LAND ROVER FRELANDER 2 2006 Repair Manual

12. W ARNING: Power s teering fluid is ext remely
flammable. Make s ure that power st eeri ng fl ui d i s not
s pil t over t he engi ne and that t he power st eering fl ui d
res ervoi r cap i s s eal ed.
12. 13.
14.

15.
16. CAUTION: Make s ure t hat the mati ng faces
are cl ean and free of foreign mat eri al .
16. 17.
18.
Installation

1. CAUTION: Make s ure that the mati ng faces are cl ean and
free of foreign mat eri al.
Inst all t he generat or.
1.
Inst all t he 2 generator bolt s .
T orque: 48 Nm 2.
Inst all t he acces sory dri ve bel t idl er pull ey.
T orque: 48 Nm 3.
Inst all t he acces sory dri ve bel t idl er pull ey dust cap.
4.
Connect t he generator electrical connect or.
5.
Connect t he batt ery cable t o t he generator.
T orque: 24 Nm 6.
At tach t he power s t eering flui d res ervoir.
7.
8. CAUTION: Make s ure that the mati ng faces are cl ean and
free of foreign mat eri al.
Inst all t he power s t eering pump.
T orque: 24 Nm 8.
Inst all t he fuel fi lt er support bracket.
T orque: 20 Nm 9.
At tach t he oil level indicator t ube to the fuel fil ter s upport bracket .
T orque: 10 Nm 10.
Inst all t he inner fuel fi lt er shi el d.
11.
Secure t he cool ant t op hos e.
12.
Inst all t he acces sory dri ve bel t.
Refer t o: Acces sory Dri ve Belt (303-05B Acces sory Drive - TD4 2.2L
Di es el, Removal and Ins tal lat ion).
13.
Inst all t he engi ne undershi eld.
Refer t o: Engi ne Unders hi eld (501-02 Front End Body Panel s ,
Removal and Ins tall ati on).
14.
Inst all t he fuel fi lt er.
Refer t o: Fuel Fil ter (310-01B Fuel Tank and Lines - TD4 2.2L Dies el ,
Removal and Ins tall ati on).
15.

Publi s hed: 11-May-2011
Information and Entertainment System - General Information - Cellular
Phone
Diagnosi s and Tes ti ng
Principles of Operation
For a detail ed descripti on of the Cel lular Phone s ys t ems , refer t o t he rel evant Des cript ion and Operat ion s ecti on in theworks hop manual . REFER to: Cell ular Phone (415-01 Informati on and Ent ert ainment Syst em, Des cript ion and Operat ion).
Inspection and Verification
CAUTION: Di agnos is by s ubs ti tut ion from a donor vehicle is NO T acceptabl e. Subs ti tut ion of cont rol modules doesnot guarant ee confirmat ion of a faul t, and may als o caus e addit ional fault s i n t he vehi cl e being t est ed and/or t he donorvehi cl e.
1. Verify t he cus t omer concern.1.
2. Vis ually ins pect for obvious s igns of mechani cal or electrical damage and sys tem integrit y.2.
Visual InspectionMechanicalElectrical
Mi crophoneBluet oot h ant ennaEl ect ri cal connect orsW iring harnes s for damage or corros ionFus es
3. If an obvious cause for an obs erved or report ed concern is found, correct t he caus e (if pos s ible) beforeproceeding t o t he next s t ep.3.
4. If t he caus e is not vis ually evi dent , verify t he concern and refer t o t he Sympt om Chart, alt ernat ively check forDi agnos ti c Trouble Codes (DTCs) and refer t o rel evant DTC Index.4.
Symptom Chart
SymptomAction
Unable t o pairGO t o Pinpoint Test A.
Not Auto Connecti ngGO t o Pinpoint Test B.
No Audio to 3rd PartyGO t o Pinpoint Test C.
No Audio from 3rd Part yGO t o Pinpoint Test D.
No AudioGO t o Pinpoint Test E.
DTC Index
• NOTE: If the control modul e or a component i s s us pect and the vehicle remains under manufacturer warrant y, refer t o theW arranty Pol icy and Procedures manual (s ect ion B1.2), or determine i f any pri or approval programme is in operat ion, pri ort o the ins tall ati on of a new module/component.
