engine YAMAHA YD110 2007 Owner's Manual

1. Spark plug gap
LikdZ Iyx dk xSi
Spark plug inspection
LikdZ Iyx dk fujh{k.kThe spark plug is an important
engine component and is easy to
inspect. The condition of the spark
plug can indicate the condition of the
engine. The ideal color on the white
insulator around the center electrode
is a medium-to-light tan color for a
Motorcycle that is being ridden
Normally. Do not attempt to diagnose
any problems yourself. Instead, take
the Motorcycle to a YMIS dealer. You
should periodically remove and
inspect the spark plug because heat
and deposits will cause the spark
plug to slowly break down and erode.
If electrode erosion becomes
excessive, or if carbon and otherBefore installing the spark plug,
measure the electrode gap with a
wire thickness gauge; adjust the gap
to specification as necessary.
LikdZ Iyx yxkus ds igys bysDVª¨M ds(xSi
) d¨ ok;j xst }kjk uki yasA tSlk
Hkh vko';d g¨ bl varj d¨ fu£n"Vuqlkj
(o£.kr&fof/k
) ls O;ofLFkr djsA
,-&LikdZ Iyx dk xsi:
0.9feñehñ
(-0.2 feñehñ
)
When installing the plug, always
clean the gasket surface and use a
new gasket. Wipe off any grime from
the threads and tighten the spark
plug to the specified torque.Iyx yxkrs le; ges'kk xSlfdV ds ry
d¨ lkQ djs rFkk u;k xSlfdV yxk;saA
pwM+h
(FkzSM~l
) ij yxh xanxh d¨ i¨aN Mkysa
v©j bls fu£n"V VkdZ rd dl nsA
Specified spark plug
fu£n"V fd;k x;k LikdZ Iyx %
P-RA7HC (Champion)
6.9A-Spark plug gap: 0.9mm(-0.2 mm)
deposits are excessive, you should
replace the spark plug with the
specified plug.LikdZ Iyx batu dk egÙoiw.kZ iqtkZ gS
rFkk bldh tk¡p djuk cgqr t#jh gSA
LikdZ Iyx dh fLFkfr ls batu dh gkyr
dk irk yxk;k tk ldrk gSA chp dh
bysDVª¨M ds pkj¨ rjQ lQsn balqysVj ds
Åij vkn'kZ jax] e/;e&gYdk Hkwjk gS t¨
;g n'kkZrk gS fd e¨VjlkbZfdy d¨
lkekU;r% lgh rjhds ls pyk;k tk jgk
gSA fdlh çdkj dh leL;kv¨a dk funku
djus ds fy, Lo;a ç;Ru u djsaA
e¨VjlkbZfdy d¨ okbZñ,eñvkbZñ,lñ Mhyj
ds ikl ys tk,¡A vkid¨ le;≤ ij
Iyx ckgj fudky dj mldh tk¡p djrs
jguk pkfg,] D;¨afd Å"ek rFkk tes gq,
d.k /khjs&/khjs LikdZ Iyx dh dk;Z&izzzzzzzðfr
d¨ [kjkc dj nsrs gS v©j bls u"V dj nsrs
gSA ;fn bysDVª¨M dk fljk
(Åij dk
fgLlk
) cgqr T;knk [kjkc g¨ tkrk gS
vFkok bl ij dkcZu rFkk nwljs tek d.kks
dh vf/kdrk c<+ tkrh gS r¨ vkid¨ bl
*LikdZ Iyx^ d¨ fu£n"V fd, x, Iyx ls
cny nsuk pkfg,A
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 47

1. Engine oil filter cap
batu vkW;y fQYVj dSi
Engine oilbatu dk rsy1. Oil level measurement
rsy ds Lrj dks ukiukA
a. Place the Motorcycle on the
centerstand. Warm up the engine
for several minutes., - e¨VjlkbZfdy d¨ lSaVj LVSaM ij [kM+k
dj nsaA batu d¨ dbZ feuV¨a rd
/khjs&/khjs xeZ djsaA
1. Maximum level
mPpre Lrj
2. Minimum level
fuEure Lrj
NOTE :Wait a few minutes until the oil level
settles before checking.u¨V %tk¡p djus ls igys tc rd vWk;y dk
Lrj ¼ysoy½ fLFkj u g¨ tk, rc rd
dqN feuV¨a ds fy, çrh{kk djsA
NOTE :
Be sure the Motorcycle is positioned
straight up when checking the oil
level. A slight tilt toward the side can
result in false readings.u¨V %;g lqfuf'pr djs fd rsy dk Lrj ns[krs
le; e¨Vj&lkbZfdy viuh txg ij lh/kh
[kM+h jgsA ,d rjQ d¨ Fk¨M+k lk Hkh
>qdko jgus ls jh¯Mx xyr g¨ ldrh gSA
ALWAYS CHANGE ENGINE OIL AT RECOMMENDED INTERVALS
FOR OPTIMUM ENGINE PERFORMANCE AND ENGINE LIFE
6.11
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 49

