steering Alfa Romeo 156 2004 Owner handbook (in English)

CAR MAINTENANCE
256
A0B0558m
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluid
1Engine oil - 2Battery - 3Brake fluid -
4Windscreen washer fluid - 5Engine
coolant fluid - 6Power steering fluidfig. 5 - JTD 16V Multijet version
fig. 6 - JTD 20V Multijet version
To improve picture detail, the engine compartment is illustrated without the bonnet
A0B0616m

CAR MAINTENANCE
262
WARNINGContact Alfa Romeo Autho-
rized Services for maintenance and repair
operations. If the level of the oil in the reservoir falls
below the specified level, top up only with
one of the products listed in the table
“Fluids and lubricants” in the “Technical
specifications” chapter as follows:
– Start the engine and allow the oil in the
reservoir to settle.
– When the engine is running turn the
steering wheel lock to lock a few minutes.
– Top up to the MAXlevel notch and
then replace the cover.Oil consumption is very
low, if topping up again is
needed shortly afterwards,
have the system checked for pos-
sible leaks by Alfa Romeo Autho-
rized Services.fig. 19 fig. 18
A0B0158m
A0B0158m
POWER STEERING OIL LEVEL Fig. 17: T.SPARK versions
Fig. 18: 2.0 JTS versions
Fig. 19: 2.5 V6 24V and JTD versions
Check that the oil level in the reservoir is
at the MAX level.
This operation must be carried out with the
car on level ground and when the engine
is stationary and cold.
Check that the level reaches the MAXref-
erence notch on the reservoir or coincides
with the upper notch (maximum level) on
the dipstick integral with the reservoir cap.fig. 17
A0B0159m
Power steering fluid is
highly inflammable. Do not
let it come into contact with hot en-
gine parts.
WARNING

CAR MAINTENANCE
271
WHEELS AND TYRESTYRES PRESSURECheck the pressure of each tyre, includ-
ing the compact spare wheel, every two
weeks and before a long journey.
The pressure should be checked with the
tyre rested and cold.
It is normal for the pressure to increase
when the car is in use. If you have to check
or restore the pressure when the tyres are
hot, bear in mind that the pressure should
be +0.3 bar compare with the specified rat-
ing.
For the correct tyre inflation pressure, see
“Wheels” in the “Technical specifications”
chapter.Incorrect pressure causes abnormal tyre
wear fig. 25:
A- Normal pressure: tread evenly worn.
B- Low pressure: tread particularly worn
at the edges.
C- High pressure: tread particularly worn
in the centre.
fig. 25
A0B0235m
WARNINGS
Where possible, avoid sudden braking, tyre
squealing starts, etc.
Particularly avoid violent bumps against
kerbs, potholes or obstacles of various kinds.
Prolonged driving on rough roads may dam-
age the tyres.
Routinely check the tyres for cuts on the
sides, swellings or uneven tread wear. If nec-
essary contact Alfa Romeo Authorized Ser-
vices.
Avoid overloading the vehicle when trav-
elling: this may cause serious damage to the
wheels and tyres.
If a tyre is punctured, stop immediately
and change it to avoid damage to the tyre,
the rim, suspensions and steering system.
Tyres age even if they are not used much.
Cracks in the tread rubber are a sign of ag-
ing. In any case, if the tyres have been on
the car for over 6 years, they should be
checked by specialised personnel, to see if
they can still be used. Also remember to
check the spare wheel.
Remember that car road
holding also depends on
correct tyre inflation pressure.
WARNING
Excessively low pressure
causes overheating of the
tyre with the possibility of serious
damage to it.
WARNING
Tyres should be changed when the tread
thickness is reduced to 1.6 mm. In any case
follow local regulations.