• NOTE: Generic scan t ool s may not read the codes li st ed, or may read only fi ve digit codes . Mat ch the five di git s from t hes can tool to the firs t fi ve di git s of the seven digi t code l is ted to ident ify t he faul t (t he las t t wo digi ts gi ve ext rainformat ion read by the manufact urer-approved diagnost ic s ys tem).
• NOTE: W hen performing volt age or res is t ance t est s , always use a digi tal mult imeter (DMM) accurat e t o t hree deci malplaces and wit h a current cal ibrat ion cert ificate. W hen tes ti ng res i st ance, always take the res is tance of the DMM l eads i ntoaccount.
• NOTE: Check and recti fy bas ic faul ts before beginni ng diagnos t ic rout ines i nvol vi ng pinpoint t es t s.
• NOTE: If DTCs are recorded and, aft er performi ng the pi npoi nt tes ts , a fault is not present , an int ermi tt ent concern maybe t he caus e. Always check for loose connect ions and corroded terminals .
For a compl ete lis t of all Di agnos ti c Trouble Codes (DTCs) t hat could be logged on this vehicle, pleas e refer to Sect ion100-00.
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Cell ul ar Tel ephone Control Modul e (Bluetooth Tel ephone Module)(BPM) (100-00 General Informat ion, Des cript ion and Operat ion).
Pinpoint Tests
PINPOINT TEST A : UNABLE TO PAIR
T ESTCO NDIT IONSDET AILS/RESULT S/ACT IONS
A1: 'NO PHONE FIT T ED' DISPLAY

1
1
1
1
1
1
1
1
• NOTE: Prior to cont inuing wi th any di agnos is , ens ure t hat the Cus tomer t elephone and level of s oft ware is i ncl uded ont he JLR approved l is t , the t elephone bat tery is full y charged and in a s erviceabl e condi ti on, t he bluet oot h funct ion i sacti vat ed and t he tel ephone hands et is placed wit hin t he vehi cle cabin area.
Carry out checks to det ermi ne if 'No Phone Fit ted' is s hown on vehicle di s pl ay.
Is 'No Phone Fit ted' dis played?YesGO to A2.NoLocat e t he connect ed t elephone and i f not Cus t omer telephone, di sconnect from the sys tem.
A2: T ELEPHONE BLUET OOT H DEVICE SEARCHCarry out Bluetoot h devi ce search us i ng Cust omer hands et.
Is 'Land Rover' i dent ified i n Bl uet oot h device l is t?YesSelect device from li s t, t hen cont inue wi th di agnos is .GO t o A3.NoCarry out further Bluetoot h devi ce s earch, t o a maxi mum of 4 ti mes , wai ti ng approximat ely 20 s econdsbetween s earches. If 'Land Rover' st il l not i dent ified i n Bl uet oot h device l is t, s et igni ti on st atus toOFF, wai t approximat el y 30 s econds and s et ignit ion st atus t o ON. Carry out furt her Bl uet ooth devices earch, t o a maxi mum of 4 ti mes , wait ing approximat ely 20 seconds bet ween s earches . If 'Land Rover's ti ll not identi fi ed in Bl uetooth devi ce lis t , cont act your local i n market s upport for furt her as s is tance.
A3: T ELEPHONE HANDSET ERRORCheck for any error s hown on t he t elephone hands et when 'Land Rover' i s s elect ed from the Bl uetoothdevi ce li st .
W as an error i mmediat el y s hown on t he tel ephone handset ?YesW ai t approxi matel y 10 s econds t hen re-at t empt sel ect ion, to a maximum of 4 t imes , wait ingapproximat el y 10 s econds bet ween each at tempt . If error s ti ll being di spl ayed, cont act your local i nmarket s upport for as s is tance.NoEnter PIN '2121' t hen cont inue wi th diagnos i s.GO t o A4.A4: PIN ENT RY ST AT US
Check for s uccess ful PIN entry.
W as PIN ent ry s ucces s ful?YesGO to A5.NoW ai t approxi matel y 10 s econds t hen re-at t empt PIN ent ry, t o a maximum of 4 t imes, wai ti ngapproximat el y 10 s econds bet ween each at tempt . If PIN ent ry i s s ti ll un-s ucces s ful, contact your l ocalin market s upport for as si st ance.A5: 'NO PHONE FIT T ED' DISPLAY
Carry out checks to det ermi ne if 'No Phone Fit ted' is s t ill s hown on vehicle di s pl ay.
