sensor ISUZU AXIOM 2002 Service Repair Manual

6D2±6
IGNITION SYSTEM (6VE1 3.5L)
Crankshaft Position Sensor
Removal
1. Disconnect battery ground cable
2. Wiring connector from crankshaft position sensor.
3. Remove crankshaft position sensor from cylinder
block.
012RS008
Installation
1. Install crankshaft position sensor into the cylinder
block.
Before installation,apply small amount of engine oil to
the O±ring.
Torque: 10 N´m (87 lb in)
2. Reconnect wiring connector to crankshaft position
sensor.

6D2±7
IGNITION SYSTEM (6VE1 3.5L)
Main Data and Specifications
General Specifications
Ignition System
Ignition FormElectronic Ignition System (El system) with Crankshaft position Sensor
Spark Plug
TypeK16PR±P11
RC10PYP4
PK16PR11
Plug gap1.0 mm ± 1.1 mm (0.0394 in ± 0.0433 in)
Torque18 N´m (13lb ft)
Torque Specifications
E06R100003

6D3±5
STARTING AND CHARGING SYSTEM (6VE1 3.5L)
Starter
Removal
1. Battery ground cable.
2. Disconnect Heated O
2 Sensor connector (1).
3. Remove exhaust front left pipe(2).
150R100011
4. Disconnect starter wiring connector from terminals
ª30º (1) and ª50º (2).
5. Remove starter assembly mounting bolts on inside
and outside(3).
6. Remove starter assembly (4) toward the bottom of
engine.
065RY00050
Legend
(1) Terminal ª30º
(2) Terminal ª50º
(3) Fixing Bolts
(4) Starter Assembly
Installation
1. Install starter assembly(4).
2. Install mounting bolts and tighten bolts to specified
torque(3).
Torque: 40 N´m (30 lb ft)
3. Reconnect the connectors to terminals ª50º (2)
tighten terminals ª30º (1) to specified torque.
Torque: 9 N´m (78 lb in)
065RY00050
Legend
(1) Terminal ª30º
(2) Terminal ª50º
(3) Fixing Bolts
(4) Starter Assembly
4. Install exhaust front left pipe (2) and tighten bolts and
nuts to specified torque.
Stud Nuts
Torque: 67 N´m (49 lb ft)
Bolts
Torque: 43 N´m (32 lb ft)

6D3±6
STARTING AND CHARGING SYSTEM (6VE1 3.5L)
5. Connect two Heated O2 Sensor connector (1).
150R100011
6. Reconnect the battery ground cable.

6E±1
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
AXIOM
ENGINE
6VE1 3.5L ENGINE
DRIVEABILITY AND EMISSIONS
CONTENTS
Specifications 6E±6. . . . . . . . . . . . . . . . . . . . . . . . . . .
Tightening Specifications 6E±6. . . . . . . . . . . . . . .
Diagrams and Schematics 6E±7. . . . . . . . . . . . . . . .
PCM Wiring Diagram (1 of 7) 6E±7. . . . . . . . . . . .
PCM Wiring Diagram (2 of 7) 6E±8. . . . . . . . . . . .
PCM Wiring Diagram (3 of 7) 6E±9. . . . . . . . . . . .
PCM Wiring Diagram (4 of 7) 6E±10. . . . . . . . . . . .
PCM Wiring Diagram (5 of 7) 6E±11. . . . . . . . . . . .
PCM Wiring Diagram (6 of 7) 6E±12. . . . . . . . . . . .
PCM Wiring Diagram (7 of 7) 6E±13. . . . . . . . . . . .
PCM Pinouts 6E±14. . . . . . . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF1 ~ 20º 6E±14. . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF20 ~ 40º 6E±15. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF41 ~ 60º 6E±16. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Blue Connector
± Row ªF61 ~ 80º 6E±17. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS1 ~ 20º 6E±19. . . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS21 ~ 40º 6E±21. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS41 ~ 60º 6E±23. . . . . . . . . . . . . . . . . . . . .
PCM Pinout Table, 80-Way Red Connector
± Row ªS61 ~ 80º 6E±25. . . . . . . . . . . . . . . . . . . . .
Component Locators 6E±27. . . . . . . . . . . . . . . . . . .
Undercarriage Component Locator 6E±29. . . . . .