TECHNICAL SPECIFICATIONS
305
SPARK PLUGClean, intact spark plugs are determinant
with regard to engine efficiency and for re-
ducing the emission of pollutants.Spark plugs should be re-
placed at the intervals
specified in the Scheduled
Maintenance Programme. Only use
spark plugs of the specified type: if
the thermal capacity is inadequate
or if the envisaged life is not guar-
anteed inconveniences may ensue.BRAKESService brakes:
– front
– rearParking brake
If examined by an expert eye, the ap-
pearance of a spark plug is a sound clue
for locating a fault, even if not involving the
ignition system. Therefore if you are expe-
riencing any engine problems, it is impor-
tant to have the spark plugs checked by Al-
fa Romeo Authorized Services.
STEERING
1.6 T.SPARK 1.8 T.SPARK 2.0 JTS 2.0 JTS 2.5 V6 24V 2.5 V6 24V JTD JTD 20V
Selespeed Q-System JTD 16V Multijet
MultijetSelf-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated Self-ventilated
disk disk disk disk disk disk disk disk
Disk Disk Disk Disk Disk Disk Disk Disk
Wheel anti-look system (ABS) with electronic braking distribution.
Servo-brake. Electronic control with brake pad wear sensors. Gasket of ecological type.
Controlled by hand lever operating rear brakes.
Type Turning radius(between pavements)
1.6 T.SPARK 1.8 T.SPARK 2.0 JTS 2.0 JTS 2.5 V6 24V 2.5 V6 24V JTD-JTD 16V JTD 20V
Selespeed Q-System Multijet Multijet
Rack and pinion.
Hydraulic power steering with liquid reservoir in engine compartment
11.1 m 11.1 m 11.1 m 11.1 m 11.6 m 11.6 m 11.1 m 11.1

TECHNICAL SPECIFICATIONS
321
UseLubricants and greases
for transmissionsBrake fluidProtective agent for radiatorsAdditive for fuel oil
Windscreen/
rearscreen/headlampwasher fluid
(*) IMPORTANTDo not add or mix with fluids with specifications other than the specified ones.Quality features of fluids and lubricants
for correct vehicle operation
Synthetic-based engine oil, SAE 75W-80 EP grade that passes API GL5
and MIL-L-2105 D Lev specifications
SAE 75W-85 completly synthetic engine oil.
Meets API GL 4 and ZF TE ML06 (B&C) LEVEL, ALLISON C4 specifications
“ATF DEXRON II D LEV”, type oil
“ATF DEXRON III” type specific oil
“ATF DEXRON II D LEV”, SAE 10W type oil
Lithium-soap-based grease with molybdenum bisulphate.
Consistency NLGI 2
FMVSS n° 116 DOT 4, ISO 4925, SAE J1704,
CUNA NC 956-01 synthetic fluid
Protective with antifreeze action, blue color, based on inhibited monoethylene
glycol, CUNA NC 956-16
Protective with antifreeze action, red colour, based on inhibited monoethylen
glycol, with O.A.T.-based organic formula, that passes CUNA NC 956-16,
ASTM D 3306 specifications
Additive for fuel oil with protective action for Diesel engines
Mixture of spirits and surface-active agents CUNA NC 956-11Recommended fluids
and lubricants
TUTELA CAR
ZC 75 Synth
TUTELA CAR
MATRYX
TUTELA GI/2
TUTELA CAR
CS SPEED
TUTELA GI/A
TUTELA MRM 2
TUTELA CAR TOP 4
for Alfa Romeo
PARAFLU 11 (*)
or
PARAFLU UP (*)
DIESEL MIX
TUTELA
PROFESSIONAL
SC 35
Applications
Mechanical gearbox and
differential
Mechanical gearbox and
differential for high
temperatures
Automatic gearbox
Selespeed transmission
electrically-operated
electrohydraulic drive
Hydraulic power steering
C.V. joints
Hydraulic brake and
clutch control
Cooling ducts
Percentage:
50% down to –35°C
To be mixed with the fuel
oil (25 cc per 10 litres)
To be used neat
or diluted

ALPHABETICAL INDEX
327
Bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219Car lifting
– with arm hoist ....................... 245
– with jack .............................. 245
– with workshop hoist .............. 245
Car maintenance..................... 248
Carrying children safely ................ 35
Catalytic converter ....................... 188
Ceiling lights................................ 162
– centre rear roof lamp .............. 163
– courtesy light......................... 163
– front roof light ....................... 162
– rear roof light ........................ 163
Centre rear roof lamp.................... 163
– bulb replacement ................... 231
Changing battery of key
with remote control ................... 10
Changing bulbs
– general instructions ............... 218
– replacement .......................... 217
– types of bulbs ................. 218-219
Changing wheels.......................... 209
– general instructions ................ 207Charging the battery .............. 242-268
Checking levels ............................ 254
– brake and clutch fluid ............. 263
– engine coolant....................... 261
– engine oil ............................. 257
– power steering oil .................. 261
– Q-system automatic
gearbox oil............................ 260
– Selespeed gearbox oil ............ 259
– windscreen/rearscreen/
headlamp washing fluid .......... 264
Child safety device .............. 19-35-279
Children (carrying safely) ............. 35
– child’s seats .................... 35-38
– presetting for installing the
Isofix type child restraint system 39
Cigar lighter ............................... 164
Cleaning and maintenance
– car exterior ........................... 274
– car interior ............................ 277
– engine compartment ............. 276
– fabric seats .......................... 277
– leather seats ........................ 277
– plastic parts........................... 277
– windows ............................... 276
Climate control system.................. 108
– air vents................... 108-109-110– controls ................................ 118
Climate control system, automatic
two-zone ................................. 114
Clock .......................... 57-58-59-60-61
Clutch
– checking fluid level
and topping up ...................... 263
CO
2emissions ............................. 324
CODE card................................... 7
Compact spare wheel ................... 294
– technical data ........................ 312
Controls ...................................... 135
Correct use of the car............ 189
Courtesy light .............................. 163
– bulb replacement ................... 232
Cruise control
(constant speed adjustment) ...... 53
Current socket (boot) ................... 285
D
ashboard ................ 57-58-59-60-61
– brighting adjustment............... 63
Dashboard lighting dimming .......... 136
Demisting-defrosting
– door mirrors .................... 25-133
– rearscreen....................... 26-133
– windscreen and front
side windows ........................ 132

