicle battery out of reach of children.
● The vehicle battery contains sulfuric acid which could cause
blindness or serious burn
injuries.

Vehicle care161● See the Owner's Manual forfurther information.
● Explosive gas may be present in the vicinity of the battery.
Additional battery
Depending on the vehicle's auxiliary
equipment, certain models may have
an additional battery mounted under
the front seat.
Diesel fuel filter
Drain diesel fuel filter of residual
water at every engine oil change.
Place a container underneath the
filter housing. Loosen the knurled
screws on the filter cover and on the
lower part of the filter by approx. one
turn, to drain off the water.
The filter is drained as soon as diesel fuel emerges from the knurled screw
at the bottom. Retighten the two
screws.
Check diesel fuel filter at shorter
intervals if the vehicle is subjected to
extreme operating conditions.
Diesel fuel system bleedingIf the fuel tank has been run dry, it will be necessary to air vent or bleed the
diesel fuel system.
Fill the tank with fuel and proceed as
follows:
1. Place a suitable container underneath the fuel filter vent
screw to collect fuel.
2. Loosen the vent screw (arrowed) by one turn.
3. Manually operate the in-line supply pump slowly and steadily
until fuel discharging from the
loosened vent screw is free of air
bubbles.
4. Retighten the vent screw.
If the engine cannot be started after
several attempts to bleed the diesel
fuel system, seek the assistance of a
workshop.

182Vehicle care9.Connect the red < power supply
lead on the compressor to the
jump start terminal 3 188.
Notice
Depending on model, the jump start
terminal may be located at the left-
hand or right-hand side of the engine compartment.
10. Connect the black ] power
supply lead to a vehicle grounding
point, e.g. the engine block or an
engine mounting bolt.
Notice
Depending on tyre repair kit type, it
may be necessary to connect the
single power supply lead to the
power outlet or cigarette lighter
socket.
For this type, the red < and
black ] power supply leads will not
be present.
To avoid discharging the battery,
we recommend running the
engine.
11. Set the rocker switch on the compressor to position I. The tyre
is filled with sealant.
12. The compressor pressure gauge briefly indicates up to 6 bar. Then
the pressure starts to drop.
13. All of the sealant is pumped into the tyre. Then the tyre is inflated.
14. The prescribed tyre pressureshould be obtained within
10 minutes. Tyre pressure
3 219 . When the correct pressure
is obtained, turn off the
compressor by setting rocker
switch to position O.
If the prescribed tyre pressure is
not obtained within 10 minutes,
remove the tyre repair kit. Move
the vehicle one tyre rotation
(approx. 2 metres). Reattach the
tyre repair kit and continue the
filling procedure for 10 minutes. If
the prescribed tyre pressure is still not obtained, the tyre is too badly

188Vehicle careThe following applies to tyres fitted
opposing the rolling direction:
● Driveability may be affected. Have the defective tyre renewed
or repaired as soon as possible.
● Do not drive faster than 50 mph.
● Drive particularly carefully on wet
and snow-covered road
surfaces.Jump starting
Do not start with a quick charger.
A vehicle with a discharged battery
can be started using jump leads and
the battery of another vehicle.9 Warning
Be extremely careful when starting
with jump leads. Any deviation
from the following instructions can
lead to injuries or damage caused
by battery explosion or damage to the electrical systems of both
vehicles.
9 Warning
Avoid contact with eyes, skin,
fabrics, and painted surfaces. The fluid contains sulphuric acid which can cause injuries and damage in
the event of direct contact.
Caution
The air suspension system must
be switched off prior to jump
starting.
9 Warning
Avoid contact of the battery with
eyes, skin, fabrics and painted
surfaces. The fluid contains
sulphuric acid which can cause
injuries and damage in the event
of direct contact.
● Never expose the vehicle battery
to naked flames or sparks.
● A discharged vehicle battery can already freeze at a temperature
of 0 °C. Defrost the frozen vehicle
battery before connecting jump leads.
● Wear eye protection and protective clothing when
handling a vehicle battery.

Vehicle care189● Use a booster battery with thesame voltage (12 volts). Its
capacity (Ah) must not be much less than that of the discharged
vehicle battery.
● Use jump leads with insulated terminals and a cross section of
at least 25 mm 2
.
● Do not disconnect the discharged
battery from the vehicle.
● Switch off all unnecessary electrical consumers.
● Switch off the air suspension system 3 122.
● Do not lean over the vehicle battery during jump starting.
● Do not allow the terminals of one
lead to touch those of the other
lead.
● The vehicles must not come into contact with each other during
the jump starting process.
● Apply the parking brake and engage neutral (manual
transmission) or N (manual
transmission automated).Jump start terminal
In the event of a discharged vehicle
battery, the jump start terminal
enables the vehicle to be started
without the need to access the battery inside the vehicle.
The jump start terminal is located in
the engine compartment and
identified by a " <" sign on the red
insulating cover. Lift the red insulating
cover to access the terminal
connector.
Ensure the red insulating cover is
latched back into position when not in
use.
Jump starting procedure
Depending on model, the jump start
terminal may be located at the left-
hand or right-hand side of the engine
compartment.