Is 'No Phone Fit ted' s ti ll dis played?YesFrom the telephone hands et, s elect t he connect opt ion for the 'Land Rover' device identi fi ed in theBluet oot h device li s t. If 'No Phone Fit ted' is st il l di s pl ayed, s uspect a t elephone hands et fault . Carryout Pinpoi nt tes t again us ing known good t elephone hands et .NoThe t el ephone i s paired and connect ed t o t he s ys t em. No further acti on is requi red for thi s s ymptom.
PINPOINT TEST B : NOT AUTOMATICALLY CONNECTING
T ESTCONDIT IONSDET AILS/RESULT S/ACT IONS
B1: BLUET OOT H MODULE PAIRED DEVICE LIST
• NOTE: Prior to cont inuing wi th any di agnos is , ens ure t hat the Cus tomer t elephone and level of s oft ware is i ncl uded ont he JLR approved l is t , the t elephone bat tery is full y charged and in a s erviceabl e condi ti on, t he bluet oot h and aut oconnect functi ons are acti vat ed and t he tel ephone handset i s placed wit hin t he vehicle cabin area.
Carry out checks to det ermi ne if t he Cus tomer t elephone is s hown in the Bl uetooth Modul e paireddevi ce li st .
Is the Cus tomer t elephone in t he Bl uet oot h Module pai red device l is t?YesGO to B2.NoCarry out Unabl e t o Pair Pinpoint Test .GO t o A.B2: CUST OMER HANDSET PAIRED DEVICE LIST
Carry out checks to det ermi ne if t he Bl uet oot h Module is s hown i n t he Cus t omer tel ephone paireddevi ce li st .Is the Bl uet ooth Modul e in the Cus tomer t elephone pai red device l is t?YesGO to B3.NoCarry out Unabl e t o Pair Pinpoint Test .GO t o A.
B3: CUST OMER T ELEPHONE IN POSIT ION 1
Carry out checks to det ermi ne if t he Cus tomer t elephone is i n posi ti on 1 i n t he Bluetoot h Modulepaired devi ce lis t .
Is the Cus tomer t elephone in pos it ion 1?YesGO to B4.NoAdvi s e Cust omer t hat aut o connecti on wil l onl y be att empt ed wit h t he devi ce that is shown inposi ti on 1 i n Bluet oot h Module pai red device l is t.
B4: CHECK FOR DT C B1A56-13

1
1
1
1
1
1
1
1
Us ing Manufacturer approved di agnos ti c s ys t em, check for DTC B1A56-13.
Is DTC B1A56-13 logged?YesCarry out remedial acti ons as out li ned in DTC Index. If s ymptom remai ns, contact your l ocal inmarket s upport for as s is tance.NoGO to B5.B5: BLUET OOT H CONNECT ION
Carry out checks to det ermi ne if Bl uet ooth connect ion i con is s hown on Cus tomer Bl uet ootht el ephone s creen but s hows 'No Phone Fit ted' on vehi cle s creen.Is Bluetooth connect ion icon s hown on the Cus t omer hands et but 'No Phone Fi tt ed' di spl ayed on vehi cl es creen?YesGO to B9.NoGO to B6.B6: 'LAND ROVER' AUT HORISAT ION
• NOTE: Some hands et s may require operator int erventi on to manual ly aut horis e connect ion.
Carry out checks to det ermi ne if 'Land Rover' i s authori sed in t he Cus tomer Bluet ooth t elephonedevi ce li st menu.
Is 'Land Rover' aut horis ed i n the Cus t omer Bluetooth tel ephone device li s t menu?YesGO to B7.NoAdvi s e cus t omer that 'Land Rover' needs t o be aut horis ed i n t he Cus t omer Bluetoot h tel ephonedevi ce li st menu, or operator i nterventi on may be required to manual ly authoris e connecti on.
B7: SEARCH FOR DEVICES SCREEN
Select the s earch for devices butt on on t he vehicle di spl ay.
Does pres si ng t he search for devi ces but ton bring up the s earching s creen on t he vehicle di spl ay?YesContact your l ocal in market s upport for ass i st ance.NoGO to B8.B8: CYCLE IGNIT ION AND CHECK SEARCH FOR DEVICES SCREEN
Lock vehicle (wai t 60s ) before unlocki ng and t urning Ignit ion s tat us back to O N.