b. Unscrew the dipstick and rest it
on the threads of the oil filler hole.
The oil level should be between
the minimum and maximum
mark on the dipstick. If the level
is low, add oil to raise it to the
specified level.ch- fMikfLVd d¨ [k¨y ysa v©j bls
fQyj ds Nsn ij fVdk nsaA vkW;y
dk ysoy fMikfLVd ds fuEure o
mPpre fu'kku ds e/; esa g¨uk pkfg,A
;fn ysoy de yxs r¨ bls c<+kus ds
fy, fu£n"V Lrj rd rsy MkysaA
1. Dipstick
fMifLVd
2. Engine oil replacement
batu&rsy d¨ cnyuk
a. Warm up the engine for a few
minutes.
dqN feuV¨ ds fy, batu d¨ xeZ
djsaA
b. Stop the engine. Place an oil pan
under the engine and remove
the dipstick.
batu d¨ can dj nsA batu ds uhps
,d vkW;y iSu ¼crZu½ j[k ysa rFkk
fMikfLVd d¨ ckgj fudky ysaA
batu dh vf/kd dk;Z{kerk rFkk nh?kZ thou ds fy, batu&vkW;y d¨ ges'kk çLrkfor
varjky¨ ij cnyrs jgsaA
6.12
PERIODIC MAINTENANCE AND MINOR REPAIRlkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 50

1. Engine oil drain plug
batu vkW;y Mªsu Iyx
c. Remove the drain plug and drain
the oil.
Mªsu Iyx dks [kksy dj ckgj fudky
ysa v©j rsy dks fudyus nsaA
d. Reinstall the drain plug and
tighten it to the specified torque.
Mªsu Iyx dks fQj ls yxk nsa v©j bls
fu£n"V VkdZ rd dl nsaaA
f. Start the engine and warm up for
a few minutes. While warming
up, check for oil leakage. If oil
leakage is found, stop the engine
immediately and check for the
cause.
batu dks pkyw djsa v©j dqN feuVksa
ds fy, FkksM+k xeZ djrs le; rsy ds
fjlko dh tk¡p dj ysaA ;fn rsy
*yhd^ dj jgk gks rks batu dks rqjar
can dj nsa vkSj dkj.k dh tk¡p djsaA
ALWAYS CHANGE ENGINE OIL AT RECOMMENDED GRADE OF ENGINE OIL
ges'kk dsoy çLrkfod xzsM dk batu&vkW;y gh ç;ksx djsaA
e. Fill engine with oil and install the
dipstick.
batu dks rsy ls Hkj ysa v©j fMikfLVd
dks mlesa yxk nsaA
Tightening torque
dlk x;k VkdZ %
Drain plug
Mªsu Iyx %
14.5 Lt.-lb (2.0 m-kg)
Recommended oil:
YAMALUBE 4 stroke motor oil
(20 W 40 type SG) or equivalent.
Oil quantity:
Total amount : 1.2 L
Periodic oil change :1.0 L
6.13
çLrkfod rsy %
;kekY;wc&
4 LVªksd eksVj vkW;y
¼
20
M~CY;w
40
Vkbi ,l th½ vFkok
mlds leku½
rsy dh ek=kk %
dqy ek=kk %
1.2
fyñ
le;≤ ij rsy esa
ifjorZu %
1.0
fyñ
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
1
PG1_55.pmd10/15/2006, 9:15 AM 51