190Vehicle care
Lead connection order:1. Connect the red lead to the positive terminal of the booster
battery.
2. Connect the other end of the red lead to the jump start terminal of
the vehicle with the discharged
vehicle battery.
3. Connect the black lead to the negative terminal of the booster
battery.
4. Connect the other end of the black
lead to a vehicle grounding point,
such as the engine block or an
engine mounting bolt. Connect as
far away from the discharged
vehicle battery as possible,
however at least 60 cm.
Route the leads so that they cannot
catch on rotating parts in the engine
compartment.
To start the engine: 1. Start the engine of the vehicle providing the jump start.
2. After 5 minutes, start the other engine. Start attempts should be
made for no longer than
15 seconds at an interval of
1 minute.
3. Allow both engines to idle for approx. 3 minutes with the leads
connected.
4. Switch on electrical consumers (e.g. headlights, heated rear
window) of the vehicle receiving
the jump start.
5. Reverse above sequence exactly when removing leads.Towing
Towing the vehicle
The towing eye is stowed with the vehicle tools 3 174.
Disengage the cover using a suitable
tool and remove.
Screw the towing eye clockwise into
the front towing point and tighten fully using the wheel wrench.
Attach a tow rope - or better still a tow
rod - to the towing eye, never to the
bumper or front suspension units.

224IndexAAccessories and vehicle modifications .......................... 154
Adaptive forward lighting .....98, 164
AdBlue .......................... 87, 125, 196
Adblue gauge ............................... 79
AdBlue tank ................................ 218
Adjustable air vents ...................113
Airbag and belt tensioners ...........84
Airbag deactivation ................53, 84
Airbag label................................... 49 Airbag system .............................. 49
Air conditioning regular operation ................................ 114
Air conditioning system .............. 104
Air intake .................................... 114
Air suspension ........................... 122
Air suspension system................ 190
Air vents...................................... 113
Antifreeze ................................... 157
Antilock brake system ................ 134
Antilock brake system (ABS) .......86
Anti-theft alarm system ................31
Anti-theft bolts............................. 184
Anti-theft locking system .............. 30
Anti-theft security lock ..................21
Appearance care ........................192
Armrest ........................................ 44
Ashtrays ....................................... 77
Automatic light control .................95Automatic locking ...................21, 25
Autostop ..................................... 118
Auxiliary heater ........................... 109
B Battery discharge protection ......102
Battery, jump starting.................. 188
Belts.............................................. 46 BlueInjection ............................... 125
Bonnet ....................................... 155
Brake assist ............................... 136
Brake fluid .......................... 159, 196
Brakes ............................... 134, 159
Brake system ............................... 85
Breakdown.................................. 190
Bulb replacement ....................... 162
C Capacities .................................. 218
Cargo management system ........67
Car Pass ...................................... 19
Catalytic converter .....................124
Central locking system ................21
Centre high-mounted brake light 167
Changing tyre and wheel size ...179
Charging system .......................... 84
Child locks ................................... 25
Child restraint installation locations ................................... 56
Child restraints.............................. 55
Child restraint systems ................55

228Steering...................................... 116
Steering column controls ..............73
Steering wheel adjustment ......9, 73
Steering wheel controls ...............73
Stop engine .................................. 85
Stop-start system............ 16, 88, 119
Storage ......................................... 64
Storage compartments .................64
Sunglasses storage .....................65
Sun visors .................................... 37
Suspension height ......................122
Suspension seat ........................... 40
Symbols ......................................... 4
T
Tachograph ............................ 89, 94
Tachometer ................................. 78
Tail lights ................................... 166
Technical data ............................ 201
Three-point seat belt .................... 47
Tools .......................................... 174
Top-tether fastening eyes ............63
Tow bar....................................... 150
Towing ........................................ 150
Towing another vehicle .............191
Towing a trailer ........................... 150
Towing equipment .....................151
Towing eye ................................. 190
Towing the vehicle .....................190
Traction Control system ............. 136Trailer coupling ........................... 150
Trailer stability assist .................151
Trailer towing ............................. 150
Transmission ............................... 16
Transmission display ...........81, 130
Tread depth ............................... 179
Trip computer .............................. 92
Triple-Info-Display .......................90
Trip odometer .............................. 78
Turbo engine warm-up ...............118
Turn and lane-change signals .....98
Turn signal ................................... 83
Tyre chains ................................ 180
Tyre changing ............................. 184
Tyre designations ......................176
Tyre pressure ............................ 176
Tyre pressure monitoring system ............................... 87, 177
Tyre pressures ........................... 219
Tyre repair kit ............................. 180
Tyres .......................................... 175
Tyres and wheel size, changing. 179
U Ultrasonic parking assist............. 142
Underseat storage .......................66
Upholstery .................................. 193
Upshift .......................................... 86
Using this manual ..........................3V
Vehicle battery ........................... 159
Vehicle checks............................ 155
Vehicle data ................................ 200
Vehicle data recording and privacy ..................................... 221
Vehicle dimensions .................... 209
Vehicle Identification Number ....198
Vehicle jack ................................ 174
Vehicle messages .......................90
Vehicle security ............................ 30
Vehicle specific data ......................3
Vehicle storage ........................... 154
Vehicle tools ............................... 174
Vehicle unlocking ........................... 6
Vehicle weight ........................... 202
Ventilation ................................... 103
W
Warning chimes ........................... 91
Warning lights ............................... 77
Warning triangle .......................... 69
Washer and wiper systems .........14
Washer fluid ............................... 159
Washing the vehicle ...................192
Wheel changing .........................184
Wheel covers ............................. 180
Wheels and tyres .......................175
Wheel wrench ............................. 174
Wide view mirror .....................34, 37