engine VOLVO XC70 2004 Service Manual

VOLVO XC70 2004 Service Manual XC70 2004 VOLVO VOLVO https://www.carmanualsonline.info/img/45/58552/w960_58552-0.png VOLVO XC70 2004 Service Manual

Page 155 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
Replacing high/low beam headlight bulbs
The headlight bulbs must be replaced from the engine compartment. 
CAUTION: 
l     Do not touch the glass on halogen bulbs with your fingers. G

Page 164 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
pg. 128 Paint touch up 
Paint touch-up
Paint damage requires immediate attention to avoid rusting. Make it a ha\
bit to check the finish regularly 
- when washing the car for instance

Page 166 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
l     A stiff-bristle brush and lukewarm soapy water can be used to clean the \
wiper blades. Frequent 
cleaning improves visibility considerably. 
l     Wash off the dirt from the un

Page 170 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
 
pg. 132 Fuel/emissions systems 
Fuel system
The fuel system continually compensates for variation in engine load, sp\
eed and temperature. A mass air 
flow sensor continuously measu

Page 171 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
charcoal canister to the engines air intake system and into the combust\
ion process.
NOTE: 
l     Overfilling the fuel tank can cause damage to the evaporative control sy\
stem. 
l

Page 172 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
coolant circulation between the engine and the expansion tank during eng\
ine warm up and cooling. 
Changing coolant
Normally, the coolant does not need to be changed. If the system m

Page 173 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
Fuel filter
The fuel filter should be replaced at 105,000 miles (168,000 km) or at\
 120,000 miles (193,000 km) for 
the 2.5T engine on AWD models. The filter is replaced as a complet

Page 174 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
 
pg. 135 Servicing 
 
Washer fluid reservoir
The washer fluid reservoir is located in the engine compartment and hold\
s approx. 4.7 US qts. (4.5 
liters). 
During cold weather, the

Page 175 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
If a two-post hoist is used to lift the car, the front and rear lift arm\
 pads should be centered under the 
reinforced lift plates on the inboard edge of the sill rail (see illust\

Page 176 of 241

VOLVO XC70 2004 Service Manual 
2004 VOLVO XC70
Engine compartment
1 Expansion tank - coolant  
2 Power steering fluid reservoir 
3 Washer fluid reservoir 
4 Dipstick - engine oil 
5 Radiator/cooling fan 
6 Oil filler cap - engine