CHEVROLET SUBURBAN 1994 Owners Manual

GASOLINE ENGINES WITH LIGHT DUTY EMISSIONS
- MAINTENANCE SCHEDULE Iv
Item
No.
1
2
3
4
5
6
7
9
10
11
14
15
17
23
24
25
*P
** s
$7
n
n r(
tT
hi
TO4031
C
Service
1 Emission Control Service
3e “Explanation of Scheduled Maintenance Services” in the Index.
le California Air Resources Board has determined that the failure to perform this
aintenance item
will not nullify the emission warranty or limit recall liability prior to the
)mpletion of vehicle useful life. General Motors, however, urges that all re\
commended
aintenance services be performed at the indicated intervals and \
the maintenance be
corded.
) determine the emissions classification of your engine, refer to “Selecting the Proper
aintenance Chart” in this section.
r0903
I
7-8
ProCarManuals.com

THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (100 000 km) ARE TO BE
DONE AFTER 60,000 MILES AT THE SAME INTERVALS.
T0403a/T0903a
7-9 ProCarManuals.com

GASOLINE ENGINES WITH HEAVY DUTY EMISSIONS
- MAINTENANCE SCHEDULE yf
Item Miles (000) 3
No. Kilometers (000) 5 Service
I
1 Engine Oil Change*-Every 3 Months, or t
Oil Filter Change*-Every 3 Months, or t
12 Chassis Lubrication-Every 12 Months, or I+
II
3 Clutch Fork Ball Stud Lubrication (5-speed manual
transmission with deeplow only)
Cooling System Service*-Every 24 Months or
Air Cleaner Filter Replacement* Front Wheel Bearing Repack
Transmission Service
**
Fuel Filter Replacement*
10
11
12
13
14
15
16
17
18
I9
Spark Plugs Replacement*
Spark Plug Wire Inspection*
EGR System Inspection*
Electronic Vacuum Regulator Valve (EVRV)
Inspection*
Engine Timing Checkk
Fuel Tank, Cap and Lines Inspection
*
Thermostatically Controlled Air Cleaner
Inspectionk
Engine Accessory Drive (Serpentine) Belt
Inspection*
Evaporative Control System Inspection*
Shields and Underhood Insulation InspectionA.
20
21
-
23
24
-
Air Intake System InspectionA. I
Brake Systems Inspection** I
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in the Index.
A A Noise Emission Control Service
Applicable only to vehicles sold in the United States
t To determine the emissions classification of your engine, refer to “Selecting the Proper
Maintenance Chart” in this section.
TO404
7-10
ProCarManuals.com

GASOLINE ENGINES WITH HEAVY DUTY EMISSIONS
- MAINTENANCE SCHEDULE # (continued)
THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (1 00 000 km) ARE TO BE
DONE AFTER 60,000 MILES AT THE SAME INTERVALS.
TO405
7-11 ProCarManuals.com

GASOLINE ENGINES WITH HEAVY DUTY EMISSIONS
- MAINTENANCE SCHEDULE Iff
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in the Index.
A A Noise Emission Control Service
H Applicable only to vehicles sold in the United States
t To determine the emissions classification of your engine, refer to “Selecting the Proper
Maintenance Chart” in this section.
TO406
7- 12 ProCarManuals.com

GASOLINE ENGINES WITH HEAVY DUTY EMISSIONS
- MAINTENANCE SCHEDULE IFl (continued)
7- 13
ProCarManuals.com

DIESEL ENGINES - MAINTENANCE SCHEDULE fi
* Change filter every 15,000 miles (24 000 km), except when operating i
conditions. Dusty conditions may require more frequent filter re\
placem
dust and
dirt operating conditions (off-road), may require the air filter tl
often as every 300 miles (483 km) and replaced as necessary.
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in this section.
A A Noise Emission Control Service
Applicable only to vehicles sold in the United States
t This maintenance schedule applies to all diesel engines available.
T0408D0908
I dusty
nt. Extreme
1 be checked as
7- 14
ProCarManuals.com

DIESEL ENGINES - MAINTENANCE SCHEDULE t"f
(continued)
THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (I00 000 km) ARE TO BE
DONE AFTER
60,000 MILES AT THE SAME INTERVALS.
T0409lT0909
7- 15
ProCarManuals.com

DlES€L ENGINES - MAINTENANCE SCHEDULE Ifi
Item
No.
1
-
8 CDRV System Inspection*
9 Fuel Filter Replacement*
12 EGR System Inspection*
17 Engine Accessory Drive (Serpentine) Belt Inspection*
19 Shields and Underhood Insulation
20 Air Intake System InspectionAD
0 0
InspectionAH 0 0
21 Thermostatically Controlled Engine Cooling Fan 0 0
CheckAH-Every 12 Months or
22 Exhaust Pressure Regulator Valve
Inspection*
23 Tire and Wheel Rotation**
0 0
24 Drive Axle Service** 0 0 0 0
25 Brake Systems Inspection**
* An Emission Control Service
** See “Explanation of Scheduled Maintenance Services” in this section,
A A Noise Emission Control Service
H Applicable only to vehicles sold in the United States.
t This maintenance scheduled applies to all diesel engines available.
TO4
1 Oflo91 0
7-16
ProCarManuals.com

DIESEL ENGINES - MAINTENANCE SCHEDULE 1fl
(continued)
THE SERVICES SHOWN ON THIS CHART UP TO 60,000 MILES (1 00 000 km) ARE TO BE
DONE AFTER 60,000 MILES AT THE SAME INTERVALS.
TO41 1 /TO91 1
ProCarManuals.com