Fuse and Relay Panel (Underhood
Electrical Center) 6E±30. . . . . . . . . . . . . . . . . . . . .
Sensors and Miscellaneous Component
Locators 6E±31. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnosis 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Strategy-Based Diagnostics 6E±33. . . . . . . . . . . . .
DTC Stored 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . .
No DTC 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
No Matching Symptom 6E±33. . . . . . . . . . . . . . . . .
Intermittents 6E±33. . . . . . . . . . . . . . . . . . . . . . . . . .
No Trouble Found 6E±33. . . . . . . . . . . . . . . . . . . . .
Verifying Vehicle Repair 6E±33. . . . . . . . . . . . . . . .
General Service Information 6E±33. . . . . . . . . . . . . .
OBD II Serviceablity Issues 6E±33. . . . . . . . . . . . .
Emissions Control Information Label 6E±34. . . . .
Visual / Physical Engine Compartment
Inspection 6E±34. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Basic Knowledge of Tools Required 6E±35. . . . . .
Serial Data Communications 6E±35. . . . . . . . . . . . . . Class 2 Serial Data Communications 6E±35. . . . .
On-Board Diagnostic (OBD II) 6E±35. . . . . . . . . . . . .
On-Board Diagnostic Tests 6E±35. . . . . . . . . . . . .
Comprehensive Component Monitor
Diagnostic Operation 6E±35. . . . . . . . . . . . . . . . . .
System Status and Drive Cycle for
Satisfying Federal Inspection/Maintenance
(I/M 240) Regulations 6E±36. . . . . . . . . . . . . . . . . .
Common OBD II Terms 6E±36. . . . . . . . . . . . . . . . .
The Diagnostic Executive 6E±36. . . . . . . . . . . . . . .
DTC Types 6E±37. . . . . . . . . . . . . . . . . . . . . . . . . . .
Decimal/Binary/Hexadecimal Conversions 6E±39
Verifying Vehicle Repair 6E±39. . . . . . . . . . . . . . . .
Reading Diagnostic Trouble Codes Using
The Tech 2 Scan Tool 6E±39. . . . . . . . . . . . . . . . .
Tech 2 6E±40. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Tech 2 Features 6E±41. . . . . . . . . . . . . . . . . . . . . . .
Getting Started 6E±41. . . . . . . . . . . . . . . . . . . . . . . .
Operating Procedure (For Example) 6E±42. . . . .
DTC Modes 6E±43. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC Information Mode 6E±43. . . . . . . . . . . . . . . . .
Miscellaneous Test 6E±44. . . . . . . . . . . . . . . . . . . .
Lamps Test 6E±44. . . . . . . . . . . . . . . . . . . . . . . . . . .
Relays Test 6E±46. . . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Test 6E±47. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel System Test 6E±48. . . . . . . . . . . . . . . . . . . . . .
Instruments Test 6E±50. . . . . . . . . . . . . . . . . . . . . . .
EGR Control Test 6E±52. . . . . . . . . . . . . . . . . . . . . .
Variable Intake Manifold Solenoid Test 6E±52. . .
Injector Balance Test 6E±54. . . . . . . . . . . . . . . . . . .
Plotting Snapshot Graph 6E±54. . . . . . . . . . . . . . . . .
Plotting Graph Flow Chart (Plotting graph
after obtaining vehicle information) 6E±55. . . . . .
Flow Chart for Snapshot Replay (Plotting
Graph) 6E±56. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Primary System-Based Diagnostic 6E±57. . . . . . . . .
Primary System-Based Diagnostic 6E±57. . . . . . .
Fuel Control Heated Oxygen Sensor 6E±57. . . . .
HO2S Heater 6E±57. . . . . . . . . . . . . . . . . . . . . . . . .
Catalyst Monitor Heated Oxygen Sensors
and Diagnostic Operation 6E±57. . . . . . . . . . . . . .
Misfire Monitor Diagnostic Operation 6E±58. . . . . . .
Misfire Monitor Diagnostic Operation 6E±58. . . . .
Misfire Counters 6E±58. . . . . . . . . . . . . . . . . . . . . . .

6E±2
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Fuel Trim System Monitor Diagnostic
Operation 6E±59. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Trim System Monitor Diagnostic
Operation 6E±59. . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Trim Cell Diagnostic Weights 6E±59. . . . . . .