CAUTION :
•Make sure the air filter is
properly seated in the air filter
case.
• The engine should never be run
without the air filter installed.
Excessive piston and/or
cylinder wear may result.
• Dirty Element Air Cleaner
causes excessive fuel
consumption and loss of
power.
• Clean Element Air Cleaner after
every 2000 kms.
• The Element Air Cleaner should
be cleaned and lubricated more
frequently (every 1000 km,s), if
Motorcycle is operated in very
dusty (e.g. unpaved, dust laden
roads) conditions. lko/kkuh %•
;g lqfufpr djsa fd ,;j&fQYVj
lgh tk,A
excess oil. They should be wet
but not dripping.çR;sd ewy Hkkx dh van#uh lrg ij
çLrkfod rsy gh yxk, v©j Qkyrw
rsy ds fupksM+ ysA os ¼ewy Hkkx½ xhys
gksus pkfg, u fd rsy esa Mwcs gq,A
6.15
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
Recommended oil
çLrkfod rsy :
20W40 type SG
7. Pull the air filter elements over
the frame and install the air filter
in the case.
,;j&fQYVj ds ,yhesaV ¼ewy&fgLlksa½
dks Ýse ds Åij ls [khap ys rFkk
,;j&fQYVj dks dsl ds vanj yxk nsaA
8. Install the Spring Wire.
¯Lçx okW;j Hkh yxk,¡A
9. Install the air filter case cover and
panel
,;j&fQYVj dsl ds doj v©j iSuy
dks yxk nsaA
CAUTION :

Do not twist Element Air Cleaner.lko/kkuh
:
,;j&fQYVj ,fyesaV dks u ?kqek;saA WARNINGEnsure no distortion/proper
positioning of felt seal 1 if damaged
contact YMIS dealer.
psrkouh
QsYV lhy
1 lgh rjg ls yx;sa vxj [kjkc
gks rks okbZñ ,eñ vkbZñ ,lñ ds Mhyj ls laidZ
djsaA1
PG1_55.pmd10/17/2006, 8:31 AM 53

•
,;j&fQYVj dks yxk, fcuk batu
dHkh Hkh ugh pykuk pkfg,A blds
dkj.k fiLVu v©j flysaMj dk f?klko
vf/kd gks ldrk gSA
•
/kwy feêh ls Hkjs xans Þ,yhesaV ,;j
Dyhujß ls rsy dh [kir cgqr c<+
tkrh gS rFkk 'kfDr ¼ikWoj½ dh {kfr
gksrh gSA
•
,yhesaV ,;j Dyhuj dks çR;sd
2000
fdñehñ ds ckn lkQ djsaA
•
;fn eksVjlkbZfdy dks cgqr /kwy&feêh
;qDr fLFkfr;ksa esa pyk;k tkrk gS rks
,yhesaV ,;j Dyhuj dh lQkbZ rFkk
Y;qczhdsa'ku T;knk 'kh?kzrk ls gksuk
pkfg, ¼çR;sd
1000
fdñehñ ij½A
Carburetor adjustmentdkc¨ZjsVj dks lSV djukThe carburetor is a vital part of the
engine and requires very
sophisticated adjustments. Most
adjustments should be left to a YMIS
dealer who has the professional
knowledge and experience to do so.
However, the following may be
serviced by the owner as part of
routine maintenance.
dkc¨ZjsVj batu dk ,d egÙoiw.kZ Hkkx
g¨rk gS v©j bldh ,MtLVesaV mPp
rduhd }kjk djuh iM+rh gSA cgqr lh
,MtLVesaVl ¼rky&esy½ d¨
okbZñ,eñvkbZñ,lñ Mhyj ds Åij N¨M+
nsuk pkfg,] ftUgs bl rjg dk dke djus
dk i;kZIr vuqHko rFkk O;olkf;d Kku
gSA tcfd fuEufyf[kr dks e¨VjlkbZfdy
dk ekfyd vke ejEer dh rjg dj
ldrk gSSA
6.16
CAUTION :
The carburetor is set at the YMIS
factory after many tests. If the
settings are changed, poor engine
performance and damage may
result. lko/kkuh
:
vusd¨ VsLV djus ds ckn dkc¨ZjsVj d¨
okbZñ,eñvkbZñ,lñ dkj[kkus esa O;ofLFkr
fd;k tkrk gSA ;fn bldh *lS¯Vx^ esa
ifjorZu yk;k tkrk gS r¨ ;g batu dh
rqPN dk;Z{kerk v©j {kfr dk dkj.k cu
ldrh gSA
Idle speed adjustmentvkn'kZ xfr dh ,MtLVesaVNOTE :
A diagnostic tachometer must be
used for this procedure.u¨V
:
bl çfd;k ds fy, ,d *Mk;xu¨fLVd
VSd¨ehVj^ dk ç;¨x fd;k tkuk pkfg,A1. Attach the tachometer. Start the
engine and warm it up for a few
minutes at approximately 1,000
to 1,500 r/min. Occasionally rev
the engine to 4,000 to 5,000 r/
min. The engine is warm when it
quickly responds to the throttle.
VSd¨ehVj yxk;sa] batu d¨ pkyw djsa
v©j dqN feuVks ds fy, xeZ djsa rkfd
bldh xfr
1,000
ls
1,500
pDdj
çfr feuV rd igq¡p tk;saA dHkh&dHkh
bls
4,000
ls
5,000
pDdj çfr
feuV ij Hkh ysa tk;saA tc batu
'kh?kzrk ls FkzkWVy ds vuqdwy dk;Z
djrk gS r¨ ;g xeZ g¨rk gSA
PERIODIC MAINTENANCE AND MINOR REPAIRlkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 54

