brake sensor MAZDA PROTEGE 1992 User Guide

TECHNICAL DATA TD
Item
Coolant Engine/Transaxle B6 SOHC BP SOHC BP DOHC
MTX 1 ATX 1 MTX 1 ATX 1 MTX 1 ATX
Capacity
liters tus qt, Imp qt) (5Z.4) (8.E.3) (5&4) (SE.3) (5.?i.4) (S.E.3)
Coolant protection Volume percentage %
Specific gravity at
Water Coolant 20% (68OF)
Antifreeze solution Above -16OC (3OF)
65 35 1.054
Above -26OC (-15OF) 55 45 1.066
I Above -4OOC (-40°F) 45 55
1.078
F. FUEL AND EMISSION CONTROL SYSTEMS Item
idle speed*‘**
Ignition timing** Fuel pump
Maximum output pressure Fuel filter Engine
B6 SOHC BP SOHC BP DOHC
vm 700-800
BTDC 6O--8O 4O---6O 90-l 10
kPa (kg/cm*, psi) 1 441-637 (4.5-6.5, 64-92) ‘Type
Low-pressure side Nylon element (in fuel pump)
High-pressure side Paper element Pressure regulator
Regulating pressure kPa (kg/cm*, psi) 1 265-314 (2.7-3.2, 38-46) Injector
Type
High-ohmic
Type of drive Electromechanical
Resistance n 12-16 Idle speed control (ISC) valve
Type
Rotary
Resistance n ] 11-13 Purge control solenoid valve
Resistance n 1 23-27 Water thermosensor
-20°C( -4OF) 14.6-17.8
Resistance k6 20°C( 68QF) 2.21-2.69
40% (104OF) 1.0-l .3
80°C(1760F) 0.29-0.35 Airflow meter
E2++Vs Fully closed 20-600 q D Fully open 20-l ,000
E~HVC 200-400
Resistance g Ez++THAA -2O%(-4OF) 13,600-18,400
(Intake air 20%( 68OF) 2,210-2,690
thermosensor)
60°C(1400F) 493-667
Eic*Fc Fully closed 00
Fully open 0 Fuel tank
Capacity liters (US gal, Imp gal) I
Hatchback 50 (13.2, 11.0) PROTEGE . . . . 55 (14.5, 12.1) Air cleaner
Element type Oil permeated Fuel
Specification Unleaded regular (RON 91 or higher)
*’ With parking brake applied (Canada)
*’ TEN terminal of diagnosis connector grounded
TD-9

TD TECHNICAL DATA
Spring name
2-3 accumulator
small spring Outer diameter Free length Wire diameter
mm (in) mm (in) No. of coil
mm (in) BP DOHC 11.6 (0.457)
59.7 (2.350)
16.9 1.8 (0.071)
56 SOHC
BP SOHC 10.0 (0.394) 71.8
(2.827) 24.2 1.4 (0.055)
2-3 accumulator BP DOHC 15.0
(0.591) 71.8 (2.827) 9.8
1.2 (0.047)
large spring B6 SOHC
BP SOHC 15.0 (0.591)
71.8 (2.827)
15.8 2.0 (0.079)
l-2 accumulator small spring
11.2 (0.441)
84.7 (3.335)
25.5 1.5 (0.059)
BP DOHC
- - -
-
l-2 accumulator
Accumulator large spring B6 SOHC
BP SOHC 16.0 (0.630)
84.7 (3.335) 19.5
1.9 (0.075)
B6 SOHC 10.8 (0.425) 101.2 (3.984)
28.2
1.2 (0.047)
N-D Accumulator
small spring BP SOHC
BP DOHC
10.8 (0.425) 101.2 (3.984)
28.2
1.2 (0.047)
B6 SOHC
15.0 (0.591) 94.2 (3.709)
16.5
1.6 (0.063)
N-D Accumulator
large spring BP SOHC
BP DOHC 15.0 (0.591) 94.2
(3.709) 16.5
1.6 (0.063)
N-R Accumulator small spring
9.8 (0.386)
93.2 (3.669) 31.5
1.3 (0.051)
N-R Accumulator large spring
14.0 (0.551) 106.5 (4.193)
23.0 1.7 (0.067)
3-4 clutch
Return spring
74.4 (2.929)
40.5 (1.594) 1 .o
5.0 (0.197)
Coasting clutch
Return spring
7.3 (0.287) 20.45 (0.805)
10.0 1 .o (0.039)
Low and reverse
brake Return
spring 5.55 (0.219)
14.3 (0.563)
12.0 0.75 (0.030)
Servo
Return spring
27.7 (1.091) 43.25 (1.703)
4.5
3.2 (0.126)
Vehicle Speed at Shift point Table -
lode
- -
angc
-
D Throttle condition
(Throttle sensor
voltage)
Fully opened
(4.0 volt)
Half throttle
(1.6-2.2 volt)
/ &%L) j 3 1 850-2,500 2,100-2,650 2,300-3,000 74-100 (46-62) 91-116 (56-72) 93-120 (58-74
Lock-up
[1,850-2,20011,950-2.550(2,300-2,700/74-88 (46--55)185-110 (53-68)(93-108 (58-67)1
Kir.kdnwn OD -+ DI
1,05U
%lly opened
i4.0 volt)
Half throttle
s2 -+ s3 5,000-5,45c
s3 -+ s2 2,900
S2 -+ ST 2,300-2,6OC
SI * 52
2.500-3.35C
(1.6-2.2 volt)
s2 -+ s3 v, v...