Does pres si ng t he search for devi ces but ton bring up the s earching s creen on t he vehicle di spl ay?YesNo furt her acti on required for t his Sympt om. Poss ibl e int ermi tent faul t.NoContact your l ocal in market s upport for ass i st ance.B9: PAIRED DEVICE
Check Cus t omer t elephone pai red device l is t t o es tabli sh which devi ce the Cus t omer telephone isconnected t o.Is the Cus tomer t elephone connect ed t o t he vehi cl e?YesLock vehicle (wai t 60s ) before unlocki ng and t urning Ignit ion s tat us back to O N. If Not Automat icall yConnecti ng, contact you local in market support for as s is t ance.NoUs ing t he Cus tomer t el ephone controls , dis connect from t he current ly connect ed devi ce and del et efrom pai red device l is t. Lock vehi cl e (wait for 60s ) before unl ocking and turni ng Igi ti on s tat us to ON.If Not Aut omati cal ly Connect ing, cont act your local i n market s upport for as s is t ance.
PINPOINT TEST C : NO AUDIO TO THIRD PARTY
T EST CONDIT IONSDET AILS/RESULT S/ACT IONS
C1: MICROPHONE DIAGNOST IC T ROUBLE CO DES (DT CS)• NOTE: Prior to cont inuing wi th any di agnos is , ens ure t hat the Cus tomer t elephone and level of s oft ware is i ncl uded ont he JLR approved l is t , the t elephone bat tery is full y charged and in a s erviceabl e condi ti on, t he t elephone is placed wi thint he vehi cl e cabi n area and is connect ed to the vehicle vi a bluet oot h.
Us ing t he Manufacturer approved diagnost ic sys tem, check for any logged mi crophone DTCs i nAudio Front Control modul e.
Is DTC B1D79-01 logged?YesCarry out diagnos is of el ect ri cal failure as advis ed in Act ion column of DTC Index.NoContact your l ocal in market s upport for ass i st ance.
PINPOINT TEST D : NO AUDIO FROM THIRD PARTY
T EST CONDIT IO NSDET AILS/RESULT S/ACT IONS
D1: ' IN CALL' DISPLAY
• NOTE: Prior to cont inuing wi th any di agnos is , ens ure t hat the Cus tomer t elephone and level of s oft ware is i ncl uded ont he JLR approved l is t , the t elephone bat tery is full y charged and in a s erviceabl e condi ti on, t he t elephone is placed wi thint he vehi cl e cabi n area and is connect ed to the vehicle vi a bluet oot h.Carry out checks t o determine i f 'In Call ' i s s hown on t he vehi cl e dis play.
Is vehi cl e dis play s howing 'In Call'?YesContact your l ocal in market s upport for as si s tance.NoCall has ended. No further act ion i s requi red for this sympt om.
PINPOINT TEST E : NO AUDIO

1
1
1
1
T EST CONDIT IO NSDET AILS/RESULT S/ACT IONS
E1: AUDIO FROM T HIRD PART Y
• NOTE: Prior to cont inuing wi th any di agnos is , ens ure t hat the Cus tomer t elephone and level of s oft ware is i ncl uded ont he JLR approved l is t , the t elephone bat tery is full y charged and in a s erviceabl e condi ti on, t he t elephone is placed wi thint he vehi cl e cabi n area and is connect ed to the vehicle vi a bluet oot h.Es tabli s h from Cus t omer feedback/s ymptom if t here i s Audio from t he Thi rd Party.
Is t here Audio from t he Thi rd Party?YesGO to E2.NoRefer t o t he 'No Audi o From Thi rd Party' Pinpoint t est .GO t o D.
E2: AUDIO T O T HIRD PART Y
Es tabli s h from Cus t omer feedback/s ymptom if t here i s Audio t o t he Third Part y.
Is t here Audio t o t he Third Part y?YesGO to E3.NoRefer t o t he 'No Audi o To Third Part y' Pi npoi nt t es t.GO t o C.
E3: CD O R RADIO AUDIO
Es tabli s h from Cus t omer feedback/s ymptom if t here i s Audio from t he CD or Radio.
Is t here Audio from t he CD or Radio?YesGO to E4.NoSus pect MOST ring fault , refer t o elect rical circuit di agrams and check/recti fy MOST ri ng asneces s ary.