On-Board Diagnostic (OBD II) System Check 6E±60
Circuit Description 6E±60. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±60. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±60. . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Control Circuit Diagnosis 6E±63. . . . . . .
Circuit Description 6E±63. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±63. . . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Diagnosis 6E±64. . . . . . . . . . . . . . . . . .
Electronic Ignition System Diagnosis 6E±68. . . . . . .
EVAP Canister Purge Solenoid and EVAP
Vent Solenoid Valve 6E±68. . . . . . . . . . . . . . . . . . . . .
Visual Check of The Evaporative Emission
Canister 6E±68. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System Check 6E±68. . . . . . . . . . . . .
Fuel System Pressure Test 6E±68. . . . . . . . . . . . . . .
Fuel Injector Coil Test Procedure and Fuel
Injector Balance Test Procedure 6E±68. . . . . . . . . .
Test Description 6E±68. . . . . . . . . . . . . . . . . . . . . . .
Injector Coil Test Procedure (Steps 1-6)
and Injector Balance Test Procedure
(Steps 7-11) 6E±69. . . . . . . . . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) Diagnosis 6E±73
Multiple PCM Information Sensor DTCs Set 6E±73
Circuit Description 6E±73. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±73. . . . . . . . . . . . . . . . . . . . . . . .
Exhaust Gas Recirculation (EGR) Diagnosis 6E±76
Engine Tech 2 Data Definitions and Ranges 6E±76
Typical Scan Data Values 6E±78. . . . . . . . . . . . . . . .
Test Conditions 6E±78. . . . . . . . . . . . . . . . . . . . . . . .
No Malfunction Indicator Lamp (MIL) 6E±84. . . . . . .
Circuit Description 6E±84. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±84. . . . . . . . . . . . . . . . . . . . . . . .
Malfunction Indicator Lamp (MIL) ªONº
Steady 6E±87. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit description 6E±87. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±87. . . . . . . . . . . . . . . . . . . . . . . .
No Reduced Power Lamp (RPL) 6E±89. . . . . . . . . .
Circuit Description 6E±89. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±89. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±89. . . . . . . . . . . . . . . . . . . . . . .
Reduced Power Lamp (RPL) ªONº Steady 6E±93. .
Circuit Description 6E±93. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±93. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±93. . . . . . . . . . . . . . . . . . . . . . .
Starter Control System Check 6E±96. . . . . . . . . . . . .
Circuit Description 6E±96. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±96. . . . . . . . . . . . . . . . . . . . . . . .
Engine Cranks But Will Not Run 6E±100. . . . . . . . . . .
Circuit Description 6E±102. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±102. . . . . . . . . . . . . . . . . . . . . . . . Test Description 6E±102. . . . . . . . . . . . . . . . . . . . . . .
Fuel System Electrical Test 6E±107. . . . . . . . . . . . . . .
Circuit Description 6E±108. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±108. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±108. . . . . . . . . . . . . . . . . . . . . . .
Fuel Pressure Relief Procedure 6E±108. . . . . . . . .
Electric Throttle Control (ETC) System
Check 6E±111. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±112. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±112. . . . . . . . . . . . . . . . . . . . . . . .
Test Description 6E±112. . . . . . . . . . . . . . . . . . . . . . .
Fuel System Diagnosis 6E±115. . . . . . . . . . . . . . . . . . .
Circuit Description 6E±116. . . . . . . . . . . . . . . . . . . . .
Test Description 6E±116. . . . . . . . . . . . . . . . . . . . . . .
Fuel Pressure Relief Procedure 6E±117. . . . . . . . .
Exhaust Gas Recirculation (EGR) System
Check 6E±120. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±120. . . . . . . . . . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Output
Check 6E±122. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±122. . . . . . . . . . . . . . . . . . . . .
Evaporative (EVAP) Emissions Canister
Purge Valve Check 6E±124. . . . . . . . . . . . . . . . . . . . .
Circuit Description 6E±124. . . . . . . . . . . . . . . . . . . . .
Diagnostic Aids 6E±124. . . . . . . . . . . . . . . . . . . . . . . .
PCM Diagnostic Trouble Codes 6E±127. . . . . . . . . . .
DTC P0101 MAF System Performance 6E±131. . . .