Fully opened Ll + L2 5,150-5,75(
w-dt I7w-ln
nlf throttle 6-7 7 vnltl I Ll + L2 (2.500-3.350(2,850-3,8OOj3.300-4.300125-34 (16-21$1-41 (19-25)j33-43 (20-27)1
TD-16

PARTS INDEX
‘I
A
ACCELERATOR CABLE ............................. F-l 14
ACCELERATOR PEDAL ............................. F-l 14
AIR CONDITIONER ...................................... u-30
A/C RELAY.. ........................................... U-56
A/C SWITCH ...........................................
U-57
COMPRESSOR.. ..................................... U-41
CONDENSER.. ....................................... U-53
CONDENSER FAN ................................. u-57
CONDENSER FAN RELAY .................... U-56
COOLING UNIT ..................................... U-38
MAGNETIC CLUTCH ............................. u-51
RECEIVER/DRIER .................................. U-52
REFRIGERANT PRESSURE SWITCH.. .. U-55
AIR FLOW METER ..................................... F-l 68
AIR VALVE.. ................................................ F-l 16
ALTERNATOR .............................................. G-10
ANTENNA FEEDER
AUDIO
....... .......................................................................................... T-i;
AUTOMATIC TRANSAXLE ............................. K-l
2-4 BRAKE BAND ................................ K-l 97
3-4 CLUTCH.. ....................................... K-l 87
ACCUMULATORS ................................ K-l 67
ATF ....................................................... K-135
ATF THERMOSENSOR ........................ K-142
BEARING COVER ASSEMBLY ............ K-208
CLUTCH ASSEMBLY ........................... K-l 72
CONTROL VALVE BODY.. .....
K-21 0,224,234
DIFFERENTIAL ..................................... K-236
DRIVE PLATE.. ..................................... K-267
EC-AT CONTROL UNIT ....................... K-144
HOLD SWITCH ..................................... K-140
HYDRAULIC CIRCUIT .......................... K-278
IDLER GEAR ........................................ K-203
INHIBITOR SWITCH ............................. K-l 41
LOW AND REVERSE BRAKE .............. K-192
MAIN CONTROL VALVE BODY .......... K-220
OIL COOLER.. ...................................... K-265
OIL PUMP ............................................
K-169
OIL SEAL ..............................................
K-209
ONE-WAY CLUTCH 2
CARRIER HUB ASSEMBLY ............... K-185
OUTPUT GEAR .................................... K-206
P RANGE SWITCH.. ............................. K-271
PREMAIN CONTROL VALVE BODY .a. K-218
PULSE GENERATOR ........................... K-142
SELECTOR LEVER ............................... K-272
SHIFT MECHANISM ............................. K-269
SHIFT-LOCK ACTUATOR
..................... K-271
SMALL SUN GEAR AND
ONE-WAY CLUTCH 1 ........................ K-l 82
SOLENOID VALVE.. ............................. K-l 43
SPEEDSENSOR .................................. K-l 43
THROTTLE CABLE .............................. K-l 37
TORQlJE CONVERTER.. ...................... K-l 66
TRANSAXLE UNIT. ......... K-149,153,246,261 UPPER CONTROL VALVE BODY.. ..... K-215
BACK-UP LIGHT SWITCH..
..........................
BATTERY T;4;
- .......................................................
BLOWER UNIT ............................................
