maintenance GENESIS G70 2023 Repair Manual

09
9-71
Bright-metal maintenance

[To remove road tar and insects, use
a tar remover, not a scraper or other
sharp object.

[ To protect the surfaces of brightmetal
parts from corrosion, apply a coating
of wax or chrome preservative and rub
to a high luster.

[ During winter weather or in coastal
areas, cover the bright metal parts
with a heavier coating of wax or
preservative. If necessary, coat the
parts with non-corrosive petroleum
jelly or other protective compound.
Underbody maintenance
Corrosive materials used for ice and
snow removal and dust control may
collect on the underbody. If these
materials are not removed, accelerated
rusting can occur on underbody parts
such as the fuel lines, frame, floor pan
and exhaust system, even though they
have been treated with rust protection.
Thoroughly flush the vehicle underbody
and wheel openings with lukewarm or
cold water once a month, after off-road
driving and at the end of each winter.
Pay special attention to these areas
because it will do more harm than good
if the road grime becomes wet without
removing it. The lower edges of doors,
rocker panels, and frame members have
drain holes that should not be allowed
to clog with dirt; trapped water in these
areas can cause rusting.
WARNING
After washing the vehicle, test the
brakes while driving slowly to see if
they have been affected by water. If
braking performance is impaired, dry
the brakes by applying them lightly
while maintaining a slow forward
speed.
Aluminum wheel maintenance
The aluminum wheels are coated with a
clear protective finish.

[Do not use abrasive cleaner, polishing
compound, solvent, or wire brushes
on aluminum wheels.

[ Clean the wheel when it has cooled.

[ Use only a mild soap or neutral
detergent, and rinse thoroughly with
water. Also, clean the wheels after
driving on salted roads.

[ Do not wash the wheels with high-
speed car wash brushes.

[ Do not use any cleaners containing
acid or alkaline detergents.

Maintenance9-72
Corrosion protection
Protecting your vehicle from corrosion
By using the most advanced design
and cons
truction practices to combat
corrosion, Genesis Branded Vehicle
produces vehicles of the highest quality.
However, this is only part of the job.
To achieve the long-term corrosion
resistance, the owner’s cooperation and
assistance is also required.
Common causes of corrosion
The most common causes of corrosion
on y
our vehicle are:

[ Road salt, dirt and moisture that is
allowed to accumulate underneath
the vehicle.

[ Removal of paint or protective
coatings by stones, gravel, abrasion
or minor scrapes and dents which
leave unprotected metal exposed to
corrosion. igh-corrosion areas
If you live in an area where your vehicle is
r
egularly exposed to corrosive materials,
corrosion protection is particularly
important. Some of the common causes
of accelerated corrosion are road salts,
dust control chemicals, ocean air and
industrial pollution.
Moisture breeds corrosion
Moisture creates the conditions in
which corr
osion is most likely to occur.
For example, corrosion is accelerated
by high humidity, particularly when
temperatures are just above freezing. In
such conditions, the corrosive material is
kept in contact with the vehicle surfaces
by moisture that is slow to evaporate.
Mud is particularly corrosive because
it is slow to dry and holds moisture in
contact with the vehicle. Although the
mud appears to be dry, it can still retain
moisture and promote corrosion.
High temperatures can also accelerate
corrosion of parts that are not properly
ventilated so the moisture can be
dispersed. For all these reasons, it is
particularly important to keep your
vehicle clean and free of mud or
accumulations of other materials. This
applies not only to the visible surfaces
but particularly to the underside of the
vehicle.

Maintenance9-74
Interior Care
Interior general precautions
Prevent caustic solutions such as
perfume and cosmetic oil, from
contacting the interior parts because
they may cause damage or discoloration.
If they do contact the interior parts,
wipe them off immediately. See the
instructions for the proper way to clean
vehicle interior surfaces.
NOTICE

[ Never allow water or other liquids
to come in contact with electrical/
electronic components inside the
vehicle as this may damage them.

[ When cleaning leather products
(steering wheel, seats etc.), use
neutral detergents or low alcohol
content solutions. If you use high
alcohol content solutions or acid/
alkaline detergents, the color of the
leather may fade or the surface may
get stripped off.
Cleaning the upholstery and interior
trim
ehicle interior surfaces
Remove dust and loose dirt from interior
surf
aces with a whisk broom or a vacuum
cleaner.
If necessary, clean interior surfaces with
a mixture of warm water and mild non-
detergent cleaner (test all cleaners on a
concealed area before use).
Fabric
Remove dust and loose dirt from
f

abric with a whisk broom or vacuum
cleaner. Clean with a mild soap solution
recommended for upholstery or carpets.
Remove fresh spots immediately with
a fabric spot cleaner. If fresh spots do
not receive immediate attention, the
fabric can be stained and its color can be
affected. Also, its fire-resistant properties
can be reduced if the material is not
properly maintained.
NOTICE
Using anything but recommended
cleaners and procedures may affect the
fabric’s appearance and fire-resistant
properties.

