CHEVROLET KODIAK 2009 Owners Manual

Underhood Fuse Block
When a circuit goes out, the problem could be in either
the primary or secondary underhood fuse blocks.
These blocks use blade-type fuses.
Both underhood fuse blocks are located in the engine
compartment, on the passenger side of the vehicle.
To access the fuse blocks, gently squeeze both sides of
the cover to unlatch the tabs at the top. Then, unsnap
both attachments at the bottom and remove the cover.
Notice:Spilling liquid on any electrical components
on the vehicle may damage it. Always keep the
covers on any electrical component.
Be sure to replace fuses with fuses of the same rating.
Do not use fuses of higher amperage than those
indicated on the fuse block.
Fuse Usage
RR DEFOG Rear Defogger
ENG 1 Engine 1
ENG 3 Engine 3 (L18/LF6/LF8)Primary Underhood Fuse Block
5-99

Fuse Usage
PCM-B Powertrain Control Module
TCM Transmissions (LF8)
ENG 4 Engine 4 (LMM/LF6/LF8)
ENG 2 Engine 2 (L18/LMM)
HTD FUEL Heated Fuel (LMM)
BLANK Not Used
BLANK Not Used
NOTE 3 Fan Relay (LMM), Emissions (L18)
A/C COMP Air Conditioning Compressor
ABS 1 Antilock Brake System 1
ABS 2 Antilock Brake System 2
ABS 3 Antilock Brake System 3
ENGINE Engine
E/A PUMP Electronic/Automatic Pump
HORN Horn
NOTE 2Fuel (L18/LMM), Electronic Control
Module (LF6)Fuse Usage
NOTE 4 Electronic Control Module (LF6)
STUD A Spare
STUD B Spare
Relay Usage
NOTE 1 LMM/L18 Fuel Pump Relay
IGN B RELAY Ignition Relay
STARTER
RELAYStarter Relay
HORN RELAY Horn Relay
IGN A RELAY Ignition Relay
PTO/ECU*
RELAYPower Take-Off/Engine Control Unit
(*Diesel 7.8L LF8)
REVERSE
RELAYReverse Relay
FAN RELAY Fan Relay (LMM)
5-100

Fuse Usage
IGN 1 Ignition 1
IGN 4 Ignition 4
IGN 3 Ignition 3
BATT/HAZ Battery/Hazard Warning Flashers
HEADLAMP Headlamps
LIGHTING Interior/Exterior Lamps
HVAC Climate Control System
NOTEC4/C5 Electric Brake,
C6/C7/C8 Brake Lamps
Secondary Underhood
Fuse Block
5-101

Capacities and Specifications
The following approximate capacities are given in English and metric conversions. SeePart C: Recommended Fluids
and Lubricants on page 6-31for more information.
ApplicationCapacities
English Metric
Air Conditioning Refrigerant R134aFor the air conditioning system refrigerant charge
amount, see the refrigerant caution label located
under the hood. See your dealer/retailer for more
information.
Cooling System – C4/C5 Models
6.6L V8 Automatic Transmission 27.9 qt 26.4 L
8.1L V8 Automatic Transmission 29.8 qt 28.2 L
8.1L V8 Manual Transmission 30.1 qt 28.5 L
Cooling System – C6/C7/C8 Automatic Transmission
7.2L L6 Engine 32.0 qt 30.2 L
Isuzu 6H Engine (207 - 275 hp) 34.8 qt 32.9 L
Isuzu 6H Engine (300 hp) 33.9 qt 32.1 L
8.1L V8 Engine 32.5 qt 30.8 L
5-102

ApplicationCapacities
English Metric
Cooling System – C6/C7/C8 Manual Transmission
7.2L L6 Engine 30.4 qt 28.8 L
7.2L L6 Engine with A/C and Increased Cooling 33.9 qt 32.1 L
Isuzu 6H Engine (207–275 hp) 32.7 qt 31.0 L
Isuzu 6H Engine (207–275 hp) with A/C and Increased
Cooling35.9 qt 34.0 L
Isuzu 6H Engine (300 hp) 36.0 qt 34.1 L
Isuzu 6H Engine (300 hp) with A/C and Increased Cooling 36.0 qt 34.1 L
8.1L V8 Engine 33.3 qt 31.5 L
8.1L V8 Engine with A/C and Increased Cooling 34.9 qt 33.0 L
Engine Oil with Filter
6.6L V8 Engine 14.6 qt 13.8 L
7.2L L6 Caterpillar
®C7 Engine 30.0 qt 28.4 L
Isuzu 6H
1Engine 23.8 qt 22.5 L
8.1L V8 Engine 10.0 qt 9.4 L
Check fill level on the oil indicator after initial fill to make sure it is actually full. Oil level may vary depending on
vehicle option content.
1Additional oil is required with auxiliary oil filter systems. Make sure to add enough extra oil to fill the auxiliary oil
filter system. For vehicles equipped with the LUBERFINER 750-C, add 14 quarts (13.25 L).
5-103