U-23
BRAKE FLUID.. .............................................. P-8
BRAKE MASTER CYLINDER. ...................... P-10
BRAKE PEDAL ...............................................
P-8
C
CALIPER .................................................. P-21,26
CARGO COMPARTMENT LAMP ................. T-54
CENTRAL PROCESSING UNIT..
.................. T-55
CHARCOAL CANISTER ............................. F-l 41
CHECK VALVE (TWO-WAY) .......................
CHECK-AND-CUT VALVE - .......................... ;-;b$
CIRCUIT OPENING RELAY.. ...................... F-129
CLUTCH COVER ......................................... H-l 7
CLUTCH DISC ............................................. H-l 7
CLUTCH FLUID ............................................. H-4
CLUTCH MASTER CYLINDER.. .................... H-7
CLUTCH PEDAL ............................................ H-5
CLUTCH RELEASE CYLINDER..
................. H-12
CLUTCH SWITCH (MTX) ............................ F-l 72
COMBINATION SWITCH .............................. T-23
COWL GRILLE ............................................. S-53
CRUISE CONTROL UNIT.. ...................... T-78,85
D
DASHBOARD ............................................... S-94
DASHPOT ................................................... F-l 42
DISTRIBUTOR .............................................. G-20
DOOR LOCK TIMER UNIT ........................... T-17
DOOR MIRROR ............................................ S-54
REMOTE CONTROL MIRROR ............... S-56
REMOTE CONTROL MIRROR SWITCH. S-55
DOOR SPEAKER .......................................... T-98
DRIVE SHAFT.. ....................................... M-l 7,21
DRL RELAY.. ................................................ T-18
DRL RESISTOR ............................................ T-46
DUAL PROPORTIONING VALVE..
............... P-l 6
DYNAMIC CHAMBER ................................ F-l 12
E
ELECTRIC COOLING FAN SYSTEM ........... E-13
ENGINE (B6 & BP SOHC) ........................... Bl-2
CAMSHAFT ..........................................
Bl-58
CAMSHAFT PULLEY ...........................
Bl-65
CONNECTING ROD ............................. 81-63
PI-I

PARTS
DIFFERENTIAL ..................................... Jl-52
SHIFT MECHANISM ............................. Jl-56
TRANSAXLE ............................................ Jl-8
TRANSAXLE OIL .................................... Jl-7
MANUAL TRANSAXLE (G5M-R) .................. J2-2
DIFFERENTIAL ..................................... J2-43
SHIFT MECHANISM ............................. J2-46
TRANSAXLE.. .......................................... J2-8
TRANSAXLE OIL .................................... J2-7
MOLDING, PROTECTOR, GARNISH ...........
S-42
BELTLINE MOLDING ............................. S-48
REAR WINDOW MOLDING.. ............. S-43,44
ROOF MOLDING.. .................................. S-46
SIDE PROTECTOR ................................. S-49
UPPER WINDSHIELD MOLDING,
A-PILLAR GARNISH ............................ S-42
NEUTRAL SWITCH (MTX) . . . . . . . . . . . . . . . . . . . . . . . . . . F-l 73
0
1
\_ OIL COOLER (ENGINE). ................................ D-8
OIL PAN (ENGINE) ........................................ D-9
OIL PUMP (ENGINE) ................................... D-l 3
..................................... F-l 71
OXYGEN SENSOR
P
PARKING BRAKE ......................................... P-31
PARKING BRAKE CABLE ............................ P-32
PARKING BRAKE LEVER ............................ P-33
PARKING BRAKE SHOE ............................. P-31
PASSIVE SHOULDER BELT SYSTEM.. ..... S-103
DOOR CATCH SWITCH ....................... S-l 07
LIMIT SWITCH ...................................... S-l 07
PASSIVE SHOULDER BELT MOTOR.. S-106
SPEED SENSOR ................................... S-l 07
WARNING SWITCH .............................. S-l 07
PCV VALVE ................................................
POWER BRAKE UNIT ‘;--=I;;
..................................
POWER DOOR LOCK SYSTEM ................... S-23
DOOR LOCK CONTROL.. ...................... S-26
DOOR LOCK SWITCH.. .......................... S-26
DOOR LOCK TIMER AND RELAY.. ....... S-26
POWER STEERING.. .................................... N-23
POWER STEERING FLUID .......................... N-27
POWER STEERING OIL PUMP.. ................. N-37
POWER STEERING PRESSURE SWITCH . . F-l 73
POWER WINDOW SYSTEM.. .......................