Maintenance9-76

[ Handling prime napa leather
Try to avoid excessive sunlight and
heat exposure. Excessive sunlight
and heat exposure naturally fades
and dries out napa leather, causing
wrinkles and discoloration. If the napa
leather is wet with liquid, immediately
clean it with lint-free cloth to minimize
damage. Do not scratch the napa
leather surface with a sharp object.
If your napa leather seat is bright
colored, it may be contaminated or
stained from dyed materials such as
jeans.
Interior wooden trim

[Use a wooden furniture protector (for
example, wax, coating compound) to
clean the interior wooden trim.

[ Wipe the interior wooden trim with a
lint-free, clean cloth to maintain the
unique wooden textures for a longer
period of time.

[ If you spill beverage (for example,
water, coffee) over the interior
wooden trim, immediately wipe it with
clean, dry cloth.

[ Sharp objects (for example, driver,
knife), adhesive materials, or tapes
may damage the interior wooden trim.

[ Any strong impacts may damage the
interior wooden trim.

[ If the coating finish over the interior
wooden trim is removed, moisture
may damage or change wood traits.

[ If the interior wooden trim is
damaged, you may get a splinter
from the wood surface. Therefore,
you should immediately have the
damaged interior wooden trim
replaced by an authorized retailer of
Genesis Branded products.
Cleaning the seat belt webbing
Clean the belt webbing with any
mild soap solution recommended for
cleaning upholstery or carpet. Follow
the instructions provided with the soap.
Do not bleach or re-dye the webbing
because this may weaken the seat belt.
Cleaning the interior window glass
If the interior glass surfaces of the
vehicle become fogged (that is, covered
with an oily, greasy or waxy film), they
should be cleaned with glass cleaner.
Follow the directions on the glass cleaner
container.
NOTICE
Do not scrape or scratch the inside of
the rear window. This may result in
damage to the rear window defroster
grid.

09
9-77
EMISSION CONTROL SYSTEM
The emission control system of your
vehicle is covered by a written limited
warranty. Please see the warranty
information contained in the Owner’s
Handbook & Warranty Information
booklet in your vehicle.
Your vehicle is equipped with an
emission control system to meet all
applicable emission regulations. There
are three emission control systems, as
follows.
(1) Crankcase emission control system
(2) Evaporative emission control system
(3) Exhaust emission control system
In order to ensure the proper function
of the emission control systems, it
is recommended that you have your
vehicle inspected and maintained by an
authorized retailer of Genesis Branded
products in accordance with the
maintenance schedule in this manual.
NOTICE
For the Inspection and Maintenance
Test (with Electronic Stability Control
(ESC) system)

[ To prevent the vehicle from misfiring
during dynamometer testing, turn
the Electronic Stability Control
(ESC) system off by pressing the ESC
switch (ESC OFF light illuminated).

[ After dynamometer testing is
completed, turn the ESC system back
on by pressing the ESC switch again.
1. Crankcase Emission Control
System
The positive crankcase ventilation system
is employed to prevent air pollution
caused by blow-by gases being emitted
from the crankcase. This system supplies
fresh filtered air to the crankcase through
the air intake hose. Inside the crankcase,
the fresh air mixes with blow-by gases,
which then pass through the PCV valve
into the induction system.
2. Evaporative Emission Control System Including Onboard
Refueling Vapor Recovery
(ORVR)
The Evaporative Emission Control System
is designed to prevent fuel vapors from
escaping into the atmosphere. The
ORVR system is designed to allow the
vapors from the fuel tank to be loaded
into a canister while refueling at the gas
station, preventing the escape of fuel
vapors into the atmosphere.
Canister
Fuel vapors generated inside the fuel
tank are absorbed and stored in the
onboard canister. When the engine is
running, the fuel vapors absorbed in the
canister are drawn into the surge tank
through the purge control solenoid valve.
Purge Control Solenoid Valve (PCSV)
The purge control solenoid valve
is controlled by the Engine Control
Module (ECM); when the engine coolant
temperature is low during idling, the
PCSV closes so that evaporated fuel
is not taken into the engine. After the
engine warms up during ordinary driving,
the PCSV opens to introduce evaporated
fuel to the engine.

