YAMAHA BIG BEAR PRO 400 2005 Manuale de Empleo (in Spanish)
Manufacturer: YAMAHA, Model Year: 2005, Model line: BIG BEAR PRO 400, Model: YAMAHA BIG BEAR PRO 400 2005Pages: 398, tamaño PDF: 16.52 MB
Page 11 of 398
FBU00801
RENSEIGNEMENTS
IMPORTANTS SUR CE MANUEL
LE NON-RESPECT DES AVERTISSEMENTS DON-
NÉS DANS CE MANUEL PEUT ENTRAÎNER DES
BLESSURES GRAVES ET LA MORT.
Les informations particulièrement importantes sont repé-
rées par les notations suivantes:_ Le symbole de danger incite à ÊTRE VIGILANT
AFIN DE GARANTIR SA SÉCURITÉ!
AVERTISSEMENT
_ Le non-respect des instructions AVERTISSEMENT
peut entraîner des blessures graves ou la mort
du pi-
lote, d’un tiers ou d’une personne inspectant ou répa-
rant le véhicule.
SBU00801
INFORMACIÓN IMPORTANTE
SOBRE ESTE MANUAL
LA INOBSERVANCIA DE LAS ADVERTENCIAS
CONTENIDAS EN ESTE MANUAL PUEDE ACA-
RREAR LESIONES GRAVES O INCLUSO MOR-
TALES.
La información de especial importancia se señala en
este manual con las siguientes notaciones:_ El símbolo de alerta de seguridad significa
¡ATENCIÓN! ¡MANTÉNGASE ALERTA! ¡PELI-
GRA SU SEGURIDAD!
ADVERTENCIA
_ La inobservancia de las instrucciones de AD-
VERTENCIA puede ser causa de lesiones graveso mortales
para el usuario de la máquina, las per-
sonas situadas en sus proximidades o los técni-
cos encargados de su inspección o reparación.
U1C160.book Page 2 Wednesday, May 12, 2004 4:55 PM
Page 12 of 398
CAUTION:
A CAUTION indicates special precautions that
must be taken to avoid damage to the ma-
chine.NOTE:
A NOTE provides key information to make proce-
dures easier or clearer.
U1C160.book Page 3 Wednesday, May 12, 2004 4:55 PM
Page 13 of 398
ATTENTION:_ Un ATTENTION indique les précautions particuliè-
res à prendre pour éviter d’endommager le véhicule.N.B.:N.B.: Un N.B. fournit les renseignements nécessaires à la clari-
fication et à la simplification des divers travaux.
AT E N C I O N :_ Los avisos de ATENCIÓN indican precauciones
especiales que deben adoptarse para evitar que
la máquina sufra daños.NOTA:
Las NOTAS contienen información importante para
facilitar o aclarar los procedimientos.
U1C160.book Page 4 Wednesday, May 12, 2004 4:55 PM
Page 14 of 398
EBU00111
3-IMPORTANT NOTICE
This ATV is designed and manufactured for use on
UNPAVED surfaces only. It is unsafe to operate
this ATV on any paved surface, paved street,
paved road or motorway.
Please check your local riding laws and regula-
tions before operating this ATV.
EBU01056
YFM400FPT
YFM400FWT
OWNER’S MANUAL
©2004 by Yamaha Motor Co., Ltd.
1st edition, May 2004
All rights reserved. Any reprinting or
unauthorized use without the written
permission of Yamaha Motor Co., Ltd.
is expressly prohibited.
Printed in Japan.
U1C160.book Page 1 Wednesday, May 12, 2004 4:55 PM
Page 15 of 398
FBU00111
REMARQUE IMPORTANTE
Ce véhicule est conçu et fabriqué pour une utilisation sur
surfaces NON REVÊTUES uniquement. La conduite de
ce véhicule sur les surfaces ou les routes revêtues est dan-
gereuse.
Prendre connaissance des règlements locaux avant de
conduire ce véhicule.
FBU01056
YFM400FPT
YFM400FWT
MANUEL DU PROPRIÉTAIRE
©2004 par Yamaha Motor Co., Ltd.
1re édition, mai 2004
Tous droits réservés. Toute réimpression ou
utilisation non autorisée sans la permission
écrite de la Yamaha Motor Co., Ltd.
est formellement interdite.