S-27
MAIN POWER WINDOW SWITCH.. .......
S-31
POWER WINDOW MOTOR.. ..................
S-32
POWER WINDOW SUB-SWITCH ........... S-32
PRESSURE REGULATOR (FUEL). ............. F-l 29 . . . . . . . . , . . . . . , . RADIATOR CAP .............................................
E-7
RADIATOR GRILLE,
I
LOWER GRILLE MOLDING ....................... S-51 fl
RADIATOR THERMOSWITCH ...................... E-17 t
REAR AXLE ................................................. M-10
REAR BRAKE (DISC) ................................... P-23
REAR BRAKE (DRUM) ................................. P-28
REAR BUMPER ............................................ s-40
REAR COMBINATION LIGHT.. ....
REAR CROSSMEMBER ............................... R-29
REAR DOOR ................................................ S-l 5
REAR DOOR LOCK AND OPENER.. .
REAR FINISHER ........................................... s-52
REAR HATCH ............................................... s-20
REAR HATCH LOCK AND OPENER.. ......... S-22
REAR SHOCK ABSORBER AND SPRING.. R-21
REAR SIDE MARKER LIGHT ....................... T-48
REAR SIDE WINDOW REGULATOR AND . . . . . . . . .
AI .,.n
INDEX
Q
QUARTER WINDOW GLASS . . . . . . . . . . . . ..a........ S-62
R
RADIATOR . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
kiLA33 ........................................................ a-- I I
REAR SPEAKER ........................................... T-99
REAR SPOILER ............................................ s-41
REAR STABILIZER.. ..................................... R-27
REAR SUSPENSION .................................... R-20
REAR WINDOW GLASS ............................... S-63
REAR WINDOW DEFROSTER.. .................... T-74
REAR WINDOW DEFROSTER SWITCH ....... T-77
REAR WIPER AND WASHER ...................... S-74
REAR WASHER MOTOF
REAR WIPER AND WASHER SWITCH . . S-77
REAR WIPER MOTOR ............................ s-77
RELEASE BEARING (CLUTCH). . . . . . . . . . ..s..... H-17 I . . . . . . . . ...*. .*......*..
SEAT BELT.. ........................................ S-100,102
BUCKLE SWITCH.. ............................... S-l 02
SEAT ........................................................... s-110
SEPARATOR (FUEL) .................................. F-l 40
SHUTTER VALVE ACTUATOR (VICS) ........ F-l 18
SLIDING SUNROOF ..................................... S-80
MOTOR ASSEMBLY ............................... S-81
SUNROOF RELAY.. ................................ S-82
SUNROOF SWITCH.. .............................. S-82
SOLENOID VALVE
(PRESSURE REGULATOR CONTROL) .... F-135
SOLENOID VALVE (PURGE CONTROL). .. F-140
SOLENOID VALVE (VICS) .......................... F-l 18
SPARK PLUGS ............................................ G-18
-II__

T.&condition
-t
Off
IQ”&” switch
ON
Whik cranking
lgnitlon switch ON
Test switch at “SELF-TEST”
Lamp illuminated for 3 sec. after ignition
SwiIch OFF-KIN
Lamp not illuminated after 3 sec. collect vdtaQe
ReRlar*
ve
For backup
ov
-
V%
Approx. tov
ov
4 5--5.5v With Self-
D&Q”& Check-
er and system
Vi3 st?lt?ctor Input &PJ
- -
0
0
0
0
0
0
- -
- -
0
0
c
- -
0 connectkfl to mnina
Connection to
Stoplight swtch Test condition
-L 1A
Bake pedal released
IEI
IC Main relay
(FUEL INJ relay) Brake pedal depressed
lQ”ih0” switch ON
___-- P/S Qrc?ss"re
switch
Ignition switch
(START) P/S ON at idle
P/S OFF at idle
A/C switch ON
A/C switch OFF
Cwlng fan operatng (Engine coolant tem-
perature over 97°C (207°F) or dlagnosls
connector terminal TFA grounded) (IG ON)
Fan not ooeralmg (Idle) 1D .self-mag”osls
Checker
(Monitor lamp) A!C switch
coohng fan swtctl
Test switch at “02 MONITOR” at idle
Monitor lamp ilfummated
Test switch at “02 MONITOR” at idle
Monitor lamp not illuminated
Lamp illuminated for 3 sec. after ignition
switch OFF&N
Lamp not illuminated after 3 ser.