Maintenance9-78
3. Exhaust Emission Control System
The Exhaust Emission Control System is
a highly effective system which controls
exhaust emissions while maintaining
good vehicle performance.
When the engine starts or fails to start,
excessive attempts to restart the engine
may cause damage to the emission
system.
Engine exhaust (carbon monoxide)
precautions

[ Carbon monoxide can be present
with other exhaust fumes. If you smell
exhaust fumes of any kind in your
vehicle, drive with all the windows
fully open. Have your vehicle checked
and repaired immediately.
WARNING
Engine exhaust gases contain carbon
monoxide (CO). Though colorless and
odorless, it is dangerous and could be
lethal if inhaled. Follow the instructions
on this page to avoid CO poisoning.
WARNING
CALIFORNIA PROPOSITION 65
WARNING
Engine exhaust and a wide variety of
automobile components and parts,
including components found in the
interior furnishings in a vehicle, contain
or emit chemicals known to the State
of California to cause cancer and
birth defects and reproductive harm.
In addition, certain fluids contained
in vehicles and certain products of
component wear contain or emit
chemicals known to the State of
California to cause cancer and birth
defects or other reproductive harm.
Do not operate the engine in confined
or closed areas (such as garages) any
more than what is necessary to move the
vehicle in or out of the area.

[When the vehicle is stopped in an
open area for more than a short time
with the engine running, adjust the
ventilation system (as needed) to draw
outside air into the vehicle.

[ Never sit in a parked or stopped
vehicle for any extended time with the
engine running.

[ When the engine stalls or fails to
start, excessive attempts to restart
the engine may cause damage to the
emission control system.

IndexI-2
A
Accessing Your Vehicle ........................................................................\
................. 5-4
Immobilizer System ........................................................................\
................ 5-12
Smart Key........................................................................\
.................................. 5-4
Air Bag - Supplemental Restraint System ........................................................... 3-43
Additional Safety Precautions ........................................................................\
. 3-65
Air Bag Warning Labels ........................................................................\
.......... 3-65
How does the Air Bags System Operate? ....................................................... 3-49
Occupant Classification System (OCS) .......................................................... 3-54
SRS Care ........................................................................\
................................. 3-64
What to Expect After an Air Bag Inflates ....................................................... 3-53
Where are the Air Bags? ........................................................................\
......... 3-45
Why Didn’t My Air Bag Go Off in a Collision? ............................................. 3-59
Air cleaner ........................................................................\
................................... 9-26
Filter Replacement ........................................................................\
.................. 9-26
Air Conditioner Compressor Label ..................................................................... 2-16
Air Conditioning System ........................................................................\
............. 2-11
All Wheel Drive (AWD) ........................................................................\
.............. 6-37
Emergency Precautions ........................................................................\
........... 6-39
For Safe AWD Operation ........................................................................\
........ 6-38
Appearance Care ........................................................................\
.......................... 9-68
Exterior Care ........................................................................\
........................... 9-68
Interior Care ........................................................................\
............................ 9-74
Automatic Climate Control System ..................................................................... 5-93
Automatic Heating and Air Conditioning ....................................................... 5-95
Manual Heating and Air Conditioning ............................................................ 5-96
System Maintenance ........................................................................\
............. 5-104
System Operation ........................................................................\
.................. 5-102
Automatic transmission ........................................................................\
............... 6-10
Automatic Transmission Operation................................................................. 6-10
Good Driving Practices ........................................................................\
........... 6-19
LCD Display Messages ........................................................................\
........... 6-16
Paddle Shifter (Manual shift mode) ................................................................ 6-15