DTC P0102 MAF Sensor Circuit Low
Frequency 6E±134. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0103 MAF Sensor Circuit High
Frequency 6E±137. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0106 MAP System Performance 6E±140. . . .
DTC P0107 MAP Sensor Circuit Low
Voltage 6E±143. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0108 MAP Sensor Circuit High
Voltage 6E±146. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0112 IAT Sensor Circuit Low
Voltage 6E±149. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0113 IAT Sensor Circuit High
Voltage 6E±152. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0117 ECT Sensor Circuit Low
Voltage 6E±155. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0118 ECT Sensor Circuit High
Voltage 6E±158. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0125 ECT Excessive Time to Closed
Loop Fuel Control 6E±161. . . . . . . . . . . . . . . . . . . . . . .
DTC P0128 Thermostat Insufficient
Temperature for Stable Operation 6E±164. . . . . . . . .
DTC P0131 HO2S Circuit Low Voltage
Bank 1 Sensor 1 6E±166. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0132 HO2S Circuit High Voltage
Bank 1 Sensor 1 6E±169. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0133 HO2S Slow Response
Bank 1 Sensor 1 6E±172. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0134 HO2S Circuit Insufficient
Activity Bank 1 Sensor 1 6E±176. . . . . . . . . . . . . . . . .

6E±3
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P0135 HO2S Heater Circuit
Bank 1 Sensor 1 6E±179. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0137 HO2S Circuit Low Voltage
Bank 1 Sensor 2 6E±182. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0138 HO2S Circuit High Voltage
Bank 1 Sensor 2 6E±185. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0140 HO2S Circuit Insufficient Activity
Bank 1 Sensor 2 6E±188. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0141 HO2S Heater Circuit
Bank 1 Sensor 2 6E±191. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0151 HO2S Circuit Low Voltage
Bank 2 Sensor 1 6E±194. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0152 HO2S Circuit High Voltage
Bank 2 Sensor 1 6E±197. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0153 HO2S Slow Response
Bank 2 Sensor 1 6E±200. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0154 HO2S Circuit Insufficient Activity
Bank 2 Sensor 1 6E±204. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0155 HO2S Heater Circuit Open
Bank 2 Sensor 1 6E±207. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0157 HO2S Circuit Low Voltage
Bank 2 Sensor 2 6E±210. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0158 HO2S Circuit High Voltage
Bank 2 Sensor 2 6E±213. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0160 HO2S Circuit Insufficient Activity
Bank 2 Sensor 2 6E±216. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0161 HO2S Heater Circuit
Bank 2 Sensor 2 6E±219. . . . . . . . . . . . . . . . . . . . . . . .
DTC P0171 Fuel Trim System Lean Bank 1 6E±222.
DTC P0172 Fuel Trim System Rich Bank 1 6E±226.
DTC P0174 Fuel Trim System Lean Bank 2 6E±230.
DTC P0175 Fuel Trim System Rich Bank 2 6E±234.
DTC P0201 Injector 1 Control Circuit 6E±238. . . . . .
DTC P0202 Injector 2 Control Circuit 6E±241. . . . . .
DTC P0203 Injector 3 Control Circuit 6E±244. . . . . .
DTC P0204 Injector 4 Control Circuit 6E±247. . . . . .
DTC P0205 Injector 5 Control Circuit 6E±250. . . . . .
DTC P0206 Injector 6 Control Circuit 6E±253. . . . . .
DTC P0300 Engine Misfire Detected 6E±256. . . . . . .
DTC P0301 Cylinder Misfire Detected 6E±260. . . . . .
DTC P0302 Cylinder Misfire Detected 6E±262. . . . . .
DTC P0303 Cylinder Misfire Detected 6E±264. . . . . .
DTC P0304 Cylinder Misfire Detected 6E±266. . . . . .
DTC P0305 Cylinder Misfire Detected 6E±268. . . . . .
DTC P0306 Cylinder Misfire Detected 6E±270. . . . . .
DTC P0325 ION Sensing Module/ION
Sensing Knock Intensity Circuit Fault 6E±272. . . . . .
DTC P0336 58X Reference Signal Circuit 6E±275. .
DTC P0337 CKP Sensor Circuit Low
Frequency 6E±278. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0351 Ignition 1 Control Circuit 6E±281. . . . . . .
DTC P0352 Ignition 2 Control Circuit 6E±284. . . . . . .