ALPHABETICAL INDEX
329
Front light units
– bulb arrangement................... 220
Front roof light ............................ 162
– changing bulbs ...................... 230
Front seats .................................. 21
– adjustments .......................... 21
– centre armrest ....................... 22
– electric heating ..................... 22
– headrests .............................. 23
– rear pockets .......................... 23
Fuel
– consumption ......................... 322
– emergency flap opening
device ............................ 186-292
– fuel cap ............................... 186
– fuel flap................................ 137
– inertial fuel cut-off switch ........ 137
– level gauge and reserve
warning light ......................... 62
– refilling ................................ 319
– refuelling ........................ 185-292
– specifications ......................... 319
Fuel reserve ......................... 62-319
Fuel supply (technical data)........... 303
Fuel tank (capacity) .................... 319
Fuses and relays
– fuse summary table................ 238– fuses above the main fusebox.. 236
– fuses and relays accessible from
the glovebox ......................... 236
– fuses and relays in engine bay . 236
– fuses and relays in the main
fusebox ................................ 235
– generalities and cautions ........ 234
– list of protected devices .......... 238
– specific fuses for Sportwagon
versions ................................ 299
G
earshift lever ........................... 139
Getting to know your car.... 6
Glovebox light
– changing bulbs ..................... 232
Grab handles .......................... 161-292
H
andbrake lever......................... 138
Hazard lights
– switching on ......................... 135
Headlight aiming device
(corrector)................................ 138
Headlight washer ................... 52-274
Headlights
– beam adjustment .................. 138
– beam adjustment abroad ........ 177
– bulb replacement ............. 217-220– compensation for tilt............... 175
– gas discharge headlights ......... 176
Headrests
– front .................................... 23
– rear ............................... 24-279
Horn .......................................... 56
Identification data ....................... 299
Identification labels ...................... 300
Ignition device and steering lock 17-18
In an emergency.................... 205
In the event of a puncture ....... 207-294
– changing a wheel................... 209
– FIX&GO (quick tyre repair kit) . 212
– general instructions ................ 207
In the event of an accident ............ 246
– first aid kit ............................ 247
– if anybody is injured .............. 246
Inertial fuel cut-off switch .............. 137
Infocenter ................................... 64
– access to main menu screen .... 72
– control buttons ...................... 66
– date setting/time setting ........ 76
– default value reset ................. 85
– display ................................. 64
– display contrast adjustment ..... 84

ALPHABETICAL INDEX
331
N
umber plate lights
– changing bulbs ................ 229-296
O
ddment recesses
– in the boot ........................... 285
– on centre console ................... 165
– on dashboard ........................ 165
Odometer ................................... 59
Paintwork (maintenance) ............ 275
– colour label ........................... 301
Parking....................................... 191
Parking sensors............................ 187
Partial odometer .......................... 63
Performance................................ 314
Pockets and compartments
on front doors ........................... 165
Pollen filter ................................ 266
Power steering
– checking fluid level
and topping up ..................... 262
Power windows ........................... 27
Pre-tensioning devices ................... 32
Protecting emission reducing
devices ....................................... 198
Q
-system automatic gearbox........ 152
– acoustic warning .................... 159
– automatic operation ............... 154
– checking the oil level .............. 260
– fault signalling ....................... 158
– manual operating mode/
Q-System activation................ 157
– moving off ............................ 152
– push starting ......................... 159
– selecting automatic/
manual gearshifting................ 153
– selecting the driving modes ..... 156
– starting the engine ................. 152
– stopping the car ..................... 157
– towing the car ....................... 160
R
adio transmitters and cellular
telephones ............................... 167
Rain sensor ................................. 51
Rear fog guards
– changing bulbs ............... 227-294
– switching on.......................... 136
Rear light units
– bulb replacement ................... 227
Rear roof lights ............................ 163
– changing bulbs ...................... 231
Rear seats................................... 23– centre armrest ................. 23-280
– headrests ....................... 24-279
– ski compartment.............. 24-280
Rear suspensions
(automatic geometry control) ..... 293
Rearscreen heating................. 26-133
Rearscreen washer ....................... 281
– spray jet ............................... 281
Rearscreen wiper
– blade replacement ................. 281
– operation .............................. 281
Reducing running costs
and environment pollution .......... 197
Refilling ..................................... 319
Remote control ............................ 7-12
– additional remote controls ...... 12
– alarm system ........................ 11
– boot opening ......................... 8
– changing the battery .............. 10
– door opening-closing ............... 7
– ministerial homologation ......... 325
– remote door locking/
unlocking .............................. 16
Rev counter................................. 62
Reversing lights
– changing bulbs ................ 227-294