Imprimé au Japon
SBU00111
AVISO IMPORTANTE
Este ATV ha sido fabricado y diseñado únicamente
para su utilización en terrenos SIN PAVIMENTAR.
Por lo tanto, es peligroso, circular con el ATV por su-
perficies pavimentadas, calles pavimentadas, carre-
teras pavimentadas o autopistas pavimentadas.
Se ruega consultar las leyes y reglamentaciones lo-
cales sobre vehículos motorizados antes de usar el
ATV.
SBU01056
YFM400FPT
YFM400FWT
MANUAL DEL PROPIETARIO
©2004 por Yamaha Motor Co., Ltd.
1ª Edición, mayo 2004
Reservados todos los derechos. Queda
expresamente prohibida cualquier reimpresión
o uso no autorizado sin el consentimiento por
escrito de Yamaha Motor Co., Ltd.
Impreso en Japón.
U1C160.book Page 2 Wednesday, May 12, 2004 4:55 PM
Page 16 of 398
EBU00015
1-CONTENTS
LOCATION OF THE WARNING AND
SPECIFICATION LABELS ....................... 1-1
SAFETY INFORMATION ......................... 2-1
DESCRIPTION AND MACHINE
IDENTIFICATION .................................... 3-1
Identification number records ............... 3-3
Key identification number ..................... 3-5
Vehicle identification number ............... 3-7
Model label ........................................... 3-9
CONTROL FUNCTIONS ......................... 4-1
Main switch........................................... 4-1
Indicator and warning lights.................. 4-3
Speedometer ........................................ 4-9
Fuel gauge ......................................... 4-11
Handlebar switches ............................ 4-13
Throttle lever ...................................... 4-17
Speed limiter ...................................... 4-19
Front brake lever ................................ 4-21
Brake pedal and rear brake lever ....... 4-23
Parking brake ..................................... 4-25
Shift pedal .......................................... 4-27
1234
Drive select lever ............................... 4-27
Recoil starter ...................................... 4-29
Fuel tank cap ..................................... 4-29
Fuel cock............................................ 4-31
Starter (choke) ................................... 4-33
Seat.................................................... 4-35
Storage box........................................ 4-37
Front carrier ....................................... 4-37
Rear carrier ........................................ 4-37
Front shock absorber adjustment ...... 4-39
Rear shock absorber adjustment ....... 4-41
Auxiliary DC jack ................................ 4-43
PRE-OPERATION CHECKS ................... 5-1
Front and rear brakes .......................... 5-5
Fuel ...................................................... 5-9
Engine oil/transfer gear oil ................. 5-13
Final gear oil/Differential gear oil ....... 5-15
Throttle lever ...................................... 5-15
Fittings and fasteners......................... 5-17
Lights ................................................. 5-17
Switches............................................. 5-17
Tires ................................................... 5-19
How to measure tire pressure ............ 5-23
5
U1C160.book Page 1 Wednesday, May 12, 2004 4:55 PM
Page 17 of 398
Tire wear limit......................................5-25
OPERATION ............................................6-1
Starting a cold engine ...........................6-3
Starting a warm engine .........................6-9
Warming up...........................................6-9
Drive select lever operation and
reverse driving ..................................6-11
Reverse lock release wire ...................6-15
Shifting ................................................6-17
To start out and accelerate .................6-19
To decelerate ......................................6-21
Engine break-in ...................................6-23
Parking ................................................6-27
Parking on a slope ..............................6-27
Accessories and loading .....................6-29
RIDING YOUR ATV..................................7-1
Getting to know your ATV .....................7-3
Ride with care and good judgement .....7-5
Be careful where you ride ...................7-27
Turning your ATV ................................7-41
Climbing uphill.....................................7-47
Riding downhill ....................................7-57
Crossing a slope .................................7-61
Crossing through shallow water ..........7-65
Riding over rough terrain ....................7-69
67
Sliding and skidding............................ 7-71
What to do if ....................................... 7-75
What to do .......................................... 7-75
PERIODIC MAINTENANCE AND
ADJUSTMENT ......................................... 8-1
Owner’s manual and tool kit ................. 8-3
Periodic maintenance/lubrication.......... 8-7
Engine oil and oil filter element........... 8-17