Lamp illuminated
Lamp not #lluminated VB
Below 2.w With System
Selector test
VB swtch at
“SELF-TEST”
Eelow 2.5v
VS Blower Control
swttch Blower control switch OFF or 1 st posihon
Blower control swtch 2nd or htgher
position 1E
Malfunction indicator
lamp
NJ
Rear window defroster swtch OFF Rear wmdow
defroster switch
Headkght switch Rear window defroster Switch ON
-2-A - I
tieadlghts ON
Headlights OFF
Neutral positton or clutch pedal
depressed
OlhWS l Wiih Self-
DkQnosls
Checker and
Svstem Selector Self- Diaanosis Buzzer sounded for 3 sec. after ignition
switch OFF-ON
Buzzer not sounded after 3 set 6&w 2.5v
V8 Checke;
(Cede Number) I
ov Ignition swtch
ON NeulraliClutch
switches
. ‘.&h System
Selector test
switch at Buzzer sou”ded
1 Below 2.5V 1
VB
ov -
ov -
ov -
ov -
APprox. ov
or 4 5-5 5v
-
Approx. 2V
-
-
AQWOX. Ov
or 4 5-5 5v
-
APQ~OX 1.5V Buzzer not sounded
I VE
I
Ground (Injector)
Ground
(OUtQUt)
Ground (CPU)
Grou”d (Input)
constant
lgnlti swtch ON
klk “SELF-TEST”
ov
-
Ap~rox O.2V
- - Constant
Co”stant lgnller
1H
Constant
Igntho” swdch ON -
- D&ribulor
(Ne-sIgnal) II
1J
1K
1L
1M
1N -
fgnition switch ON
AX switch ON al idle
NC switch OFF at Idle
System Selector lest switch at
“0-z MONITOR” I -
- VB
5&w 2.w -
Vi3
VB Ignition switch
ON
System Selector test swatch at
“SELF-TEST”
ParkIng brake pulled wth lgndlon swtch ON
(DRL OFF) ov
VB
l DRL: oaytime Running tigms
Idle (DFtL ON) Below 2.5v A/C relay
Idle
-
Ignition swtch ON
-
Distributor
(G-stgnal) [DOHC]
3ignosis
x”“ec1or
,TEN terminal) Idle
3RL relay (canada)
-
Accelerator pedal released
Accelerafor pedal depressed
-
ov
VB
-
Ignition switch
ON rhr0ttte sensor
‘Idle switch)

Terminal vdt
wminal lrput
1A -
1B 0
-
1C 0
1D e (ATX) ve: aattefy voltage
1
Connected to
I Test wndition ~cwrect rc4t.gej F&W*
-
0
-
-
3attery
Uain r&y
:FUEL INJ relay) Constant
tgnition swdch V% For backt@
OFF ov
ON V6
Ignition swtch
(START)
Self-Diagnosis
Checker
[monitor lamp)
3 - White crankii npprox 1ov
fgnition switch ON ov
Test swtch at “SELF-TEST’ With Self-
Lamp illuminated for 3 sec. after igmtmn 4.5-5.w Diagnosis Check-
switch OFF-+ON er and System
Selector
Lamp net illuminated after 3 Sec. VS
Test swtch at “02 MONITOR” at idle
i Monitor lamp illuminated 4.5-55v
Test switch at “02 MONtTOR” at idfe
Monitor lamp not illuminated
Malfunction indicator
lamp illuminated for 3 sec. after ignition
Below 2 5v With System
lalllp switch OFF+ON selector test
WLI switch at
Lamp not luminated after 3 sec. VE
“SELF-TEST”
lamp ifluminated BelOW 2.w
Lamp not illuminated VS
Self-Diagnosis Buzzer sounded for 3 sec. after ignrtion
l With Self-
Checker switch OFF-+ON Below 2.5V
Diagm!3s
(code number) Checker and
Buzzer not sounded after 3 set VB
system
Select0 Buzzer sou&?d Below 2 5v l With System
Selector test
I Buzzer not sounded
tgmter Ignition switch ON ov
Idle Appror 0 2v -
Headlight switch Headlights ON
f VB
-
Headlbhts OFF ! ov
Diagnosis
connector
, System Selector test switch at
VS Ignition witch
“02 MONITOR” ON
(TEN terminal)
Rear window
defroster switch
Ground Icalifornia) System Selector tesf switch at
“SELF-TEST”
Rear window defroster watch OFF
Rear window de!roster watch ON
ConSlant QV
ov lgmhon switch
__ ON
VO
ov
- Main relay (canadal fgmtion switch ON VB
AC relay Ignitiin switch ON VB
A/C switch ON at Idle Below 2.5% -
Vehicle speed A/C switch OFF at Gle
/ Vehicle stopped
P/S pressure
switch lgmhon switch ON
P/S ON at idle Iturnino)
I.