Adjust the throttle cable by turning the
adjusting nut so that specified free
play at the throttle grip is obtained.,Mt¯LVx uV d¨ ?kqekdj FkzkWVy dscy
d¨ O;ofLFkr djs] ftlls fd FkzkWVy fxzi
ij fof'k"V Lora=k Iys çkIr fd;k tk
ldsA
Free play
Ýh Iys %
3 ~ 7 mm NOTE :
If the specified idle cannot be
obtained by performing the above
adjustment, consult a YMIS dealer.
u¨V %;fn mij¨Dr vMtLVesaV d¨ dk;Z:i
nsus ij Hkh fof'k"V vkn'kZ xfr çkIr ugh
dh tk ldrh gS r¨ okbZñ,eñvkbZñ,lñ
Mhyj ls laidZ djsaAThrottle cable free play
adjustmentFkzkWVy dscy dh Ýh Iys ,MtLVesaVNOTE :
Before checking the throttle cable
free play, the engine idling speed
should be adjusted.u¨V%FkzkWVy dscy dh Ýh Iys dh tk¡p djus ls
igys] batu dh vkn'kZ xfr d¨ O;ofLFkr
fd;k tkuk pkfg,A
1. Throttle stop screw
FkzkWVy d¨ j¨dus dk isp
2. Set the idle to the specified
engine speed by adjusting the
throttle stop screw. Turn the
screw in direction ç to increase
engine speed and in directions
è to decrease engine speed.FkzkWVy d¨ j¨dus dk isp d¨ O;ofLFkr
djrs gq, batu dh fof'k"V xfr d¨
vkn'kZ fLFkfr esa ysdj vk,¡A batu dh
xfr c<+kus ds fy, isap d¨ , dh fn'kk
esa ?kqek,¡A batu dh xfr ?+kVkus ds fy,
isap d¨ ch dh fn'kk esa ?kqek,¡A
Standard idle speed LVSaMMZ vkn'kZ xfr
:
1,300 ~ 1,500 pDdj çfr feuV
6.17
PERIODIC MAINTENANCE AND MINOR REPAIR
lkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 55