ApplicationCapacities
English Metric
Fuel Capacity – C4/C5 Models
Standard (Mid-Mounted) 25 gal 94.6 L
Optional
1(Dual-Tank) (Mid-Mounted) 40 gal 151.4 L
Optional (Mid-Mounted) 32 gal 121.1 L
Optional (Side-Mounted) 35 gal 132.5 L
Optional (Mid-Mounted) 40 gal 151.4 L
Optional (Mid-Mounted) 60 gal 227.1 L
Optional (Mid-Mounted) 80 gal 302.8 L
1One 25-gallon (94.6 L) tank and one 15-gallon (56.8 L) tank
Fuel Capacity – C6/C7/C8 Models
Optional 35 gal 132.4 L
Standard 50 gal 189.2 L
Optional 50 gal 189.2 L
Optional
1(Dual Tanks) 70 gal 264.8 L
Optional
2(Dual Tanks) 75 gal 283.8 L
Optional
3(Dual Tanks) 100 gal 378.5 L
1Two 35-gallon (132.4 L) tanks2One 25-gallon (94.6 L) tank and one 50-gallon (189.2 L) tank3Two 50-gallon (189.2 L) tanks
5-104

ApplicationCapacities
English Metric
Front 4WD Axle (G38) 7.0 pt 3.6 L
Rear Axle – Single Speed
80 (GL4) 10.0 pt 4.7 L
19060D (HPM), 19060S (HPK), 21060D (HPN),
21060S (HPP), 22060S (HPG)31.0 pt 14.7 L
23090S (HPT) 42.5 pt 20.1 L
23105D (HNB), 23105S (HNA) 51.0 pt 24.1 L
26105S (HPA) 51.0 pt 24.1 L
S110 (HD2) and S130 (HD1) 15.0 pt 7.1 L
Rear Axle – Tandem
DS344 (front) (HPI) 34.0 pt 16.1 L
DS344 (rear) (HPI) 31.0 pt 14.7 L
DS404 (HPE), DS404P (HPJ) (front/rear unit) 32.0 pt 15.1 L
RSH44 (front/ rear unit) (HP3) 29.0 pt 13.7 L
5-105

ApplicationCapacities
English Metric
Rear Axle – Two-Speed
19060T (HPL), 22060T (HPH) 38.0 pt 18.0 L
21060T (H15) 38.0 pt 18.0 L
23082T (H25) 44.0 pt 20.8 L
26080T (GJ4) 44.0 pt 20.8 L
Transfer Case (Four-Wheel Drive) 4.0 pt 1.9 L
Transmission Fluid, Automatic
3000 RDS and EVS, and 3500 RDS and EVS with PTO
Provision59.0 pt 28.1 L
3000 RDS and EVS, and 3500 RDS and EVS without PTO
Provision52.0 pt 24.6 L
1000 HS, RDS, MH, PTS and EVS, 2200 HS, RDS, MH,
PTS and EVS, 2500 HS and RDS, and 2300 HS and RDS35.0 pt 16.5 L
Add 2 pints (1 L) when changing spin-on or remote filter.
See the Allison
®Automatic Transmission Operator’s Manual for fluid check and maintenance information.
5-106

ApplicationCapacities
English Metric
Transmission Fluid, Manual
ES052-7, ES066-7 22.0 pt 10.4 L
FS5205A 12.5 pt 5.9 L
FSO8406, FS6305A, FS6305B, FS6406, FS5406A 19.5 pt 9.2 L
FS4205A, FS4205B 11.5 pt 5.4 L
RT6609 12.0 pt 5.7 L
RT8709 26.0 pt 12.3 L
RT8908LL 28.0 pt 13.2 L
All capacities are approximate. When adding, be sure to fill to the approximate level, as recommended in this
manual. Recheck the fluid level after filling.
Engine Specifications
Engine RPO Type
6.6L V8 DURAMAX®LMM Common Rail Fuel System
7.2L L6 Caterpillar
®C7 LF6Hydraulic/Electronic Unit Injector
Fuel System
7.8L L6 Isuzu 6H LF8 Common Rail Fuel System
8.1L V8 VORTEC™ L18Single Port Fuel Injector Fuel
System
5-107

Normal Maintenance Replacement Parts
Maintenance Replacement Parts
Replacement parts identified by name, part number, or specification can be obtained from your dealer.
Part GM Part Number ACDelco Part Number
Air Compressor Filter
Haldex compressor (8.1L Engine Only)88915425 A507CF
Engine Air Cleaner/Filter
6.6L V8 (C4/C5 Models) 19152817 A3102C
7.2L L6; Isuzu 6H (C6/C7/C8 Models) with Standard Air
Cleaner88937525 A2031C
7.2L L6; Isuzu 6H (C6/C7/C8 Models) with Heavy Duty Air
Cleaner88937525
1A2031C
8.1L V8 (C4/C5 Models) 88937527 A2032C
8.1L V8 (C6/C7/C8 Models) with Heavy Duty Air Cleaner 88937525 A2031C
8.1L V8 (C6/C7/C8 Models) with Standard Air Cleaner 88937545 A2034C
Engine Oil Filter
6.6L V8 88917036 PF2232
7.2L L6 — 1R-1807
2
Isuzu 6H 94392475 —
8.1L V8 25324052 PF454
5-108