P/S OFF at idle I VB Terminal voltage v‘s: Battery vottage
I I
1
Terminal input Output Connected to Test condition comcl voltage Remark
10
0 A/C swatch AIC switch ON Befow25V ignition switch
ON and blower
A/C switch OFF VB I
motor ON
IP
ii Blower control Blower control swtch OFF or 1 St poSItion VB tgnibon switch
switch ON
Blower control switch 2nd or higher
ov
position
1Q
0 Stopltght switch Brake pedal released Below 1 ov
-
IT <; Brake pedal depressed VE
lnhtbitor switch N or P range ov Ignition switch
(P N range) ON
Other ranges VB
Cruise control man Set or Resume swtch ON or vehicle speed lgmhon swtch
switch 8kmih &mph) lower than preset speed &tow 1 5~ ON
(Drwng vehcfe crwse cantrol
OperatiOn)
Fk
z 1v -
3A ’ Throttle Sensor
(Idle switch) Normal conditions
Accelerator pedal released
Accelerator pedal depressed “8
Bebw 1 ov lgnihon swatch
ON
VS
I -
-
- - -
-
-
- - -
D&rib&r
-‘. / b / / (Ne-signal) lgmtion swtch ON
/ ,,,, Approx. OV
or 5v
-
Approx 2v
I ._.
/
28 1
AdlOw meter lgmhon switch ON
Approx 3 BV .,
-
Idle Approx 3 3V
2c j r:
I \’ oxygen sensor fgmtson switch ON ov
1
20 Idle (cold englIIei
Idle (after warn-up)
lncreasma enwe speed (after warm-up) ov
O-l ov -
0 w-1 .ov
_ -
,
Deceleration o-o 4v
Coolmg fan swtch Fan operahng (engine coolant temperature
over 97°C (207’F) or diagnosis connector DV
termmat TFA grounded) -
Fan not operatmg (idle)
Water thermosensor Engine codant temperature L” %, I”” I , ‘Y”8’.“” . . . ...-1.
After warm-up
I
Thrnttb SP”SOi 1 Accelerator pedal released Approx 0.5V
2G .._..._ --..--
-
Accelerator pedal fully depressed Approx. 4 OV
0 ATF thermosensor -XPC (-2o”~)--1x1~c (302°F) aprxox as5-~m lgmhon swtch
ON
ATF temp 20°C (68°F) Approx. 4.6V
13OOC (266°F) Aporox 1.54V
I I I I I I
2H / i, I / Hold switch Hold mode Below 2V Ingbhon switch
Normal mode

j Z WlRiNQ MAQRAM A.. .EC-AT 0 .CANACA
/
l NSTRUMENT CLUSTER & WARNING LAMPS *...WITH PASSIVE SHOULDER BELT
c
BATTERY
0 01 MAIN
BOA
0 0, B (E)
0 (F)
.-I
FLASHER UNIT
SECTION F-l
(SECTION E-3) HEADLIGHTS
(SECTION E-2) INSTRUMENT CLUSTER
ILLUMINATION LAMP
;REFER TO SECTION I-4
k,
JR-06 @
METER
15A
STARTING SYSTEM
(SECTION n-i)
E J&O4 0
WY
Fl
I
INSTRUMENT CLUSTER
OOHC SEYSOR
&
:-04 PARKING BRAKE C-07 WATER THERMOSENSOR
SWITCH (I?) (EMI
(INJI
DOHC

Vs: Battery voltags
Terminal Connecte4t to
Voltage . . . Procedure
a (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
b (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
c (Output) Actuator ov Ignition switch ON
Approx. 9V Main switch ON
d
e (Input) Cruise control main VEI Ignition switch ON
switch (N.C)
f (input) Cruise control main Ve Main switch ON
switch (N.0).