Transfer gear oil replacement............. 8-29
Final gear oil ....................................... 8-33
Differential gear oil replacement ......... 8-39
Axle boots ........................................... 8-41
Spark plug inspection ......................... 8-43
Air filter cleaning ................................. 8-47
Carburetor adjustment ........................ 8-55
Idle speed adjustment ........................ 8-57
Valve clearance adjustment ............... 8-59
Select lever safety system cable
adjustment ........................................ 8-59
Throttle lever adjustment .................... 8-61
Front brake pad check ........................ 8-61
Rear brake shoe inspection ................ 8-63
Brake fluid level check ........................ 8-63
Brake fluid replacement ...................... 8-67
Front brake lever free play.................. 8-69
8
U1C160.book Page 2 Wednesday, May 12, 2004 4:55 PM
Page 18 of 398
Brake pedal and rear brake lever
adjustment........................................ 8-71
Adjusting the rear brake light switch... 8-79
Clutch adjustment............................... 8-81
Cable inspection and lubrication ........ 8-83
Brake and shift pedal/brake lever
lubrication ......................................... 8-83
Wheel removal ................................... 8-85
Wheel installation ............................... 8-85
Battery ................................................ 8-87
Battery maintenance .......................... 8-91
Fuse replacement............................... 8-93
Replacing a headlight bulb ................. 8-97
Headlight beam adjustment................ 8-99
Tail/brake light bulb replacement ..... 8-101
Troubleshooting................................ 8-103
Troubleshooting chart....................... 8-105
CLEANING AND STORAGE ................... 9-1
A. Cleaning ........................................... 9-1
B. Storage ............................................ 9-7
SPECIFICATIONS ................................. 10-1
CONVERSION TABLE .......................... 11-1
91011U1C160.book Page 3 Wednesday, May 12, 2004 4:55 PM
Page 19 of 398
U1C160.book Page 4 Wednesday, May 12, 2004 4:55 PM
Page 20 of 398
FBU00015
TABLE DES MATIÈRES
EMPLACEMENT DES ÉTIQUETTES
D’AVERTISSEMENT ET DE
CARACTÉRISTIQUES ...................................... 1-2
CONSIGNES DE SÉCURITÉ............................ 2-2
DESCRIPTION ET IDENTIFICATION DU
VÉHICULE........................................................... 3-2
Numéros d’identification ................................. 3-4
Numéro d’identification de la clé.................... 3-6
Numéro d’identification du véhicule ............... 3-8
Étiquette de modèle ........................................ 3-10
FONCTION DES COMMANDES ..................... 4-2
Contacteur à clé................................................ 4-2
Témoins et témoins d’avertissement ............... 4-4
Compteur de vitesse ....................................... 4-10
Jauge de carburant .......................................... 4-12
Contacteurs au guidon .................................... 4-14
Levier d’accélération ...................................... 4-18
Limiteur de vitesse.......................................... 4-20
Levier de frein avant....................................... 4-22
Pédale de frein et levier de frein arrière......... 4-24
Frein de stationnement ................................... 4-26
1234
Pédale de sélection ......................................... 4-28
Levier de présélection .................................... 4-28
Lanceur à réenroulement ............................... 4-30
Bouchon du réservoir de carburant ............... 4-30
Robinet de carburant ...................................... 4-32
Starter (enrichisseur) ...................................... 4-34
Selle................................................................. 4-36
Compartiment de rangement ......................... 4-38
Porte-bagages avant ....................................... 4-38
Porte-bagages arrière...................................... 4-38
Réglage des amortisseurs avant..................... 4-40
Réglage de l’amortisseur arrière.................... 4-42
Prise pour accessoires .................................... 4-44
CONTRÔLES AVANT LE DÉMARRAGE......5-2
Freins avant et arrière........................................5-6
Carburant ........................................................ 5-10
Huile de moteur et huile de boîte
intermédiaire ................................................ 5-14
Huile de transmission finale et huile de
différentiel .................................................... 5-16
Levier d’accélération...................................... 5-16
Visserie ........................................................... 5-18
Éclairage ......................................................... 5-18
5
U1C160.book Page 1 Wednesday, May 12, 2004 4:55 PM