DTC P0353 Ignition 3 Control Circuit 6E±287. . . . . . .
DTC P0354 Ignition 4 Control Circuit 6E±290. . . . . . .
DTC P0355 Ignition 5 Control Circuit 6E±293. . . . . . . DTC P0356 Ignition 6 Control Circuit 6E±296. . . . . . .
DTC P0401 EGR Flow Insufficient 6E±299. . . . . . . . .
DTC P0402 EGR Pintle Crank Error 6E±302. . . . . . .
DTC P0404 EGR Open Stuck 6E±304. . . . . . . . . . . . .
DTC P0405 EGR Low Voltage 6E±306. . . . . . . . . . . .
DTC P0406 EGR High Voltage 6E±309. . . . . . . . . . .
DTC P0420 TWC System Low Efficiency
Bank 1 6E±312. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0430 TWC System Low Efficiency
Bank 2 6E±315. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0440 EVAP System 6E±318. . . . . . . . . . . . . . . .
DTC P0442 EVAP System Small Leak
Detected 6E±321. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0444 EVAP Purge Control Circuit
Open 6E±324. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0445 EVAP Purge Control Circuit
Short 6E±326. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0446 EVAP Canister Vent Control
Malfunction 6E±328. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0447 EVAP Vent Solenoid Circuit
Open 6E±331. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0448 EVAP Vent solenoid Circuit
Short 6E±333. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0452 Fuel Tank Pressure Sensor
(Vapor Pressure Sensor) Low Voltage 6E±335. . . . .
DTC P0453 Fuel Tank Pressure Sensor
(Vapor Pressure Sensor) High Voltage 6E±338. . . . .
DTC P0456 EVAP Very Small Leak 6E±341. . . . . . .
DTC P0461 Fuel Level Sensor Performance 6E±344
DTC P0462 Fuel Level Sensor Circuit±Low
Voltage 6E±346. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0463 Fuel Level Sensor Circuit±High
Voltage 6E±349. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0462 Fuel Level Sensor Noisy Signal 6E±351
DTC P0502 VSS Circuit Low Input 6E±353. . . . . . . . .
DTC P0506 Idle Air Control System Low
RPM 6E±356. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0507 Idle Air Control System High
RPM 6E±359. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0562 System Voltage Low 6E±362. . . . . . . . . .
DTC P0563 System Voltage High 6E±364. . . . . . . . .
DTC P0565 Cruise Main Switch Circuit Error 6E±366
DTC P0566 Cruise Cancel Switch Circuit
Error 6E±368. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0567 Cruise Resume Switch Circuit
Error 6E±370. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P0568 Cruise Set Switch Circuit Error 6E±372.
DTC P0571 No Brake Switch Signal 6E±374. . . . . . .
DTC P0601 PCM Memory 6E±376. . . . . . . . . . . . . . . .
DTC P0602 PCM Programming Error 6E±378. . . . . .
DTC P0604 PCM RAM Error 6E±380. . . . . . . . . . . . . .
DTC P0606 PCM Internal Performance 6E±382. . . .
DTC P1106 MAP Sensor Circuit Intermittent
High Voltage 6E±384. . . . . . . . . . . . . . . . . . . . . . . . . . .

6E±4
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
DTC P1107 MAP Circuit Intermittent Low
Voltage 6E±386. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
D T C P 1111 I AT Sensor Circuit Intermittent
High Voltage 6E±388. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1112 IAT Sensor Circuit Intermittent
Low Voltage 6E±391. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1114 ECT Sensor Circuit Intermittent
Low Voltage 6E±393. . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1115 ECT Sensor Circuit Intermittent
High Voltage 6E±395. . . . . . . . . . . . . . . . . . . . . . . . . . .
Diagnostic Trouble Code(DTC)P1120-TPS 1
Throttle Position Sensor (TPS1) Output
Abnormal 6E±398. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1125 ETC (Electric Throttle Control)
Limit Performance Mode 6E±401. . . . . . . . . . . . . . . . .
DTC P1133 HO2S Insufficient Switching
Bank 1 Sensor 1 6E±404. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1134 HO2S Transition Time Ratio
Bank 1 Sensor 1 6E±408. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1153 HO2S Insufficient Switching
Bank 2 Sensor 1 6E±412. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1154 HO2S Circuit Transition Time
Ratio Bank 2 Sensor 1 6E±416. . . . . . . . . . . . . . . . . .