9 Wwft) EC-AT control unit VI3 Ignition switch ON
(only ATX)
h (Output) Stoplight switch 2 (NC) Approx. 9V Main switch ON
i (Input) Inhibitor switch (ATX) ov “N” or “P” range and main switch ON
Note Approx. 5V Other range and main switch ON
Disconnect
EGI control Clutch switch (MTX) ov
Clutch pedal depressed and main switch ON
unit connector Approx. 5V Main switch ON
I (Input) Horn relay VB Horn switch OFF
m (Input) Stoplight switch 1 (N.0) ov Ignition switch ON
VEI
Brake pedal depressed
n (Input) Cruise control switch VE Main switch ON
(Resumelaccel switch) Approx. 9V While pushing the resume/accel switch after main switch
ON
Cruise control switch VEI Main switch ON
(Set/coast switch) Approx. 5V While pushing the set/coast switch after main switch ON
0 (Input) Stoplight switch 2 (N.C) Approx. 9V Main switch ON
ov
Brake pedal depressed
P (Input) Speed sensor Run out
Note While rotating the rear tire
between
O&connect 0-w
EC-AT control
unit connector
q
r
S Battery Vs
Constant
t Ground ov
Constant

DIAGRAM Z
rl PARTS NAME
-
PA ,K
SECTION T
CIGARETTE LIGHTER ............................................
I-1
CIRCUIT OPENING RELAY ..............................
B-l&Pa
I CLUTCH
SWITCH .............................................. B-lc
CONDENSER ................................................. B-la.2a
CONDENSER FAN ..................................................
G
CONDENSER
FAN RELAY ....................................... G
COMBINATION
SWITCH .................................... E-l.2
COOLING FAN MOTOR .....................................
B-3,4
COOLING
FAN RELAY ........................................ B-3,4
COURTESY LAMP ................................................
l-3
CPU .................................................................... l-2
CRUISE CONTROL
MAIN SWITCH ........................... Q
CRUISE
CONTROL SWITCH .................................... Q
CRUISE CONTROL UNIT ......................................... Q 0 ACTUATOR ........................................................... Q
A/C RELAY ........................................................... G
t A/C SWITCH .........................................................
G
t AIRFLOW METER .......................................... B-lc,Pc
t ALTERNATOR .....................................................
A-2
I AUDIO SYSTEM .....................................................
J
@BACK-UP LIGHT .................................................. F-3
BACK-UP LIGHT SWITCH
..................................... F-3
I
BLOWER MOTOR ...................................................
G
h BLOWER SWITCH ..................................................
G
I BRAKE FLUID SWITCH ...........................................
C
BUCKLE SWITCH .............................................
l-2, S
@I DIAGNOSIS CONNECTOR .......................................
U
DIGITAL CLOCK
................................................... l-l
DIODE ..................................................................
G
DISTRIBUTOR ...............................................
B-l b,2b
DOOR CATCH SWITCH .......................................... S
DOOR
SPEAKER ..................................................... J
DOOR SWITCH ....................................................
l-2
DRL CONTROL UNIT ............................................
E-3
DRL RELAY .........................................................
E-3
ORL RESISTOR ....................................................
E-3
ENGINE CONTROL UNIT
.................................... B-1.2
ii@ FLASHER UNIT ....................................................
F-l
FRONT TURN LIGHT ............................................
F-l
FUEL METER
......................................................... C
FUEL
TANK UNIT .......................................... B-la,2a
HAZARD SWITCH ...............................................
F-l _
HEADLIGHT .....................................................
E-l.2
HEADLIGHT RELAY .............................................
E-2
h HIGH
MOUNT STOPLIGHT ....................................
F-2
h HOLD SWITCH .................................................. B-2c
4 HORN .................................................................
F-3
! HORN RELAY
...................................................... F-3
HORN SWITCH ....................................................
F-3
0 IC REGULATOR ..................................................
A-2
-L
T-S INDEX
PARTS NAME SECTION
IGNITER ........................................................ B-la,2a
IGNITION COIL ..............................................
B-la.2a
IGNITION KEY CYLINDER LAMP .............................
l-2
IGNITION KEY REMINDER SWITCH ........................ l-2
ILLUMINATION LAMP
A/C SWITCH ..................................................... l-4
AT SELECT
....................................................... l-4
AUDIO SYSTEM
................................................. l-4
BLOWER SWITCH .............................................
l-4
CIGARETTE LIGHTER
......................................... l-4
CRUISE CONTROL
MAIN SWITCH ....................... l-4
HAZARD SWITCH .............................................
l-4
INSTRUMENT CLUSTER
..................................... l-4
REAR WINDOW DEFROSTER SWITCH
................. l-4
INHIBITOR SWITCH .................................... A-l, B-2c
INJECTOR ....................................................