I
I-5
E
Electronic Control Suspension........................................................................\
.... 6-41
System Malfunction ........................................................................\
................ 6-41
Emission Control System ........................................................................\
............ 9-77
Engine ........................................................................\
............................................ 2-8
Engine Compartment ........................................................................\
..................... 2-7
Engine Compartment ........................................................................\
..................... 9-3
Engine Coolant ........................................................................\
............................ 9-21
Changing Coolant........................................................................\
.................... 9-23
Checking the Coolant Level ........................................................................\
.... 9-21
Engine Number ........................................................................\
............................ 2-16
Engine Oil ........................................................................\
.................................... 9-18
Checking the Engine Oil and Filter ................................................................. 9-20
Checking the Engine Oil Level ....................................................................... 9-18
Engine Start/Stop Button ........................................................................\
............... 6-5
Engine Stop/Start Button Positions ................................................................... 6-6
Remote Start ........................................................................\
.............................. 6-8
Starting the Engine ........................................................................\
.................... 6-7
Turning Off the Engine ........................................................................\
............. 6-8
Explanation of Scheduled Maintenance Items .................................................... 9-15
Brake Discs, Pads, Calipers and Rotors .......................................................... 9-17
Brake Fluid ........................................................................\
............................. 9-17
Exhaust Pipe and Muffler ........................................................................\
....... 9-17
Parking Brake ........................................................................\
.......................... 9-17
Vacuum crankcase ventilation hoses .............................................................. 9-15
Exterior Features ........................................................................\
.......................... 5-63
Hood ........................................................................\
........................................ 5-63
Trunk ........................................................................\
....................................... 5-64
Exterior Overview (I) ........................................................................\
.................... 2-2
Exterior Overview (II) ........................................................................\
................... 2-3

IndexI-6
F
Forward Collision–Avoidance Assist (FCA) (Sensor fusion) ............................... 7-2
Forward Collision-Avoidance Assist Malfunction and Limitations ................ 7-10
Forward Collision-Avoidance Assist Operation ................................................ 7-5
Forward Collision-Avoidance Assist Settings ................................................... 7-3
Forward/Reverse Parking Distance Warning (PDW) ....................................... 7-109
Forward/Reverse Parking Distance Warning Malfunction and Limitations . 7-112
Forward/Reverse Parking Distance Warning Operation ............................... 7-110
Forward/Reverse Parking Distance Warning Settings .................................. 7-109
Fuel Requirements ........................................................................\
......................... 1-5
Fuses ........................................................................\
............................................ 9-47
Engine Compartment Panel Fuse Replacement .............................................. 9-49
Fuse/Relay Panel Description ........................................................................\
. 9-50
Instrument Panel Fuse Replacement ............................................................... 9-48
G
Genesis Customer Care........................................................................\
.................. 1-2
Genesis Digital Key ........................................................................\
..................... 5-13
Digital Key (Card Key) ........................................................................\
........... 5-19
Digital Key (Smart Phone) ........................................................................\
...... 5-13
Limitations of the System ........................................................................\
....... 5-25
Personalized Profile and Vehicle Settings ....................................................... 5-22
Used Vehicle/Digital Key Maintenance .......................................................... 5-25
Guide to Genesis Parts ........................................................................\
................... 1-3
H
Hazard Warning Flasher ........................................................................\
................ 8-2
Head-Up Display (HUD) ........................................................................\
............. 5-76
Head-Up Display Information.............................................\
............................ 5-76
Head-Up Display Settings ........................................................................\
....... 5-76
Precautions While Using the Head-Up Display .............................................. 5-77
High Beam Assist (HBA) ........................................................................\
............ 5-84
High Beam Assist Malfunction and Limitations ............................................. 5-85
High Beam Assist Operation ........................................................................\
... 5-85
High Beam Assist Settings ........................................................................\
...... 5-84

IndexI-10
M
Maintenance Services ........................................................................\
.................... 9-4
Owner Maintenance Precautions...........................................\
............................ 9-4
Owner’s Responsibility ........................................................................\
............. 9-4
Mirrors ........................................................................\
......................................... 5-39
Inside Rearview Mirror ........................................................................\
........... 5-39
Reverse Parking Aid ........................................................................\
................ 5-51
Side View Mirrors ........................................................................\
................... 5-49
N
Navigation-Based Smart Cruise Control (NSCC) ............................................... 7-69
Limitations of Navigation-based Smart Cruise Control.................................. 7-72
Navigation-based Smart Cruise Control Operation ........................................ 7-70
Navigation-based Smart Cruise Control Settings ........................................... 7-69
O
Owner Maintenance ........................................................................\
....................... 9-5
Owner Maintenance Schedule..............................................\
............................. 9-6
P
Power Trunk ........................................................................\
................................ 5-66
Emergency trunk safety release....................................................................... 5-70
Fuel Filler Door ........................................................................\
....................... 5-73
Operating the power trunk ........................................................................\
...... 5-67
Power trunk operating conditions ................................................................... 5-66
Power trunk settings ........................................................................\
................ 5-70
Resetting the power trunk ........................................................................\
....... 5-70
Smart Trunk ........................................................................\
............................. 5-71