E4: T ELEPHONE HANDSET AUDIOEs tabli s h from Cus t omer feedback/s ymptom if t here i s Audio from t he tel ephone hands et .
Is t here Audio from t he tel ephone hands et ?YesEns ure vehicle is parked. Dis connect and reconnect hands et. If is s ue not res olved, contact yourl ocal in market s upport for ass i st ance.NoContact you local in market support for as s is t ance.

Publi shed: 26-Jul-2011
Information and Entertainment System - General Information - Information
and Entertainment System
Diagnosi s and Tes ti ng
Principles of Operation
For a detail ed descripti on of the Informati on and Entertainment s ys tems , refer to the relevant Des cri pt ion and Operati ons ect ion i n t he works hop manual . REFER to:
Audi o Syst em (415-01 Informati on and Entert ainment Syst em, Des cript ion and Operat ion),Speakers (415-01 Informati on and Ent ert ainment Syst em, Des cript ion and Operat ion),Navi gat ion Sys tem (415-01 Informat ion and Ent ert ai nment Sys t em, Des cri pti on and Operati on),Ant enna (415-02 Ant enna, Des cri pt ion and Operati on).
Inspection and Verification
CAUTION: Di agnos is by s ubs ti tut ion from a donor vehicle is NO T acceptabl e. Subs ti tut ion of cont rol modules doesnot guarant ee confirmat ion of a faul t, and may als o caus e addit ional fault s i n t he vehi cl e being t est ed and/or t he donorvehi cl e.
1. Verify t he cus t omer concern.1.
2. Vis ually ins pect for obvious s igns of mechani cal or electrical damage and sys tem integrit y.2.
Visual Inspection
MechanicalElectricalIntegrat ed audi o moduleInformat ion and ent ert ainment moduleAudio ampl ifierCompact di s c player jammed, not loadingScrat ched/di rt y compact dis csSpeakersNavigati on s ys t em DVD player mechanis m
Fus esW iring harnes sCorrect engagement of electrical connect orsLoos e or corroded connect or(s )Rout ing of fibre opt ic harnes s esCorrect engagement of opt ical connectorsCorrect placement of opt ical connect ors (ri ng order)Correct as sembl y of opt ical connect ors (backout , et c)Damage to fi bre (chafing, abrasi on, ki nki ng, cuts , et c)Int egrated audio modul eInformat ion and entertai nment modul eAudi o ampli fi erSpeakersNavi gat ion s ys tem dis playNavi gat ion s ys tem moduleGPS ant ennaW iring harnes s for damage and corros ionABS Modul eAudi o unit
3. If an obvious cause for an obs erved or report ed concern is found, correct t he caus e (if pos s ible) beforeproceeding t o t he next s t ep.3.
4. If t he caus e is not vis ually evi dent , check for Di agnos ti c Trouble Codes (DTCs) and refer t o rel evant DTC Index.4.
Navigation System Symptom Chart
SymptomPossible CauseActionPoor sat elli te recept ionEl ect ri cal harnes s open/s hortci rcuit , di s -connectedComponent fail ureNo recept ion from s atel lit e
GO t o Pinpoint Tes t B.
Map di sc will not i ns ert /ejectEl ect ri cal harnes s open/s hortci rcuit , di s -connectedComponent fail ureMap dis c fai lure
GO t o Pinpoint Tes t C.
Black s creen (navi gat ionmap screen does notdis play)
El ect ri cal harnes s open/s hortci rcuit , di s -connectedComponent fail ureGVIF cable
GO t o Pinpoint Tes t D.
Navigati on map s creen colori s abnormalEl ect ri cal harnes s open/s hortci rcuit , di s -connectedComponent fail ureGVIF cable
GO t o Pinpoint Tes t E.
Vehicle’s current posi ti onmark t urns independentl yEl ect ri cal harnes s open/s hortci rcuit , di s -connectedComponent fail ureVehicl e on a t urnt abl e i n aparki ng buildi ng
GO t o Pinpoint Tes t F.DTC Index
• NOTE: If the control modul e or a component i s s us pect and the vehicle remains under manufacturer warrant y, refer t o theW arranty Pol icy and Procedures manual (s ect ion B1.2), or determine i f any pri or approval programme is in operat ion, pri or

1
t o the ins tall ati on of a new module/component.