ALPHABETICAL INDEX
332
Roof bars/ski racks ...................... 292
Roof rack provision ....................... 174
Rubber hoses .............................. 272Safe driving ............................... 192
– before driving off ................... 192
– driving in the fog ................... 194
– driving in the rain ................... 194
– driving on snow and ice .......... 195
– driving with ABS .................... 195
– mountain driving .................... 194
– night driving .......................... 193
– when travelling ...................... 192
Safeguarding the environment ...... 187
Scheduled maintenance
programme .............................. 249
Seat belts ................................... 28
– carrying children safely ........... 35
– front and rear side belt
height adjustment .................. 31
– general instructions ................ 33
– maintenance ......................... 34
– pretensioners......................... 32
– rear central abdominal belt ..... 30
– use ...................................... 28
Seats (front and rear) ............ 21-23
Selespeed gearbox ....................... 141– automatic operation (CITY) ..... 150
– checking the oil level .............. 259
– failure signalling .................... 150
– moving off ............................ 146
– operation with the engine off ... 143
– parking the vehicle ................. 151
– semiautomatic operation
(MANUAL) ............................ 148
– signalling with the buzzer........ 151
– starting the engine ................. 145
– stopping the car ..................... 148
– system activation ................... 142
– towing the vehicle .................. 151
– turning the engine off ............. 145
– warnings .............................. 146
Side lights
– changing front bulbs ............... 226
– changing rear bulbs ............... 228
– switching on.......................... 48
Ski compartment ......................... 24
Snow chains................................ 202
Sound system ...................... 183-293
Sound system presetting
system ............................. 183
Spark plugs (technical data) .......... 305
Speedometer............................... 63
Spray jets – windscreen/rearscreen/
headlight .............................. 274
Starting the engine....................... 189
– emergency starting .......... 191-205
– ignition switch ....................... 17
– procedure for JTD versions ....... 190
– procedure for petrol versions .... 189
– switching off the engine .......... 190
– warming the engine ............... 190
Starting with an auxiliary battery ... 242
Steering system
– specifications ......................... 305
– steering wheel adjustments .... 25
Steering lock .............................. 18
Steering wheel
– adjustment............................ 25
Steering wheel levers ................... 48
Stop lights
– changing bulbs ...................... 228
Sunroof ...................................... 167
– emergency operation ............. 169
– sliding forwards/backwards..... 168
– raising to the quarterlight
position ............................... 168
Sun visors .................................. 166
Symbols .................................... 5-6

RIGHT HAND DRIVE VERSION
342
DASHBOARD1.Side air outlets - 2.Defrosting/demisting vents for side windows - 3.Upper side vents - 4.Passanger’s Air bag - 5.Sound system -
6.Engine coolant temperature gauge - 7.Clock - 8.Centre air vents - 9.Infocenter display - 10.Fuel level gauge - 11.Cruise control
lever (where fitted) - 12.Outside lights control lever - 13.Speedometer. - mileage recorder - 14.Check panel - 15.Rev counter -
16.Windscreen wiper control lever - 17.Bonnet opening lever - 18.Radio controls on the steering wheel (where applicable) -19.Igni-
tion switch - 20.Steering wheel lock/release lever - 21.Driver’s Air bag and horns - 22.Controls unit: instrument panel lighting adjust-
ment and healamp diming - 23.Controls for heating, ventilation and climate control - 24.Ashtray and cigar lighter - 25.Hazard warning
lights switch - 26.Glove box.fig. 1
A0B0611m