DTC P1167 Fuel System Rich During Decel
Fuel Cut Off (Bank 1) 6E±420. . . . . . . . . . . . . . . . . . . .
DTC P1169 Fuel System Rich During Decel
Fuel Cut Off (Bank 2) 6E±422. . . . . . . . . . . . . . . . . . . .
DTC P1171 Fuel System Lean During
Acceleration 6E±424. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1220 Throttle Position Senser2
(TPS2) Circuit Fault 6E±427. . . . . . . . . . . . . . . . . . . . .
DTC P1221 TPS1 ± TPS2 Correlation
(Circuit Performance) 6E±430. . . . . . . . . . . . . . . . . . .
DTC P1271 APS 1± 2 Correlation Error 6E±433. . .
DTC P1272 APS 2 ± 3 Correlation Error 6E±436. . .
DTC P1273 APS 1 ± 3 Correlation Error 6E±439. . . .
DTC P1275 APS 1 Output Fault 6E±442. . . . . . . . . . .
DTC P1280 APS 2 Output Fault 6E±444. . . . . . . . . . .
DTC P1285 APS 3 Output Fault 6E±446. . . . . . . . . . .
DTC P1290 ETC Forced Idle Mode 6E±448. . . . . . . .
DTC P1295 ETC Power Management Mode 6E±451
DTC P1299 ETC Forced Engine Shutdown
Mode 6E±455. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1310 ION Sensing Module Diagnosis 6E±459
DTC P1311 ION Sensing Module SEC
Line 1 Circuit Fault 6E±462. . . . . . . . . . . . . . . . . . . . . .
DTC P1312 ION Sensing Module SEC
Line 2 Circuit Fault 6E±465. . . . . . . . . . . . . . . . . . . . . .
DTC P1326 ION Sensing Module Combustion
Quality Input Circuit Fault 6E±468. . . . . . . . . . . . . . . .
DTC P1340 ION Sensing Module Cylinder ID
Fault (Cylinder Synchronization Fail) 6E±471. . . . . .
DTC P1404 EGR Stuck Closed 6E±474. . . . . . . . . . .
DTC P1441 EVAP System Flow During
Non-Purge 6E±477. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1514 TPS - MAF Correlation Error 6E±480. . . DTC P1515 Command - Actual TPS
Correlation Error 6E±484. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1516 Command - Actual TPS
Correlation Error 6E±487. . . . . . . . . . . . . . . . . . . . . . . .
DTC P1523 Actuator Control Return
Performance 6E±490. . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1571 Brake Switch No Operation 6E±493. . . .
DTC P1625 PCM Unexpected Reset 6E±495. . . . . . .
DTC P1635 Reference Voltage # 1 Circuit
Fault 6E±496. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1639 Reference Voltage # 2 Circuit
Fault 6E±498. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1640 Driver-1-Output Circuit Fault
(ODM) 6E±500. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
DTC P1650 Quad Driver Module ªAº Fault 6E±503. .
Symptom Diagnosis 6E±506. . . . . . . . . . . . . . . . . . . . .
Default Matrix Table 6E±535. . . . . . . . . . . . . . . . . . . . .
On Vehicle Service
Crankshaft Position (CKP) Sensor 6E±538. . . . . . . . .
Engine Coolant Temperature (ECT) Sensor 6E±538.
Heated Oxygen Sensor (HO2S) 6E±539. . . . . . . . . . .
Intake Air Temperature (IAT) Sensor 6E±542. . . . . . .
ION Sensing Module 6E±542. . . . . . . . . . . . . . . . . . . . .
Mass Air Flow (MAF) Sensor 6E±543. . . . . . . . . . . . .
Manifold Absolute Pressure (MAP) Sensor 6E±544.
Malfunction Indicator Lamp (MIL) 6E±545. . . . . . . . . .
Reduced Power Lamp 6E±545. . . . . . . . . . . . . . . . . . .
Powertrain Control Module (PCM) 6E±545. . . . . . . . .
Service Precaution 6E±545. . . . . . . . . . . . . . . . . . . .
EEPROM 6E±547. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Position (TP) Sensor 6E±547. . . . . . . . . . . . .
Vehicle Speed Sensor (VSS) 6E±548. . . . . . . . . . . . .