• NOTE: Generic scan t ool s may not read the codes li st ed, or may read only fi ve digit codes . Mat ch the five di git s from t hes can tool to the firs t fi ve di git s of the seven digi t code l is ted to ident ify t he faul t (t he las t t wo digi ts gi ve ext rainformat ion read by the manufact urer-approved diagnost ic s ys tem).
• NOTE: W hen performing volt age or res is t ance t est s , always use a digi tal mult imeter (DMM) accurat e t o t hree deci malplaces and wit h a current cal ibrat ion cert ificate. W hen tes ti ng res i st ance, always take the res is tance of the DMM l eads i ntoaccount.
• NOTE: Check and recti fy bas ic faul ts before beginni ng diagnos t ic rout ines i nvol vi ng pinpoint t es t s.
• NOTE: Ins pect connect ors for s igns of water ingres s , and pins for damage and/or corros ion.
• NOTE: If DTCs are recorded and, aft er performi ng the pi npoi nt tes ts , a fault is not present , an int ermi tt ent concern maybe t he caus e. Always check for loose connect ions and corroded terminals .
Informat ion and Ent ert ai nment Modul e (Low Line)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Infotai nment Cont rol Modul e (ICM) - Low Li ne (100-00 GeneralInformat ion, Des cript ion and Operat ion).
Informat ion and Ent ert ai nment Modul e (High Line)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Infotai nment Cont rol Modul e (ICM) - High Line (100-00 GeneralInformat ion, Des cript ion and Operat ion).
Audio Front Control Modul e (ACM)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Audio Front Cont rol Modul e (ACM) (100-00 General Informati on,Des cript ion and Operat ion).
Audio Ampl ifier Modul e (AAM)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Audio Ampl ifier Module (AAM) (100-00 General Informati on,Des cript ion and Operat ion).
Front Control Di s pl ay Int erface Modul e (FCDIM) (hi gh level di s pl ay front)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Front Controls Di spl ay Int erface Module (FCDIM) - Front Int egratedControl Panel (100-00 General Informati on, Des cript ion and Operat ion).
Navigati on Cont rol Module (NCM)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Navigati on Cont rol Module (NAV) (100-00 General Informat ion,Des cript ion and Operat ion).
Satell it e Radio Modul e (SRM)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Satel lit e Di git al Audio Radi o Syst em Module (SARM) (100-00General Informat ion, Descri pti on and Operat ion).
Digi tal Audio Broadcast Modul e (DAB)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: Digi tal Audio Broadcas t Modul e (DABM) (100-00 GeneralInformat ion, Des cript ion and Operat ion).
High Defini ti on Tuner Module (HDR)
REFER to: Di agnos ti c Trouble Code (DTC) Index - DTC: High Defini ti on Radi o Module (HDR) (100-00 General Informat ion,Des cript ion and Operat ion).
Pinpoint Tests
• NOTE: Vis uall y ins pect for any of t he fol lowi ng condit ions and rect ify any faul t identi fied prior t o carryi ng out any tes tson t he MOST Net work.
Any s harp bends in the opt ical fibre harnes s (check for t hi s before dis turbing any module or connect or)Incorrect engagement of any opti cal connect orsIncorrect engagement of any elect rical connectorsDamage t o t he opt ical fi bre harnes s (chafing, abrasi on, ki nki ng, cuts , break, etc)Incorrect as s embly of t he opti cal network
• NOTE: Unles s ot herwis e s t at ed, ens ure vehi cl e igni ti on st atus is s et to 'ON' when carryi ng out MOST Network t est s .
PINPOINT TEST A : MOST NETWORK TESTS
T ESTCONDIT IONSDET AILS/RESULT S/ACT IONS
A1: CHECK HLDF DISPLAY
Check HLDF dis play
Is t he HLDF showi ng a flas hi ng Land Rover l ogo, or a blank s creen?YesGO to A2.NoNo ri ng break faul t has occurred. Sus pect invali d Car Configurat ion Fi le paramet er fault s , checkmodules on MOST Network for relat ed DTCs and refer t o t he rel evant DTC Index.

1
1
2
3
4
5
6
7
1
1
2
3
1
1
2
1
2
3
1
1
A2: CHECK RD1 RING BREAK LINK
Check the RD1 Ring Break link in Auxil iary Juncti on Box (AJB) is not dis connected or open circui t.