B-1 b,2b
INSTRUMENT CLUSTER ..........................................
C
INTERIOR & SPOT LAMP .......................................
l-2
ISC VALVE ...................................................
B-1 b,26
@ LICENSE PLATE LIGHT .........................................
E-4
LIMIT SWITCH .......................................................
S
481 MAGNETIC
CLUTCH .............................................. G
MAIN RELAY (FUEL INJ) ................................
B-la,Pa
@ NEUTRAL SWITCH ............................................
B-lc
@ OIL PRESSURE SWITCH ..........................................
C
OXYGEN SENSOR ......................................... B-la.2a
@ PANEL LIGHT CONTROL .......................................
l-4
PARKING BRAKE SWITCH ......................................
C
PASSIVE SHOULDER BELT CONTROL UNIT
.............. S
PASSIVE SHOULDER BELT
MOTOR .......................... S
POSITION LIGHT .................................................
E-4
POWER DOOR LOCK MOTOR
............................... K-2
POWER DOOR LOCK RELAY
................................. K-2
POWER DOOR LOCK SWITCH
.............................. K-2
POWER
OUTSIDE MIRROR ...................................... L
POWER OUTSIDE MIRROR MOTOR
.......................... L
POWER OUTSIDE MIRROR SWITCH .........................
L
POWER STEERING PRESSURE SWITCH ........... B-l b.2b
POWER WINDOW MAIN SWITCH .........................
K-l
POWER WINDOW MOTOR ...................................
K-l
POWER WINDOW SWITCH
.................................. K-l
@ REAR TURN LIGHT ..............................................
F-l
REAR SiDE MARKER LIGHT ..................................
E-4
REAR
SPEAKER ......................................................
J
REAR WASHER MOTOR ......................................
D-3
REAR WINDOW DEFROSTER
................................. I-1
REAR WINDOW DEFROSTER SWITCH ....................
I-1
REAR WIPER MOTOR
.......................................... D-3
REAR WIPER & WASHER SWITCH
........................ D-3
REFRIGERANT PRESSURE SWITCH
.......................... G
RESISTOR ASSEMBLY ............................................
G

PAWS INDEX
‘ARTS NAME SECTION
@ SHIFT-LOCK UNfT .................................................. H
SHORT CONNECTOR ........................................ B-3,4
SLIDING SUNROOF ................................................ M
SLIDING SUNROOf MOTOR .............................. l-2. M
SLlDlNG SUNROOF RELAY ..................................... M
SLIDING SUNROOF SWITCH ............................. l-2, M
SOLENOID VALVE
EC-AT ........................................................... 8-2~
PRESSURE REGULATOR CONTROL .............. B-l b,2b
PURGE CONTROL ...................................... B-l b.2b
VICS ........................................................ B-lb,Sb
SPEED SENSOR ..................................................... C
SPOT LAMP ......................................................... l-2
STARTER ........................................................... A-l
STARTER INTERLOCK SWITCH ............................ A-l
STOPLIGHT SWITCH ....................................... F-2, Q
STOPLIGHT ........................................................ F-2
@ TACHOMETER.. ...................................................... C
TAILLIGHT .......................................................... E-4
TAILLIGHT RELAY ............................................... E-2
TEMP METER ....................................................... c
THERMOSWITCH ................................................... G
THROTTLE SENSOR ...................................... B-lc.2~ 1 PARTS NAME SECTION
TRUNK COMPARTMENT LAMP
r ~~~~~~
.............................. l-3
TRUNK COMPARTMENT LAMP SWITCH ................. l-3
TURN SWITCH ....................................................
F-l
@WARNING LAMP
BEAM ................................................................ C
BELTS ...............................................................
C
BRAKE
............................................................... C
CHARGE ............................................................
C
CHECK .............................................................. C
FUEL ................................................................. C
HAZARD ............................................................
C
HOLD ................................................................ C
OIL ....................................................................
C
TURN ................................................................
C
WASHER
............................................................
C
WASHER LEVEL SENSOR
........................................ C
WATER THERMOSENSOR ........................... B-l b,2b,C
WATER THERMOSWITCH ................................. B-3.4
WINDSHIELD WASHER
MOTOR .........................
D-l .2
WINDSHIELD WIPER
MOTOR ............................. D-l,2
WINDSHIELD WIPER & WASHER SWITCH .......... D-1.2
WINDSHIELD WIPER RELAY ................................. D-2