Air Cleaner/Air Filter 6E±549. . . . . . . . . . . . . . . . . . . . .
Common Chamber 6E±549. . . . . . . . . . . . . . . . . . . . . .
Accelerator Pedal Replacement 6E±550. . . . . . . . . . .
Accelerator Position Sensor Replacement 6E±551. .
Accelerator Position Sensor Adjustment 6E±551. . . .
Fuel Filler Cap 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Filter 6E±552. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Gauge Unit 6E±553. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Injectors 6E±554. . . . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Metering System 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Assembly 6E±555. . . . . . . . . . . . . . . . . . . .
Fuel Pump Relay 6E±556. . . . . . . . . . . . . . . . . . . . . . . .
Fuel Rail Assembly 6E±557. . . . . . . . . . . . . . . . . . . . . .
Fuel Tank 6E±558. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Throttle Body (TB) 6E±558. . . . . . . . . . . . . . . . . . . . . . .
Electronic Ignition System 6E±560. . . . . . . . . . . . . . . .
Catalytic Converter 6E±561. . . . . . . . . . . . . . . . . . . . . .
Air Conditioning Thermo Relay 6E±561. . . . . . . . . . .
EVAP Canister Hoses 6E±561. . . . . . . . . . . . . . . . . . . .
EVAP Canister 6E±562. . . . . . . . . . . . . . . . . . . . . . . . . .
EVAP Canister Vent Solenoid 6E±562. . . . . . . . . . . . .

6E±5
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Fuel Tank Pressure
(Vapor Pressure) Sensor 6E±563. . . . . . . . . . . . . . . . .
EVAP Canister Purge Solenoid (Purge Duty
Solenoid Valve) 6E±564. . . . . . . . . . . . . . . . . . . . . . . . .
Fuel Tank Vent Valve
(Vent Solenoid Valve) 6E±565. . . . . . . . . . . . . . . . . . .
Linear Exhaust Gas
Recirculation (EGR) Valve 6E±565. . . . . . . . . . . . . . . .
Positive Crankcase Ventilation (PCV) Valve 6E±566.
Wiring and Connectors 6E±566. . . . . . . . . . . . . . . . . . .
PCM Connectors and Terminals 6E±567. . . . . . . . . . .
Wire Harness Repair: Twisted Shielded
Cable 6E±567. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Twisted Leads 6E±568. . . . . . . . . . . . . . . . . . . . . . . . . .
Weather-Pack Connector 6E±569. . . . . . . . . . . . . . . . .
Com-Pack III 6E±570. . . . . . . . . . . . . . . . . . . . . . . . . . .
Metri-Pack 6E±571. . . . . . . . . . . . . . . . . . . . . . . . . . . . .
General Description (PCM and Sensors) 6E±572. . .
General Description (Air Induction) 6E±577. . . . . . . .
General Description (Fuel Metering) 6E±578. . . . . . .
General Description (Electronic Ignition
System) 6E±580. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
A/C Clutch Diagnosis 6E±583. . . . . . . . . . . . . . . . . . . .
General Description (Evaporative (EVAP)
Emission System) 6E±583. . . . . . . . . . . . . . . . . . . . . .
General Description (Exhaust Gas
Recirculation (EGR) System) 6E±588. . . . . . . . . . . . .
General Description (Positive Crankcase
Ventilation (PCV) System) 6E±589. . . . . . . . . . . . . . .
Special Tools 6E±591. . . . . . . . . . . . . . . . . . . . . . . . . . .

6E±6
6VE1 3.5L ENGINE DRIVEABILITY AND EMISSIONS
Specifications
Tightening Specifications
ApplicationN´mLb Ft.Lb In.
EGR Bolt2518Ð
Engine Coolant Temperature Sensor3022Ð
Fuel Drain Plug2014Ð
Fuel Pressure Regulator Attaching Screw3Ð26
Fuel Rail Bolts2518Ð
Fuel Tank Undercover Retaining Bolts3627Ð
Heated Oxygen Sensor5540Ð
Lower Intake Manifold to Engine Block Bolts2518Ð
Lower Intake Manifold to Engine Block Nuts2518Ð
Spark Plugs1813Ð
Throttle Body Mounting Bolts10Ð87
Common Chamber to Lower Intake Manifold Bolts2518Ð
VSS Retaining Bolt1612Ð