steering VOLKSWAGEN JETTA 1998 Service Manual

Downloaded from www.Manualslib.com manuals search engine Repair Manual,
Suspension, Wheels,
Steering, Repair
Group 40
Removing
and installing
Стр. 8из 14 Electrical/electronic components and locations

Downloaded from www.Manualslib.com manuals search engine Repair Manual,
Suspension, Wheels,
Steering, Repair
Group 42
Стр. 10из 14 Electrical/electronic components and locations

Downloaded from www.Manualslib.com manuals search engine 01-133


ABS Mark 60 On Board
Diagnostic (OBD), vehicles
from my 10.00
There are four versions of the ABS Mark 60.

ABS

ABS/EDL/ASR

ABS/EDL/ASR/ESP with front wheel drive

ABS/EDL/ASR/ESP with 4MOTION
Each version has its own control module. The
control modules can be coded accordingly
through coding bridges via tester VAS 5051 or
V.A.G 1551.
The ESP (Electronic Stabilization Program) is
an electronic dynamics Program (EDP). It
stabilizes the vehicle when oversteering or
understeering. The ESP works over the whole
speed range. If the ESP is regulating the
system the ESP warning lamp will flash 3 times
per second.

The ESP is a further extension of the
familiar vehicle safety systems.
ESP increases control over the vehicle in
critical situations. It reduces the danger of
skidding and increases the steering control
when compared with familiar vehicle safety
systems.
Стр. 1из 10 ABS Mark 60 On Board Diagnostic (OBD), vehicles from my 10.00

Downloaded from www.Manualslib.com manuals search engine 01-140



Technical information

Electrical Wiring Diagrams, Troubleshooting
&Component Locations binder
Repair Manual, Brake System
Repair Manual, Suspension, Wheels,
Steering
Стр. 8из 10 ABS Mark 60 On Board Diagnostic (OBD), vehicles from my 10.00

Downloaded from www.Manualslib.com manuals search engine 01-145



Repair Manual,
Brake System, Repair
Group 45; Removing
and installing parts of
ESP system 3 -
Sender for
Rotation Rate -
G202-

Vehicles with
ABS/EDL/ASR/ESP
only

Location:
Under
instrument
panel next to
steering
column

Checked by
OBD

Can be
checked via
read
measured
value block
Page 01
-240
Observe
installation
instructions
Стр. 4из 17 Electrical/electronic components and installing locations

Downloaded from www.Manualslib.com manuals search engine 01-146



Repair Manual,
Brake System, Repair
Group 45; Removing
and installing parts of
ESP system 4 -
Sensor for
transverse
acceleration -
G200-

Vehicles with
ABS/EDL/ASR/ESP
only

Location:
Under
instrument
panel next to
steering
column

Checked by
OBD

Can be
checked via
read
measured
value block
Page 01
-240
Observe
installation
instructions
When the
sensor for
transverse
acceleration -
G200- is
replaced, a
zero
compensation
must be
performed

Initiate basic
setting
Page 01
-264 ,
perform
display group
number 063
Стр. 5из 17 Electrical/electronic components and installing locations

Downloaded from www.Manualslib.com manuals search engine 01-150



Repair Manual,
Brake System, Repair
Group 45; Removing
and installing parts of
ESP system 8 -
Brake booster
9 -
Steering angle
sensor -G85-

Vehicles with
ABS/EDL/ASR/ESP
only

Location: On
steering
column
between
steering wheel
and steering
column switch.

Checked by
OBD

Can be
checked via
read
measured
value block
Page 01
-240
Observe
installation
instructions
When the
steering angle
sensor -G85-
is replaced, a
zero
compensation
must be
performed

Introduce
basic setting
Page 01
-
264 , perform
display group
number 060
Стр. 10из 17 Electrical/electronic components and installing locations

Downloaded from www.Manualslib.com manuals search engine Steering, Repair
Group 40; Servicing
front suspension; II -
Servicing wheel
bearings
Стр. 15из 17 Electrical/electronic components and installing locations

Downloaded from www.Manualslib.com manuals search engine 01-154



Repair Manual,
Suspension, Wheels,
Steering, Repair
Group 42; Servicing
19 -
Right/left rear
speed sensor
-G44-/-G46-

Checked by
OBD

Before
inserting the
sensor clean
the inner
surface of
the sensor
mounting
and coat with
lubricating
paste G 000
650

When
connecting
the speed
sensor wire
make sure it
is not twisted
in the wheel
housing

Securing bolt
tightening
torque - 10
Nm (7.4 ft lb)
20 -
Wheel hub
with rotor for
speed
sensors

Rotor and
speed
sensors for
left rear and
right-hand
sides are
identical

Removing
and installing
Стр. 16из 17 Electrical/electronic components and installing locations

Downloaded from www.Manualslib.com manuals search engine 01-208


V.A.G 1551 print-out
Possible cause
Repair
00778
Steering angle sensor -
G85-
No
signal/communication
1)
Open circuit or loose contact
in data bus wiring between
steering angle sensor -G85-
and control module -J104-

Terminals 15 and 30 on
steering angle sensor -G85-,

Ground not present- Check wiring and
connections using wiring
diagram

- Perform electrical check
Page 01
-288

Steering angle sensor -G85-
faulty
Repair Manual, Brake
System, Repair Group 45;
Removing and installing parts
of ESP system - Replace steering angle
sensor -G85-
- Perform a zero
compensation:
- Initiate basic settings Page
01-264 Display group number
060
1) For ABS/EDL/ASR/ESP and ABS/EDL/ASR/ESP 4MOTION
Стр. 50из 129 On Board Diagnostic (OBD), performing