Is t he RD1 Ring Break li nk in Auxil iary Juncti on Box (AJB) dis connected or open circui t?YesRecti fy t he faul t condit ion and re-tes t vehi cl e.NoGO to A3.
A3: INIT IAT E RING BREAK DIAGNOST IC (RBD) & READ DT CSEns ure RD1 Ring Break l ink i s in AJB.
Ens ure remote key is i ns erted i nto key holder.
Set vehi cle i gni ti on s tat us from 'OFF' t o 'ON'.
Cl ear al l DTCs .
Remove RD1 Ri ng Break l ink from AJB, wai t at least t en s econds , re-ins ert RD1 Ri ng Break l ink int oAJB.
W ait at leas t 30 s econds for RBD to init iat e and complete.
Read all DTCs .
Is DTC U1A1587 logged?YesGO to A4.NoCheck HLDF for addit ional DTCs and refer t o rel evant DTC Index.
A4: CHECK FOR FAILURE AT INT ERMEDIAT E CONNECT O R C23T PIN 2
Di sconnect t he MOST net work i nt ermedi ate connect or C23T.
Is t he bright red li ght vi si ble at MOST intermediat e connector C23T pin 2?YesGO to A5.NoGO to A6.A5: CHECK FOR FAILURE AT FIRST HALF OF MOST NET WORK
Connect t he Opt ical Bus Tes ter (OBT) to intermediat e connector C23T usi ng adapt or lead s uppl ied.
Swi tch OBT 'ON' and s et t o 2+0 opt ion.
Select t he vi s ible LED opt ion.
Is t he Rx lamp/LED permanentl y 'ON' and t he HLDF s creen permanentl y dis playing 'Home menu s creen' orLand Rover l ogo?YesFault i s in second half of MOST Net work. Dis connect OBT and re-connect intermediat e connector.GOt o A13.NoDi sconnect OBT from i nt ermedi at e connect or C23T and connect opti cal LINK providedGO t o A10.
A6: CHECK FOR FAILURE AT INFORMAT ION AND ENT ERT AINMENT MODULE
Di sconnect MOST connect or C2ME05B from informat ion and ent ertai nment modul e.
Is t he bright red li ght vi si ble at module s ide of connector C2ME05B pin 2?YesIf there is a HLDF ins t al led t o t he vehi cle.GO to A7. If t here i s no HLDF ins t al led, t he fault i s in theopt ical fibre between C2ME05B pin 2 and C23T pin 2, rect ify t he fault and re-t es t the vehicle.NoInst all a new informat ion and entertai nment modul e and re-tes t vehi cle.
A7: CHECK FOR FAILURE OF OPT ICAL FIBRE T O HLDFRe-connect MO ST connect or C2ME05B to i nformati on and ent ert ainment module.
Di sconnect MOST connect or C2MN08C from HLDF.
Is t he bright red li ght vi si ble at harnes s s ide of MOST connect or C2MN08C pi n 1?YesGO to A8.NoFault i s in opt ical fi bre harnes s between C2ME05B pin 2 and C2MN08C pin 1, rect ify the faul t andre-t est vehicle.A8: CHECK FOR FAILURE OF OPT ICAL FIBRE FROM HLDF
Connect OBT to HLDF MOST connector C2MN08C.
Swi tch OBT 'ON' and s et t o 2+0 opt ion.
Select t he vi s ible LED opt ion.
Is t he bright red li ght vi si ble at MOST intermediat e connector C23T pin 2?YesGO to A9.NoFault i s in opt ical fi bre harnes s between C23T pi n 2 and C2MN08C pin 2, recti fy t he faul t and re-tes tvehicle.
A9: CHECK FOR FAILURE AT HLDFConnect t he opti cal Link provi ded to MOST int ermediat e connector C23T.
Is t he Rx lamp/LED permanentl y 'ON' and t he HLDF permanentl y dis playing bl ank s creen?YesCheck/repair power feed and ground lines t o HLDF. If power feed and ground lines ok, ins tal l a newHLDF.REFER t o: Vi deo Dis play (415-01 Informati on and Ent ert ainment Syst em, Removal and Inst all ati on).NoCheck int egrit y of int ermediat e connector C23T connecti ons , and re-t est vehicle.
A10: CHECK FOR FAILURE OF OPT ICAL FIBRE T O INT EGRAT ED AUDIO MODULEDi sconnect MOST connect or C2ME44B from int egrated audio module.