1. Tread depth
VsªªM MsIFk
2. Side wall
lkbM okWy
Tyres
Vk;j
To ensure maximum performance, long
service and safe operation, note the
following:vR;f/kd dk;Z{kerk] nh?kZ l£ol v©j lqjf{kr
dk;Z ds fy, fuEufyf[kr ij /;ku nsa %1. Tyre air pressure
Always check and correct the tyre
pressure before operating the
Motorcycle.
Vk;j esa gok dk ncko
e¨Vj&lkbZfdy pykus ls igys ges'kk Vk;j
esa gok ds ncko d¨ tk¡p ys v©j bls
O;ofLFkr djasA
1. Free play
Ýh Iys
2. Locknut
ykWd uV
3. Adjusting nut
,Mt¯LVx uV
1. Loosen the locknut.
ykWd uV dks 2. Turn the adjusting nut in direction
ç to increase free play and in
direction è to decrease free play.
Ýh Iys d¨ c<+kus ds fy, ,Mt¯LVx uV
d¨ , dh fn'kk esa ?kqek,¡ rFkk Ýh Iys d¨
de djus ds fy, bls ch fn'kk esa ?kqek,¡A
3. Tighten the locknut.
ykWd uV d¨ dl nsaA
Valve clearance adjustment:okYo dh Dyh;jsal dk rkyesy %The correct valve clearance changes
with use, resulting in improper fuel/
air supply or engine noise. To prevent
this, the valve clearance must be
adjusted regularly. This adjustment
however, should be left to a YMIS
dealer.mfpr okYo Dyh;jsal t¨ fd batu ds ç;¨x
ds lkFk cnyrk jgrk gS] vuqfpr b±/ku@gok
dh lIykbZ vFkok batu esa 'k¨j dk dkj.k curk
gSA blds cpus ds fy, okYo ds Dyh;jsal d¨
yxkrkj O;ofLFkr djrs jguk pkfg,A oSls bl
rjg ds ,MtLVesaV ¼ rkyesy½ d¨
okbZñ,eñvkbZñ,lñ Mhyj }kjk gh djok;k tkuk
pkfg,A
KEEP RECOMMENDED TYRE PRESSURE IN BOTH THE TYRES
n¨u¨ Vk;j¨a esa vuqe¨fnr ok;q&ncko gh j[ksaA
6.18
PERIODIC MAINTENANCE AND MINOR REPAIRlkef;d j[kj[kko rFkk ekewyh ejEer
PG1_55.pmd10/15/2006, 9:15 AM 56

fy, batu ds uhps ,d LVS.M yxk ysaaA
vxys QksdsZa ds fupys fljs dks idM+ dj
j[ksa vkSj mUgsa vkxs rFkk ihNs dh vksj
pykus dk iz;Ru djsaA ;fn fdlh rjg
dk Lora=k ¼Ýh½ Iys eglwl fd;k tk jgk
gks rks okbZñ,eñvkbZñ,lñ Mhyj ls LVs;¯jx
dh tk¡p djus vkSj ^,MtLV* djus dks
dgsaA ;fn vkxs dk ifg;k gVk fn;k tk,
rks tk¡p djuk vklku gks tkrk gSA WARNINGSecurely support the Motorcycle
so there is no danger of it falling
over. psrkouheksVjlkbfdy dks lqjf{kr rjhds ls lgkjk
nsdj j[ksa rkfd blds iyV dj fxjus
dk [krjk u jgsA
Steering inspectionLVs;¯jx dh tk¡pPeriodically inspect the condition
of the steering. Worn out or loose
steering bearings may be
dangerous. Place a stand under
the engine to raise the front wheel
off the ground. Hold the lower end
of the front forks and try to move
them forward and backward. If any
free play can be felt, ask a YMIS
dealer to inspect and adjust the
steering. Inspection is easier if the
front wheel removed.le;≤ ij LVs;¯jx dh fLFkfr dk
fujh{k.k djrs jgasA LVs;¯jx dh f?klh gqbZ
vFkok vxys ifg, dks t+ehu ls Åij mBkus ds
6.32
CAUTION :If any damage or unsmooth
movement is found with the front
fork, consult a YMIS dealer. lko/kkuh %;fn vxys QksdZ dks dk;Z djus esa dksbZ
:dkoV vk jgh gS vFkok ;g dgha ls
{kfrxzLr gk x;k gS rks okbZñ,eñvkbZñ,lñ
Mhyj ls ijke'kZ ysaAPERIODIC MAINTENANCE AND MINOR REPAIRlkef;d j[kj[kko rFkk ekewyh ejEer
pg56_96.pmd10/15/2006, 8:53 AM 68

Enough fuel
Go to compression check
No fuel
Supply fuel
Engine doesn’t start, go to
compression check.
There is compression
Go to Ignition check.
No compression
Ask YMIS dealer to inspect.
Wipe clean with dry cloth
and correct spark plug
or replace spark plug.
Wet
Open the throttle halfway
and start the engine.If Engine does not start
Contact YMIS dealer.
Ask YMIS
dealer to inspect.
Dry with
Black Soot
Check if there is fuel
in the fuel tankUse kick starter.Remove spark
plug and check
electrode.
Troubleshooting chart - For Starting
WARNINGNever Check the fuel system while smoking or in the vicinity of an open flame.
1. Fuel
2. Compression
3. Ignition
6.46
PERIODIC MAINTENANCE AND MINOR REPAIRlkef;d j[kj[kko rFkk ekewyh ejEer
pg56_96.pmd10/15/2006, 8:53 AM 82